Dodge Pickup R3500 (1996-2010) totally integrated Wiring diagrams

1 2 3 4 D DR AJAR LR DR AJAR RR DR AJAR P DR AJAR 18 17 CAN B BUS(-) CAN B BUS(+) AAT RTN B(+) BLK WIRE BLK/GRY WIRE CAB CHASSIS) CAN B CLUSTER COM-LIN TIRE PRESS COMPUTER DATA HEADLIGHTS LINES SYSTEM SYSTEM COMPUTER DATA LINES SYSTEM DIESEL GAS DRIVER DOOR LATCH (LEFT FRONT DOOR) ELECTRONICS FUSE 11 FUSE 2 FUSED B (+) FUSED HOOD IGN SW AJAR OUTPUT SWITCH (RUN-START) SENSE FUSED IGN SW OUT GRY/LT BLU WIRE GRY/RED WIRE GRY/YEL WIRE HOOD AJAR SWITCH HORN CONTROL OUTPUT HORNS SYSTEM HOT AT ALL TIMES IGN SW SENS IGNITION SWITCH LEFT FRONT TIRE PRESSURE TRANSPONDER LT GRN/BLK WIRE PASSENGER DOOR LATCH PICK-UP PNK/WHT WIRE POWER LOCKS POWER MODULE (LEFT FRONT FENDER) RED WIRE RIGHT FRONT TIRE PRESSURE TRANSPONDER (RIGHT SIDE OF ENGINE COMPT) TOTALLY INTEGRATED VIO WIRE VIO/BRN WIRE VIO/GRY WIRE VIO/LT BLU WIRE VIO/TAN WIRE VIO/WHT WIRE VIO/YEL WIRE WHT WIRE WHT/GRY WIRE WHT/LT GRN WIRE WHT/ORG WIRE WIRELESS CONTROL MODULE

3 1 BTSI SOL ULK TRS RNG PRK ABMT TEMP/FCM SSR RTN 1 AMBIENT AIR TEMPERATURE SENSOR (LEFT FRONT OF ENGINE COMPT) BATT FEED BLK WIRE BLK/WHT WIRE BRAKE TRANSMISSION SHIFT INTERLOCK SOLENOID BRN/YEL WIRE BUS BAR CIRCUIT FT BOARD DRV DR ULK DIODE DK GRN WIRE DOOR LOCK RELAY DR AJAR LT RR SIG DR AJAR RT RR SIG DR LK LT FT DR LK RT FT DR ULK RT FT DRIVER DOOR LATCH DRIVER DOOR UNLOCK RELAY DRV DR AJAR SW SNS DRV FT DR AJAR SW IN DRV RR UNLK CTRL FRONT WASHER FLUID LEVEL SENSOR FT LT DR ULK FUSE FUSE FUSE GRY/LT BLU WIRE GRY/YEL WIRE HOOD ABMT/ AJAR FCM SW SSR SNS RTN 1 HOOD AJAR SWITCH (LEFT FRONT OF ENGINE COMPT) HORN RELAY HORN RLY COIL DRV HORN SW SIG HORNS SYSTEM HOT AT ALL TIMES LEFT REAR DOOR LATCH (EXCEPT REGULAR CAB) LT GRN/GRY WIRE LT RR LK LT RR ULK PASS DR DR LOCK AJAR RLY SW SNS CTRL PASS FT DR AJAR SW IN PASSENGER DOOR LATCH PASSENGER DOOR UNLOCK RELAY POWER MODULE (LEFT FRONT OF ENGINE COMPT) RIGHT REAR DOOR LATCH (EXCEPT REGULAR CAB) RT RR LK RT RR LT RR DR DR AJAR AJAR SIG SIG RT RR ULK TAN/BRN WIRE TAN/DK BLU WIRE TAN/LT BLU WIRE TAN/LT GRN WIRE TAN/ORG WIRE TAN/VIO WIRE TAN/WHT WIRE TOTALLY INTEGRATED VIO WIRE VIO/BRN WIRE VIO/GRY WIRE VIO/LT BLU WIRE VIO/WHT WIRE VIO/YEL WIRE YEL/DK BLU WIRE

1 2 ANT SIG ANT SHLD BLK/ORG WIRE COMPUTER DATA LINES SYSTEM DK GRN/GRY WIRE DK GRN/LT GRN WIRE DK GRN/VIO WIRE DK GRN/YEL WIRE FUSE POWER MODULE (LEFT FRONT OF ENGINE COMPT) GRY/DK GRN WIRE GRY/LT GRN WIRE GRY/VIO WIRE GRY/YEL WIRE HOT AT ALL TIMES LEFT FRONT DOOR SPEAKER LEFT INSTRUMENT PANEL SPEAKER LEFT REAR SPEAKER LR SPEAKER (+) LR SPEAKER (-) RR SPEAKER (+) RR SPEAKER (-) GND CAN IHS BUS (+) RADIO RADIO ANTENNA RED WIRE RF SPEAKER (+) RF SPEAKER (-) LF SPEAKER (+) LF SPEAKER (-) RIGHT FRONT DOOR SPEAKER RIGHT INSTRUMENT PANEL SPEAKER RIGHT REAR SPEAKER TOTALLY INTEGRATED WHT/GRY WIRE WHT/ORG WIRE WHT/YEL WIRE YEL WIRE YEL/RED WIRE

10 11 CAN B BUS (+) CAN B BUS (-) 11 12 CAN B BUS (-) CAN B BUS (+) 14 4 CAN B BUS (+) CAN B BUS (-) 16 15 CAN B BUS (+) CAN B BUS (-) 17 18 CAN B BUS(+) CAN B BUS(-) 2 3 3 18 CAN C BUS (+) CAN C BUS (-) 20 21 CAN C BUS (+) CAN C BUS (-) 3 4 CAN B BUS (+) CAN B BUS (-) 34 35 CAN C BUS (+) CAN C BUS (-) 4 3 CAN B BUS (-) CAN B BUS (+) 4 5 1 21 CAN C BUS (+) CAN C BUS (-) 5 4 CAN B BUS (-) CAN B BUS (+) 5 6 CAN B BUS (+) CAN B BUS (-) 6 17 CAN B BUS (+) CAN B BUS (-) 6 7 2 CAN B BUS (+) CAN B BUS (-) COM-LIN TIRE 6.7L DIESEL 5.9L DIESEL A/C HEATER CONTROL ANTI-LOCK BRAKES MODULE (LEFT REAR OF AWAL RWAL B(+) BLK/LT GRN WIRE BLK/WHT WIRE CAN B BUS (+) CAN C (-) DIAGNOSTIC CAN C BUS (+) CAN C BUS (+) CAN C BUS (-) CLUSTER COM-LIN TIRE PRESS MONI LAN DIESEL ELECTRONIC OVERHEAD MODULE (EXCEPT BASE) ELECTRONICS ENGINE COMPT) ENGINE CONTROL MODULE (LOWER LEFT FRONT OF ENGINE BLOCK) FINAL DRIVE CONTROL MODULE (POWER WAGON) (RIGHT FRONT OF ENGINE COMPT) FUSE 11 GAS GRY/RED WIRE HANDS FREE MODULE (RIGHT SIDE OF DASH) HOT AT ALL TIMES LEFT FRONT TIRE PRESSURE TRANSPONDER MONITOR/DVD MEDIA SYSTEM OCCUPANT RESTRAINT CONTROLLER MODULE (CENTER FRONT OF BODY) POWER MODULE (LEFT FRONT FENDER) POWERTRAIN CONTROL MODULE (RIGHT REAR OF RADIO RADIO AMPLIFIER (PREMIUM) (RIGHT SIDE OF DASH) RIGHT FRONT TIRE PRESSURE TRANSPONDER (RIGHT SIDE OF ENGINE COMPT) SATELLITE RECEIVER (PREMIUM) SUNROOF MOTOR/MODULE (DVD) (SUNROOF MOTOR: CENTER OF HEADLINER) TOTALLY INTEGRATED TRANSMISSION CONTROL MODULE (RC) WHT WIRE WHT/BRN WIRE WHT/GRY WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE WHT/ORG WIRE WIRELESS CONTROL MODULE

1 2 3 4 5 6 DSL HIGH SIDE DRVR RTN ENG CTRL COM SNSR RTN RAD FAN MTR SPD SIG 30 53 17 ENG CTRL COM SNSR RTN ENG CTRL COM SNSR RTN 4 RAD FAN MTR SPD SIG A/C PRESS PRESS SNS SNS SIG RTN FD A/C PRESS SIG A/C PRESS SNSE RTN A/C PRESS SNSR FD A/C PRESSURE TRANSDUCER BLK WIRE BLK/LT BLU WIRE BRN/LT BLU WIRE BRN/ORG WIRE BRN/PNK WIRE BRN/WHT WIRE BUS (-) CAN COMPUTER DATA LINES SYSTEM DK BLU/DK GRN WIRE DK BLU/GRY WIRE DK GRN/DK BLU WIRE ENGINE CONTROLS SYSTEM ENGINE COOLANT TEMPERATURE SENSOR FAN RADIATOR FUSE HALLEFCT ELECN ENG SPD OUT HALLEFCT ELECN ENG SPD OUT ENG CTRL COM SNSR RTN 2 COOL TEMP SNSR SIG HOT AT ALL TIMES IGN ULK/RUN/STRT 16 33 6 LT BLU/BRN WIRE LT BLU/ORG WIRE PNK/WHT WIRE PNK/YEL WIRE POWER MODULE (LEFT FRONT OF ENGINE COMPT) CIRCUIT BOARD POWERTRAIN CONTROL MODULE PRESS. RAD FAN HI SPD SIG RAD FAN LOW SPD SIG RADIATOR FAN DRIVE RADIATOR FAN HIGH RELAY RADIATOR FAN LOW RELAY RUN/START TOTALLY INTEGRATED VIO/ORG WIRE WHT/DK BLU WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE

1 2 3 4 5 6 7 8 9 10 LIN BUS LIN BUS RTN EC MRR RTN 1 2 3 4 5 6 7 8 9 10 MRR PDDLE LMP DRV MRR TURN PUDDLE BATT FD DRIV BATT FD DRIV 1 2 3 4 5 6 7 8 9 10 BLK WIRE BLK/DK GRN WIRE BLK/GRY WIRE BLK/ORG WIRE BRN WIRE BRN/BLK WIRE COMPUTER DATA LINES SYSTEM DK BLU WIRE DK GRN WIRE DK GRN/BLK WIRE DRIV HEATD MRR FD DRIV HEATD MRR RTN DRIV HEATD MRR FD DRIVER DOOR MODULE DRIVER OUTSIDE REARVIEW MIRROR DRIVER WINDOW DN DRIVER WINDOW MOTOR DRV MEM MRR VERT SNSE DRV MEM MRR SNSE COM DRV MEM MRR HORZ SNSE DRV MRR MEM HORZ SNSE DRV PWR MRR DRV WINDOW EC MRR RTN FUSE FUSE POWER MODULE (LEFT FRONT OF ENGINE COMPT) GRY WIRE GRY/BLK WIRE HOT AT ALL TIMES INSIDE REARVIEW MIRROR MEM SEL MUX MEM SEL MUX MEM SEL SNSE RTN MEM SEL SNSE RTN MEMORY SET SWITCH (IF EQUIPPED) MRR PDDLE LMP DRV MRR RTN DRIV HEATD MRR SIG OUTSDE EC MRR TURN MRR TURN PUDDLE RTN DRIV MTR COM MTR HORZ MTR VERT ORG/ WIRE ORG/LT GRN WIRE ORG/WHT WIRE RED WIRE RED/LT BLU WIRE RED/LT GRN WIRE RTN DRIV RTN DRIV 1 2 3 4 CAN IHS BUS (-) CAN IHS BUS (+) OUTSDE EC MRR SIG GND SENS RTN SENS SIG DRV WINDOW SENS SPLY DRV WINDOW SIG DRIV SNSE COM DRV MEM MRR TAN/ORG WIRE TAN/WHT WIRE TOTALLY INTEGRATED VERT SNSE DRV MEM MRR VIO WIRE VIO/BRN WIRE VIO/YEL WIRE WHT WIRE WHT/GRY WIRE WHT/LT GRN WIRE WHT/ORG WIRE WINDOW UP

5.7L POWER WAGON 6.7L DIESEL 6.7L DIESEL 5.7L GAS A/C PNK/ HEATER CONTROL WIRE A/T ANTI-LOCK BRAKES MODULE AUXILIARY BATTERY (DIESEL) AUXILIARY PDC BOX (LEFT REAR OF ENGINE COMPT) BASE BATTERY BENCH BLK WIRE BRN WIRE CIGAR LIGHTER CLUSTER CLUTCH INTERLOCK/ UPSTOP SWITCH CONSOLE CONSOLE POWER POWER OUTLET OUTLET (UPPER CONSOLE) DIESEL DK BLU WIRE DK GRN WIRE DK GRN/ORG WIRE DRIVER SEAT BELT TENSION REDUCER (STANDARD CAB) ENGINE COMPARTMENT UPFITTER ACCESSORIES EXCEPT 5.7L POWER WAGON EXCEPT BASE EXCEPT BASE TO SPLICE PNK/ (DIAGRAM 2 OF 3) WIRE EXCEPT BENCH EXCEPT RAM 2500 FINAL DRIVE CONTROL MODULE FINAL DRIVE CONTROL MODULE (5.7L OFF ROAD) FROM FUSE 4 (DIAGRAM 1 OF 3) B(+) FUSE FUSE 1 FUSE 2 FUSE 30 FUSE 33 FUSE 39 FUSE 4 (RAM 3500 (CAB CHASSIS)) FUSE 40 FUSE 9 (POWER WAGON) FUSED B (+) FUSED IGNITION SWITCH OUTPUT (RUN) FUSED IGNITION SWITCH OUTPUT (RUN-ACC) FUSED IGNITION SWITCH OUTPUT (RUN-START) FUSIBLE LINK (10 GA- FUSIBLE LINK (16 GA- FUSIBLE LINK (8 GA- GAS GENERATOR GROUND GRY/PNK WIRE IGN SW RUN INSTRUMENT PANEL POWER OUTLET INTAKE AIR HEATER MODULE RELAY (6.7L DIESEL, (DIESEL) EXCEPT SHIFT ON THE FLY) JUMPER KIT UPFITTER ACCESSORIES LEFT CHASSIS LT BLU WIRE LT GRN WIRE M/T (LEFT REAR OF ENGINE 6.7L COMPT) (6.7L DIESEL) DIESEL ORG/ WIRE ORG/LT GRN WIRE PNK PNK WIRE PNK UPFITTER ACCESSORIES WIRE PNK WIRE PNK/RED WIRE PNK/YEL WIRE POWER MODULE (LEFT FRONT FENDER) POWER MODULE (LEFT FRONT FENDER) ELECTRONICS POWERTRAIN CONTROL MODULE RADIATOR FAN DRIVE (5.9L) RAM 2500 REAR OF ENGINE COMPT) RED WIRE RED/YEL WIRE STANDARD QUAD CAB CAB STARTER SUNROOF MOTOR/ MODULE TO ELECTRONICS (DIAGRAM 1 OF 3) TO FUSE 11 (DIAGRAM 2 OF 3) TO FUSE 32 (DIAGRAM 3 OF 3) TOTALLY INTEGRATED TRANSMISSION CONTROL MODULE TRANSMISSION CONTROL MODULE (RC) VIO WIRE VIO/BRN WIRE VIO/YEL WIRE W/ HEATED SEATS WASTEGATE SOLENOID (5.9L) WINCH ASSEMBLY (POWER WAGON) YEL WIRE

2 OF 3) A/C HEATER CONTROL ANTI-LOCK BRAKES MODULE BASE BLK WIRE BRAKE PROVISION MODULE DATA LINK CONNECTOR DK GRN WIRE DRIVER HEATED SEAT SWITCH DRIVER WINDOW/ DOOR LOCK SWITCH ELECTRONIC OVERHEAD MODULE ENGINE CONTROL MODULE EXCEPT BASE FROM ELECTRONICS (DIAGRAM 1 OF 3) FROM FUSE 26 (DIAGRAM 2 OF 3) FROM TOTALLY INTEGRATED POWER MODULE (DIAGRAM 1 OF 3) FRONT FENDER) FUSE FUSE 11 FUSE 12 (TRAILER TOW) FUSE 22 FUSE 24 (RAM 3500) (CAB CHASSIS) FUSE 26 FUSE 42 (DIESEL) FUSE FUSE GRY WIRE HANDS EXCEPT FREE HANDS FREE HANDS SATELLITE FREE RECEIVER MODULE HEAVY DUTY LIGHT DUTY LT BLU WIRE MONITOR/ DVD MEDIA SYSTEM ORG/ WIRE PASSENGER DRIVER SEAT SWITCH SEAT SWITCH PASSENGER HEATED SEAT SWITCH POWER (NEAR ENGINE CONTROL MODULE) OUTLET POWER MODULE (LEFT FRONT FENDER) POWERTRAIN CLUSTER CONTROL MODULE RADIO RADIO AMPLIFIER (PREMIUM) RAM GAS (RIGHT REAR OF ENGINE (LEFT SIDE COMPT) OF DASH) RED WIRE SLT- SLT+ STOP LAMP SWITCH TAN WIRE TO FUSE 27 (DIAGRAM TO IGNITION SWITCH (DIAGRAM 3 OF 3) TOTALLY INTEGRATED TOTALLY INTEGRATED POWER MODULE (LEFT TRANSMISSION RELAY UNDERHOOD LAMP W/ HEATED SEATS W/ SATELLITE WIRELESS CONTROL CLUSTER MODULE (WCM) YEL WIRE

3 1 BTSI SOL ULK TRS RNG PRK ABMT TEMP/FCM SSR RTN 1 AMBIENT AIR TEMPERATURE SENSOR (LEFT FRONT OF ENGINE COMPT) BATT FEED BLK WIRE BLK/WHT WIRE BRAKE TRANSMISSION SHIFT INTERLOCK SOLENOID BRN/YEL WIRE BUS BAR CIRCUIT FT BOARD DRV DR ULK DIODE DK GRN WIRE DOOR LOCK RELAY DR AJAR LT RR SIG DR AJAR RT RR SIG DR LK LT FT DR LK RT FT DR ULK RT FT DRIVER DOOR LATCH DRIVER DOOR UNLOCK RELAY DRV DR AJAR SW SNS DRV FT DR AJAR SW IN DRV RR UNLK CTRL FRONT WASHER FLUID LEVEL SENSOR FT LT DR ULK FUSE FUSE FUSE GRY/LT BLU WIRE GRY/YEL WIRE HOOD ABMT/ AJAR FCM SW SSR SNS RTN 1 HOOD AJAR SWITCH (LEFT FRONT OF ENGINE COMPT) HORN RELAY HORN RLY COIL DRV HORN SW SIG HORNS SYSTEM HOT AT ALL TIMES LEFT REAR DOOR LATCH (EXCEPT REGULAR CAB) LT GRN/GRY WIRE LT RR LK LT RR ULK PASS DR DR LOCK AJAR RLY SW SNS CTRL PASS FT DR AJAR SW IN PASSENGER DOOR LATCH PASSENGER DOOR UNLOCK RELAY POWER MODULE (LEFT FRONT OF ENGINE COMPT) RIGHT REAR DOOR LATCH (EXCEPT REGULAR CAB) RT RR LK RT RR LT RR DR DR AJAR AJAR SIG SIG RT RR ULK TAN/BRN WIRE TAN/DK BLU WIRE TAN/LT BLU WIRE TAN/LT GRN WIRE TAN/ORG WIRE TAN/VIO WIRE TAN/WHT WIRE TOTALLY INTEGRATED VIO WIRE VIO/BRN WIRE VIO/GRY WIRE VIO/LT BLU WIRE VIO/WHT WIRE VIO/YEL WIRE YEL/DK BLU WIRE

ABMT TEMP/ CAN FCM BUS (-) ABMT TEMP/FCM B(+) BATTERY BLK WIRE BLK/LT GRN WIRE BRN WIRE CAN CAN BUS (-) BUS (+) CAN-BUS CHARGING CIRCUIT CIRCUIT BOARD COMPUTER DATA LINES SYSTEM DK BLU WIRE DK GRN WIRE FUSE GRY WIRE HOLD-IN HOOD AJAR SWITCH (LEFT FRONT OF ENGINE COMPT) HOT AT ALL TIMES IGN RUN ST IGN SW FD LT BLU WIRE LT BLU/RED WIRE LT GRN WIRE ORG/ WIRE PNK WIRE PNK/TAN WIRE POWER MODULE (LEFT FRONT OF ENGINE COMPT) POWERTRAIN CONTROL MODULE (LEFT REAR OF ENGINE) PRK NEUT SIG PRK/NEUT SIG PULL- IN RED WIRE STARTER STARTER RELAY STARTER RLY COIL STARTER RLY RTN TOTALLY INTEGRATED TRANSMISSION SOLENOID/TRS ASSEMBLY (LEFT SIDE OF TRANSMISSION) UHOOD SW SIG VIO WIRE VIO/BRN WIRE VIO/LT BLU WIRE WHT WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE WIRELESS IGNITION NODE YEL WIRE YEL/DK BLU WIRE