Dodge Pickup R3500 (1996-2010) radiator fan drive Wiring diagrams

1 2 3 4 5 6 DSL HIGH SIDE DRVR RTN ENG CTRL COM SNSR RTN RAD FAN MTR SPD SIG 1 2 3 4 AUTO HEADLAMPS SIG SUN SENSOR SIG 1 SUN SENSOR SIG 2 SENSOR GROUND 1 4 3 IGN RUN CTRL OUT IR SENSOR RETURN IR SENSOR SIGNAL 30 53 17 52 ENG CTRL COM SNSR RTN ENG CTRL COM SNSR RTN 4 RAD FAN MTR SPD SIG 4 2 3 1 BLWR MTR HI DRV FT BLW FD BLWR CTRL GND 70 16 33 6 IGN ULK/RUN/STRT A/C CLUTCH A/C CLUTCH COIL A/C COMPRESSOR, CLUTCH (LEFT SIDE OF ENGINE) A/C HEATER CONTROL A/C PRESS SIG A/C PRESS SNSE RTN A/C PRESS SNSE RTN A/C PRESS SNSR FD A/C PRESS SIG 1 2 3 A/C PRESS SNSR FD A/C PRESSURE TRANSDUCER B(+) BLK WIRE BLK/LT BLU WIRE BLK/LT GRN WIRE BLK/TAN WIRE BLOWER MODULE BLOWER MOTOR (RIGHT SIDE OF DASH) BLW MTR SPLY BRN WIRE BRN/LT BLU WIRE BRN/ORG WIRE BRN/PNK WIRE BRN/WHT WIRE BUS (-) CAN CAN IHS BUS (-) CAN IHS BUS (+) IOD FD FUSED IGN RUN CTRL OUT COIL COMPUTER DATA LINES SYSTEM CTRL OUT DK BLU WIRE DK BLU/DK GRN WIRE DK BLU/GRY WIRE DK BLU/LT BLU WIRE DK BLU/LT GRN WIRE DK BLU/ORG WIRE DK BLU/PNK WIRE DK BLU/RED WIRE DK BLU/TAN WIRE DK BLU/WHT WIRE DK BLU/YEL WIRE DK GRN WIRE DRIVER BLEND DOOR ACTUATOR (ON HVAC UNIT) ENGINE CONTROLS SYSTEM ENGINE COOLANT TEMPERATURE SENSOR EVAP SIG EVAP SNSE RTN EVAPORATOR TEMPERATURE SENSOR (CENTER OF DASH) FAN RADIATOR HIGH RELAY FAN RADIATOR LOW RELAY FUSE HALLEFCT ELECN ENG SPD OUT HALLEFCT ELECN ENG SPD OUT ENG CTRL COM SNSR RTN 2 COOL TEMP SNSR SIG 65 20 40 HOT AT ALL TIMES HOT AT ALL TIMES FUSE HOT W/ RUN RELAY ENERGIZED INFRARED SENSOR LT BLU WIRE LT BLU/BRN WIRE LT BLU/ORG WIRE LT BLU/RED WIRE LT GRN WIRE MODE DOOR ACTUATOR 1 (ON HVAC UNIT) MODE DOOR ACTUATOR 2 (ON HVAC UNIT) NAVIGATION SYSTEM ORG/ WIRE PASSENGER BLEND DOOR ACTUATOR (ON HVAC UNIT) PNK/WHT WIRE PNK/YEL WIRE POWERTRAIN CONTROL MODULE RAD FAN RAD FAN LOW SPD SIG RADIATOR FAN RADIATOR FAN DRIVE RECIRCULATION DOOR ACTUATOR RED/WHT WIRE RUN/START SIG HI SPD SUN SENSOR TAN WIRE TOTALLY INTEGRATED POWER MODULE (LEFT FRONT OF ENGINE COMPT) CIRCUIT BOARD VIO/LT BLU WIRE VIO/ORG WIRE WHT/DK BLU WIRE WHT/GRY WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE WHT/ORG WIRE WHT/VIO WIRE

1 2 3 4 5 6 DSL HIGH SIDE DRVR RTN ENG CTRL COM SNSR RTN RAD FAN MTR SPD SIG 30 53 17 ENG CTRL COM SNSR RTN ENG CTRL COM SNSR RTN 4 RAD FAN MTR SPD SIG A/C PRESS PRESS SNS SNS SIG RTN FD A/C PRESS SIG A/C PRESS SNSE RTN A/C PRESS SNSR FD A/C PRESSURE TRANSDUCER BLK WIRE BLK/LT BLU WIRE BRN/LT BLU WIRE BRN/ORG WIRE BRN/PNK WIRE BRN/WHT WIRE BUS (-) CAN COMPUTER DATA LINES SYSTEM DK BLU/DK GRN WIRE DK BLU/GRY WIRE DK GRN/DK BLU WIRE ENGINE CONTROLS SYSTEM ENGINE COOLANT TEMPERATURE SENSOR FAN RADIATOR FUSE HALLEFCT ELECN ENG SPD OUT HALLEFCT ELECN ENG SPD OUT ENG CTRL COM SNSR RTN 2 COOL TEMP SNSR SIG HOT AT ALL TIMES IGN ULK/RUN/STRT 16 33 6 LT BLU/BRN WIRE LT BLU/ORG WIRE PNK/WHT WIRE PNK/YEL WIRE POWER MODULE (LEFT FRONT OF ENGINE COMPT) CIRCUIT BOARD POWERTRAIN CONTROL MODULE PRESS. RAD FAN HI SPD SIG RAD FAN LOW SPD SIG RADIATOR FAN DRIVE RADIATOR FAN HIGH RELAY RADIATOR FAN LOW RELAY RUN/START TOTALLY INTEGRATED VIO/ORG WIRE WHT/DK BLU WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE

A/T A/T ANTI-LOCK ENGINE BRAKES MODULE CONTROL MODULE ASSEMBLY WINCH (POWER WAGON) AUXILIARY BATTERY (DIESEL) BATTERY BLK WIRE BLK/LT BLU WIRE BRAKE PROVISION MODULE BRN WIRE BRN/RED WIRE CLUSTER FREE HANDS MODULE CLUSTER MOTOR/ SUNROOF MODULE DASH) DATA LINK CONNECTOR DIESEL DK GRN WIRE DK GRN/RED WIRE DK GRN/YEL WIRE DRIVER DRIVER SEAT WINDOW/ SWITCH DOOR LOCK SWITCH ELECTRONIC A/C OVERHEAD HEATER MODULE CONTROL (EXCEPT BASE) EXCEPT BASE EXCEPT SRT-10 EXCEPT SRT-10 SRT-10 FINAL DRIVE CONTROL MODULE FUSE FUSE 1 FUSE 11 FUSE 12 FUSE 13 (TRAILER TOW) (AWAL) FUSE 2 FUSE 25 FUSE 26 FUSE 27 FUSE 31 (EXCEPT SRT-10) FUSE 38 (EXCEPT SRT-10) FUSE 5 FUSE 35 (EXCEPT BASE) FUSE 6 (DIESEL) FUSE 7 (SRT-10) FUSE 9 (POWER WAGON) FUSE FUSE 18 42 (DIESEL) (AWAL) FUSED B (+) FUSIBLE LINK (12 GA- FUSIBLE LINK (8 GA- GAS GENERATOR GRY/RED WIRE IGNITION IGNITION SWITCH SWITCH OUTPUT MUX (START) SENSE IGNITION SWITCH IGNITION SWITCH OUTPUT (RUN-START) IGNITION SWITCH SENSE RETURN INTAKE AIR HEATER RELAY (DIESEL) LT BLU WIRE LT BLU/RED WIRE NCA WIRE NEAR ENGINE CONTROL MODULE) OF ENGINE) ORG/RED WIRE PASSENGER SEAT SWITCH PNK/WHT WIRE PNK/YEL WIRE POWER OUTLET POWER OUTLET CONSOLE (EXCEPT BASE) PUSH BUTTON STARTER SWITCH RADIATOR FAN DRIVE RADIO AMPLIFIER (PREMIUM) RADIO CLUSTER RED WIRE RED/DK BLU WIRE RED/LT BLU WIRE RED/ORG WIRE RED/YEL WIRE REVERSE LOCKOUT SOLENOID SATELLITE MONITOR/ RECEIVER DVD MEDIA SYSTEM SENTRY KEY REMOTE ENTRY MODULE SHIFT MOTOR/MODE SENSOR ASSEMBLY SLT+/ SRT-10 SRT-10 SRT-10 EXCEPT SRT-10 SLT+/ STARTER STARTER MOTOR RELAY (EXCEPT SRT-10) STOP LAMP SWITCH SUBWOOFER AMPLIFIER (SRT-10) TAN/RED WIRE TO TOTALLY INTEGRATED POWER MODULE (DIAGRAM 2 OF 2) TOTALLY INTEGRATED POWER MODULE (AT LEFT FRONT FENDER) UNDERHOOD LAMP (SRT-10) (BEHIND LEFT SIDE OF DASH) POWERTRAIN CONTROL MODULE VIO/BRN WIRE VIO/ORG WIRE W/ SATELLITE W/ W/O HANDS HANDS FREE FREE WASTEGATE SOLENOID YEL/RED WIRE

4 RTN 4 SIG 5 RTN 5 SIG 6 RTN 6 SIG AIR INTKE THRTL MTR (+) AIR INTKE THRTL MTR (-) ALTR FLD FD ASD CTRL BLK WIRE BOOST PRESSURE SENSOR BRN/DK BLU WIRE BRN/DK GRN WIRE BRN/GRY WIRE BRN/LT BLU WIRE BRN/LT GRN WIRE BRN/ORG WIRE BRN/PNK WIRE BRN/TAN WIRE BRN/VIO WIRE BRN/WHT WIRE BRN/YEL WIRE BST PRESS SIG CAM POSTN CAMSHAFT POSITION SENSOR CHRGE AIR TEMP SNSR COM SNSR COM SNSR RTN 4 COMPUTER DATA LINES SYSTEM CTRL COM SNSR RTN 4 DIFF PRESS SNSE DK BLU WIRE DK BLU/BRN WIRE DK BLU/GRY WIRE DK BLU/LT GRN WIRE DK BLU/WHT WIRE DK BLU/YEL WIRE DSL HIGH SIDE DRVR RTN EGR BYPSS VLV SIG EGR MTR OUT EGR MTR POS SIG 2 TURBO SPD SNSR SIG CAM POSTN SNSR SIG ELECTRONIC TURBO ACTUATOR ENG CTRL COM SNSR RTN 4 AIR THRTL STAT FDBK SIG 2 ENG FAN SPD OUT EXHAUST DIFFERENTIAL PRESSURE SENSOR FD 3 FUEL INJ + FUEL INJ 3 RTN FUEL INJ 2 RTN FUEL INJ 1 RTN FUEL INJECTOR 4 (TOP OF ENGINE, OVER CYLINDER 4) FUEL PUMP MOTOR GRY/BRN WIRE HI SIDE DRVR RTN INLET AIR PRESSURE SENSOR INTKE THRTL MTR (+) LT BLU/BRN WIRE LT GRN/BRN WIRE MAF AFLW SIG OIL PRESSURE SWITCH (LEFT SIDE OF ENGINE) ORG/BRN WIRE PMP PNK/YEL WIRE POWERTRAIN CONTROL MODULE RAD FAN MTR SPD RAD FAN MTR SPD SIG OIL PRESS SNSE/SW SIG RADIATOR FAN DRIVE RED/VIO WIRE RTN 4 SNSR SIG SSR IGN FD STARTING/ CHARGING SYSTEM THRTL STAT FDBK SIG 2 VIO/GRY WIRE VIO/ORG WIRE VLTG FD WHT/BRN WIRE WHT/DK GRN WIRE WHT/LT GRN WIRE YEL/BRN WIRE