Dodge Pickup R3500 (1996-2010) tan Wiring diagrams

A/C COMPRESSOR CLUTCH A/C COMPRESSOR CLUTCH RELAY A/C HEATER CONTROL A/C HIGH PRESSURE SWITCH A/C LOW PRESSURE SWITCH (ON TOP OF A/C ACCUMULATOR) A/C SELECT SENSE BI-LEVEL PANEL RECIRC/ PANEL BLK WIRE BLK/ORG WIRE BLK/WHT WIRE BLOWER MOTOR BLOWER MOTOR RELAY BLOWER MOTOR RESISTOR BLOCK (RIGHT SIDE OF DASH) BLOWER SWITCH BRN WIRE DEF MODE SWITCH DIESEL GAS DK BLU WIRE DK BLU/BLK WIRE DK BLU/ORG WIRE DK BLU/WHT WIRE DK GRN WIRE FLOOR MIX FUSE 12 FUSE 2 HI-A/C HEAT-HI HOT AT ALL TIMES HOT AT ALL TIMES FUSE HOT IN RUN HOT IN RUN OR START FUSE 9 JOINT CONNECTOR NO. 1 (IN POWER DISTRIBUTION CENTER) JUNCTION BLOCK LT BLU WIRE LT GRN WIRE LT GRN/WHT WIRE OFF OFF HEAT-LOW LOW-A/C ORG/ WIRE PNK/DK BLU WIRE POWER DISTRIBUTION CENTER TAN WIRE

1 2 3 4 GROUND PANEL LAMPS DRIVER ESP ON/OFF SENSE SENSOR GROUND 1 2 3 6 IGN SW OUT (RUN-START) DYNAMICS HIGH DATA DYNAMICS LOW DATA GROUND 17 18 10 CAN B BUS (+) CAN B BUS (-) SENSOR GROUND 35 34 CAN C BUS (-) CAN C BUS (+) 43 44 45 46 RH RR WHEEL SPD SENS (+) RH RR WHEEL SPD SENS (-) GROUND 5.9L 6.7L ANTI-LOCK BRAKES MODULE (LEFT REAR OF ENGINE COMPT) B(+) BLK WIRE BLK/DK GRN WIRE BLK/LT GRN WIRE BLK/ORG WIRE BLK/PNK WIRE BRAKE FLUID LEVEL SENSOR (LEFT REAR OF ENGINE COMPT) BRAKE SWITCH 1 SIGNAL BRAKE SWITCH 1 SIGNAL CAN C BUS (+) BRK FLUID LEVEL SW SENSE CAN B CAN B BUS (+) BUS (-) CAN C BUS (+) CAN C CAN C BUS (+) BUS (-) CLUSTER COMPUTER DATA LINES SYSTEM DIESEL DK DK DK GRN WIRE DK GRN/BRN WIRE DK GRN/LT BLU WIRE DK GRN/LT GRN WIRE DK GRN/ORG WIRE DK GRN/RED WIRE DK GRN/TAN WIRE DK GRN/VIO WIRE DK GRN/WHT WIRE DK GRN/YEL WIRE DYNAMICS SENS HIGH DATA DYNAMICS SENS LOW DATA DYNAMICS SENSOR (W/ ESP) (UNDER FRONT OF CENTER CONSOLE) ELECTRONICS ENGINE CONTROL MODULE (LOWER LEFT FRONT OF ENGINE BLOCK) ESP ON/OFF SENSE ESP SWITCH (IF EQUIPPED) FUSE 13 FUSE 18 FUSE 28 FUSE 30 FUSED B (+) CAN C BUS + FUSED B (+) IGN SW OUT (RUN-START) FUSED IGN SW OUT (RUN-START) GAS GRN WIRE GRN/GRY WIRE GROUND GRY WIRE HOT AT ALL TIMES HOT IN RUN OR START IGN SW OUT (RUN-START) CAN C BUS (+) CAN C BUS (-) GROUND LEFT FRONT ABS WHEEL SPEED SENSOR (LEFT REAR OF ENGINE COMPT) LEFT REAR ABS WHEEL SPEED SENSOR LF WHEEL SPD SENSOR (+) LF WHEEL SPD SENSOR (-) LT BLU WIRE LT GRN WIRE ORG/ WIRE ORG/DK BLU WIRE PANEL LAMPS DRIVER PNK WIRE PNK/ (EXCEPT ESP/5.7L POWER WAGON, 6.7L EXCEPT SHIFT ON THE FLY) WIRE PNK/GRY WIRE PNK/LT GRN WIRE POWERTRAIN CONTROL MODULE (RIGHT REAR OF ENGINE COMPT) REAR ABS WHEEL SPEED SENSOR (W/O ESP) (NEAR RIGHT REAR FRAME RAIL) RED WIRE RF WHEEL SPD SENSOR (+) RF WHEEL SPD SENSOR (-) RIGHT FRONT ABS WHEEL SPEED SENSOR (ON KNUCKLE SPINDLE ASSEMBLY) RIGHT REAR ABS WHEEL SPEED SENSOR (W/ ESP) (AT RIGHT REAR WHEEL ASSEMBLY) STEERING ANGLE SENSOR (W/ ESP) STOP LAMP SWITCH (ON BRAKE PEDAL SUPPORT) TAN WIRE TAN/RED WIRE TOTALLY INTEGRATED POWER MODULE (AT LEFT FRONT FENDER) TRAILER TOW DAMPING RLY CTRL VIO WIRE VIO/DK BLU WIRE W/ ESP W/O ESP WHT WIRE WHT/GRY WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE WHT/ORG WIRE YEL WIRE

ASH RECEIVER LAMP BLK WIRE BLK/LT BLU WIRE BLK/LT GRN WIRE BLK/ORG WIRE BLK/WHT WIRE BRN/LT GRN WIRE CARGO LAMP 1 CARGO LAMP 2 CENTRAL TIMER MODULE (LEFT SIDE OF DASH) CUP HOLDER LAMP DOME LAMP DOME ON CARGO ON FUSE 12 FUSE 7 GLOVE BOX LAMP) HEADLAMP SWITCH HOT AT ALL TIMES HOT IN RUN IGNITION SWITCH JOINT CONNECTOR 5 (BEHIND LEFT SIDE OF DASH) JOINT CONNECTOR 6 (NEAR BRAKE PEDAL ASSY) JUNCTION BLOCK (RIGHT END OF DASH) LEFT DOOR JAMB SWITCH LEFT VISOR LAMP LOW LINE LT BLU WIRE OVERHEAD CONSOLE OVERHEAD MAP/ COURTESY LAMPS PNK WIRE PNK/ 3 1 WIRE PNK/BLK WIRE PNK/DK BLU WIRE RIGHT DOOR JAMB SWITCH RIGHT VISOR LAMP TAN WIRE UNDERHOOD LAMP/ MERCURY SWITCH YEL (OR WIRE YEL WIRE YEL/RED WIRE

ANTI-LOCK BRAKES MODULE AUXILIARY BATTERY (6.7L) BATTERY BLK WIRE BLK/DK GRN WIRE BLK/TAN WIRE BRAKE PROVISION MODULE CENTER HIGH MOUNTED STOP/CARGO LAMP CENTER RIGHT CLEARANCE CLEARANCE LAMP LAMP 1 CUP HOLDER LAMP DATA LINK CONNECTOR DK GRN WIRE DRIVER DOOR LATCH EGR BYPASS COOLING ACTUATOR EXCEPT REGULAR CAB REGULAR CAB FRONT WIPER MOTOR HEADLAMP SWITCH LEFT LEFT CLEARANCE CLEARANCE LAMP 2 LAMP 1 MASS AIR FLOW SENSOR MODULE ORG/ WIRE POWERTRAIN CONTROL MODULE RADIO RIGHT CLEARANCE LAMP 2 RIGHT FRONT OCCUPANT PARK/TURN RESTRAINT LAMP HORN 1 CONTROLLER MODULE TAN WIRE

BLK WIRE BLK/TAN WIRE BLOWER MOTOR (BEHIND RIGHT SIDE OF DASH) BLOWER MOTOR RELAY BLOWER MOTOR RESISTOR BLOCK (BEHIND RIGHT SIDE OF DASH, ON A/C-HEATER HOUSING) BLOWER MOTOR SPEED SWITCH DEFROST DK BLU WIRE DK GRN WIRE DK GRN/YEL WIRE FLOOR BI-LEVEL FLOOR/DEFROST PANEL FUSE 12 FUSE 2 HEATER CONTROL HIGH LOW HOT AT ALL TIMES HOT IN RUN ILLUM J/C 1 J/C 8 (BEHIND CENTER OF DASH) JUNCTION BLOCK (LEFT END OF DASH) LT BLU WIRE LT GRN WIRE MED 1 MED 2 MED 2 MED 1 MODE SELECT SWITCH OFF ORG/ WIRE TAN WIRE YEL WIRE

AAT SIGNAL AMBIENT AIR TEMPERATURE SENSOR (LEFT FRONT OF ENGINE COMPT) B(+) BLK/WHT WIRE CAN B AAT BUS (-) RETURN CAN B BUS (+) ELECTRONIC OVERHEAD MODULE (EXCEPT BASE) ELECTRONICS FUSED B (+) GROUND GRY/RED WIRE HOT AT ALL TIMES TOTALLY INTEGRATED LT GRN WIRE ORG/ WIRE POWER FUSE 11 MODULE (LEFT FRONT FENDER) TAN WIRE VIO WIRE VIO/LT GRN WIRE VIO/TAN WIRE WHT WIRE WHT/ORG WIRE

5.9L 6.7L B(+) CAN C BUS (+) BLK WIRE BLK/DK GRN WIRE BLK/ORG WIRE BRAKE SWITCH 1 SIGNAL BRAKE SWITCH 1 SIGNAL 34 35 C BUS (+) C BUS (-) BRK FLUID LEVEL SW SENSE CAN C BUS (+) COMPUTER DATA LINES SYSTEM DIESEL DK DK DK GRN WIRE DK GRN/LT GRN WIRE DK GRN/ORG WIRE DK GRN/RED WIRE DK GRN/TAN WIRE DK GRN/WHT WIRE DK GRN/YEL WIRE ELECTRONICS FUSED IGN SW OUT (RUN-START) ENGINE CONTROL MODULE FUSE 13 FUSE 30 GAS GRN WIRE HOT AT ALL TIMES LF WHEEL SPD SENSOR (-) LT BLU WIRE LT GRN WIRE ORG/ WIRE PNK WIRE PNK/LT GRN WIRE RED WIRE TAN WIRE TOTALLY INTEGRATED POWER MODULE (AT LEFT FRONT FENDER) WHT WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE YEL WIRE

29 30 31 PNK WIRE 5.2L, 5.9L ONLY AUTOMATIC SHUTDOWN RELAY BLK WIRE BLK/GRY WIRE BLK/LT BLU WIRE BLK/RED WIRE BLK/TAN WIRE BLK/WHT WIRE BRN WIRE BRN/DK BLU WIRE BRN/WHT WIRE CAM POS SNS IDLE AIR 1 IDLE AIR 4 CONTROLLER ANTI-LOCK BRAKE DISTRIBUTOR DK BLU WIRE DK BLU/BLK WIRE DK BLU/YEL WIRE DK GRN WIRE DK GRN/BLK WIRE DK GRN/ORG WIRE DK GRN/RED WIRE DK GRN/WHT WIRE FUEL INJECTORS FUEL PUMP RELAY FUSE FUSE 3 FUSE 6 FUSED B(+) TPS SENS IN GEN FIELD DRV TCC DRVR INJ 6 DRIVER INJ 8 DRIVER GROUND GROUND GRY WIRE GRY/BLK WIRE GRY/LT BLU WIRE GRY/ORG WIRE GRY/RED WIRE HOT AT ALL TIMES HOT IN RUN OR START IAT SENS IN ECT SENS IN IDLE AIR 2 IDLE AIR 3 IGN (POWER) INJ 1 DRIVER INJ 3 DRIVER INJ 5 DRIVER INJ 2 DRIVER INJ 4 DRIVER JUNCTION BLOCK (RIGHT END OF DASH) FUSE 9 LT BLU WIRE LT BLU/BRN WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/RED WIRE LT GRN/WHT WIRE MAP SENS IN NCA WIRE OIL PRESS SIG ORG/ WIRE ORG/BLK WIRE ORG/DK BLU WIRE OUTPUT SENS OVERDRV SOL PARK/NEUTRAL POSITION SWITCH (ON LEFT SIDE OF TRANSMISSION) PNK WIRE POWERTRAIN CONTROL MODULE (IN ENG COMPT, ON RIGHT SIDE OF FIREWALL) PRK/NEUTRAL COIL DRIVER CRNK POS SNS RED WIRE RED/WHT WIRE SENSOR GRD STARTING/ CHARGING SYSTEM TAN WIRE TAN/BLK WIRE TAN/WHT (OR ORG/BLK) WIRE TAN/YEL WIRE TRANSMISSION OUPUT SHAFT SPEED SENSOR (ON LEFT SIDE OF TRANSMISSION) VAR FRCE SOL VIO WIRE VIO/BLK WIRE VIO/TAN WIRE VIO/WHT WIRE VSS IN OUTPUT SENS GOV PRESS SIG TRANS RELAY WHT/DK BLU WIRE WHT/ORG WIRE YEL WIRE YEL/BLK WIRE YEL/WHT WIRE

BATTERY BLK WIRE BLK/LT BLU WIRE BLK/PNK WIRE BLK/RED WIRE BLK/TAN WIRE BLK/WHT WIRE BRN WIRE COOLANT TEMP DIAG REQ DK BLU WIRE DK BLU/YEL WIRE DK GRN WIRE DK GRN/ORG WIRE DK GRN/RED WIRE EGR CONTROL MODULE EGR ENGINE ENGINE COOLANT TEMPERATURE SENSOR EGR FAULT EGR IAT EGR INTAKE AIR TEMPERATURE SENSOR EGR SOL EGR SOLENOID (RIGHT SIDE OF ENGINE) ENGINE SPEED SENSOR (FRONT OF ENGINE) ENGINE STARTER MOTOR RELAY (HOT IN START) FUEL HEATER (ABOVE STARTER MOTOR) FUEL HEATER RELAY (NEAR MASTER CYLINDER) FUEL SHUT DOWN RELAY (NEAR MASTER CYLINDER) FUEL SHUT DOWN SOLENOID (NEAR REAR OF INJECTION PUMP) GRY/BLK WIRE GRY/YEL WIRE LT GRN/BLK WIRE LT GRN/ORG WIRE LT GRN/RED WIRE NCA WIRE ORG/ WIRE ORG/DK BLU WIRE PNK 13 14 WIRE PNK 22 23 WIRE PNK/DK GRN WIRE RED WIRE RED/VIO WIRE SHUT DWN REL TAN WIRE TAN/BLK WIRE TEMP SEN GRD TP SENS SIG VEHICLE SPEED SENSOR (REAR OF TRANSMISSION) VIO WIRE VIO/WHT WIRE WHT/ORG WIRE

28 29 30 PNK WIRE AUTOMATIC SHUTDOWN RELAY BLK/DK GRN WIRE BLK/GRY WIRE BLK/LT BLU WIRE BLK/RED WIRE BLK/TAN WIRE BLK/WHT WIRE BRN WIRE BRN/DK BLU WIRE BRN/WHT WIRE CALIF CAM POS SNS IDLE AIR 1 IDLE AIR 4 CAPACITOR CONTROLLER ANTI-LOCK BRAKE DK BLU WIRE DK BLU/BLK WIRE DK BLU/WHT WIRE DK BLU/YEL WIRE DK GRN BLK/ WIRE DK GRN WIRE DK GRN/BLK WIRE DK GRN/GRY WIRE DK GRN/ORG WIRE DK GRN/RED WIRE FUEL INJECTORS FUEL PUMP RELAY FUSE 6 FUSE 3 FUSED B(+) TPS SENS IN GRN WIRE GROUND GROUND GRY WIRE GRY/BLK WIRE GRY/LT BLU WIRE GRY/ORG WIRE GRY/RED WIRE HOT AT ALL TIMES IAT SENS IN ECT SENS IN IGNITION COIL 4-PACK IGNITION COIL 6-PACK LT BLU WIRE LT BLU/BRN WIRE LT GRN/ BLK WIRE LT GRN/BLK WIRE LT GRN/RED WIRE LT GRN/WHT WIRE MAP SENS IN NCA WIRE OIL PRESS SIG ORG/ WIRE ORG/BLK WIRE ORG/DK BLU WIRE OUTPUT SENS OUTPUT SPEED SENSOR (ON LEFT SIDE OF TRANSMISSION) OVERDRV SOL PARK/NEUTRAL POSITION SWITCH (ON LEFT SIDE OF TRANSMISSION) PNK WIRE POWERTRAIN CONTROL MODULE (IN ENG COMPT, ON RIGHT SIDE OF FIREWALL) RED WIRE RED/BLK WIRE RED/LT BLU WIRE RED/WHT WIRE STARTING/ CHARGING SYSTEM TAN WIRE TAN/BLK WIRE TAN/WHT WIRE TAN/YEL WIRE TO SPARK PLUGS TO SPARK PLUGS TO SPARK PLUGS TO SPARK PLUGS TO SPARK PLUGS VAR FRCE SOL VIO WIRE VIO/BLK WIRE VIO/TAN WIRE VIO/WHT WIRE VSS IN OUTPUT SENS GOV PRESS SIG TRANS RELAY WHT WIRE WHT/DK BLU WIRE WHT/ORG WIRE YEL WIRE YEL/BLK WIRE YEL/GRY WIRE YEL/WHT WIRE