Dodge Pickup R3500 (1996-2010) vio/brn Wiring diagrams

2 4 6 16 17 22 23 31 32 FUSED IGN (ST/RUN) SENSOR GND PNP SW SENSE ECT SENS SIG 28 30 CCD (-) CCD (+) 6 13 24 25 OD LAMP DRIVER TRANS OD SW SENSE BRAKE SW SENSE GENERATOR OUTPUT 8 9 10 11 PNK WIRE BLK WIRE BLK/LT BLU WIRE BLK/LT GRN WIRE BLK/TAN WIRE BLK/WHT WIRE BRN WIRE CCD(-) DATA LINK CONNECTOR (PARTIAL) (LEFT BOTTOM OF DASH) DK BLU WIRE DK BLU/BLK WIRE FUEL PUMP, AUTOMATIC SHUTDOWN RELAYS FUSE 14 FUSE 9 FUSED B(+) TP SENS SIG GND GND GRY WIRE HOT AT ALL TIMES HOT IN RUN OR START IND INSTRUMENT CLUSTER JOINT CONNECTOR 1 JOINT CONNECTOR 3 JOINT CONNECTOR 7 JUNCTION BLOCK LT GRN WIRE LT GRN/BLK WIRE LT GRN/ORG WIRE LT GRN/WHT WIRE MIL IND ORG/ WIRE ORG/BLK WIRE ORG/DK BLU WIRE ORG/WHT WIRE OVER- DRIVE OFF IND OVERDRIVE SWITCH PNK WIRE POWERTRAIN CONTROL MODULE (IN ENG COMPT, ON RIGHT SIDE OF FIREWALL) RED/WHT WIRE STOP LAMP SWITCH (TOP OF BRAKE PEDAL BRACKET) SWITCH (ON FRONT AXLE TUBE) TAN/BLK WIRE TL GRN WIRE TRANSMISSION OUTPUT SHAFT SPEED SENSOR (ON LEFT SIDE OF TRANSMISSION) VIO WIRE VIO/BRN WIRE VIO/WHT WIRE WHT WIRE WHT/BLK WIRE WHT/DK BLU WIRE WHT/ORG WIRE WHT/PNK WIRE YEL WIRE

2 4 6 16 17 22 23 31 32 FUSED IGN (ST/RUN) SENSOR GND PNP SW SENSE ECT SENS SIG 28 30 CCD (-) CCD (+) 6 13 24 25 OD LAMP DRIVER TRANS OD SW SENSE BRAKE SW SENSE GENERATOR OUTPUT 8 9 10 11 PNK WIRE BLK WIRE BLK/LT BLU WIRE BLK/LT GRN WIRE BLK/TAN WIRE BLK/WHT WIRE BRN WIRE CCD(-) DATA LINK CONNECTOR (PARTIAL) (LEFT BOTTOM OF DASH) DK BLU WIRE DK BLU/BLK WIRE FUEL PUMP, AUTOMATIC SHUTDOWN RELAYS FUSE 14 FUSE 9 FUSED B(+) TP SENS SIG GND GND GRY WIRE HOT AT ALL TIMES HOT IN RUN OR START IND INSTRUMENT CLUSTER JOINT CONNECTOR 1 JOINT CONNECTOR 3 JOINT CONNECTOR 7 JUNCTION BLOCK LT GRN WIRE LT GRN/BLK WIRE LT GRN/ORG WIRE LT GRN/WHT WIRE MIL IND ORG/ WIRE ORG/BLK WIRE ORG/DK BLU WIRE ORG/WHT WIRE OVER- DRIVE OFF IND OVERDRIVE SWITCH PNK WIRE POWERTRAIN CONTROL MODULE (IN ENG COMPT, ON RIGHT SIDE OF FIREWALL) RED/WHT WIRE STOP LAMP SWITCH (TOP OF BRAKE PEDAL BRACKET) SWITCH (ON FRONT AXLE TUBE) TAN/BLK WIRE TL GRN WIRE TRANSMISSION OUTPUT SHAFT SPEED SENSOR (ON LEFT SIDE OF TRANSMISSION) VIO WIRE VIO/BRN WIRE VIO/WHT WIRE WHT WIRE WHT/BLK WIRE WHT/DK BLU WIRE WHT/ORG WIRE WHT/PNK WIRE YEL WIRE

AIR BAG CONTROL MODULE (BEHIND LOWER CENTER OF DASH) BLK WIRE BLK/LT GRN WIRE BLK/TAN WIRE BLK/WHT WIRE CCD BUS (-) CENTRAL TIMER MODULE (ON LEFT SIDE OF DASH) CONTROLLER ANTI-LOCK BRAKE (RWAL: LEFT FRONT INNER FENDER) CUMMINS BUS (-) CUMMINS BUS (DIESEL) (LEFT FRONT OF ENGINE) CUMMINS BUS SHIELD DASH) DATA LINK CONNECTOR (DLC) (ON LEFT BOTTOM OF DASH) DIESEL DK BLU WIRE DK GRN WIRE DRAIN WIRE ENGINE CONTROL MODULE (ON LEFT SIDE OF ENGINE, BEHIND FUEL FILTER) FUSE 12 GAS GAS DIESEL GROUND HOT AT ALL TIMES HYDRAULIC CONTROL UNIT INSTRUMENT CLUSTER J/C 5 (BEHIND LEFT SIDE OF DASH) JUNCTION BLOCK (ON LEFT END OF NCA WIRE OVERHEAD CONSOLE (HIGHLINE) PNK WIRE PNK/DK BLU WIRE POWERTRAIN CONTROL MODULE (ON RIGHT SIDE OF FIREWALL) RADIO SCI RECEIVE SCI TRANSMIT VIO/BRN WIRE WHT/BLK WIRE WHT/VIO WIRE YEL/DK BLU WIRE YEL/DK GRN WIRE

3 2 1 SPD CTRL SW FD SW SPD CTRL RDNT SW SPD CTRL RTN A/T ACCELERATOR PEDAL POSITION SENSOR (LEFT SIDE OF DASH) ACCL PED POSTN SNSE ACCL PED POSTN 1 SIG BATT FD BATT RUN/START BLK WIRE BLK/TAN WIRE BRK SNSE SIG BRK SNSE SIG 2 BRN/LT GRN WIRE BRN/VIO WIRE BRN/YEL WIRE CIRCUIT BOARD CLUTCH INTERLOCK SWITCH (M/T) (LEFT SIDE OF DASH) COMPUTER DATA LINES SYSTEM DK GRN/BRN WIRE DK GRN/ORG WIRE DK GRN/RED WIRE DK GRN/VIO WIRE FUSE ENGINE COMPT) HOT AT ALL TIMES INPUT SPEED SENSOR LT BLU/DK GRN WIRE LT GRN/RED WIRE M/T OUTPUT SPEED SENSOR PARK/NUET SIG PED POS SNSE RTN PNK/WHT WIRE PNK/YEL WIRE POWERTRAIN CONTROL MODULE SPD CTRL SW FD SPEED CONTROL SWITCH STEERING CONTROL MODULE (LEFT SIDE OF DASH) STOP LAMP SWITCH (ON BRAKE PEDAL SUPPORT) SW CTRL RDNT FD SW SPD CTRL RTN TOTALLY INTEGRATED POWER MODULE (LEFT FRONT OF TRANS PRK/NEUT SIG TRANSMISSION SOLENOID ASSEMBLY (TRS) VIO WIRE VIO/BRN WIRE VIO/ORG WIRE WHT/BRN WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE YEL/DK BLU WIRE YEL/PNK WIRE

1 2 3 4 IOD FD GND LIN CCN AUTO STICK UP SW FUSED IGN RUN/START IOD FD B(+) BLK WIRE BLK/BRN WIRE BLK/DK GRN WIRE BLK/LT GRN WIRE BLK/WHT WIRE BRAKE FLUID LEVEL SENSOR (LEFT REAR OF ENGINE COMPT) BRN WIRE BRN/WHT WIRE CAN-BUS CARGO LP SW SIG CIRCUIT BOARD CLUSTER COMPASS MODULE COMPT) COMPUTER DATA LINES SYSTEM DK BLU/WHT WIRE DK GRN/ORG (OR DK GRN/RED) WIRE DK GRN/RED WIRE DK GRN/VIO WIRE DK GRN/WHT WIRE DK GRN/YEL WIRE DRIVER COURTESY LAMPS GROUND DRIVER DOOR LATCH DRV DR AJAR SW SENS ERS AUTO STICK SWITCH EXCEPT 6.7L EXCEPT 6.7L 6.7L FUEL LVL SENS SIG FUEL PUMP MODULE FUSE FUSE FUSE GROUND GROUND LIN CCN HDLP POS FOG LMP SW MODE SELECT HDLP SW MUX RTN HEADLIGHTS SYSTEM HEADLIGHTS SYSTEM TRANSMISSIONS SYSTEM HORN SW SNS HORNS SYSTEM HOT AT ALL TIMES HOT W/ RUN/START RELAY ENERGIZED IGN RUN/ START CTRL IND DRV INVERTER MODULE LEFT REAR DOOR LATCH (QUAD, CREW CAB) LR DR AJAR SW SENS LT GRN WIRE LT GRN/DK BLU WIRE LT GRN/GRY WIRE LT GRN/LT BLU WIRE LT GRN/ORG WIRE LT GRN/TAN WIRE LT GRN/WHT WIRE LT GRN/YEL WIRE LVL SW SENS BRK FLUID OIL PRESS SW OIL PRESSURE SENSOR OIL PRESSURE SWITCH ORG/BRN WIRE ORG/GRY WIRE PANEL LP DIMMER SIG PARK BRAKE SW SNS LR HEATED SEAT SW SENS RR HEATED SEAT SW SENS PARKING BRAKE SWITCH (TOP OF PARKING BRAKE PEDAL) PASS DR AJAR SW SENS PASSENGER DOOR LATCH PNK/LT GRN WIRE POWERTRAIN CONTROL MODULE (3.7L, 4.7L: REAR OF ENGINE) RAIL LAMP FDS DRIVER CARGO LAMPS RED WIRE RED/GRY WIRE RIGHT REAR DOOR LATCH (QUAD, CREW CAB) RR DR AJAR SW SENS RR HEATED SEAT LO IND RR HEATED SEAT HI IND SEATS SYSTEM SEATS SYSTEM SEATS SYSTEM SENS RTN FUEL LVL TOTALLY INTEGRATED POWER MODULE (LEFT FRONT OF ENGINE COMPT) TRANSFER CASE POS SENS TRANSMISSIONS SYSTEM VIO WIRE VIO/BRN WIRE VIO/GRY WIRE VIO/WHT WIRE VIO/YEL WIRE WHT WIRE WHT/DK GRN WIRE WHT/GRY WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE WHT/ORG WIRE WHT/TAN WIRE WHT/YEL WIRE YEL/LT BLU WIRE YEL/WHT WIRE

1 2 CCD BUS (+) CCD BUS (-) 14 16 17 MUX CTRL CCD (+) CCD (-) ANTENNA BLK WIRE BLK/LT GRN WIRE BLK/VIO WIRE BLK/YEL WIRE BRN/LT BLU WIRE BRN/RED WIRE BRN/YEL WIRE CENTRAL TIMER MODULE (LEFT SIDE OF DASH, INBOARD OF STEERING COLUMN OPENING) CLOCK SPRING 1 DK BLU WIRE DK BLU/ORG WIRE DK BLU/RED WIRE DK BLU/WHT WIRE DK GRN WIRE FUSE 12 FUSE 8 HOT AT ALL TIMES HOT IN RUN OR ACC JOINT CONNECTOR 5 (LEFT SIDE OF DASH) JOINT CONNECTOR 6 (LEFT SIDE OF DASH) JOINT CONNECTOR 7 (BEHIND LEFT SIDE OF DASH) JUNCTION BLOCK (LEFT END OF DASH) LEFT FRONT DOOR SPEAKER LEFT REAR SPEAKER LEFT REMOTE RADIO SWITCH LF SPKR (-) RF SPKR (-) DAY SENSE ILLUMINATION FUSED IGN FUSED B(+) LR SPKR (+) RR SPKR (+) LF SPKR (+) RF SPKR (+) LR SPKR (-) RR SPKR (-) NCA WIRE ORG/ WIRE PNK WIRE PRESET RADIO RED WIRE RED/BLK WIRE RED/WHT WIRE RIGHT FRONT DOOR SPEAKER RIGHT REAR SPEAKER SEEK DN SEEK UP VIO WIRE VIO/BRN WIRE VOL DN RIGHT REMOTE RADIO SWITCH VOL UP WHT WIRE WHT/BLK WIRE

1 2 CCD BUS (+) CCD BUS (-) 14 16 17 MUX CTRL CCD (+) CCD (-) AMP L REAR SPKR (+) AMP R REAR SPKR (-) AMP TWEETER SPKR (+) ANTENNA BLK WIRE BLK/LT GRN WIRE BLK/RED WIRE BLK/VIO WIRE BLK/YEL WIRE BRN/LT BLU WIRE BRN/RED WIRE BRN/YEL WIRE CENTRAL TIMER MODULE (LEFT SIDE OF DASH, INBOARD OF STEERING COLUMN OPENING) CLOCK SPRING 1 DK BLU WIRE DK BLU/ORG WIRE DK BLU/RED WIRE DK BLU/WHT WIRE DK GRN WIRE FUSE 12 FUSE 4 FUSE 8 GRN WIRE GROUND HOT AT ALL TIMES HOT IN RUN OR ACC JOINT CONNECTOR 5 (LEFT SIDE OF DASH) JOINT CONNECTOR 6 (LEFT SIDE OF DASH) JOINT CONNECTOR 7 (BEHIND LEFT SIDE OF DASH) JUNCTION BLOCK (LEFT END OF DASH) L FRONT SPKR - L REAR SPKR - LEFT FRONT DOOR SPEAKER LEFT REAR SPEAKER LEFT REMOTE RADIO SWITCH LEFT TWEETER SPEAKER LF SPKR (-) RF SPKR (-) DAY SENSE ILLUMINATION FUSED IGN FUSED B(+) LT BLU/BLK WIRE LT BLU/RED WIRE LT GRN WIRE NCA WIRE ORG/ WIRE PNK WIRE PRESET R FRONT SPKR - R REAR SPKR - RADIO RADIO CHOKE RADIO CHOKE RELAY (BEHIND CENTER OF DASH) RED WIRE RED/BLK WIRE RED/WHT WIRE RIGHT FRONT DOOR SPEAKER RIGHT REAR SPEAKER RIGHT TWEETER SPEAKER SEEK DN SEEK UP TAN/BLK WIRE TAN/VIO WIRE VIO WIRE VIO/BRN WIRE VOL DN RIGHT REMOTE RADIO SWITCH VOL UP WHT WIRE WHT/BLK WIRE WHT/DK GRN WIRE WHT/VIO WIRE YEL/BLK WIRE YEL/RED WIRE

6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 LINE 1 LINE 1 LINE 2 9 10 CCD (-) CCD (+) AIR BAG CONTROL MODULE (BEHIND LOWER CENTER OF DASH) AIR BAG WARNING INDICATOR BLK WIRE BLK/LT BLU WIRE BLK/PNK WIRE BLU WIRE BRN WIRE BRN/YEL WIRE BUS (-) BUS (+) CLOCKSPRING DATA LINK CONNECTOR (DLC) (PARTIAL) (ON LEFT BOTTOM OF DASH) DK BLU WIRE DK BLU/YEL WIRE DK GRN WIRE DRIVER AIR BAG FUSE 19 GRN WIRE GROUND LINE 2 HOT IN RUN JUNCTION BLOCK (ON LEFT END OF DASH) FUSE 18 HOT IN RUN OR START IGNITION IGNITION INDICATOR DRIVER INSTRUMENT CLUSTER J/C 7 (LEFT SIDE OF DASH) J/C 8 (CENTER OF DASH) LINE 1 LINE 2 LINE 2 LT BLU WIRE LT GRN WIRE LT GRN/YEL WIRE NCA WIRE OFF INDICATOR PASSENGER AIR BAG LINE 1 PASSENGER AIR BAG ON/OFF SWITCH PNK WIRE RESISTOR FUSED VIO WIRE VIO/BRN WIRE VIO/YEL WIRE WHT WIRE WHT/BLK WIRE YEL WIRE

1 2 3 4 5 6 7 8 TRANS RLY OUT AIR CONDI- TIONING SYSTEM AUTO SHT RLY CRUISE VAC SOL CRUISE VNT SOL BLK/LT BLU WIRE BLK/LT GRN WIRE BLK/RED WIRE BRN WIRE BRN/WHT WIRE CCD(-) CRUISE CONTROL SYSTEM CRUISE SW IN DATA LINK CONNECTOR (LEFT BOTTOM OF DASH) DK BLU WIRE DK BLU/ORG WIRE DK BLU/WHT WIRE DK BLU/YEL WIRE DK GRN WIRE DK GRN/ORG WIRE FUEL PMP RLY EVAP SOL DRVR FUSE 11 FUSE I GENERATOR HOT AT ALL TIMES HOT IN RUN OR START INSTRUMENT CLUSTER INTAKE AIR TEMPERATURE SENSOR (IN RIGHT FRONT SIDE OF INTAKE MANIFOLD) JOINT CONNECTOR 1 (IN PDC) JOINT CONNECTOR 11 9 2 14 6 5 JUNCTION BLOCK (RIGHT END OF DASH) LEAK DETECTION PUMP (RIGHT FRONT OF INNER FENDER) LT GRN/RED WIRE LT GRN/WHT WIRE NCA WIRE ORG/ WIRE ORG/BLK WIRE ORG/DK BLU WIRE ORG/WHT WIRE OVERDRIVE SWITCH PNK 1 2 WIRE PNK WIRE PNK/DK BLU WIRE PNK/WHT WIRE PNK/YEL WIRE POWER DISTRIBUTION CENTER (IN ENG COMPT, ON LEFT INNER FENDER PANEL) POWERTRAIN CONTROL MODULE (IN ENG COMPT, ON RIGHT SIDE OF FIREWALL) RED WIRE RED/LT GRN WIRE SENSOR GRD GOV PRESS SIG VAR FORCE SOL OVERDRV SOL TCC SOL CTRL TRANS TEMP SNS STOP LAMP SWITCH (ON BRAKE PEDAL BRACKET) TAN/RED WIRE THROTTLE POSITION SENSOR (ON THROTTLE BODY) TRANS- MISSION RELAY TRANSMISSION SOLENOID ASSEMBLY (ON LEFT SIDE OF TRANSMISSION) VIO WIRE VIO/BRN WIRE VIO/WHT WIRE WHT/BLK WIRE WHT/DK GRN WIRE WHT/PNK WIRE YEL/RED WIRE

1 2 3 4 5 6 7 8 TRANS RLY OUT AIR CONDI- TIONING SYSTEM AIR CONDITIONING SYSTEM AUTO SHT RLY CRUISE VAC SOL CRUISE VNT SOL BLK/LT BLU WIRE BLK/LT GRN WIRE BLK/RED WIRE BRN WIRE BRN/VIO WIRE BRN/WHT WIRE CCD(-) CRUISE CONTROL SYSTEM CRUISE SW IN DATA LINK CONNECTOR (LEFT BOTTOM OF DASH) DK BLU WIRE DK BLU/ORG WIRE DK BLU/WHT WIRE DK BLU/YEL WIRE DK GRN WIRE DK GRN/ORG WIRE DK GRN/PNK WIRE DK GRN/WHT WIRE DK GRN/YEL WIRE DOWNSTREAM OXYGEN SENSOR RELAY FUEL PMP RLY EVAP SOL DRVR FUSE GENERATOR HOT AT ALL TIMES INSTRUMENT CLUSTER INTAKE AIR TEMPERATURE SENSOR (IN LEFT FRONT SIDE OF INTAKE MANIFOLD) JOINT CONNECTOR 1 (IN PDC) JOINT CONNECTOR 11 9 2 14 6 5 LEAK DETECTION PUMP (ON RIGHT FRONT OF INNER FENDER) LT GRN/RED WIRE LT GRN/WHT WIRE M/T ONLY ORG/ WIRE ORG/BLK WIRE ORG/DK BLU WIRE ORG/WHT WIRE OVERDRIVE SWITCH PNK WIRE PNK/DK BLU WIRE PNK/WHT WIRE PNK/YEL WIRE POWERTRAIN CONTROL MODULE (IN ENG COMPT, ON RIGHT SIDE OF FIREWALL) RED WIRE RED/LT GRN WIRE SENSOR GRD GOV PRESS SIG VAR FORCE SOL OVERDRV SOL TCC SOL CTRL TRANS TEMP SNS STOP LAMP SWITCH (ON BRAKE PEDAL BRACKET) TAN/RED WIRE THROTTLE POSITION SENSOR (ON THROTTLE BODY) TRANSMISSION RELAY FUSE I TRANSMISSION SOLENOID ASSEMBLY (ON LEFT SIDE OF TRANSMISSION) VIO WIRE VIO/BRN WIRE VIO/WHT WIRE WHT/BLK WIRE WHT/DK GRN WIRE WHT/PNK WIRE YEL WIRE YEL/RED WIRE