Dodge Pickup R3500 (1996-2010) power distribution center Wiring diagrams

5 VOLT SUPPLY 8 9 10 11 PNK WIRE BLK WIRE BLK/LT BLU WIRE BLK/WHT WIRE BRN WIRE CONTROLLER ANTI-LOCK BRAKE DK BLU WIRE ENG HARN, NEAR FUEL INJ 5 BREAKOUT) ENGINE CONTROLS SYSTEM ENGINE COOLANT TEMPERATURE SENSOR (ON THERMOSTAT HOUSING) ENGINE STARTER MOTOR RELAY FUSE FUSE 3 GENERATOR GOVERNOR PRESSURE SIGNAL GRN WIRE HOT AT ALL TIMES INNER FENDER) JOINT CONNECTOR 2 LT BLU WIRE LT GRN/WHT WIRE OF HYDRAULIC CONTROL UNIT) ORG/ WIRE ORG/BLK WIRE ORG/DK BLU WIRE OVERDRIVE SOLENOID CONTROL VARIABLE FORCE SOLENOID CONTROL PARK/ NEUTRAL POSITION SWITCH (ON LEFT SIDE OF TRANSMISSION) PNK WIRE POWER DISTRIBUTION CENTER RED WIRE RED/WHT WIRE SENSOR GROUND TAN WIRE TAN/BLK WIRE THROTTLE POSITION SENSOR (ON THROTTLE BODY) TORQUE CONVERTER CLUTCH SOLENOID CONTROL TRANS CTRL RLY OUTPUT TRANSMISSION CONTROL RELAY TRANSMISSION SOLENOID ASSEMBLY (TRANSMISSION) TRANSMISSION TEMPERATURE SENSOR SIGNAL VIO WIRE VIO/WHT WIRE WHT WIRE WHT/DK BLU WIRE WHT/ORG WIRE YEL WIRE

AUTOMATIC SHUT DOWN RELAY (IN POWER DISTRIBUTION CENTER) BLK WIRE DK BLU WIRE DK GRN WIRE DK GRN/ORG WIRE FUSE 4 FUSE 8 GEN FUSE GENERATOR GENERATOR FIELD GRY/WHT WIRE LEFT BATTERY ORG/ WIRE PNK POWER DISTRIBUTION WIRE POWER DISTRIBUTION CENTER POWERTRAIN CONTROL MODULE (RIGHT SIDE OF DASH PANEL) RELAY B+ RED WIRE RED/WHT WIRE RIGHT BATTERY STARTING SYSTEM WHT WIRE

A/T A/T ONLY BLK WIRE BLK/TAN WIRE BLK/WHT WIRE BRN WIRE CLUTCH PEDAL POSITION SWITCH (ON CLUTCH ROD) DK BLU WIRE DK BLU/YEL WIRE ENGINE STARTER MOTOR ENGINE STARTER MOTOR RELAY (IN POWER DISTRIBUTION CENTER) FUSE 2 FUSE 3 IGNITION SWITCH LEFT BATTERY LOCK M/T M/T ONLY PARK/NEUTRAL POSITION SWITCH PNK/BLK WIRE POWER DISTRIBUTION CENTER POWERTRAIN CONTROL MODULE (RIGHT SIDE RED WIRE RIGHT BATTERY RUN WIRE STARTER OF DASH PANEL) TO FUEL SHUTDOWN RELAY WHT WIRE YEL WIRE YEL/RED WIRE

10 11 12 13 PNK WIRE BLK WIRE BLK/LT BLU WIRE BLK/WHT WIRE BRN WIRE DK BLU WIRE EGR CONTROL MODULE ENGINE CONTROLS SYSTEM ENGINE COOLANT TEMPERATURE SENSOR (BETWEEN GENERATOR, A/C COMPRESSOR) ENGINE SPEED SENSOR (ON FRONT OF ENG, IN TIMING CHAIN CASE/COVER) ENGINE STARTER MOTOR RELAY FUEL PUMP RELAY FUSE 8 GENERATOR GOVERNOR PRESSURE SIGNAL GRN WIRE GRY/BLK WIRE HOT AT ALL TIMES INSTRUMENT CLUSTER (SPEEDOMETER) LT BLU WIRE LT GRN/WHT WIRE OF TRANSFER CASE) OF TRANSMISSION EXTENSION HOUSING, ORG/ WIRE ORG/BLK WIRE ORG/DK BLU WIRE PARK/ NEUTRAL POSITION SWITCH (ON LEFT SIDE OF TRANSMISSION) PNK WIRE POWER DISTRIBUTION CENTER RED WIRE RED/WHT WIRE SENSOR GROUND 5 VOLT SUPPLY TAN/BLK WIRE THROTTLE POSITION SENSOR (ON TOP OF INJECTOR PUMP) TRANS CTRL RLY OUTPUT TRANSMISSION CONTROL RELAY TRANSMISSION SOLENOID ASSEMBLY (TRANSMISSION) TRANSMISSION TEMPERATURE SENSOR SIGNAL VEHICLE SPEED SENSOR VIO WIRE VIO/WHT WIRE W/ EGR COTROL MODULE W/O EGR COTROL MODULE WHT WIRE WHT/DK BLU WIRE WHT/ORG WIRE

5 VOLT SUPPLY 8 9 10 11 PNK WIRE BLK WIRE BLK/LT BLU WIRE BLK/WHT WIRE BRN WIRE CONTROLLER ANTI-LOCK BRAKE DK BLU WIRE ENG HARN, NEAR FUEL INJ 5 BREAKOUT) ENGINE CONTROLS SYSTEM ENGINE COOLANT TEMPERATURE SENSOR (ON THERMOSTAT HOUSING) ENGINE STARTER MOTOR RELAY FUSE FUSE 3 GENERATOR GOVERNOR PRESSURE SIGNAL GRN WIRE HOT AT ALL TIMES INNER FENDER) JOINT CONNECTOR 2 LT BLU WIRE LT GRN/WHT WIRE OF HYDRAULIC CONTROL UNIT) ORG/ WIRE ORG/BLK WIRE ORG/DK BLU WIRE OVERDRIVE SOLENOID CONTROL VARIABLE FORCE SOLENOID CONTROL PARK/ NEUTRAL POSITION SWITCH (ON LEFT SIDE OF TRANSMISSION) PNK WIRE POWER DISTRIBUTION CENTER RED WIRE RED/WHT WIRE SENSOR GROUND TAN WIRE TAN/BLK WIRE THROTTLE POSITION SENSOR (ON THROTTLE BODY) TORQUE CONVERTER CLUTCH SOLENOID CONTROL TRANS CTRL RLY OUTPUT TRANSMISSION CONTROL RELAY TRANSMISSION SOLENOID ASSEMBLY (TRANSMISSION) TRANSMISSION TEMPERATURE SENSOR SIGNAL VIO WIRE VIO/WHT WIRE WHT WIRE WHT/DK BLU WIRE WHT/ORG WIRE YEL WIRE

A/C COMPRESSOR CLUTCH A/C COMPRESSOR CLUTCH RELAY A/C HEATER CONTROL A/C HIGH PRESSURE SWITCH A/C LOW PRESSURE SWITCH (ON TOP OF A/C ACCUMULATOR) A/C SELECT SENSE BI-LEVEL PANEL RECIRC/ PANEL BLK WIRE BLK/ORG WIRE BLK/WHT WIRE BLOWER MOTOR BLOWER MOTOR RELAY BLOWER MOTOR RESISTOR BLOCK (RIGHT SIDE OF DASH) BLOWER SWITCH BRN WIRE DEF MODE SWITCH DIESEL GAS DK BLU WIRE DK BLU/BLK WIRE DK BLU/ORG WIRE DK BLU/WHT WIRE DK GRN WIRE FLOOR MIX FUSE 12 FUSE 2 HI-A/C HEAT-HI HOT AT ALL TIMES HOT AT ALL TIMES FUSE HOT IN RUN HOT IN RUN OR START FUSE 9 JOINT CONNECTOR NO. 1 (IN POWER DISTRIBUTION CENTER) JUNCTION BLOCK LT BLU WIRE LT GRN WIRE LT GRN/WHT WIRE OFF OFF HEAT-LOW LOW-A/C ORG/ WIRE PNK/DK BLU WIRE POWER DISTRIBUTION CENTER TAN WIRE

A/C COM- PRESSOR CLUTCH A/C FUEL COM- SHUT PRESSOR DOWN FUEL CLUTCH SOLENOID HEATER AIRBAG CONTROL MODULE RADIO BLK WIRE BLK/DK BLU WIRE BLK/LT GRN WIRE BLK/PNK WIRE BLK/TAN WIRE BLK/VIO WIRE BLK/WHT WIRE BLOWER MOTOR RELAY BRAKE UNDER- HOOD WIPER PRESSURE LAMP MOTOR SWITCH CONTROLLER GENERATOR ANTI-LOCK BRAKE DATA LINK CONNECTOR DAYTIME RUNNING LAMP MODULE DIESEL DIESEL ONLY ENGINE STARTER MOTOR RELAY FOG LAMP RELAY FUEL HEATER RELAY FUEL PUMP MODULE FUEL PUMP RELAY FUEL SHUT DOWN RELAY GAS HIGH NOTE HORN J/C 1 (IN PDC) J/C 3 J/C 4 LEFT BACK-UP LAMP LEFT FOG LAMP LEFT HEADLAMP LEFT PARK/TURN SIGNAL LAMP LEFT RIGHT FRONT FRONT DOOR DOOR SPEAKER SPEAKER LEFT UPSTREAM HEATED OXYGEN POWERTRAIN SENSOR CONTROL MODULE LOW NOTE HORN LOW WASHER FLUID SWITCH POWER DISTRIBUTION CENTER POWERTRAIN CONTROL MODULE PREMIUM RADIO CHOKE RELAY RIGHT HEADLAMP RIGHT PARK/TURN SIGNAL LAMP RIGHT RIGHT BACK-UP LICENSE TRAILER LAMP LAMP TOW CON- NECTOR RIGHT TAIL/ STOP/TURN SIGNAL LAMP SWITCH TOP OF TRANSMISSION) TRAILER TOW RELAY VEHICLE SPEED CONTROL SERVO RIGHT FOG LAMP WINDSHIELD WASHER PUMP MOTOR

A/C COMPRESSOR CLUTCH A/C HEATER CONTROL ASH RECEIVER LAMP BLK ORG/ WIRE BLK TAN/ WIRE BLK WIRE BLK/LT GRN WIRE BLK/ORG WIRE BLK/PNK WIRE BLK/TAN WIRE BLK/WHT WIRE CENTER HIGH CENTER HIGH MOUNTED MOUNTED STOP LAMP STOP LAMP CENTRAL TIMER MODULE CLUB CAB ONLY COMBINATION FLASHER CUMMINS BUS POWER DATA LINK CONNECTOR DAY/ OVER- NIGHT HEAD MIRROR CONSOLE DRIVER PASSENGER SEAT SEAT SOLENOID SOLENOID ELECTRIC BRAKE CUP HOLDER LAMP ENGINE CONTROL MODULE ENGINE STARTER MOTOR RELAY EXCEPT CLUB CAB FOG LAMP SWITCH FROM FUEL HEATER FUEL INJECTOR PUMP FUEL TRANSFER PUMP GLOVE BOX LAMP) HEATED MIRROR SWITCH INSTRU- CIGAR MENT LIGHTER CLUSTER INSTRU- MENT CLUSTER INTAKE AIR HEATER RELAY 1 INTAKE AIR HEATER RELAY 2 INTEGRATED ELECTRONIC MODULE J/C 5 (BEHIND LEFT SIDE OF DASH) JUNCTION BLOCK LEFT CENTER OUTBOARD IDENTI- IDENTIFICATION FICATION LAMP LAMP LEFT DOOR DISARM SWITCH LEFT DOOR LEFT WINDOW/ POWER LOCK MIRROR SWITCH MOTORS LEFT DOOR WINDOW/ LOCK SWITCH LEFT OUTBOARD CLEARANCE LAMP LEFT RIGHT VISOR/ VISOR/ VANITY VANITY LAMP LAMP LEFT SEAT DOOR BELT JAMB CONTROL SWITCH MODULE ORG BLK WIRE OVER DRIVE SWITCH OVER- HEAD CONSOLE OVERHEAD MAP/ COURTESY LAMPS POWER DISTRIBUTION CENTER POWER MIRROR SWITCH POWER OUTLET POWER SEAT SWITCH POWERTRAIN CONTROL MODULE RIGHT DOOR JAMB SWITCH RIGHT OUTBOARD CLEARANCE LAMP RIGHT OUTBOARD IDENTIFICATION LAMP STOP LAMP SWITCH

1 2 3 4 5 6 7 8 TRANS RLY OUT A/T AUTOMATIC SHUTDOWN RELAY BATTERY BLK WIRE BLK/LT BLU WIRE BLK/RED WIRE BLK/TAN WIRE BLK/WHT WIRE BRN WIRE DK BLU WIRE DK BLU/BLK WIRE DK BLU/YEL WIRE DK GRN WIRE DK GRN/ORG WIRE DK GRN/RED WIRE EGR FAULT MON EGR SOL CTRL ENGINE COOLANT TEMPERATURE SENSOR (LEFT REAR OF CYLINDER HEAD) FUSE 8 FUSE 4 FUSED B(+) TPS SENS IN GEN FIELD DRV TCC DRVR GROUND GROUND GRY/BLK WIRE GRY/WHT WIRE GRY/YEL WIRE HEATED INTAKE AIR SYSTEM HEATED INTAKE AIR SYSTEM RELAY NO. 1 (BELOW LEFT BATTERY) HEATED INTAKE AIR SYSTEM RELAY NO. 2 (BELOW LEFT BATTERY) HOT AT ALL TIMES HOT IN RUN AND START FUSE BLOCK FUSE 9 IAT SENS IN ECT SENSOR IGN (POWER) INSTRUMENT CLUSTER SYSTEM LT GRN WIRE LT GRN/BLK WIRE LT GRN/ORG WIRE LT GRN/RED WIRE LT GRN/WHT WIRE M/T NCA WIRE ORG/ WIRE ORG/BLK WIRE ORG/DK BLU WIRE OUTPUT SENS PARK/NEUTRAL POSITION SWITCH PNK 22 23 WIRE PNK WIRE POWER DISTRIBUTION CENTER POWERTRAIN CONTROL MODULE (RIGHT SIDE SAFETY WALL) PRK/NEUTRAL AIR SYS RLY 1 SPEED SENS SIG AIR SYS RLY 2 RED WIRE RED/WHT WIRE SENSOR GRD SENSOR GRD GOV PRESS SIG VAR FORCE SOL OVERDRV SOL TCC SOL CTRL TRANS TEMP SNS TAN/BLK WIRE THROTTLE POSITION SENSOR (SIDE OF THROTLLE BODY) TRANS TEMP IN TRANSMISSION OUPUT SHAFT SPEED SENSOR (LEFT REAR OF TRANSMISSION) TRANSMISSION SOLENOID ASSEMBLY (TRANSMISSION) VAR FRCE SOL VIO WIRE VIO/WHT WIRE VSS IN OUTPUT SENS GOV PRESS SIG TRANS RELAY WAIT TO START OVERDRV SOL WATER IN FUEL WHT/ORG WIRE YEL/BLK WIRE

A/C COMP RLY A/C HIGH PRESSURE CUTOUT SWITCH (A/C HIGH PRESSURE LINE) A/C LOW PRESSURE CUTOUT SWITCH (A/C LOW PRESSURE LINE) A/C REQUEST A/C SELECT IN BRAKE SW IN GENERATOR A/C SYSTEM AIR CONDITIONING SYSTEM (A/C-HEATER CONTROL SWITCH) AUTO SHT RLY CRUISE VAC SOL CRUISE VNT SOL OVERDRV IND TRANS TEMP IND BATT TEMP SENS GEN IND DRVR MIL IND DRVR WATER IN FUEL BATTERY TEMPER- ATURE SENSOR (BELOW BATTERY) BLK/LT BLU WIRE BLK/ORG WIRE BLK/PNK WIRE BLK/RED WIRE BLK/WHT WIRE BRN WIRE CRUISE CONTROL SYSTEM CRUISE FEED ASD RELAY SENS TRANS OVERDRV DATA LINK CONNECTOR DK BLU/ORG WIRE DK BLU/WHT WIRE DK BLU/YEL WIRE DK GRN WIRE DK GRN/ORG WIRE DK GRN/RED WIRE EGR DIAG FUSE 11 FUSE BLOCK GEN IND LAMP GENERATOR GRY/LT BLU WIRE HOT IN START OR RUN INSTRUMENT CLUSTER INSTRUMENT CLUSTER SYSTEM INTAKE AIR TEMPER- ATURE SENSOR (RIGHT SIDE OF INTAKE MANIFOLD) JOINT CONNECTOR C (BEHIND LEFT KNEE BOLSTER) LT GRN WIRE LT GRN/ORG WIRE LT GRN/RED WIRE LT GRN/WHT WIRE MIL IND LAMP NCA WIRE ORG/ WIRE ORG/BLK WIRE ORG/WHT WIRE OVERDRIVE SWITCH PNK 13 14 WIRE PNK WIRE PNK/BLK WIRE PNK/DK BLU WIRE PNK/DK GRN WIRE PNK/YEL WIRE POWER DISTRIBUTION CENTER POWERTRAIN CONTROL MODULE (RIGHT SIDE SAFETY WALL) RED WIRE RED/LT GRN WIRE SCI RECEIVE SCI TRANSMIT SPEEDOMETER STOP LAMP SWITCH (UNDER LEFT SIDE OF I/P) TACH SIGNAL TACH SIGNAL CRUISE SW IN TAN/ORG WIRE TAN/RED WIRE TAN/YEL WIRE TRANS- MISSION RELAY WATER IN FUEL SENSOR (BOTTOM OF FUEL FILTER) WHT/DK BLU WIRE WHT/ORG WIRE WHT/PNK WIRE YEL/RED WIRE