Dodge Pickup R3500 (1996-2010) red Wiring diagrams

5.9L 6.7L 1 2 AUXILIARY BATTERY BATTERY BLK WIRE BRN WIRE ENGINE CONTROL MODULE (LOWER LEFT FRONT OF ENGINE BLOCK) FUSED B(+) FUSED B(+) FUSED B(+) GEN SENSE FUSIBLE LINK (8 GA- GEN FIELD CTRL GENERATOR GRY WIRE HOT AT ALL TIMES LT BLU WIRE NCA WIRE RED WIRE STARTER B(+) TOTALLY INTEGRATED POWER MODULE (AT LEFT FRONT FENDER) FUSE 42

6 10 (5.9L) (6.7L) A/T AUXILIARY BATTERY B(+) BATTERY BLK WIRE BLK/GRY WIRE BRN WIRE CAN B BUS (+) CHARGING CIRCUIT CLUTCH INTERLOCK SWITCH (EXCEPT 6.7L: BEHIND LEFT SIDE OF DASH) COMPUTER DATA LINES SYSTEM DK BLU WIRE ELECTRONICS ENGINE CONTROL MODULE (LOWER LEFT FRONT OF ENGINE BLOCK) EXCEPT RAM 3500 (CAB CHASSIS) FUSE 10 FUSE 11 FUSE 22 FUSED B (+) GRY WIRE GRY/RED WIRE HOLD-IN HOT AT ALL TIMES IGN SW OUT (START) GND IGN SW SENSE IGNITION SWITCH LT BLU WIRE M/T NCA WIRE ORG/ WIRE PULL- IN RAM 3500 (CAB CHASSIS) REAR OF ENGINE COMPT) RED WIRE SENSE SENTRY KEY REMOTE ENTRY MODULE (ON STEERING COLUMN) STARTER STARTER MTR CTRL OUTPUT TOTALLY INTEGRATED POWER MODULE TRANSMISSION RANGE SENSOR (LEFT SIDE OF TRANSMISSION) TRANSMISSION SOLENOID/TRS ASSEMBLY (RFE) (LEFT SIDE OF TRANSMISSION) TRS VIO WIRE VIO/BRN WIRE WHT WIRE WHT/ORG WIRE YEL WIRE

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 INPUT SPEED SENS SIG 1 2 3 4 5 6 7 8 9 10 11 12 PRESS SW 1 PRESS SW 6 1 2 3 4 5 6 7 8 9 10 NEUTRAL SW ALL TIMES B(+) TRANS SNS CTRL OUT BLK WIRE BLK/LT GRN WIRE CAN C BUS (+) CAN C BUS (-) COMPT) COMPUTER DATA LINES SYSTEM DK GRN WIRE DK GRN/BRN WIRE DK GRN/DK BLU WIRE DK GRN/GRY WIRE DK GRN/LT BLU WIRE DK GRN/LT GRN WIRE DK GRN/ORG WIRE DK GRN/PNK WIRE DK GRN/RED WIRE DK GRN/TAN WIRE DK GRN/VIO WIRE DK GRN/WHT WIRE DK GRN/YEL WIRE FUSE 10 FUSE 4 FUSE 24 FUSED B (+) GROUND FUSED IGN SW OUT (OFF-RUN-START) INPUT SPEED SENSOR (LEFT SIDE OF TRANSMISSION) LINEAR SOL 4 (+) LINEAR SOL 2 (+) LINEAR SOL 4 (-) LINEAR SOL 2 (-) PRESS SW 2 PRESS SW 3 LT BLU/BLK WIRE ORG/LT GRN WIRE OUTPUT SPEED SENS SIG TRANS CTRL OUTPUT TRANS CTRL OUTPUT OUTPUT SPEED SENSOR (LEFT REAR OF TRANSMISSION) PNK/WHT WIRE POWER TAKE OFF RELAY (INFO NOT AVAILABLE) POWER TAKEOFF RLY ENABLE RANGE SW 1 (OFF-RUN-START) TRS PARK SW GROUND RANGE SW DRV RANGE SW REVERSE RED WIRE TOTALLY INTEGRATED POWER MODULE (LEFT FRONT FENDER) ELECTRONICS TOW/HAUL OVERDR OFF SW TRANS TEMP SENS SIG TORQUE OIL TEMP SIG GROUND TOW/HAUL OVERDRIVE OFF SWITCH TRANSMISSION CONTROL MODULE (LEFT END OF DASH) TRANSMISSION RANGE SENSOR (LEFT SIDE OF TRANSMISSION) TRANSMISSION RELAY TRANSMISSION SOLENOID ASSEMBLY (LEFT SIDE OF TRANSMISSION) TRANSMISSION TEMPERATURE SENSOR (RIGHT SIDE OF TRANSMISSION) TRS RANGE SW DRV TRS RANGE SW PARK TRS RANGE SW REVERSE TRX-LINEAR SOL 3 (+) TRS RANGE SW 1 TRX-PRESS SW 4 TRX-PRESS SW 1 TRX-PRESS SW 5 TRX-PRESS SW 3 TRX-PRESS SW 6 TRX-PRESS SW 2 TRX-PRESS SW 8 WHT/LT BLU WIRE WHT/LT GRN WIRE YEL WIRE YEL/BRN WIRE YEL/DK BLU WIRE YEL/GRY WIRE YEL/ORG WIRE YEL/PNK WIRE YEL/RED WIRE YEL/VIO WIRE YEL/WHT WIRE

17 18 CAN B BUS(+) CAN B BUS(-) 33 42 28 27 APPS 1 RTN 36 37 6 25 SPEED CTRL BRAKE SW 4 5 1 21 CAN C BUS (+) CAN C BUS (-) 44 45 33 35 48 3 SPD SENS SIG SENS GND 6.7L 5.9L ACCEL ACCELERATOR PEDAL POSITION SENSOR (LEFT SIDE OF DASH) APPS 1 SIG APPS 1 RTN APPS 2 RTN APPS 2 SIG APPS 2 SIG APPS 2 RTN APPS 1 SIG BLK WIRE BLU WIRE BRN WIRE BRN/VIO WIRE BRN/WHT WIRE BRN/YEL WIRE CAN C BUS (+) CLUSTER COMPUTER DATA LINES SYSTEM DECEL DK BLU WIRE DK BLU/DK GRN WIRE DK GRN WIRE DK GRN/BRN WIRE DK GRN/ORG WIRE DK GRN/VIO WIRE DK GRN/WHT WIRE ENGINE CONTROL MODULE (LOWER LEFT FRONT OF ENGINE BLOCK) FUSE 28 GRN WIRE GRY WIRE HOT AT ALL TIMES HOT AT ALL TIMES TOTALLY INTEGRATED POWER MODULE (LEFT FRONT FENDER) FUSE 26 INPUT SPEED SENSOR (LEFT SIDE OF TRANSMISSION) LEFT SPEED CONTROL SWITCH OFF ORG/ WIRE OUTPUT SPEED SENSOR (5.9L) (BOTTOM OF TRANSMISSION) OUTPUT SPEED SENSOR (LEFT REAR OF TRANSMISSION) PNK EXTERIOR LIGHTS SYSTEM WIRE PNK WIRE REAR OF ENGINE COMPT) RED WIRE RESUME RIGHT SPEED CONTROL SWITCH SENS GND SENS GND S/C SW RTN S/C SW 1 SIG S/C SW 2 SIG 33 40 56 46 56 SENS SIG STEERING CONTROL MODULE (ON STEERING COLUMN) STOP LAMP SWITCH (ON BRAKE PEDAL SUPPORT) TAN WIRE TRANSMISSION CONTROL MODULE VIO WIRE VIO/BRN WIRE VIO/ORG WIRE VIO/YEL WIRE WHT WIRE WHT/BRN WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE WHT/ORG WIRE YEL WIRE YEL/DK BLU WIRE

5.9L 6.7L 1 2 AUXILIARY BATTERY BATTERY BLK WIRE BRN WIRE ENGINE CONTROL MODULE (LOWER LEFT FRONT OF ENGINE BLOCK) FUSED B(+) FUSED B(+) FUSED B(+) GEN SENSE FUSIBLE LINK (8 GA- GEN FIELD CTRL GENERATOR GRY WIRE HOT AT ALL TIMES LT BLU WIRE NCA WIRE RED WIRE STARTER B(+) TOTALLY INTEGRATED POWER MODULE (AT LEFT FRONT FENDER) FUSE 42

6 10 (5.9L) (6.7L) A/T AUXILIARY BATTERY B(+) BATTERY BLK WIRE BLK/GRY WIRE BRN WIRE CAN B BUS (+) CHARGING CIRCUIT CLUTCH INTERLOCK SWITCH (EXCEPT 6.7L: BEHIND LEFT SIDE OF DASH) COMPUTER DATA LINES SYSTEM DK BLU WIRE ELECTRONICS ENGINE CONTROL MODULE (LOWER LEFT FRONT OF ENGINE BLOCK) EXCEPT RAM 3500 (CAB CHASSIS) FUSE 10 FUSE 11 FUSE 22 FUSED B (+) GRY WIRE GRY/RED WIRE HOLD-IN HOT AT ALL TIMES IGN SW OUT (START) GND IGN SW SENSE IGNITION SWITCH LT BLU WIRE M/T NCA WIRE ORG/ WIRE PULL- IN RAM 3500 (CAB CHASSIS) REAR OF ENGINE COMPT) RED WIRE SENSE SENTRY KEY REMOTE ENTRY MODULE (ON STEERING COLUMN) STARTER STARTER MTR CTRL OUTPUT TOTALLY INTEGRATED POWER MODULE TRANSMISSION RANGE SENSOR (LEFT SIDE OF TRANSMISSION) TRANSMISSION SOLENOID/TRS ASSEMBLY (RFE) (LEFT SIDE OF TRANSMISSION) TRS VIO WIRE VIO/BRN WIRE WHT WIRE WHT/ORG WIRE YEL WIRE

2 1 UP PASS DN PASS 4 6 7 8 PASS HORI RR RD FUSED B (+) GND PASS HORI FR RD BLK/WHT WIRE CIRCUIT BREAKER HOT AT ALL TIMES LT GRN/BRN WIRE LT GRN/GRY WIRE LT GRN/ORG WIRE LT GRN/VIO WIRE LT GRN/WHT WIRE ORG LT GRN/ WIRE ORG/ WIRE ORG/RED WIRE PASS REC DN SW PASS REC UP SW PASSENGER SEAT HORIZONTAL ADJUSTER MOTOR PASSENGER SEAT RECLINER ADJUSTER MOTOR PASSENGER SEAT SWITCH RED WIRE TOTALLY INTEGRATED POWER MODULE (LEFT FRONT OF ENGINE COMPT) WHT LT GRN/ WIRE

AIR CONDITIONING SYSTEM AUXILIARY BATTERY BATTERY TEMPERATURE SENSOR (UNDER BATTERY TRAY) BLK WIRE BRAKE LAMP SIG HTR RLY CTRL S/C SW 2 SIG GROUND BRN WIRE BRN/BLK WIRE BRN/DK BLU WIRE BRN/DK GRN WIRE BRN/LT BLU WIRE BRN/ORG WIRE BRN/VIO WIRE BRN/WHT WIRE BRN/YEL WIRE CLUTCH INTERLOCK/ UPSTOP SWITCH (M/T) (LEFT SIDE OF DASH) COMPUTER DATA LINES SYSTEM DIAGNOSTIC PORT (TOP LEFT SIDE OF ENGINE) DK BLU/DK GRN WIRE DK BLU/LT GRN WIRE DK BLU/VIO WIRE DK GRN WIRE DK GRN/ORG WIRE DK GRN/WHT WIRE ENGINE CONTROL MODULE (LOWER LEFT FRONT OF ENGINE BLOCK) EXHAUST PRESSURE SENSOR 1/2 (RIGHT SIDE OF TRANSMISSION) EXHAUST TEMPERATURE SENSOR 1/1 (IN EXHAUST, FORWARD OF CATALYTIC CONVERTER) EXHAUST TEMPERATURE SENSOR 1/2 (IN EXHAUST, AT REAR OF CATALYTIC CONVERTER) EXHAUST TEMPERATURE SENSOR 1/3 (IN EXHAUST, DOWNSTREAM OF CATALYTIC CONVERTER) FUSED B (+) FUSIBLE LINK (10 GA- GROUND GROUND FUSED B(+) FUSED B(+) LOW DATA LINK INTAKE AIR HEATER INTAKE AIR HEATER RELAY (LEFT FRONT BUMPER) LT BLU WIRE LT GRN/BLK WIRE ORG/BRN WIRE PNK WIRE PNK/GRY WIRE RAM 2500 RED WIRE RED/YEL (OR BLK) WIRE RED/YEL (OR DK GRN) WIRE RED/YEL WIRE RLY CTRL RTN S/C SW 1 SIG RMT THROTTLE SIG S/C SW RTN PRES SENS SIG APPS 1 SIG SMT PWR RLY RTN A/C CLUTCH CTRL IGN SW OUT (RUN-START) TEMP 1 SENS SIG CAN C BUS (-) APPS 2 RTN UPSTOP SW SIG TAKEOFF SW IN INTERLOCK SW SIG SW RLY SIG VIO WIRE VIO/BRN WIRE VIO/DK GRN WIRE VIO/ORG WIRE VIO/YEL WIRE WHT WIRE WHT/BRN WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE WHT/ORG WIRE

5 VOLT SUPPLY ACCELERATOR PEDAL POSITION SENSOR (LEFT SIDE OF DASH) ADJ PIN SNS 2 APPS 1 RTN APPS 1 SIG APPS 2 RTN APPS 2 SIG B(+) HTR CTRL PMP CAN C CTRL OUT CTRL BUS (+) OUT BLK WIRE BLK/BRN WIRE BLK/ORG WIRE BLK/WHT WIRE BRN WIRE BRN/DK GRN WIRE BRN/LT BLU WIRE BRN/LT GRN WIRE BRN/ORG WIRE BRN/TAN WIRE BRN/VIO WIRE BRN/WHT WIRE CAN B BUS (+) CAN C BUS (+) CLUSTER (LEFT REAR OF ENGINE) COMPUTER DATA LINES SYSTEM CURRENT PIN FEED CURRENT TRIM DK BLU/DK GRN WIRE DK BLU/LT BLU WIRE DK BLU/WHT WIRE DK BLU/YEL WIRE DK GRN/WHT WIRE EGR SENS FEED ELECTRONICS EXHAUST BRAKE SWITCH FUEL HEATER (LEFT SIDE OF ENGINE) FUEL LVL SENS SIG FUEL PMP FUEL FUEL PUMP MODULE (IN FUEL TANK) FUSE 28 FUSE 30 FUSE 37 FUSE 42 GROUND HIGH DATA LINK HOT AT ALL TIMES HOT IN RUN OR HTR CTRL IGN (RUN-START) IGN SW OUT (RUN-START) LOW DATA LINK ORG/DK BLU WIRE ORG/RED WIRE PANEL LAMP DRV PNK/GRY WIRE PNK/YEL WIRE RED WIRE RED/ORG WIRE RTN (DOWNSTREAM) RTN (UPSTREAM) S/C SW 1 SIG S/C SW 2 SIG S/C SW RTN SENSOR GROUND SIGNAL STEERING CONTROL MODULE (ON STEERING COLUMN) STOP LAMP SWITCH (ON BRAKE PEDAL SUPPORT) TOTALLY INTEGRATED POWER MODULE (LEFT FRONT FENDER) VIO WIRE VIO/BRN WIRE VIO/DK GRN WIRE VIO/ORG WIRE VIO/WHT WIRE VIO/YEL WIRE WHT WIRE WHT/BRN WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE WHT/ORG WIRE

BLK WIRE BRN WIRE BRN/DK BLU WIRE BRN/DK GRN WIRE BRN/GRY WIRE BRN/LT BLU WIRE BRN/ORG WIRE BRN/PNK WIRE BRN/TAN WIRE BRN/VIO WIRE BRN/WHT WIRE BRN/YEL WIRE CRANKSHAFT POSITION SENSOR (LOWER LEFT FRONT OF ENGINE) DK BLU WIRE DK BLU/BRN WIRE DK BLU/GRY WIRE DK BLU/LT BLU WIRE DK BLU/LT GRN WIRE DK BLU/TAN WIRE DK BLU/WHT WIRE DK BLU/YEL WIRE EGR BYPASS VLV SIG FUEL CTRL RTN EGR TEMPERATURE SENSOR (TOP LEFT FRONT OF ENGINE) EGR VALVE ASSEMBLY ENGINE CONTROL MODULE (LOWER LEFT FRONT OF ENGINE BLOCK) ENGINE COOLANT TEMPERATURE SENSOR (TOP FRONT OF ENGINE) FAN SPD SENS GND FUEL INJECTOR 1 (TOP OF ENGINE, OVER CYLINDER 1) FUEL INJECTOR 2 (TOP OF ENGINE, OVER CYLINDER 2) FUEL INJECTOR 3 (TOP OF ENGINE, OVER CYLINDER 3) FUEL INJECTOR 4 (TOP OF ENGINE, OVER CYLINDER 4) FUEL INJECTOR 5 (TOP OF ENGINE, OVER CYLINDER 5) FUEL INJECTOR 6 (TOP OF ENGINE, OVER CYLINDER 6) GRY WIRE GRY/BRN WIRE GRY/DK BLU WIRE INTAKE TEMPERATURE /PRESSURE SENSOR (RAM 2500) (RIGHT SIDE OF ENGINE) LT BLU/BRN WIRE LT GRN/BRN WIRE OIL PRESSURE SWITCH (LEFT SIDE OF ENGINE) ORG/BRN WIRE PNK/YEL WIRE RED WIRE SENS GND SENS SIG SIG STARTING/ CHARGING SYSTEM TAN WIRE TTVA MTR (+) CRANKCASE SENS SIG ECT SIG TURBO SPEED SENSOR (LOWER RIGHT FRONT OF ENGINE) VIO/GRY WIRE VIO/LT GRN WIRE VIO/ORG WIRE VIO/WHT WIRE WATER IN FUEL SENSOR (MIDDLE LEFT SIDE OF ENGINE BLOCK) WHT/BRN WIRE WHT/LT GRN WIRE YEL/BRN WIRE