Dodge Pickup R3500 (1996-2010) dk blu/yel Wiring diagrams

BACK-UP LAMPS CIRCUIT, MIRRORS SYSTEM BLK WIRE BLK/RED WIRE BLK/WHT WIRE BRN WIRE BRN/LT GRN WIRE BRN/YEL WIRE DK BLU WIRE DK BLU/BLK WIRE DK BLU/YEL WIRE DK GRN WIRE DK GRN/BLK WIRE DK GRN/WHT WIRE DK GRN/YEL WIRE FUSE 38 FUSE 5 GND MS SOL CTRL GRY WIRE GRY/LT BLU WIRE HOT AT ALL TIMES HOT IN RUN IGNITION SWITCH INTEGRATED POWER MODULE (ON LEFT FRONT OF ENGINE COMPT) LOCK OFF LR/CC SOL CTRL LT BLU WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/WHT WIRE OD SOL CTRL ORG/BLK WIRE ORG/WHT WIRE PCI BUS PNK WIRE PNK/LT BLU WIRE PNK/ORG WIRE RED WIRE RED/BLK WIRE RED/WHT WIRE RUN WIRE SCI RECEIVE TAN/BLK WIRE TRANS RLY OUT GND TRANSMISSION CONTROL MODULE (ON RIGHT REAR OF ENGINE COMPT) TRANSMISSION CONTROL RELAY TRANSMISSION SOLENOID/TRS ASSEMBLY (INSIDE TRANSMISSION) VIO WIRE VIO/BLK WIRE VIO/LT GRN WIRE VIO/ORG WIRE VIO/TAN WIRE VIO/WHT WIRE VSS SIG UD PRESS SW LINE PRESS SENS WHT/DK BLU WIRE WHT/DK GRN WIRE YEL WIRE YEL/DK BLU WIRE YEL/DK GRN WIRE YEL/RED WIRE

APPS 1 OUT BLK WIRE BLK/RED WIRE BRN/YEL WIRE CONTROLLER ANTI-LOCK BRAKE (LEFT REAR OF ENGINE COMPT) DATA LINK CONNECTOR (BELOW LEFT SIDE OF DASH) DK BLU/BLK WIRE DK BLU/YEL WIRE DK GRN WIRE DK GRN/YEL WIRE GRD GRY/LT BLU WIRE INPUT SPEED SENSOR (ON LEFT FRONT OF TRANSMISSION) LINE PRESSURE SENSOR (ON RIGHT REAR OF TRANSMISSION) LT BLU WIRE LT GRN/WHT WIRE ORG/WHT WIRE OUTPUT SPEED SENSOR (ON LEFT REAR OF TRANSMISSION) OVERDRIVE SWITCH P/N SW SENS PNK WIRE PNK/LT BLU WIRE POWERTRAIN CONTROL MODULE (ON RIGHT SIDE OF FIREWALL) RED/BLK WIRE RED/WHT WIRE RPM SIG TAN/BLK WIRE TORQ SENSE TPS 1 OUT VIO WIRE VIO/ORG WIRE VIO/TAN WIRE VSS SIG WHT WIRE WHT/DK GRN WIRE YEL/DK GRN WIRE YEL/RED WIRE

17 18 TRANS CTRL OUT ASD RLY CTRL 20 21 22 23 24 25 26 FUSED IGN RUN/ST CTRL A/C CLUTCH COIL A/C PRESS SNSE RTN A/C PRESS SIG A/C PRESS SNSR FD AIR CONDITIONING SYSTEM AIR CONDITIONING, NAVIGATION SYSTEMS ANTI-LOCK BRAKES SYSTEM BATT FD BATT FD 9 BLK WIRE BLK/BRN WIRE BLK/LT BLU WIRE BRK LVL SW SIG BRN WIRE BRN/BLK WIRE BRN/GRY WIRE BRN/WHT WIRE CAN-BUS CAN-BUS COMPUTER DATA LINES SYSTEM DEFOGGER SYSTEM SEATS SYSTEM EXTERIOR LIGHTS SYSTEM DK BLU WIRE DK BLU/YEL WIRE DK GRN/ORG WIRE DK GRN/RED WIRE DOOR LOCKS SYSTEM DR LK RT FT ELEC BKLT FD IGN R TTOW PRK LMP SIG FUSED ASD RLY OUT FUSED ASD RLY OUT BATT FD ENG CTRL DRCT BATT FD ENG CTRL RUN/STRT IGN STP LMP SIG IGN ULK/RUN/STRT A/C CLUTCH FD ENGINE CONTROLS SYSTEM EXTERIOR LIGHTS SYSTEM SEATS SYSTEM POWER TOPS SYSTEM EXTERIOR LIGHTS SYSTEM FUEL PUMP CTRL GND BATT FD IGN (RUN) IGN R IGN RS LT BLU/BRN WIRE LT BLU/ORG WIRE LT GRN/GRY WIRE PNK/GRY WIRE PNK/LT GRN WIRE PNK/VIO WIRE PNK/WHT WIRE PNK/YEL WIRE POWER DISTRIBUTION SYSTEM POWER WINDOWS SYSTEM RED WIRE RED/GRY WIRE RED/LT BLU WIRE RED/LT GRN WIRE RED/VIO WIRE RED/YEL WIRE RT TTOW RLY CTRL IGN R BATT FD BATT FD 3 STARTING/CHARGING SYSTEM STARTING/CHARGING SYSTEM EXTERIOR LIGHTS SYSTEM STRTR OVRDE RLY COIL RTN SUPPLEMENTAL RESTRAINTS SYSTEM (LEFT SIDE OF ENGINE COMPT) TAN/BRN WIRE TAN/DK BLU WIRE TAN/LT BLU WIRE TAN/LT GRN WIRE TAN/ORG WIRE TAN/VIO WIRE TAN/WHT WIRE TOTALLY INTEGRATED POWER MODULE (LEFT FRONT OF ENGINE COMPT) TRANSMISSION CTRL OUT TRANSMISSIONS SYSTEM TRANSMISSIONS SYSTEM ENGINE CONTROLS SYSTEM WHT/DK BLU WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE WHT/VIO WIRE YEL/BRN WIRE YEL/GRY WIRE YEL/ORG WIRE YEL/RED WIRE

1 2 SENS GND SENS SIG A/C CLUTCH CTRL A/C CLUTCH CTRL OUTPUT A/C HEATER CONTROL A/C INDICATOR A/C PRES 5 VOLT SPLY A/C PRES GND A/C PRES SIG A/C SELECT B(+) BLEND DOOR DRIVER BLK WIRE BLK/LT BLU WIRE BLK/LT GRN WIRE BLK/ORG WIRE BLOWER MOTOR RESISTOR (RIGHT SIDE OF DASH) BLU WIRE BRN WIRE CLUSTER COMMON DOOR DRIVER COMPUTER DATA LINES SYSTEM CONDENSER FAN CTRL OUTPUT DK BLU WIRE DK BLU/BRN WIRE DK BLU/DK GRN WIRE DK BLU/LT BLU WIRE DK BLU/LT GRN WIRE DK BLU/ORG WIRE DK BLU/TAN WIRE DK BLU/VIO WIRE DK BLU/YEL WIRE DK DK DRIVER BLEND DOOR ACTUATOR (ON HVAC UNIT) ELECTRONICS EVAPORATOR TEMPERATURE SENSOR (RIGHT SIDE OF HVAC) EXCEPT BASE FENDER) FUSE 23 FUSE 33 FUSED IGN SW OUT (RUN) FUSED IGN SW OUT (RUN-START) HEATER MIRROR INDICATOR HOT AT ALL TIMES HVAC MICRO CONTROLLER LT BLU WIRE LT BLU/BRN WIRE LT BLU/ORG WIRE LT BLU/WHT WIRE LT GRN WIRE MODE DOOR ACTUATOR 1 (PANEL TO FLOOR) (ON HVAC UNIT) MODE DOOR ACTUATOR 2 (DEFROST TO FLOOR) (ON HVAC UNIT) OFF OFF HEATED MIRROR ORG/ WIRE ORG/GRY WIRE PANEL LAMPS DRIVER PASS BLEND DOOR DRIVER PASSENGER BLEND DOOR ACTUATOR (EXCEPT BASE) (ON HVAC UNIT) PNK WIRE PNK/LT BLU WIRE PNK/LT GRN WIRE RECIRC RECIRCULATION DOOR ACTUATOR (ON HVAC UNIT) RECIRCULATION DOOR DRIVER RECIRCULATION INDICATOR RED WIRE TAN WIRE TOTALLY INTEGRATED POWER MODULE (LEFT FRONT WHT WIRE WHT/ORG WIRE YEL WIRE

34 35 CAN C BUS (+) CAN C BUS (-) 5 4 CAN C BUS (-) CAN C BUS (+) 6.7L 5.9L A/C CLUTCH CTRL A/C COMPRESSOR CLUTCH (FRONT OF A/C COMPRESSOR) A/C PRES 5 VOLT SPLY A/C PRES GND BLK WIRE BLK/GRY WIRE BLK/LT BLU WIRE BLK/WHT WIRE BLU WIRE BRN WIRE BRN/WHT WIRE BRN/YEL WIRE COMPUTER DATA LINES SYSTEM CONDENSER FAN MOTOR (GAS) (LEFT FRONT OF ENGINE COMPT) DIESEL DK BLU WIRE DK BLU/DK GRN WIRE DK BLU/YEL WIRE DK GRN WIRE ECT SIG ENGINE BLOCK) ENGINE CONTROL MODULE (LOWER LEFT FRONT OF ENGINE CONTROLS SYSTEM ENGINE COOLANT TEMPERATURE GAS LT BLU WIRE LT BLU/BRN WIRE LT BLU/ORG WIRE LT BLU/WHT WIRE ORG/ WIRE POWERTRAIN CONTROL MODULE (RIGHT REAR OF ENGINE COMPT) SENS GND SENSOR (5.7L: FRONT OF ENGINE) (6.7L: TOP FRONT OF ENGINE) VIO WIRE VIO/ORG WIRE WHT WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE YEL WIRE

5 VOLT SPLY MDS SOL CTRL 4 FUSED B(+) IGN START B(+) BLK WIRE BLK/BRN WIRE BLK/DK GRN WIRE BLK/YEL WIRE BRN WIRE BRN/DK BLU WIRE BRN/DK GRN WIRE BRN/GRY WIRE BRN/LT BLU WIRE BRN/LT GRN WIRE BRN/ORG WIRE BRN/TAN WIRE BRN/VIO WIRE BRN/WHT WIRE BRN/YEL WIRE CAN C BUS (+) CAN C BUS (-) CMP SIG CKP SIG KNOCK SENS 2 SIG KNOCK SENS 2 RETURN ETC MOTOR (-) COIL CTRL 7 INJECTOR CTRL 8 INJECTOR CTRL 7 COMPUTER DATA LINES SYSTEM CTRL SIG DK BLU WIRE DK BLU/DK GRN WIRE DK BLU/GRY WIRE DK BLU/LT BLU WIRE DK BLU/LT GRN WIRE DK BLU/ORG WIRE DK BLU/TAN WIRE DK BLU/YEL WIRE DK GRN WIRE ELECTRONICS FUSE 31 FUSED ASD GEN FIELD CTRL ECT SIG TP 1 SIG GEN SNS GROUND FUSED B(+) IGN SW OUT (RUN-START) IGN SW OUT (OFF-RUN-START) GROUND GROUND OIL PRESSURE SIG SRV SEN OUT HOT AT ALL TIMES IGN (START) KNOCK SENS 1 (-) KNOCK SENS 1 RETURN KNOCK SENS 2 (-) KNOCK SENS 2 RETURN KNOCK SENSOR 1 KNOCK SENSOR 2 (LOWER RIGHT SIDE OF ENGINE BLOCK) MAP SIG KNOCK SENS 1 RETURN KNOCK SENS 1 SIG PNK/GRY WIRE PNK/WHT WIRE PNK/YEL WIRE POWERTRAIN CONTROL MODULE (RIGHT REAR OF ENGINE COMPT) RED WIRE RED/GRY WIRE RLY OUT RUN-START) IGN (OFF- SCI TRANSMIT (TCM) ASD CTRL OUT SENS GROUND TP 2 SIG 5 VOLT SPLY IAT SIG SHORT RUNNER VALVE SOLENOID SIG SRV ACTR SRV ACTR CTRL SIG SRV SEN OUT STARTING/ CHARGING SYSTEM TAN/ORG WIRE TAN/YEL WIRE THROTTLE BODY (ON TOP OF ENGINE) TOTALLY INTEGRATED POWER MODULE (AT LEFT FRONT FENDER) VIO/BRN WIRE VIO/GRY WIRE VIO/ORG WIRE WHT/BRN WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE YEL WIRE YEL/PNK WIRE

ASD CTRL OUT B(+) BLK WIRE BLK/LT BLU WIRE BLK/LT GRN WIRE BLK/ORG WIRE BRN WIRE BRN/DK BLU WIRE BRN/DK GRN WIRE BRN/GRY WIRE BRN/LT BLU WIRE BRN/LT GRN WIRE BRN/ORG WIRE BRN/TAN WIRE BRN/VIO WIRE BRN/WHT WIRE BRN/YEL WIRE CAN B BUS (+) CLUSTER COMPUTER DATA LINES SYSTEM DC MANUAL T CASE DK BLU/DK GRN WIRE DK BLU/GRY WIRE DK BLU/LT BLU WIRE DK BLU/LT GRN WIRE DK BLU/ORG WIRE DK BLU/TAN WIRE DK BLU/WHT WIRE DK BLU/YEL WIRE ENGINE COOLANT TEMPERATURE SENSOR (FRONT OF ENGINE) EXCEPT DC MANUAL T CASE FUEL PUMP CTRL OUT FUEL PUMP MODULE (IN FUEL TANK) FUSE 28 GROUND HOT AT ALL TIMES IGN SW OUT (RUN-START) INTAKE AIR TEMPERATURE SENSOR (TOP OF ENGINE) MAP SENSOR MULTI DISPLACEMENT SYSTEM CYLINDER 4 SOLENOID MULTI DISPLACEMENT SYSTEM CYLINDER 6 SOLENOID ORG/RED WIRE OXYGEN SENSOR 1/1 (IN EXHAUST, RIGHT OF TRANSMISSION) OXYGEN SENSOR 1/2 (IN EXHAUST, LEFT OF TRANSMISSION) OXYGEN SENSOR 2/1 OXYGEN SENSOR 2/2 (IN EXHAUST, RIGHT OF TRANSMISSION) PNK/GRY WIRE PNK/RED WIRE PNK/YEL WIRE SENS SIG FUEL LEVEL STOP LAMP SWITCH (ON BRAKE PEDAL SUPPORT) TOTALLY ELECTRONICS INTEGRATED POWER MODULE (LEFT FRONT FENDER) VIO/BRN WIRE VIO/GRY WIRE VIO/ORG WIRE VIO/WHT WIRE VIO/YEL WIRE WHT WIRE WHT/ORG WIRE YEL/PNK WIRE

5 VOLT SPLY ACCELERATOR PEDAL POSITION SENSOR (LEFT SIDE OF DASH) APP 1 RTN APP 1 SIG APP 2 RTN APP 2 SIG BRN WIRE BRN/DK BLU WIRE BRN/GRY WIRE BRN/LT BLU WIRE BRN/ORG WIRE BRN/TAN WIRE BRN/VIO WIRE BRN/WHT WIRE BRN/YEL WIRE CAMSHAFT POSITION SENSOR (RIGHT FRONT OF ENGINE) CRANKSHAFT POSITION SENSOR (RIGHT SIDE OF ENGINE) DK BLU/DK GRN WIRE DK BLU/GRY WIRE DK BLU/ORG WIRE DK BLU/TAN WIRE DK BLU/YEL WIRE LINE PRESSURE SENSOR (RIGHT SIDE OF TRANSMISSION) LINE SENS PNK/YEL WIRE SENS GND VIO/BRN WIRE VIO/GRY WIRE VIO/YEL WIRE WHT/BRN WIRE YEL/BRN WIRE YEL/PNK WIRE

5 VOLT SUPPLY ACCELERATOR PEDAL POSITION SENSOR (LEFT SIDE OF DASH) ADJ PIN SNS 2 APPS 1 RTN APPS 1 SIG APPS 2 RTN APPS 2 SIG B(+) HTR CTRL PMP CAN C CTRL OUT CTRL BUS (+) OUT BLK WIRE BLK/BRN WIRE BLK/ORG WIRE BLK/WHT WIRE BRN WIRE BRN/DK GRN WIRE BRN/LT BLU WIRE BRN/LT GRN WIRE BRN/ORG WIRE BRN/TAN WIRE BRN/VIO WIRE BRN/WHT WIRE CAN B BUS (+) CAN C BUS (+) CLUSTER (LEFT REAR OF ENGINE) COMPUTER DATA LINES SYSTEM CURRENT PIN FEED CURRENT TRIM DK BLU/DK GRN WIRE DK BLU/LT BLU WIRE DK BLU/WHT WIRE DK BLU/YEL WIRE DK GRN/WHT WIRE EGR SENS FEED ELECTRONICS EXHAUST BRAKE SWITCH FUEL HEATER (LEFT SIDE OF ENGINE) FUEL LVL SENS SIG FUEL PMP FUEL FUEL PUMP MODULE (IN FUEL TANK) FUSE 28 FUSE 30 FUSE 37 FUSE 42 GROUND HIGH DATA LINK HOT AT ALL TIMES HOT IN RUN OR HTR CTRL IGN (RUN-START) IGN SW OUT (RUN-START) LOW DATA LINK ORG/DK BLU WIRE ORG/RED WIRE PANEL LAMP DRV PNK/GRY WIRE PNK/YEL WIRE RED WIRE RED/ORG WIRE RTN (DOWNSTREAM) RTN (UPSTREAM) S/C SW 1 SIG S/C SW 2 SIG S/C SW RTN SENSOR GROUND SIGNAL STEERING CONTROL MODULE (ON STEERING COLUMN) STOP LAMP SWITCH (ON BRAKE PEDAL SUPPORT) TOTALLY INTEGRATED POWER MODULE (LEFT FRONT FENDER) VIO WIRE VIO/BRN WIRE VIO/DK GRN WIRE VIO/ORG WIRE VIO/WHT WIRE VIO/YEL WIRE WHT WIRE WHT/BRN WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE WHT/ORG WIRE

BLK WIRE BRN WIRE BRN/DK BLU WIRE BRN/DK GRN WIRE BRN/GRY WIRE BRN/LT BLU WIRE BRN/ORG WIRE BRN/PNK WIRE BRN/TAN WIRE BRN/VIO WIRE BRN/WHT WIRE BRN/YEL WIRE CRANKSHAFT POSITION SENSOR (LOWER LEFT FRONT OF ENGINE) DK BLU WIRE DK BLU/BRN WIRE DK BLU/GRY WIRE DK BLU/LT BLU WIRE DK BLU/LT GRN WIRE DK BLU/TAN WIRE DK BLU/WHT WIRE DK BLU/YEL WIRE EGR BYPASS VLV SIG FUEL CTRL RTN EGR TEMPERATURE SENSOR (TOP LEFT FRONT OF ENGINE) EGR VALVE ASSEMBLY ENGINE CONTROL MODULE (LOWER LEFT FRONT OF ENGINE BLOCK) ENGINE COOLANT TEMPERATURE SENSOR (TOP FRONT OF ENGINE) FAN SPD SENS GND FUEL INJECTOR 1 (TOP OF ENGINE, OVER CYLINDER 1) FUEL INJECTOR 2 (TOP OF ENGINE, OVER CYLINDER 2) FUEL INJECTOR 3 (TOP OF ENGINE, OVER CYLINDER 3) FUEL INJECTOR 4 (TOP OF ENGINE, OVER CYLINDER 4) FUEL INJECTOR 5 (TOP OF ENGINE, OVER CYLINDER 5) FUEL INJECTOR 6 (TOP OF ENGINE, OVER CYLINDER 6) GRY WIRE GRY/BRN WIRE GRY/DK BLU WIRE INTAKE TEMPERATURE /PRESSURE SENSOR (RAM 2500) (RIGHT SIDE OF ENGINE) LT BLU/BRN WIRE LT GRN/BRN WIRE OIL PRESSURE SWITCH (LEFT SIDE OF ENGINE) ORG/BRN WIRE PNK/YEL WIRE RED WIRE SENS GND SENS SIG SIG STARTING/ CHARGING SYSTEM TAN WIRE TTVA MTR (+) CRANKCASE SENS SIG ECT SIG TURBO SPEED SENSOR (LOWER RIGHT FRONT OF ENGINE) VIO/GRY WIRE VIO/LT GRN WIRE VIO/ORG WIRE VIO/WHT WIRE WATER IN FUEL SENSOR (MIDDLE LEFT SIDE OF ENGINE BLOCK) WHT/BRN WIRE WHT/LT GRN WIRE YEL/BRN WIRE