Dodge Pickup R3500 (1996-2010) tan/red Wiring diagrams

1 2 3 4 GROUND PANEL LAMPS DRIVER ESP ON/OFF SENSE SENSOR GROUND 1 2 3 6 IGN SW OUT (RUN-START) DYNAMICS HIGH DATA DYNAMICS LOW DATA GROUND 17 18 10 CAN B BUS (+) CAN B BUS (-) SENSOR GROUND 35 34 CAN C BUS (-) CAN C BUS (+) 43 44 45 46 RH RR WHEEL SPD SENS (+) RH RR WHEEL SPD SENS (-) GROUND 5.9L 6.7L ANTI-LOCK BRAKES MODULE (LEFT REAR OF ENGINE COMPT) B(+) BLK WIRE BLK/DK GRN WIRE BLK/LT GRN WIRE BLK/ORG WIRE BLK/PNK WIRE BRAKE FLUID LEVEL SENSOR (LEFT REAR OF ENGINE COMPT) BRAKE SWITCH 1 SIGNAL BRAKE SWITCH 1 SIGNAL CAN C BUS (+) BRK FLUID LEVEL SW SENSE CAN B CAN B BUS (+) BUS (-) CAN C BUS (+) CAN C CAN C BUS (+) BUS (-) CLUSTER COMPUTER DATA LINES SYSTEM DIESEL DK DK DK GRN WIRE DK GRN/BRN WIRE DK GRN/LT BLU WIRE DK GRN/LT GRN WIRE DK GRN/ORG WIRE DK GRN/RED WIRE DK GRN/TAN WIRE DK GRN/VIO WIRE DK GRN/WHT WIRE DK GRN/YEL WIRE DYNAMICS SENS HIGH DATA DYNAMICS SENS LOW DATA DYNAMICS SENSOR (W/ ESP) (UNDER FRONT OF CENTER CONSOLE) ELECTRONICS ENGINE CONTROL MODULE (LOWER LEFT FRONT OF ENGINE BLOCK) ESP ON/OFF SENSE ESP SWITCH (IF EQUIPPED) FUSE 13 FUSE 18 FUSE 28 FUSE 30 FUSED B (+) CAN C BUS + FUSED B (+) IGN SW OUT (RUN-START) FUSED IGN SW OUT (RUN-START) GAS GRN WIRE GRN/GRY WIRE GROUND GRY WIRE HOT AT ALL TIMES HOT IN RUN OR START IGN SW OUT (RUN-START) CAN C BUS (+) CAN C BUS (-) GROUND LEFT FRONT ABS WHEEL SPEED SENSOR (LEFT REAR OF ENGINE COMPT) LEFT REAR ABS WHEEL SPEED SENSOR LF WHEEL SPD SENSOR (+) LF WHEEL SPD SENSOR (-) LT BLU WIRE LT GRN WIRE ORG/ WIRE ORG/DK BLU WIRE PANEL LAMPS DRIVER PNK WIRE PNK/ (EXCEPT ESP/5.7L POWER WAGON, 6.7L EXCEPT SHIFT ON THE FLY) WIRE PNK/GRY WIRE PNK/LT GRN WIRE POWERTRAIN CONTROL MODULE (RIGHT REAR OF ENGINE COMPT) REAR ABS WHEEL SPEED SENSOR (W/O ESP) (NEAR RIGHT REAR FRAME RAIL) RED WIRE RF WHEEL SPD SENSOR (+) RF WHEEL SPD SENSOR (-) RIGHT FRONT ABS WHEEL SPEED SENSOR (ON KNUCKLE SPINDLE ASSEMBLY) RIGHT REAR ABS WHEEL SPEED SENSOR (W/ ESP) (AT RIGHT REAR WHEEL ASSEMBLY) STEERING ANGLE SENSOR (W/ ESP) STOP LAMP SWITCH (ON BRAKE PEDAL SUPPORT) TAN WIRE TAN/RED WIRE TOTALLY INTEGRATED POWER MODULE (AT LEFT FRONT FENDER) TRAILER TOW DAMPING RLY CTRL VIO WIRE VIO/DK BLU WIRE W/ ESP W/O ESP WHT WIRE WHT/GRY WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE WHT/ORG WIRE YEL WIRE

AIRBAG CONTROL MODULE (LOWER CENTER OF DASH) BLK WIRE BLK/LT GRN WIRE BLK/PNK WIRE DK BLU WIRE DRIVER DOOR JAMB SWITCH PASS- ENGER SEAT SOLENOID DRIVER SEAT SOLENOID FAULT SIGNAL FUSE 12 FUSE 16 GROUND HOT AT ALL TIMES HOT IN ACC AND RUN J/C 5 (BEHIND LEFT SIDE OF DASH) JUNCTION BLOCK (RIGHT END OF DASH) LH DOOR AJAR RH DOOR AJAR FUSED IGN FUSED B(+) GROUND LH BELT SOL RH BELT SOL LT GRN WIRE LT GRN/BLK WIRE ORG/ WIRE ORG/BLK WIRE ORG/RED WIRE PAS- SENGER DOOR JAMB SWITCH PNK WIRE RED WIRE SEAT BELT CONTROL MODULE (UNDER FRONT SEAT CENTER CUSHION) TAN WIRE TAN/RED WIRE WARNING SYSTEMS

7-WAY TRAILER TOW WIRING A/C HEATER CONTROL ANTI-LOCK BRAKES MODULE AUXILIARY BATTERY (6.7L) BASE PREMIUM AUDIO AUDIO BATTERY BRN/RED WIRE BUS BAR CIRCUIT BOARD IOD FD CLUSTER COMPASS MODULE DK GRN WIRE DK GRN/RED WIRE DRIVER DOOR MODULE EXCEPT RAM BOX RAM BOX FUSE FUSE FUSE FUSE FUSE FUSE FUSIBLE LINK (8 GA- GENERATOR GENERATOR (EXCEPT 6.7L) GRY WIRE HANDS FREE MODULE INTAKE AIR HEATER RELAY LEFT BIN RIGHT BIN BRAKE STORAGE STORAGE PROVISION MODULE LT BLU RED/ WIRE LT BLU WIRE LT GRN/RED WIRE MULTI- FUNCTION SWITCH PASSENGER DOOR MODULE PASSENGER DOOR UNLOCK RELAY RADIATOR FAN HIGH RELAY RADIO RADIO, AMPLIFIER RED WIRE RED YEL/ WIRE RED/ LT BLU WIRE RED/ VIO WIRE RED/ WHT WIRE RED/LT BLU WIRE RED/LT GRN WIRE RED/VIO WIRE RED/WHT WIRE RED/YEL WIRE STARTER STARTER RELAY STOP LAMP SWITCH SUNROOF MODULE (IF EQUIPPED) TAN/RED WIRE TOTALLY INTEGRATED POWER MODULE TRANSMISSION CONTROL RELAY UNDERHOOD LAMP (IF EQUIPPED) VIDEO VIDEO SCREEN SATELLITE MODULE MODULE VIO RED/ WIRE VIO WIRE WHT RED/ WIRE WHT WIRE YEL/RED WIRE

1 2 3 4 5 6 7 8 TRANS RLY OUT A/C REQUEST A/C SELECT IN BRAKE SW IN GEN FIELD OUT A/T AIR CONDI- TIONING SYSTEM AUTO SHT RLY CRUISE VAC SOL CRUISE VNT SOL OVERDRV IND BATT TEMP SENS BLK/LT BLU WIRE BLK/LT GRN WIRE BLK/RED WIRE BRN WIRE CCD(-) CRUISE CONTROL SYSTEM CRUISE FEED ASD RELAY SENS TRANS OVERDRV CRUISE SW IN DATA LINK CONNECTOR (LEFT BOTTOM OF DASH) DK BLU/ORG WIRE DK BLU/WHT WIRE DK BLU/YEL WIRE DK GRN/ORG WIRE FUSE 17 FUSE M GENERATOR HOT AT ALL TIMES HOT AT ALL TIMES JUNCTION BLOCK (RIGHT END OF DASH) FUSE 14 HOT IN RUN OR START IND INSTRUMENT CLUSTER JOINT CONNECTOR 1 (IN PDC) JOINT CONNECTOR NO 6 (TOP OF STEERING COLUMN, BEHIND INSTRUMENT PANEL) 2 3 LT GRN WIRE LT GRN/ORG WIRE LT GRN/RED WIRE LT GRN/WHT WIRE M/T ORG/ WIRE ORG/BLK WIRE ORG/DK BLU WIRE ORG/WHT WIRE OVERDRIVE OFF IND OVERDRIVE SWITCH PNK 4 5 6 WIRE PNK WIRE PNK/DK BLU WIRE PNK/WHT WIRE PNK/YEL WIRE POWER DISTRIBUTION CENTER (IN ENG COMPT, ON LEFT INNER FENDER PANEL) POWERTRAIN CONTROL MODULE (IN ENG COMPT, ON RIGHT SIDE OF FIREWALL) RED WIRE RED/LT GRN WIRE SCI TRANSMIT CCD BUS (-) SCI RECEIVE CCD BUS (+) SENSOR GRD GOV PRESS SIG VAR FORCE SOL OVERDRV SOL TCC SOL CTRL TRANS TEMP SNS STOP LAMP SWITCH (ON BRAKE PEDAL BRACKET) TAN/RED WIRE THROTTLE POSITION SENSOR (ON TOP OF INJECTOR PUMP) TRANS- MISSION RELAY TRANSMISSION SOLENOID ASSEMBLY (ON LEFT SIDE OF TRANSMISSION) VIO WIRE VIO/BRN WIRE VIO/WHT WIRE WAIT TO WHT/BLK WIRE WHT/DK BLU WIRE WHT/PNK WIRE WHT/VIO WIRE YEL WIRE YEL/RED WIRE

1 2 3 4 5 6 7 8 TRANS RLY OUT 1 2 3 4 5 6 A/C CLUTCH RLY 31 32 GROUND GROUND A/T A/T (TRANS HARN, IN BREAKOUT TO PDC) AIR CONDI- TIONING SYSTEM AUTO SHT RLY CRUISE VAC SOL CRUISE VNT SOL AUTOMATIC SHUTDOWN RELAY BATTERY TEMPER- ATURE SENSOR (BELOW BATTERY TRAY) BLK WIRE BLK/LT BLU WIRE BLK/LT GRN WIRE BLK/TAN WIRE BLK/WHT WIRE BRAKE LAMP SWITCH (ON BRAKE PEDAL BRACKET) BRN WIRE CKP ENG SIG (PINS 9-21 NOT USED) 22 23 FUSED B(+) ACC PEDAL POS CONTROLLER ANTI-LOCK BRAKE CRUISE CONTROL SYSTEM CRUISE FEED ASD RELAY SENS TRANS OVERDRV 12 13 14 15 CRUISE SW IN DK BLU WIRE DK BLU/BLK WIRE DK BLU/ORG WIRE DK BLU/WHT WIRE DK BLU/YEL WIRE DK GRN WIRE DK GRN/ORG WIRE FUEL TANK MODULE (TOP OF FUEL TANK) FUSE 6 FUSE I GEN FIELD DRV TCC DRVR GENERATOR GRY/BLK WIRE HOT AT ALL TIMES IGN (POWER) JOINT CONNECTOR 1 (IN PDC) JOINT CONNECTOR 2 (IN PCD) LT BLU WIRE LT GRN/BLK WIRE LT GRN/RED WIRE LT GRN/WHT WIRE M/T ORG/ WIRE ORG/BLK WIRE ORG/DK BLU WIRE ORG/WHT WIRE OUTPUT SENS OUTPUT SPEED SENSOR (ON LEFT SIDE OF TRANSMISSION) OVERDRV SOL PARK/NEUTRAL POSITION SWITCH (ON LEFT SIDE OF TRANSMISSION) PNK WIRE PNK/DK BLU WIRE PNK/YEL WIRE POWERTRAIN CONTROL MODULE (IN ENG COMPT, ON RIGHT SIDE OF FIREWALL) PRK/NEUTRAL RED WIRE RED/LT BLU WIRE RED/LT GRN WIRE RED/WHT WIRE SENSOR GRD SENSOR GRD GOV PRESS SIG VAR FORCE SOL OVERDRV SOL TCC SOL CTRL TRANS TEMP SNS STARTING/ CHARGING SYSTEM TAN/RED WIRE TRANS- MISSION RELAY TRANSMISSION SOLENOID ASSEMBLY (ON LEFT SIDE OF TRANSMISSION) VAR FRCE SOL VIO WIRE VIO/BRN WIRE VIO/WHT WIRE VSS IN OUTPUT SENS GOV PRESS SIG TRANS RELAY WHT/BLK WIRE WHT/ORG WIRE WHT/PNK WIRE WHT/VIO WIRE YEL WIRE YEL/RED WIRE

1 2 3 4 5 6 7 8 TRANS RLY OUT AIR CONDI- TIONING SYSTEM AUTO SHT RLY CRUISE VAC SOL CRUISE VNT SOL BLK/LT BLU WIRE BLK/LT GRN WIRE BLK/RED WIRE BRN WIRE BRN/WHT WIRE CCD(-) CRUISE CONTROL SYSTEM CRUISE SW IN DATA LINK CONNECTOR (LEFT BOTTOM OF DASH) DK BLU WIRE DK BLU/ORG WIRE DK BLU/WHT WIRE DK BLU/YEL WIRE DK GRN WIRE DK GRN/ORG WIRE FUEL PMP RLY EVAP SOL DRVR FUSE 11 FUSE I GENERATOR HOT AT ALL TIMES HOT IN RUN OR START INSTRUMENT CLUSTER INTAKE AIR TEMPERATURE SENSOR (IN RIGHT FRONT SIDE OF INTAKE MANIFOLD) JOINT CONNECTOR 1 (IN PDC) JOINT CONNECTOR 11 9 2 14 6 5 JUNCTION BLOCK (RIGHT END OF DASH) LEAK DETECTION PUMP (RIGHT FRONT OF INNER FENDER) LT GRN/RED WIRE LT GRN/WHT WIRE NCA WIRE ORG/ WIRE ORG/BLK WIRE ORG/DK BLU WIRE ORG/WHT WIRE OVERDRIVE SWITCH PNK 1 2 WIRE PNK WIRE PNK/DK BLU WIRE PNK/WHT WIRE PNK/YEL WIRE POWER DISTRIBUTION CENTER (IN ENG COMPT, ON LEFT INNER FENDER PANEL) POWERTRAIN CONTROL MODULE (IN ENG COMPT, ON RIGHT SIDE OF FIREWALL) RED WIRE RED/LT GRN WIRE SENSOR GRD GOV PRESS SIG VAR FORCE SOL OVERDRV SOL TCC SOL CTRL TRANS TEMP SNS STOP LAMP SWITCH (ON BRAKE PEDAL BRACKET) TAN/RED WIRE THROTTLE POSITION SENSOR (ON THROTTLE BODY) TRANS- MISSION RELAY TRANSMISSION SOLENOID ASSEMBLY (ON LEFT SIDE OF TRANSMISSION) VIO WIRE VIO/BRN WIRE VIO/WHT WIRE WHT/BLK WIRE WHT/DK GRN WIRE WHT/PNK WIRE YEL/RED WIRE

AIR CONDI- TIONING SYSTEM AUTO SHT RLY CRUISE VAC SOL CRUISE VNT SOL BATTERY TEMPER- ATURE SENSOR (BELOW BATTERY TRAY) BLK/LT BLU WIRE BLK/LT GRN WIRE BRN WIRE BRN/VIO WIRE BRN/WHT WIRE CCD(-) CONNECTOR CRUISE CONTROL SYSTEM CRUISE SW IN DATA LINK CONNECTOR (LEFT BOTTOM OF DASH) DK BLU WIRE DK BLU/ORG WIRE DK BLU/WHT WIRE DK BLU/YEL WIRE DK GRN WIRE DK GRN/ORG WIRE DK GRN/PNK WIRE EVAP PURGE SOLENOID (ON BRACKET, MOUNTED ON RIGHT INNER FENDER) FUEL PMP RLY EVAP SOL DRVR FUSE I GENERATOR HOT AT ALL TIMES HOT IN RUN OR START JUNCTION BLOCK (ON LEFT END OF DASH) FUSE 11 INSTRUMENT CLUSTER JOINT JOINT CONNECTOR 11 9 2 14 6 5 JOINT CONNECTOR NO 1 (IN PDC) LEAK DETECTION PUMP (ON RIGHT FRONT INNER FENDER) LT GRN/RED WIRE LT GRN/WHT WIRE ORG/ WIRE ORG/WHT WIRE OVERDRIVE SWITCH PNK 6 7 WIRE PNK WIRE PNK/DK BLU WIRE PNK/WHT WIRE PNK/YEL WIRE POWERTRAIN CONTROL MODULE (IN ENG COMPT, ON RIGHT SIDE OF FIREWALL) RED WIRE RED/LT GRN WIRE STOPLIGHT SWITCH (ON BRAKE PEDAL BRACKET) TAN/RED WIRE TRANSMISSION RELAY VIO/BRN WIRE WHT/BLK WIRE WHT/DK GRN WIRE WHT/PNK WIRE YEL WIRE YEL/RED WIRE

AIR CONDI- TIONING SYSTEM AUTO SHT RLY CRUISE VAC SOL CRUISE VNT SOL BATTERY TEMPER- ATURE SENSOR (BELOW BATTERY TRAY) BLK/LT BLU WIRE BLK/LT GRN WIRE BRN WIRE BRN/VIO WIRE BRN/WHT WIRE CCD(-) CONNECTOR CRUISE CONTROL SYSTEM CRUISE SW IN DATA LINK CONNECTOR (LEFT BOTTOM OF DASH) DK BLU WIRE DK BLU/ORG WIRE DK BLU/WHT WIRE DK BLU/YEL WIRE DK GRN WIRE DK GRN/ORG WIRE DK GRN/PNK WIRE EVAP PURGE SOLENOID (ON BRACKET, MOUNTED ON RIGHT INNER FENDER) FUEL PMP RLY EVAP SOL DRVR FUSE I GENERATOR HOT AT ALL TIMES HOT IN RUN OR START JUNCTION BLOCK (ON LEFT END OF DASH) FUSE 11 INSTRUMENT CLUSTER JOINT JOINT CONNECTOR 11 9 2 14 6 5 JOINT CONNECTOR NO 1 (IN PDC) LEAK DETECTION PUMP (ON RIGHT FRONT INNER FENDER) LT GRN/RED WIRE LT GRN/WHT WIRE ORG/ WIRE ORG/WHT WIRE OVERDRIVE SWITCH PNK 6 7 WIRE PNK WIRE PNK/DK BLU WIRE PNK/WHT WIRE PNK/YEL WIRE POWERTRAIN CONTROL MODULE (IN ENG COMPT, ON RIGHT SIDE OF FIREWALL) RED WIRE RED/LT GRN WIRE STOPLIGHT SWITCH (ON BRAKE PEDAL BRACKET) TAN/RED WIRE TRANSMISSION RELAY VIO/BRN WIRE WHT/BLK WIRE WHT/DK GRN WIRE WHT/PNK WIRE YEL WIRE YEL/RED WIRE

A/C COMP RLY A/C HIGH PRESSURE CUTOUT SWITCH (A/C HIGH PRESSURE LINE) A/C LOW PRESSURE CUTOUT SWITCH (A/C LOW PRESSURE LINE) A/C REQUEST A/C SELECT IN BRAKE SW IN GENERATOR A/C SYSTEM AIR CONDITIONING SYSTEM (A/C-HEATER CONTROL SWITCH) AUTO SHT RLY CRUISE VAC SOL CRUISE VNT SOL OVERDRV IND TRANS TEMP IND BATT TEMP SENS GEN IND DRVR MIL IND DRVR WATER IN FUEL BATTERY TEMPER- ATURE SENSOR (BELOW BATTERY) BLK/LT BLU WIRE BLK/ORG WIRE BLK/PNK WIRE BLK/RED WIRE BLK/WHT WIRE BRN WIRE CRUISE CONTROL SYSTEM CRUISE FEED ASD RELAY SENS TRANS OVERDRV DATA LINK CONNECTOR DK BLU/ORG WIRE DK BLU/WHT WIRE DK BLU/YEL WIRE DK GRN WIRE DK GRN/ORG WIRE DK GRN/RED WIRE EGR DIAG FUSE 11 FUSE BLOCK GEN IND LAMP GENERATOR GRY/LT BLU WIRE HOT IN START OR RUN INSTRUMENT CLUSTER INSTRUMENT CLUSTER SYSTEM INTAKE AIR TEMPER- ATURE SENSOR (RIGHT SIDE OF INTAKE MANIFOLD) JOINT CONNECTOR C (BEHIND LEFT KNEE BOLSTER) LT GRN WIRE LT GRN/ORG WIRE LT GRN/RED WIRE LT GRN/WHT WIRE MIL IND LAMP NCA WIRE ORG/ WIRE ORG/BLK WIRE ORG/WHT WIRE OVERDRIVE SWITCH PNK 13 14 WIRE PNK WIRE PNK/BLK WIRE PNK/DK BLU WIRE PNK/DK GRN WIRE PNK/YEL WIRE POWER DISTRIBUTION CENTER POWERTRAIN CONTROL MODULE (RIGHT SIDE SAFETY WALL) RED WIRE RED/LT GRN WIRE SCI RECEIVE SCI TRANSMIT SPEEDOMETER STOP LAMP SWITCH (UNDER LEFT SIDE OF I/P) TACH SIGNAL TACH SIGNAL CRUISE SW IN TAN/ORG WIRE TAN/RED WIRE TAN/YEL WIRE TRANS- MISSION RELAY WATER IN FUEL SENSOR (BOTTOM OF FUEL FILTER) WHT/DK BLU WIRE WHT/ORG WIRE WHT/PNK WIRE YEL/RED WIRE

1 2 3 4 5 6 7 8 TRANS RLY OUT AIR CONDI- TIONING SYSTEM AIR CONDITIONING SYSTEM AUTO SHT RLY CRUISE VAC SOL CRUISE VNT SOL BLK/LT BLU WIRE BLK/LT GRN WIRE BLK/RED WIRE BRN WIRE BRN/VIO WIRE BRN/WHT WIRE CCD(-) CRUISE CONTROL SYSTEM CRUISE SW IN DATA LINK CONNECTOR (LEFT BOTTOM OF DASH) DK BLU WIRE DK BLU/ORG WIRE DK BLU/WHT WIRE DK BLU/YEL WIRE DK GRN WIRE DK GRN/ORG WIRE DK GRN/PNK WIRE DK GRN/WHT WIRE DK GRN/YEL WIRE DOWNSTREAM OXYGEN SENSOR RELAY FUEL PMP RLY EVAP SOL DRVR FUSE GENERATOR HOT AT ALL TIMES INSTRUMENT CLUSTER INTAKE AIR TEMPERATURE SENSOR (IN LEFT FRONT SIDE OF INTAKE MANIFOLD) JOINT CONNECTOR 1 (IN PDC) JOINT CONNECTOR 11 9 2 14 6 5 LEAK DETECTION PUMP (ON RIGHT FRONT OF INNER FENDER) LT GRN/RED WIRE LT GRN/WHT WIRE M/T ONLY ORG/ WIRE ORG/BLK WIRE ORG/DK BLU WIRE ORG/WHT WIRE OVERDRIVE SWITCH PNK WIRE PNK/DK BLU WIRE PNK/WHT WIRE PNK/YEL WIRE POWERTRAIN CONTROL MODULE (IN ENG COMPT, ON RIGHT SIDE OF FIREWALL) RED WIRE RED/LT GRN WIRE SENSOR GRD GOV PRESS SIG VAR FORCE SOL OVERDRV SOL TCC SOL CTRL TRANS TEMP SNS STOP LAMP SWITCH (ON BRAKE PEDAL BRACKET) TAN/RED WIRE THROTTLE POSITION SENSOR (ON THROTTLE BODY) TRANSMISSION RELAY FUSE I TRANSMISSION SOLENOID ASSEMBLY (ON LEFT SIDE OF TRANSMISSION) VIO WIRE VIO/BRN WIRE VIO/WHT WIRE WHT/BLK WIRE WHT/DK GRN WIRE WHT/PNK WIRE YEL WIRE YEL/RED WIRE