Dodge Pickup R3500 (1996-2010) red/vio Wiring diagrams

1 2 3 4 5 6 7 8 9 10 11 12 13 14 REAR WHL SPD SENSOR (+) BLK WIRE BLK/GRY WIRE BLK/LT GRN WIRE BLK/VIO WIRE BRAKE LAMP SWITCH (ON BRAKE PEDAL BRACKET) BRAKE PRESSURE SWITCH (ON COMBINATION VALVE) CCD BUS (+) FUSE IGN SW (RUN) CONTROLLER ANTI-LOCK BRAKE (LEFT FENDER SIDE SHIELD) DATA LINK CONNECTOR (LEFT BOTTOM OF DASH) DIESEL ENGINE CONTROLS SYSTEM FUSE 11 FUSE 14 FUSE 3 GROUND FUSE B (+) REAR WHL SPD SENSOR (-) BRAKE SW SENSE CCD BUS (-) GRY WIRE GRY/BLK WIRE HOT AT ALL TIMES HOT IN IND INSTRUMENT CLUSTER J/C 1 (IN PDC) JOINT CONNECTOR 7 (LEFT SIDE OF DASH) JUNCTION BLOCK (LEFT END OF DASH) POWERTRAIN CONTROL MODULE (RIGHT REAR OF ENG COMPT) REAR WHEEL SPEED SENSOR (IN DIFFERENTIAL HOUSING) RED BRAKE IND DRIVER WIRE RED WIRE RED/DK BLU WIRE RED/DK GRN WIRE RED/GRY WIRE RED/VIO WIRE RUN WIRE VEHICLE SPEED SEN SIG GROUND FUSE B (+) VIO/BRN WIRE VSS WHT WIRE WHT/BLK WIRE WHT/DK BLU WIRE WHT/ORG WIRE WHT/PNK WIRE WHT/VIO WIRE YEL WIRE

17 18 TRANS CTRL OUT ASD RLY CTRL 20 21 22 23 24 25 26 FUSED IGN RUN/ST CTRL A/C CLUTCH COIL A/C PRESS SNSE RTN A/C PRESS SIG A/C PRESS SNSR FD AIR CONDITIONING SYSTEM AIR CONDITIONING, NAVIGATION SYSTEMS ANTI-LOCK BRAKES SYSTEM BATT FD BATT FD 9 BLK WIRE BLK/BRN WIRE BLK/LT BLU WIRE BRK LVL SW SIG BRN WIRE BRN/BLK WIRE BRN/GRY WIRE BRN/WHT WIRE CAN-BUS CAN-BUS COMPUTER DATA LINES SYSTEM DEFOGGER SYSTEM SEATS SYSTEM EXTERIOR LIGHTS SYSTEM DK BLU WIRE DK BLU/YEL WIRE DK GRN/ORG WIRE DK GRN/RED WIRE DOOR LOCKS SYSTEM DR LK RT FT ELEC BKLT FD IGN R TTOW PRK LMP SIG FUSED ASD RLY OUT FUSED ASD RLY OUT BATT FD ENG CTRL DRCT BATT FD ENG CTRL RUN/STRT IGN STP LMP SIG IGN ULK/RUN/STRT A/C CLUTCH FD ENGINE CONTROLS SYSTEM EXTERIOR LIGHTS SYSTEM SEATS SYSTEM POWER TOPS SYSTEM EXTERIOR LIGHTS SYSTEM FUEL PUMP CTRL GND BATT FD IGN (RUN) IGN R IGN RS LT BLU/BRN WIRE LT BLU/ORG WIRE LT GRN/GRY WIRE PNK/GRY WIRE PNK/LT GRN WIRE PNK/VIO WIRE PNK/WHT WIRE PNK/YEL WIRE POWER DISTRIBUTION SYSTEM POWER WINDOWS SYSTEM RED WIRE RED/GRY WIRE RED/LT BLU WIRE RED/LT GRN WIRE RED/VIO WIRE RED/YEL WIRE RT TTOW RLY CTRL IGN R BATT FD BATT FD 3 STARTING/CHARGING SYSTEM STARTING/CHARGING SYSTEM EXTERIOR LIGHTS SYSTEM STRTR OVRDE RLY COIL RTN SUPPLEMENTAL RESTRAINTS SYSTEM (LEFT SIDE OF ENGINE COMPT) TAN/BRN WIRE TAN/DK BLU WIRE TAN/LT BLU WIRE TAN/LT GRN WIRE TAN/ORG WIRE TAN/VIO WIRE TAN/WHT WIRE TOTALLY INTEGRATED POWER MODULE (LEFT FRONT OF ENGINE COMPT) TRANSMISSION CTRL OUT TRANSMISSIONS SYSTEM TRANSMISSIONS SYSTEM ENGINE CONTROLS SYSTEM WHT/DK BLU WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE WHT/VIO WIRE YEL/BRN WIRE YEL/GRY WIRE YEL/ORG WIRE YEL/RED WIRE

2 5 4 READING LPS DRV COURTESY LPS DRV PANEL LPS DRV AUTO STICK SWITCH (ERS) B(+) DRV DOOR DOOR CAN AJAR AJAR AJAR SW SW SW SNS BLK WIRE BLK/DK GRN WIRE BLK/GRY WIRE BLK/TAN WIRE BLK/WHT WIRE CAN FUSE IHS IHS SW BUS BUS SNS SNS SNS (+) (-) CARGO LP CLUSTER COMPUTER DATA LINES SYSTEM DIM SIG DRIVER DOOR LATCH ELECTRONICS EXCEPT REGULAR CAB FRONT READING LAMP FUSE FUSE FUSE FUSE GLOVE BOX LAMP) GRY WIRE HDLP SW HDLP/FOGLP HEADLAMP SWITCH HOT AT ALL TIMES HOT IN ON OR START INSTRUMENT ILLUMINATION CIRCUIT LEFT REAR DOOR LATCH (EXCEPT REGULAR CAB) LEFT STORAGE BIN (IF EQUIPPED) LEFT VANITY LAMP LT BLU WIRE LT GRN WIRE MLFCT SW RTN MUX RTN ORG/ WIRE ORG/BRN WIRE ORG/GRY WIRE PANEL LPS PANEL LPS DRV PASSENGER DOOR LATCH PNK WIRE PNK/ EXCEPT REGULAR CAB WIRE PNK/LT GRN WIRE REAR DOME LAMP RED WIRE RED/VIO WIRE RED/WHT WIRE RIGHT REAR DOOR LATCH (EXCEPT REGULAR CAB) RIGHT STORAGE BIN (IF EQUIPPED) RIGHT VANITY LAMP RR LR PASS DOOR DOOR AJAR SW SIG TOTALLY INTEGRATED POWER MODULE (LEFT FRONT OF ENGINE COMPT) UNDERHOOD LAMP (IF EQUIPPED) VIO WIRE VIO/GRY WIRE VIO/WHT WIRE VIO/YEL WIRE W/ LIGHT PACKAGE WHT WIRE WHT/GRY WIRE WHT/LT GRN WIRE WHT/ORG WIRE WHT/YEL WIRE YEL WIRE YEL/LT BLU WIRE YEL/WHT WIRE

10 15 14 34 B(+) PARK RLY CTRL TRLR L TURN TRLR R TURN 19 43 44 38 2 13 14 10 RR TURN SIGNAL LEFT BRAKE LP LR TURN SIGNAL PCI BUS 45 42 15 12 RF TURN SIGNAL LF TURN SIGNAL 5 8 HDLP SW SIG TURN SW FEED 9 19 15 HDLP SW RTN PCI BUS BRAKE SW INPUT BACK-UP LAMPS CIRCUIT BLK WIRE BLK/TAN WIRE BRAKE LAMP SWITCH (ON BRAKE PEDAL SUPPORT) BRN WIRE CENTER HIGH MOUNTED STOP LAMP (AFTERMARKET) CENTER HIGH MOUNTED STOP LAMP/ CARGO LAMP COMPUTER DATA LINES SYSTEM DK GRN WIRE DK GRN/WHT WIRE ELECTRIC BRAKE PROVISION FOG FRAME RAIL) FRONT CONTROL MODULE FUSE 15 FUSE 24 FUSE 19 FUSE 32 FUSE 33 FUSE 34 FUSE 46 FUSE 47 GRY WIRE HAZARD HEADLAMP SWITCH HEAVY DUTY HEAVY DUTY LEFT REAR FENDER LAMP (DUAL REAR WHEELS) HOT AT ALL TIMES INSTRUMENT CLUSTER INTEGRATED POWER MODULE (LEFT REAR OF ENGINE COMPT) FUSE 1 L TURN LEFT FRONT FENDER LAMP (DUAL REAR WHEELS) LEFT FRONT PARK/ TURN SIGNAL LAMP LEFT LICENSE LAMP LEFT REAR LEFT TAIL/STOP, TURN SIGNAL LAMP LT GRN WIRE MULTI- FUNCTION SWITCH OFF OFF PARK HEAD OFF PARK HEAD PARK LAMP RELAY PARK/ TURN SIGNAL LAMP PTC 5 R TURN RED WIRE RED/VIO WIRE RIGHT BRAKE LP RIGHT FRONT RIGHT LICENSE LAMP RIGHT TAIL/ STOP/ TURN SIGNAL LAMP TAIL/ STOP LAMP TAIL/ TURN LAMP TAIL/ TURN LAMP TAIL/ STOP LAMP TAILGATE LAMP ASSEMBLY TAN WIRE TAN/RED WIRE TRAILER TOW CONNECTOR TRAILER TOW CONNECTOR- ADD ON TRAILER TOW LEFT TURN RELAY TRAILER TOW RIGHT TURN RELAY TRAILER TOW) (LEFT REAR OF ENGINE COMPT) TURN SW SENSE VIO WIRE W/ TAIL LAMP JUMPER W/ TRAILER TOW CONNECTOR ADD ON WHT WIRE WHT/DK GRN WIRE WHT/GRY WIRE WHT/LT GRN WIRE WHT/ORG WIRE WHT/TAN WIRE WHT/VIO WIRE WHT/YEL WIRE YEL WIRE

7-WAY TRAILER TOW WIRING A/C HEATER CONTROL ANTI-LOCK BRAKES MODULE AUXILIARY BATTERY (6.7L) BASE PREMIUM AUDIO AUDIO BATTERY BRN/RED WIRE BUS BAR CIRCUIT BOARD IOD FD CLUSTER COMPASS MODULE DK GRN WIRE DK GRN/RED WIRE DRIVER DOOR MODULE EXCEPT RAM BOX RAM BOX FUSE FUSE FUSE FUSE FUSE FUSE FUSIBLE LINK (8 GA- GENERATOR GENERATOR (EXCEPT 6.7L) GRY WIRE HANDS FREE MODULE INTAKE AIR HEATER RELAY LEFT BIN RIGHT BIN BRAKE STORAGE STORAGE PROVISION MODULE LT BLU RED/ WIRE LT BLU WIRE LT GRN/RED WIRE MULTI- FUNCTION SWITCH PASSENGER DOOR MODULE PASSENGER DOOR UNLOCK RELAY RADIATOR FAN HIGH RELAY RADIO RADIO, AMPLIFIER RED WIRE RED YEL/ WIRE RED/ LT BLU WIRE RED/ VIO WIRE RED/ WHT WIRE RED/LT BLU WIRE RED/LT GRN WIRE RED/VIO WIRE RED/WHT WIRE RED/YEL WIRE STARTER STARTER RELAY STOP LAMP SWITCH SUNROOF MODULE (IF EQUIPPED) TAN/RED WIRE TOTALLY INTEGRATED POWER MODULE TRANSMISSION CONTROL RELAY UNDERHOOD LAMP (IF EQUIPPED) VIDEO VIDEO SCREEN SATELLITE MODULE MODULE VIO RED/ WIRE VIO WIRE WHT RED/ WIRE WHT WIRE YEL/RED WIRE

5.7L CREW CAB) 7 WAY TRAILER TOW WIRING (AT TRAILER HITCH) B(+) BACKUP LAMPS CIRCUIT BATT FD BLK WIRE BLK/DK GRN WIRE BLK/TAN WIRE BRAKE PROVISION MODULE (LEFT SIDE OF DASH) BRN WIRE CAN BUS (+) 2 CARGO LAMP CENTER HIGH MOUNTED CENTER HIGH MOUNTED STOP CIRCUIT BOARD COMPUTER DATA LINES SYSTEM CTRL RT TTOW RLY DK GRN WIRE ELEC BRK FD ENGINE COMPT) FUSE FUSE HOT AT ALL TIMES HOT W/ RUN/ START RELAY ENERGIZED IGN RS ITBM BRAKE PROVISION MODULE LMP SIG TTOW PRK LT GRN/RED WIRE PNK/LT GRN WIRE RED/VIO WIRE STOP LAMP (AFTERMARKET) STOP LAMP SWITCH (ON BRAKE PEDAL SUPPORT) STOP LP SIG STP LMP SIG TOTALLY INTEGRATED POWER MODULE (LEFT FRONT OF TRAILER TOW MODULE TTOW RLY CTRL LT WHT WIRE WHT/DK GRN WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE WHT/ORG WIRE WHT/RED WIRE WHT/VIO WIRE WIRELESS IGNITION NODE YEL/RED WIRE

18 19 20 PNK WIRE AUTOMATIC SHUTDOWN RELAY BATTERY BLK WIRE BLK/LT BLU WIRE BLK/RED WIRE BLK/TAN WIRE BLK/WHT WIRE BRN WIRE CONTROLLER ANTI-LOCK BRAKE DK BLU/BLK WIRE DK BLU/YEL WIRE DK GRN WIRE DK GRN/ORG WIRE DK GRN/RED WIRE EGR EGR SOLENOID (ON TOP FRONT OF CYLINDER HEAD) FUEL SHUT-DOWN SOLENOID (ON SIDE OF INJECTOR PUMP, ON BRACKET) FUSE 3 FUSE 6 FUSED B(+) TPS SENS IN GEN FIELD DRV TCC DRVR GROUND GROUND GRY/BLK WIRE GRY/ORG WIRE GRY/YEL WIRE HOT AT ALL TIMES IAT SENS IN ECT SENS IN IGN (POWER) INTAKE AIR HEATER INTAKE AIR HEATER RELAY 1 (ON LEFT INNER FENDER, BELOW LEFT BATTERY) INTAKE AIR HEATER RELAY 2 (ON LEFT INNER FENDER, BELOW LEFT BATTERY) LT GRN/BLK WIRE LT GRN/WHT WIRE OIL PRESS SIG ORG/ WIRE ORG/BLK WIRE ORG/DK BLU WIRE OUTPUT SENS PARK/NEUTRAL POSITION SWITCH (ON LEFT SIDE OF TRANSMISSION) PNK WIRE POWERTRAIN CONTROL MODULE (IN ENG COMPT, ON RIGHT SIDE OF FIREWALL) RED/LT BLU WIRE RED/VIO WIRE RED/WHT WIRE SENSOR GRD STARTING/ CHARGING SYSTEM TAN/BLK WIRE TRANSMISSION OUPUT SHAFT SPEED SENSOR (ON LEFT SIDE OF TRANSMISSION) VAR FRCE SOL VIO WIRE VIO/WHT WIRE VSS IN OUTPUT SENS GOV PRESS SIG TRANS RELAY WAIT TO START OVERDRV SOL WATER IN FUEL WHT/ORG WIRE YEL/BLK WIRE

18 19 20 PNK WIRE BATTERY TEMPER- ATURE SENSOR (BELOW BATTERY TRAY) BLK WIRE BLK/LT BLU WIRE BLK/RED WIRE BLK/TAN WIRE BRN WIRE DK BLU/WHT WIRE DK BLU/YEL WIRE DK GRN/ORG WIRE DK GRN/RED WIRE ENGINE COOLANT TEMPERATURE SENSOR (ON LEFT SIDE OF CYLINDER HEAD, AT REAR END) ENGINE SPEED SENSOR (ON FRONT OF ENG, IN TIMING CHAIN CASE/COVER) ENGINE STARTER MOTOR RELAY (HOT IN START) FUEL HEATER (ABOVE ENGINE STARTER MOTOR) FUEL HEATER RELAY (ON POWER DISTRIBUTION CENTER) FUEL SHUT DOWN RELAY (ON FIREWALL, NEAR MASTER CYLINDER) FUSE 7 FUSE 9 GRY/BLK WIRE GRY/ORG WIRE HOT AT ALL TIMES HOT IN RUN OR START HOT IN RUN OR START JUNCTION BLOCK (RIGHT END OF DASH) FUSE 11 JOINT CONNECTOR 1 (IN PDC) JUNCTION BLOCK (RIGHT END OF DASH) FUSE 9 LT GRN/BLK WIRE LT GRN/WHT WIRE ORG/ WIRE ORG/BLK WIRE ORG/DK BLU WIRE PNK 4 5 6 WIRE PNK/YEL WIRE RED/BLK WIRE RED/TAN WIRE RED/VIO WIRE RED/YEL WIRE TAN WIRE TAN/BLK WIRE VIO WIRE VIO/WHT WIRE WATER IN-FUEL SENSOR (AT BOTTOM OF FUEL FILTER, IN DRAIN VALVE)

BATTERY BLK WIRE BLK/LT BLU WIRE BLK/PNK WIRE BLK/RED WIRE BLK/TAN WIRE BLK/WHT WIRE BRN WIRE COOLANT TEMP DIAG REQ DK BLU WIRE DK BLU/YEL WIRE DK GRN WIRE DK GRN/ORG WIRE DK GRN/RED WIRE EGR CONTROL MODULE EGR ENGINE ENGINE COOLANT TEMPERATURE SENSOR EGR FAULT EGR IAT EGR INTAKE AIR TEMPERATURE SENSOR EGR SOL EGR SOLENOID (RIGHT SIDE OF ENGINE) ENGINE SPEED SENSOR (FRONT OF ENGINE) ENGINE STARTER MOTOR RELAY (HOT IN START) FUEL HEATER (ABOVE STARTER MOTOR) FUEL HEATER RELAY (NEAR MASTER CYLINDER) FUEL SHUT DOWN RELAY (NEAR MASTER CYLINDER) FUEL SHUT DOWN SOLENOID (NEAR REAR OF INJECTION PUMP) GRY/BLK WIRE GRY/YEL WIRE LT GRN/BLK WIRE LT GRN/ORG WIRE LT GRN/RED WIRE NCA WIRE ORG/ WIRE ORG/DK BLU WIRE PNK 13 14 WIRE PNK 22 23 WIRE PNK/DK GRN WIRE RED WIRE RED/VIO WIRE SHUT DWN REL TAN WIRE TAN/BLK WIRE TEMP SEN GRD TP SENS SIG VEHICLE SPEED SENSOR (REAR OF TRANSMISSION) VIO WIRE VIO/WHT WIRE WHT/ORG WIRE

4 RTN 4 SIG 5 RTN 5 SIG 6 RTN 6 SIG AIR INTKE THRTL MTR (+) AIR INTKE THRTL MTR (-) ALTR FLD FD ASD CTRL BLK WIRE BOOST PRESSURE SENSOR BRN/DK BLU WIRE BRN/DK GRN WIRE BRN/GRY WIRE BRN/LT BLU WIRE BRN/LT GRN WIRE BRN/ORG WIRE BRN/PNK WIRE BRN/TAN WIRE BRN/VIO WIRE BRN/WHT WIRE BRN/YEL WIRE BST PRESS SIG CAM POSTN CAMSHAFT POSITION SENSOR CHRGE AIR TEMP SNSR COM SNSR COM SNSR RTN 4 COMPUTER DATA LINES SYSTEM CTRL COM SNSR RTN 4 DIFF PRESS SNSE DK BLU WIRE DK BLU/BRN WIRE DK BLU/GRY WIRE DK BLU/LT GRN WIRE DK BLU/WHT WIRE DK BLU/YEL WIRE DSL HIGH SIDE DRVR RTN EGR BYPSS VLV SIG EGR MTR OUT EGR MTR POS SIG 2 TURBO SPD SNSR SIG CAM POSTN SNSR SIG ELECTRONIC TURBO ACTUATOR ENG CTRL COM SNSR RTN 4 AIR THRTL STAT FDBK SIG 2 ENG FAN SPD OUT EXHAUST DIFFERENTIAL PRESSURE SENSOR FD 3 FUEL INJ + FUEL INJ 3 RTN FUEL INJ 2 RTN FUEL INJ 1 RTN FUEL INJECTOR 4 (TOP OF ENGINE, OVER CYLINDER 4) FUEL PUMP MOTOR GRY/BRN WIRE HI SIDE DRVR RTN INLET AIR PRESSURE SENSOR INTKE THRTL MTR (+) LT BLU/BRN WIRE LT GRN/BRN WIRE MAF AFLW SIG OIL PRESSURE SWITCH (LEFT SIDE OF ENGINE) ORG/BRN WIRE PMP PNK/YEL WIRE POWERTRAIN CONTROL MODULE RAD FAN MTR SPD RAD FAN MTR SPD SIG OIL PRESS SNSE/SW SIG RADIATOR FAN DRIVE RED/VIO WIRE RTN 4 SNSR SIG SSR IGN FD STARTING/ CHARGING SYSTEM THRTL STAT FDBK SIG 2 VIO/GRY WIRE VIO/ORG WIRE VLTG FD WHT/BRN WIRE WHT/DK GRN WIRE WHT/LT GRN WIRE YEL/BRN WIRE