Dodge Pickup R3500 (1996-2010) vio Wiring diagrams

9 10 11 PNK WIRE ACC PDL POS SENS GND GND BLK WIRE BLK/LT BLU WIRE BLK/TAN WIRE BLK/WHT WIRE BRAKE LAMP SWITCH (ON BRAKE PEDAL BRACKET) BRN WIRE CCD (+) CCD (-) DATA LINK CONNECTOR (PARTIAL) (ON LEFT BOTTOM OF DASH) DK BLU WIRE DK BLU/BLK WIRE DK GRN WIRE ENGINE CONTROL MODULE (ON LEFT SIDE OF ENGINE, BEHIND FUEL FILTER) FUSE 14 FUSE 9 GRY WIRE GRY/BLK WIRE HOT AT ALL TIMES HOT IN RUN OR START INSTRUMENT CLUSTER JOINT CONNECTOR 1 (IN PDC) JOINT CONNECTOR 7 JUNCTION BLOCK (ON LEFT END OF DASH) LT GRN WIRE LT GRN/BLK WIRE LT GRN/WHT WIRE O/D IND ORG/ WIRE ORG/BLK WIRE ORG/DK BLU WIRE ORG/WHT WIRE OUTPUT SPEED SENSOR (ON LEFT SIDE OF TRANSMISSION) OVERDRIVE SWITCH PNK WIRE PNK/DK BLU WIRE POWERTRAIN CONTROL MODULE (IN ENGINE COMPT, ON RIGHT SIDE OF FIREWALL) RED/WHT WIRE SWITCH TAN/BLK WIRE VIO WIRE VIO/BRN WIRE VIO/WHT WIRE WHT WIRE WHT/BLK WIRE WHT/ORG WIRE WHT/PNK WIRE WHT/VIO WIRE YEL WIRE

5 VOLT SUPPLY 9 10 11 PNK WIRE BLK WIRE BLK/LT BLU WIRE BLK/WHT WIRE BRN WIRE CONTROLLER ANTI- LOCK BRAKE (RWABS: ON LEFT FRONT INNER FENDER; DK BLU WIRE ENGINE CONTROLS SYSTEM ENGINE STARTER MOTOR RELAY FUSE FUSE 3 GENERATOR GRN WIRE HOT AT ALL TIMES JOINT CONNECTOR 2 LT BLU WIRE LT GRN/WHT WIRE ORG/ WIRE ORG/BLK WIRE OVERDRIVE SOLENOID PARK/NEUTRAL POSITION SWITCH (ON LEFT SIDE OF TRANSMISSION) PNK WIRE POWER DISTRIBUTION CENTER RED WIRE RED/WHT WIRE SENSOR GROUND GOVERNOR PRESSURE SIGNAL TAN/BLK WIRE TOP OF HYDRAULIC CONTROL UNIT) TORQUE CONVERTER CLUTCH SOLENOID TRANS CTRL RLY OUTPUT TRANSMISSION CONTROL RELAY TRANSMISSION SOLENOID ASSEMBLY (ON LEFT SIDE OF TRANSMISSION) TRANSMISSION TEMPERATURE SENSOR SIGNAL VARIABLE FORCE SOLENOID VIO WIRE VIO/WHT WIRE WHT WIRE WHT/ORG WIRE YEL WIRE

1 2 CCD BUS (+) CCD BUS (-) 14 16 17 MUX CTRL CCD (+) CCD (-) ANTENNA BLK WIRE BLK/LT GRN WIRE BLK/VIO WIRE BLK/YEL WIRE BRN/LT BLU WIRE BRN/RED WIRE BRN/YEL WIRE CENTRAL TIMER MODULE (LEFT SIDE OF DASH, INBOARD OF STEERING COLUMN OPENING) CLOCK SPRING 1 DK BLU WIRE DK BLU/ORG WIRE DK BLU/RED WIRE DK BLU/WHT WIRE DK GRN WIRE FUSE 12 FUSE 8 HOT AT ALL TIMES HOT IN RUN OR ACC JOINT CONNECTOR 5 (LEFT SIDE OF DASH) JOINT CONNECTOR 6 (LEFT SIDE OF DASH) JOINT CONNECTOR 7 (BEHIND LEFT SIDE OF DASH) JUNCTION BLOCK (LEFT END OF DASH) LEFT FRONT DOOR SPEAKER LEFT REAR SPEAKER LEFT REMOTE RADIO SWITCH LF SPKR (-) RF SPKR (-) DAY SENSE ILLUMINATION FUSED IGN FUSED B(+) LR SPKR (+) RR SPKR (+) LF SPKR (+) RF SPKR (+) LR SPKR (-) RR SPKR (-) NCA WIRE ORG/ WIRE PNK WIRE PRESET RADIO RED WIRE RED/BLK WIRE RED/WHT WIRE RIGHT FRONT DOOR SPEAKER RIGHT REAR SPEAKER SEEK DN SEEK UP VIO WIRE VIO/BRN WIRE VOL DN RIGHT REMOTE RADIO SWITCH VOL UP WHT WIRE WHT/BLK WIRE

9 10 11 12 13 14 KEY-IN IGN SW WSHR SW SENSE WPR PARK SW WPR SW SIG BASE MIDLINE BATTERY BLK WIRE BLK/LT BLU WIRE BLK/LT GRN WIRE BLK/ORG WIRE BLK/RED WIRE BRN WIRE CCD BUS (+) CCD BUS (-) HORN RLY CTRL CENTRAL TIMER MODULE (LEFT SIDE OF DASH) DATA LINK CONNECTOR (LEFT BOTTOM OF DASH) DK BLU WIRE DK BLU/RED WIRE DK BLU/WHT WIRE DK GRN WIRE DOOR LOCKS SYSTEM DOOR LOCKS SYSTEM INTERIOR LIGHTS SYSTEM DOOR LOCKS SYSTEM SOUND SYSTEM FUSE 11 FUSE 6 HORNS SYSTEM HOT AT ALL TIMES HOT IN ACC OR RUN HOT IN RUN OR START IGN RUN/ACCY IGN RUN/START INTERIOR LIGHTS SYSTEM WARNING SYSTEMS J/C 5 (LEFT SIDE OF DASH) J/C 7 (LEFT KICK PANEL) JUNCTION BLOCK (LEFT END OF DASH) FUSE 13 LT BLU WIRE LT GRN WIRE LT GRN/ORG WIRE ORG/ WIRE ORG/BLK WIRE ORG/DK GRN WIRE PASS DR LK MTR RADIO CTRL MUX PNK/BLK WIRE PNK/DK GRN WIRE PNK/LT BLU WIRE RED WIRE RED/BLK WIRE RED/DK BLU WIRE TAN WIRE VIO WIRE VIO/BRN WIRE WARNING SYSTEMS WHT WIRE WHT/BLK WIRE WHT/DK BLU WIRE WIPER/ WASHER SYSTEM WIPER/WASHER SYSTEM YEL/DK GRN WIRE

AFTER- MARKET RIGHT TRAILER LICENSE TOW LAMP CONNECTOR AIR BAG WINDSHIELD CONTROL WIPER MODULE MOTOR BLK WIRE BLOWER FUEL MOTOR HEATER RELAY RELAY BLU WIRE BRAKE PRESSURE SWITCH CLOCK- SPRING CONTROLLER ANTI-LOCK BRAKE DAYTIME RUNNING LAMP (DRL) MODULE DIESEL DIESEL DUAL REAR WHEELS FUEL PUMP MODULE FUEL PUMP RELAY GRN WIRE HIGH NOTE HORN J/C 1 (IN POWER DISTRIBUTION CENTER) J/C 6 (LEFT SIDE OF DASH) J/C 8 (CENTER OF DASH) LEFT BACK-UP LAMP LEFT LEFT LICENSE LICENSE LAMP LAMP LEFT LICENSE LAMP LEFT PARK/TURN SIGNAL LAMP LEFT REMOTE RADIO SWITCH LEFT RIGHT RADIO FRONT FRONT CHOKE DOOR DOOR RELAY SPEAKER SPEAKER LEFT TAIL/ STOP/TURN SIGNAL LAMP LOW NOTE HORN LT PNK WIRE NCA WIRE OTHER OTHER AFTER- MARKET PASSENGER AIR BAG ON/OFF SWITCH PNK WIRE POWER DISTRIBUTION CENTER PREMIUM QUAD HIGH BEAM RELAY RADIO RIGHT BACK-UP LAMP RIGHT PARK/TURN SIGNAL LAMP RIGHT REMOTE RADIO SWITCH RIGHT RIGHT REAR REAR FENDER FENDER LAMP LAMP RIGHT TAIL/ STOP/TURN SIGNAL LAMP SECURITY RELAY SWITCH TAILGATE TAILGATE LAMP LAMP TRAILER TOW CONNECTOR TRAILER TOW RELAY UNDERHOOD LAMP VEHICLE SPEED CONTROL SERVO VIO WIRE WASHER FLUID LEVEL SWITCH WINDSHIELD WASHER PUMP

BASE MIDLINE BATTERY BLK/LT BLU WIRE BLK/LT GRN WIRE BRN WIRE DK BLU (OR DK BLU/WHT) WIRE DK BLU WIRE DK BLU/RED WIRE DK GRN WIRE FUSE 11 FUSE 13 FUSE 6 HOT AT ALL TIMES HOT IN ACC OR RUN HOT IN RUN OR START IGNITION KEY-IN IGN SW WSHR SW SENSE WPR PARK SW WPR SW SIG INTEGRATED ELECTRONIC MODULE (LEFT SIDE OF DASH) INTERIOR LIGHTS SYSTEM WARNING SYSTEMS JUNCTION BLOCK (LEFT END OF DASH) LT BLU WIRE RED WIRE TAN WIRE VIO WIRE WARNING SYSTEMS WHT WIRE WHT/DK BLU WIRE WIPER/ WASHER SYSTEM WIPER/WASHER SYSTEM YEL/DK GRN WIRE

1 2 CCD BUS (+) CCD BUS (-) 14 16 17 MUX CTRL CCD (+) CCD (-) AMP L REAR SPKR (+) AMP R REAR SPKR (-) AMP TWEETER SPKR (+) ANTENNA BLK WIRE BLK/LT GRN WIRE BLK/RED WIRE BLK/VIO WIRE BLK/YEL WIRE BRN/LT BLU WIRE BRN/RED WIRE BRN/YEL WIRE CENTRAL TIMER MODULE (LEFT SIDE OF DASH, INBOARD OF STEERING COLUMN OPENING) CLOCK SPRING 1 DK BLU WIRE DK BLU/ORG WIRE DK BLU/RED WIRE DK BLU/WHT WIRE DK GRN WIRE FUSE 12 FUSE 4 FUSE 8 GRN WIRE GROUND HOT AT ALL TIMES HOT IN RUN OR ACC JOINT CONNECTOR 5 (LEFT SIDE OF DASH) JOINT CONNECTOR 6 (LEFT SIDE OF DASH) JOINT CONNECTOR 7 (BEHIND LEFT SIDE OF DASH) JUNCTION BLOCK (LEFT END OF DASH) L FRONT SPKR - L REAR SPKR - LEFT FRONT DOOR SPEAKER LEFT REAR SPEAKER LEFT REMOTE RADIO SWITCH LEFT TWEETER SPEAKER LF SPKR (-) RF SPKR (-) DAY SENSE ILLUMINATION FUSED IGN FUSED B(+) LT BLU/BLK WIRE LT BLU/RED WIRE LT GRN WIRE NCA WIRE ORG/ WIRE PNK WIRE PRESET R FRONT SPKR - R REAR SPKR - RADIO RADIO CHOKE RADIO CHOKE RELAY (BEHIND CENTER OF DASH) RED WIRE RED/BLK WIRE RED/WHT WIRE RIGHT FRONT DOOR SPEAKER RIGHT REAR SPEAKER RIGHT TWEETER SPEAKER SEEK DN SEEK UP TAN/BLK WIRE TAN/VIO WIRE VIO WIRE VIO/BRN WIRE VOL DN RIGHT REMOTE RADIO SWITCH VOL UP WHT WIRE WHT/BLK WIRE WHT/DK GRN WIRE WHT/VIO WIRE YEL/BLK WIRE YEL/RED WIRE

32 33 34 PNK WIRE 5.2L, 5.9L ONLY AUTOMATIC SHUTDOWN RELAY BLK/GRY WIRE BLK/LT BLU WIRE BLK/RED WIRE BLK/TAN WIRE BLK/WHT WIRE BRN WIRE BRN/DK BLU WIRE BRN/WHT WIRE CALIF CAM POS SNS IDLE AIR 1 IDLE AIR 4 CONTROLLER ANTI-LOCK BRAKE DISTRIBUTOR DK BLU/BLK WIRE DK BLU/YEL WIRE DK GRN WIRE DK GRN/BLK WIRE DK GRN/ORG WIRE DK GRN/RED WIRE FUEL INJECTORS FUEL PUMP RELAY FUSED B(+) TPS SENS IN GEN FIELD DRV TCC DRVR INJ 6 DRIVER INJ 8 DRIVER GROUND GROUND GRY WIRE GRY/BLK WIRE GRY/LT BLU WIRE GRY/ORG WIRE GRY/RED WIRE HOT IN RUN OR START IAT SENS IN ECT SENS IN IDLE AIR 2 IDLE AIR 3 IGN (POWER) INJ 1 DRIVER INJ 3 DRIVER INJ 5 DRIVER INJ 2 DRIVER INJ 4 DRIVER JUNCTION BLOCK (ON LEFT ENG OF DASH) FUSE 9 LT BLU/BRN WIRE LT GRN/BLK WIRE LT GRN/RED WIRE LT GRN/WHT WIRE MAP SENS IN NCA WIRE OIL PRESS SIG ORG/ WIRE ORG/BLK WIRE ORG/DK BLU WIRE ORG/TAN WIRE OUTPUT SENS OUTPUT SPEED SENSOR (ON LEFT SIDE OF TRANSMISSION) OVERDRV SOL PARK/NEUTRAL POSITION SWITCH (ON LEFT SIDE OF TRANSMISSION) PNK WIRE POWER TAKE OFF SWITCH (5.2L/5.9L) POWERTRAIN CONTROL MODULE (IN ENG COMPT, ON RIGHT SIDE OF FIREWALL) PRK/NEUTRAL COIL DRIVER CRNK POS SNS PTO SW SENS RED/LT BLU WIRE RED/WHT WIRE SENSOR GRD STARTING/ CHARGING SYSTEM TAN WIRE TAN/BLK WIRE TAN/WHT (OR BLK/DK GRN) WIRE TAN/WHT WIRE TAN/YEL WIRE VAR FRCE SOL VIO WIRE VIO/BLK WIRE VIO/TAN WIRE VIO/WHT WIRE VSS IN OUTPUT SENS GOV PRESS SIG TRANS RELAY WHT/DK BLU WIRE WHT/ORG WIRE YEL/BLK WIRE YEL/WHT WIRE

BLK/LT BLU WIRE BLK/RED WIRE BRN WIRE BRN/WHT WIRE CALIF CRANKSHAFT POSITION SENSOR (RIGHT REAR OF ENG BLOCK) DK BLU/YEL WIRE DK GRN/BLK WIRE DK GRN/ORG WIRE DK GRN/PNK WIRE DK GRN/RED WIRE DK GRN/WHT WIRE DK GRN/YEL WIRE ENGINE COOLANT TEMPERATURE SENSOR (IN WATER JACKET AT FRONT OF INTAKE MANIFOLD) ENGINE OIL PRESSURE SENSOR (NEAR DISTRIBUTOR) EXCEPT CALIF CALIF FUSE FUSE 3 FUSE 6 GRY/BLK WIRE GRY/ORG WIRE GRY/RED WIRE HOT AT ALL TIMES IAC MTR 1 IAC MTR 2 IAC MTR 3 IAC MTR 4 IDLE AIR CONTROL MOTOR (ON THROTTLE BODY) LT GRN/RED WIRE LT GRN/WHT WIRE MANIFOLD ABSOLUTE PRESSURE SENSOR (ON THROTTLE BODY) ORG/ WIRE ORG/BLK WIRE ORG/DK BLU WIRE ORG/TAN WIRE OXYGEN SENSOR DOWNSTREAM RELAY PNK WIRE RED/LT BLU WIRE RED/WHT WIRE TAN/BLK WIRE TAN/WHT (OR BLK/DK GRN) WIRE TAN/YEL WIRE VIO WIRE VIO/BLK WIRE VIO/WHT WIRE YEL/BLK WIRE

1/1 (LEFT BANK UP) (5.9L H/D, 5.2L/5.9L CALIF) 1/1 (UPSTREAM) (3.9L, 5.2L, 5.9L) 1/2 (LEFT BANK DN) (5.2L/5.9L CALIF) BLK WIRE BLK/LT BLU WIRE BLK/RED WIRE BLK/WHT WIRE BRN WIRE BRN/VIO WIRE BRN/WHT WIRE CALIF CALIF: ON RIGHT EXHAUST DOWNPIPE, BEFORE MINI- CATALYTIC CONVERTER) CAMSHAFT POSITION SENSOR (IN DISTRIBUTOR) DK BLU/WHT WIRE DK BLU/YEL WIRE DK GRN WIRE DK GRN/BLK WIRE DK GRN/ORG WIRE DK GRN/PNK WIRE DK GRN/WHT WIRE DK GRN/YEL WIRE EXCEPT CALIF FUEL PUMP MODULE (TOP OF FUEL TANK) FUEL PUMP RLY OUT (B+) GOV PRESS SIG GROUND HEATED OXYGEN SENSOR HEATED OXYGEN SENSOR 1/2 (DOWNSTREAM) (3.9L, 5.2L, 5.9L) HEATED OXYGEN SENSOR 2/2 (RIGHT BANK DOWN) (5.2L/5.9L CALIF) INTAKE AIR TEMPERATURE SENSOR (IN RIGHT FRONT SIDE OF INTAKE MANIFOLD) LT GRN/RED WIRE LT GRN/WHT WIRE NCA WIRE ORG/ WIRE ORG/BLK WIRE ORG/DK BLU WIRE ORG/TAN WIRE OTHERS OVERDRV SOL PNK 6 7 WIRE PNK WIRE RED WIRE SENSOR GRD SENSOR RETURN SENSOR SIG TAN/WHT (OR BLK/DK GRN) WIRE TAN/WHT WIRE TAN/YEL WIRE TCC SOL. CTRL THROTTLE POSITION SENSOR (ON THROTTLE BODY) TRANS RLY OUT TRANS TEMP SNS TRANSMISSION SOLENOID ASSEMBLY (AT LEFT SIDE OF TRANSMISSION) VAR FORCE SOL VIO WIRE VIO/WHT WIRE WHT WIRE