Dodge Pickup R3500 (1996-2010) vio/gry Wiring diagrams

3.7L/5.7L 4.7L/ 5.7L A/C HEATER CONTROL AIR BAG CONTROL MODULE (BENEATH LOWER CENTER OF DASH) AUDIO AMPLIFIER (PREMIUM) (BEHIND UPPER RIGHT SIDE OF DASH) BLK/DK GRN WIRE COMPASS/ MINI-TRIP COMPUTER (EXCEPT BASE) CONTROLLER ANTI-LOCK BRAKE (ON LEFT REAR OF ENGINE COMPT) DATA LINK CONNECTOR (DLC) (BELOW LEFT SIDE OF DASH) DK BLU/VIO WIRE FRONT CONTROL MODULE FUSE 51 HOT AT ALL TIMES INSTRUMENT CLUSTER INTEGRATED POWER MODULE (ON LEFT FRONT OF ENGINE COMPT) LEFT SIDE IMPACT AIR BAG CONTROL MODULE (BASE OF LEFT "B" PILLAR, BEHIND TRIM) LT BLU/VIO WIRE LT GRN WIRE ORG/BLK WIRE PCI BUS PNK SCI TRANSMIT WIRE PNK WIRE PNK/LT BLU WIRE POWERTRAIN CONTROL MODULE (ON RIGHT SIDE OF FIREWALL) RADIO RIGHT SIDE IMPACT AIR BAG CONTROL MODULE SCI RECEIVE SCI TRANSMIT SENTRY KEY IMMOBILIZER MODULE (ON TOP OF STEERING COLUMN) TRANSFER CASE CONTROL MODULE TRANSMISSION CONTROL MODULE VIO WIRE VIO/BLK WIRE VIO/BRN WIRE VIO/DK BLU WIRE VIO/DK GRN WIRE VIO/GRY WIRE VIO/LT BLU WIRE VIO/LT GRN WIRE VIO/ORG WIRE VIO/PNK WIRE VIO/YEL WIRE WHT/DK GRN WIRE

1 2 3 4 D DR AJAR LR DR AJAR RR DR AJAR P DR AJAR 18 17 CAN B BUS(-) CAN B BUS(+) AAT RTN B(+) BLK WIRE BLK/GRY WIRE CAB CHASSIS) CAN B CLUSTER COM-LIN TIRE PRESS COMPUTER DATA HEADLIGHTS LINES SYSTEM SYSTEM COMPUTER DATA LINES SYSTEM DIESEL GAS DRIVER DOOR LATCH (LEFT FRONT DOOR) ELECTRONICS FUSE 11 FUSE 2 FUSED B (+) FUSED HOOD IGN SW AJAR OUTPUT SWITCH (RUN-START) SENSE FUSED IGN SW OUT GRY/LT BLU WIRE GRY/RED WIRE GRY/YEL WIRE HOOD AJAR SWITCH HORN CONTROL OUTPUT HORNS SYSTEM HOT AT ALL TIMES IGN SW SENS IGNITION SWITCH LEFT FRONT TIRE PRESSURE TRANSPONDER LT GRN/BLK WIRE PASSENGER DOOR LATCH PICK-UP PNK/WHT WIRE POWER LOCKS POWER MODULE (LEFT FRONT FENDER) RED WIRE RIGHT FRONT TIRE PRESSURE TRANSPONDER (RIGHT SIDE OF ENGINE COMPT) TOTALLY INTEGRATED VIO WIRE VIO/BRN WIRE VIO/GRY WIRE VIO/LT BLU WIRE VIO/TAN WIRE VIO/WHT WIRE VIO/YEL WIRE WHT WIRE WHT/GRY WIRE WHT/LT GRN WIRE WHT/ORG WIRE WIRELESS CONTROL MODULE

2 5 4 READING LPS DRV COURTESY LPS DRV PANEL LPS DRV AUTO STICK SWITCH (ERS) B(+) DRV DOOR DOOR CAN AJAR AJAR AJAR SW SW SW SNS BLK WIRE BLK/DK GRN WIRE BLK/GRY WIRE BLK/TAN WIRE BLK/WHT WIRE CAN FUSE IHS IHS SW BUS BUS SNS SNS SNS (+) (-) CARGO LP CLUSTER COMPUTER DATA LINES SYSTEM DIM SIG DRIVER DOOR LATCH ELECTRONICS EXCEPT REGULAR CAB FRONT READING LAMP FUSE FUSE FUSE FUSE GLOVE BOX LAMP) GRY WIRE HDLP SW HDLP/FOGLP HEADLAMP SWITCH HOT AT ALL TIMES HOT IN ON OR START INSTRUMENT ILLUMINATION CIRCUIT LEFT REAR DOOR LATCH (EXCEPT REGULAR CAB) LEFT STORAGE BIN (IF EQUIPPED) LEFT VANITY LAMP LT BLU WIRE LT GRN WIRE MLFCT SW RTN MUX RTN ORG/ WIRE ORG/BRN WIRE ORG/GRY WIRE PANEL LPS PANEL LPS DRV PASSENGER DOOR LATCH PNK WIRE PNK/ EXCEPT REGULAR CAB WIRE PNK/LT GRN WIRE REAR DOME LAMP RED WIRE RED/VIO WIRE RED/WHT WIRE RIGHT REAR DOOR LATCH (EXCEPT REGULAR CAB) RIGHT STORAGE BIN (IF EQUIPPED) RIGHT VANITY LAMP RR LR PASS DOOR DOOR AJAR SW SIG TOTALLY INTEGRATED POWER MODULE (LEFT FRONT OF ENGINE COMPT) UNDERHOOD LAMP (IF EQUIPPED) VIO WIRE VIO/GRY WIRE VIO/WHT WIRE VIO/YEL WIRE W/ LIGHT PACKAGE WHT WIRE WHT/GRY WIRE WHT/LT GRN WIRE WHT/ORG WIRE WHT/YEL WIRE YEL WIRE YEL/LT BLU WIRE YEL/WHT WIRE

1 2 3 4 IOD FD GND LIN CCN AUTO STICK UP SW FUSED IGN RUN/START IOD FD B(+) BLK WIRE BLK/BRN WIRE BLK/DK GRN WIRE BLK/LT GRN WIRE BLK/WHT WIRE BRAKE FLUID LEVEL SENSOR (LEFT REAR OF ENGINE COMPT) BRN WIRE BRN/WHT WIRE CAN-BUS CARGO LP SW SIG CIRCUIT BOARD CLUSTER COMPASS MODULE COMPT) COMPUTER DATA LINES SYSTEM DK BLU/WHT WIRE DK GRN/ORG (OR DK GRN/RED) WIRE DK GRN/RED WIRE DK GRN/VIO WIRE DK GRN/WHT WIRE DK GRN/YEL WIRE DRIVER COURTESY LAMPS GROUND DRIVER DOOR LATCH DRV DR AJAR SW SENS ERS AUTO STICK SWITCH EXCEPT 6.7L EXCEPT 6.7L 6.7L FUEL LVL SENS SIG FUEL PUMP MODULE FUSE FUSE FUSE GROUND GROUND LIN CCN HDLP POS FOG LMP SW MODE SELECT HDLP SW MUX RTN HEADLIGHTS SYSTEM HEADLIGHTS SYSTEM TRANSMISSIONS SYSTEM HORN SW SNS HORNS SYSTEM HOT AT ALL TIMES HOT W/ RUN/START RELAY ENERGIZED IGN RUN/ START CTRL IND DRV INVERTER MODULE LEFT REAR DOOR LATCH (QUAD, CREW CAB) LR DR AJAR SW SENS LT GRN WIRE LT GRN/DK BLU WIRE LT GRN/GRY WIRE LT GRN/LT BLU WIRE LT GRN/ORG WIRE LT GRN/TAN WIRE LT GRN/WHT WIRE LT GRN/YEL WIRE LVL SW SENS BRK FLUID OIL PRESS SW OIL PRESSURE SENSOR OIL PRESSURE SWITCH ORG/BRN WIRE ORG/GRY WIRE PANEL LP DIMMER SIG PARK BRAKE SW SNS LR HEATED SEAT SW SENS RR HEATED SEAT SW SENS PARKING BRAKE SWITCH (TOP OF PARKING BRAKE PEDAL) PASS DR AJAR SW SENS PASSENGER DOOR LATCH PNK/LT GRN WIRE POWERTRAIN CONTROL MODULE (3.7L, 4.7L: REAR OF ENGINE) RAIL LAMP FDS DRIVER CARGO LAMPS RED WIRE RED/GRY WIRE RIGHT REAR DOOR LATCH (QUAD, CREW CAB) RR DR AJAR SW SENS RR HEATED SEAT LO IND RR HEATED SEAT HI IND SEATS SYSTEM SEATS SYSTEM SEATS SYSTEM SENS RTN FUEL LVL TOTALLY INTEGRATED POWER MODULE (LEFT FRONT OF ENGINE COMPT) TRANSFER CASE POS SENS TRANSMISSIONS SYSTEM VIO WIRE VIO/BRN WIRE VIO/GRY WIRE VIO/WHT WIRE VIO/YEL WIRE WHT WIRE WHT/DK GRN WIRE WHT/GRY WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE WHT/ORG WIRE WHT/TAN WIRE WHT/YEL WIRE YEL/LT BLU WIRE YEL/WHT WIRE

1 PNK/ WIRE 20 21 22 23 24 25 26 SEAT BELT SW B(+) CAN C BUS (+) BLK WIRE BLK/LT BLU WIRE BLK/LT GRN WIRE BLK/ORG WIRE BLK/VIO WIRE BRAKE FLUID LEVEL BRN/WHT WIRE BRN/YEL WIRE CAN B BUS (-) CAN B BUS (+) CAN C BUS (+) CLUSTER COMPUTER DATA LINES SYSTEM DK BLU/WHT WIRE DK BLU/YEL WIRE DK GRN WIRE DK GRN/ORG WIRE DK GRN/VIO WIRE DK GRN/WHT WIRE DK GRN/YEL WIRE DOOR LOCKS SYSTEM FUEL LEVEL SENS SIG TURN LAMPS SW SIG FUSE 11 FUSE 2 FUSE 35 FUSED B (+) FUSED IGN SW (OFF-RUN-START) FUSED IGN SW OUTPUT (OFF-RUN START) GRY WIRE GRY/RED WIRE GRY/WHT WIRE HEADLIGHTS SYSTEM HIGH BEAM HORNS SYSTEM HOT AT ALL TIMES INTERIOR LIGHTS SYSTEM HEADLIGHTS SYSTEM INTERMITTENT WIPER SW SIG LR DOOR UNLOCK DRIVER RIGHT DOORS UNLOCK DRIVER FUSED B(+) FUSED B(+) LT BLU WIRE LT GRN WIRE LT GRN/DK BLU WIRE LT GRN/GRY WIRE LT GRN/ORG WIRE MODE SELECT GROUND HORN SW SENSE NEUTRAL IND OPTICAL HORN ORG/ WIRE ORG/BRN WIRE ORG/DK BLU WIRE ORG/GRY WIRE PANEL LAMPS DRIVER PARK BRAKE SW PARKING BRAKE SWITCH (TOP OF PARKING BRAKE PEDAL) PNK/WHT WIRE POS SENSOR INPUT RADIO CTRL MUX RED WIRE SOUND SYSTEMS TAN/LT GRN WIRE TAN/ORG WIRE TOTALLY INTEGRATED POWER MODULE (LEFT FRONT FENDER) ELECTRONICS TRANSMISSIONS SYSTEM VIO WIRE VIO/BRN WIRE VIO/DK GRN WIRE VIO/GRY WIRE VIO/LT BLU WIRE VIO/LT GRN WIRE VIO/WHT WIRE VIO/YEL WIRE WARNING SYSTEMS WARNING SYSTEMS HEADLIGHTS SYSTEM WASH WHT WIRE WHT/BRN WIRE WHT/LT GRN WIRE WHT/ORG WIRE WHT/YEL WIRE WIPER/WASHER SYSTEM YEL/GRY WIRE YEL/LT BLU WIRE YEL/TAN WIRE

1 21 4 5 CAN C BUS (+) CAN C BUS (-) 27 29 SENS GND 5 VOLT SPLY 35 34 CAN C BUS (-) CAN C BUS (+) 5.9L DIESEL 6.7L DIESEL BLK WIRE COMPUTER DATA LINES SYSTEM DK BLU/DK GRN WIRE DK BLU/WHT WIRE DK GRN/YEL WIRE DRIVER DOOR LATCH (DRIVER'S DOOR) ENGINE CONTROL MODULE (DIESEL) FUEL PUMP MODULE (IN FUEL TANK) LEFT REAR DOOR LATCH (LEFT REAR DOOR) LT GRN/BLK WIRE OIL PRESSURE SENSOR (5.7L A/T) (LOWER RIGHT FRONT OF ENGINE) OIL PRESSURE SIG PASSENGER DOOR LATCH (FRONT PASSENGER'S DOOR PNK/YEL WIRE RIGHT REAR DOOR LATCH (RIGHT REAR DOOR) TRANS RANGE TRANS RANGE SENS MUX TRANSMISSION RANGE SENSOR (A/T) (EXCEPT 4.7L, 5.7L: LEFT SIDE OF TRANSMISSION) VIO WIRE VIO/GRY WIRE VIO/WHT WIRE VIO/YEL WIRE W/ POWER LOCKS WHT/LT BLU WIRE WHT/LT GRN WIRE YEL/TAN WIRE

0 OFF 1 PARK 2 HEAD BLK WIRE BLK/LT BLU WIRE BLK/LT GRN WIRE CLUSTER DRIVER DOOR LATCH (LEFT FRONT DOOR) DRIVER DR AJAR SW SNS DRIVER SEAT BELT SWITCH (UNDER DRIVER'S SEAT) EXCEPT STANDARD CAB FUSE 2 FUSE 35 FUSED B (+) GROUND GRY WIRE HDLP SW RET HDLP SW SIG HEADLAMP SWITCH HOT AT ALL TIMES LEFT REAR DOOR LATCH (IN LEFT REAR DOOR) LEFT REAR DR AJAR SW SNS LT GRN WIRE LT GRN/GRY WIRE PASSENGER DOOR LATCH (RIGHT FRONT DOOR) PASSENGER DR AJAR SW SNS PASSIVE RESTRAINT SYSTEM POWER LOCKS RED WIRE RIGHT REAR DOOR LATCH (IN RIGHT REAR DOOR) RIGHT REAR DR AJAR SW SNS SEAT BLT SW TAN/YEL WIRE TOTALLY INTEGRATED POWER MODULE (AT LEFT FRONT FENDER) VIO WIRE VIO/GRY WIRE VIO/ORG WIRE VIO/WHT WIRE VIO/YEL WIRE WHT/LT GRN WIRE WHT/YEL WIRE

5 VOLT SPLY MDS SOL CTRL 4 FUSED B(+) IGN START B(+) BLK WIRE BLK/BRN WIRE BLK/DK GRN WIRE BLK/YEL WIRE BRN WIRE BRN/DK BLU WIRE BRN/DK GRN WIRE BRN/GRY WIRE BRN/LT BLU WIRE BRN/LT GRN WIRE BRN/ORG WIRE BRN/TAN WIRE BRN/VIO WIRE BRN/WHT WIRE BRN/YEL WIRE CAN C BUS (+) CAN C BUS (-) CMP SIG CKP SIG KNOCK SENS 2 SIG KNOCK SENS 2 RETURN ETC MOTOR (-) COIL CTRL 7 INJECTOR CTRL 8 INJECTOR CTRL 7 COMPUTER DATA LINES SYSTEM CTRL SIG DK BLU WIRE DK BLU/DK GRN WIRE DK BLU/GRY WIRE DK BLU/LT BLU WIRE DK BLU/LT GRN WIRE DK BLU/ORG WIRE DK BLU/TAN WIRE DK BLU/YEL WIRE DK GRN WIRE ELECTRONICS FUSE 31 FUSED ASD GEN FIELD CTRL ECT SIG TP 1 SIG GEN SNS GROUND FUSED B(+) IGN SW OUT (RUN-START) IGN SW OUT (OFF-RUN-START) GROUND GROUND OIL PRESSURE SIG SRV SEN OUT HOT AT ALL TIMES IGN (START) KNOCK SENS 1 (-) KNOCK SENS 1 RETURN KNOCK SENS 2 (-) KNOCK SENS 2 RETURN KNOCK SENSOR 1 KNOCK SENSOR 2 (LOWER RIGHT SIDE OF ENGINE BLOCK) MAP SIG KNOCK SENS 1 RETURN KNOCK SENS 1 SIG PNK/GRY WIRE PNK/WHT WIRE PNK/YEL WIRE POWERTRAIN CONTROL MODULE (RIGHT REAR OF ENGINE COMPT) RED WIRE RED/GRY WIRE RLY OUT RUN-START) IGN (OFF- SCI TRANSMIT (TCM) ASD CTRL OUT SENS GROUND TP 2 SIG 5 VOLT SPLY IAT SIG SHORT RUNNER VALVE SOLENOID SIG SRV ACTR SRV ACTR CTRL SIG SRV SEN OUT STARTING/ CHARGING SYSTEM TAN/ORG WIRE TAN/YEL WIRE THROTTLE BODY (ON TOP OF ENGINE) TOTALLY INTEGRATED POWER MODULE (AT LEFT FRONT FENDER) VIO/BRN WIRE VIO/GRY WIRE VIO/ORG WIRE WHT/BRN WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE YEL WIRE YEL/PNK WIRE

ASD CTRL OUT B(+) BLK WIRE BLK/LT BLU WIRE BLK/LT GRN WIRE BLK/ORG WIRE BRN WIRE BRN/DK BLU WIRE BRN/DK GRN WIRE BRN/GRY WIRE BRN/LT BLU WIRE BRN/LT GRN WIRE BRN/ORG WIRE BRN/TAN WIRE BRN/VIO WIRE BRN/WHT WIRE BRN/YEL WIRE CAN B BUS (+) CLUSTER COMPUTER DATA LINES SYSTEM DC MANUAL T CASE DK BLU/DK GRN WIRE DK BLU/GRY WIRE DK BLU/LT BLU WIRE DK BLU/LT GRN WIRE DK BLU/ORG WIRE DK BLU/TAN WIRE DK BLU/WHT WIRE DK BLU/YEL WIRE ENGINE COOLANT TEMPERATURE SENSOR (FRONT OF ENGINE) EXCEPT DC MANUAL T CASE FUEL PUMP CTRL OUT FUEL PUMP MODULE (IN FUEL TANK) FUSE 28 GROUND HOT AT ALL TIMES IGN SW OUT (RUN-START) INTAKE AIR TEMPERATURE SENSOR (TOP OF ENGINE) MAP SENSOR MULTI DISPLACEMENT SYSTEM CYLINDER 4 SOLENOID MULTI DISPLACEMENT SYSTEM CYLINDER 6 SOLENOID ORG/RED WIRE OXYGEN SENSOR 1/1 (IN EXHAUST, RIGHT OF TRANSMISSION) OXYGEN SENSOR 1/2 (IN EXHAUST, LEFT OF TRANSMISSION) OXYGEN SENSOR 2/1 OXYGEN SENSOR 2/2 (IN EXHAUST, RIGHT OF TRANSMISSION) PNK/GRY WIRE PNK/RED WIRE PNK/YEL WIRE SENS SIG FUEL LEVEL STOP LAMP SWITCH (ON BRAKE PEDAL SUPPORT) TOTALLY ELECTRONICS INTEGRATED POWER MODULE (LEFT FRONT FENDER) VIO/BRN WIRE VIO/GRY WIRE VIO/ORG WIRE VIO/WHT WIRE VIO/YEL WIRE WHT WIRE WHT/ORG WIRE YEL/PNK WIRE

5-VOLT APPS 1 RET APPS 1 SIG APPS 2 RET APPS 2 SIG BLK WIRE BLK/GRY WIRE BOOST SENS SIG BRN WIRE BRN/DK BLU WIRE BRN/GRY WIRE BRN/LT BLU WIRE BRN/LT GRN WIRE BRN/ORG WIRE BRN/TAN WIRE BRN/VIO WIRE BRN/WHT WIRE BRN/YEL WIRE CAMSHAFT POSITION SENSOR CAN C BUS (+) CAN C BUS (-) F/P RET GEN FIELD CTRL TTVA MOTOR (+) CKP SENS GND SENS RET CKP SIG COMPUTER DATA LINES SYSTEM CRANKSHAFT POSITION SENSOR DK BLU WIRE DK BLU/BRN WIRE DK BLU/DK GRN WIRE DK BLU/GRY WIRE DK BLU/LT GRN WIRE DK BLU/TAN WIRE DK GRN WIRE DRIVER BANK 1 ENGINE CONTROL MODULE (LOWER LEFT FRONT OF ENGINE BLOCK) ENGINE COOLANT TEMPERATURE SENSOR FUEL CTRL TTVA MOTOR (-) SENS GND CKP SIG SENS GND CMP SIG FUEL INJECTORS FUEL RAIL PRESSURE SENSOR (LEFT SIDE OF ENGINE) FUEL SENS FUEL RAIL SIG INLET SNS GRY WIRE IAT SENS SIG PRESSURE SNS ECT SIG INJ 2 CTRL INJ 3 CTRL SENS GND INJ 4 CTRL INJ 5 CTRL DRIVER BANK 2 INJ 6 CTRL LT BLU WIRE MAP TEMPERATURE/ PRESSURE SENSOR PNK/YEL WIRE RET SENS GND SENS GND INJ 1 CTRL SENS SIG CMP SENS GND APPS 1 SIG SENS SIG SIG STARTING/CHARGING SYSTEM TAN WIRE TAN/ORG WIRE TAN/PNK WIRE TAN/YEL WIRE VIO/BRN WIRE VIO/GRY WIRE VIO/LT GRN WIRE VIO/ORG WIRE VIO/WHT WIRE WHT/BRN WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE