Dodge Pickup R3500 (1996-2010) dk blu/wht Wiring diagrams

1 2 CCD BUS (+) CCD BUS (-) 14 16 17 MUX CTRL CCD (+) CCD (-) ANTENNA BLK WIRE BLK/LT GRN WIRE BLK/VIO WIRE BLK/YEL WIRE BRN/LT BLU WIRE BRN/RED WIRE BRN/YEL WIRE CENTRAL TIMER MODULE (LEFT SIDE OF DASH, INBOARD OF STEERING COLUMN OPENING) CLOCK SPRING 1 DK BLU WIRE DK BLU/ORG WIRE DK BLU/RED WIRE DK BLU/WHT WIRE DK GRN WIRE FUSE 12 FUSE 8 HOT AT ALL TIMES HOT IN RUN OR ACC JOINT CONNECTOR 5 (LEFT SIDE OF DASH) JOINT CONNECTOR 6 (LEFT SIDE OF DASH) JOINT CONNECTOR 7 (BEHIND LEFT SIDE OF DASH) JUNCTION BLOCK (LEFT END OF DASH) LEFT FRONT DOOR SPEAKER LEFT REAR SPEAKER LEFT REMOTE RADIO SWITCH LF SPKR (-) RF SPKR (-) DAY SENSE ILLUMINATION FUSED IGN FUSED B(+) LR SPKR (+) RR SPKR (+) LF SPKR (+) RF SPKR (+) LR SPKR (-) RR SPKR (-) NCA WIRE ORG/ WIRE PNK WIRE PRESET RADIO RED WIRE RED/BLK WIRE RED/WHT WIRE RIGHT FRONT DOOR SPEAKER RIGHT REAR SPEAKER SEEK DN SEEK UP VIO WIRE VIO/BRN WIRE VOL DN RIGHT REMOTE RADIO SWITCH VOL UP WHT WIRE WHT/BLK WIRE

9 10 11 12 13 14 KEY-IN IGN SW WSHR SW SENSE WPR PARK SW WPR SW SIG BASE MIDLINE BATTERY BLK WIRE BLK/LT BLU WIRE BLK/LT GRN WIRE BLK/ORG WIRE BLK/RED WIRE BRN WIRE CCD BUS (+) CCD BUS (-) HORN RLY CTRL CENTRAL TIMER MODULE (LEFT SIDE OF DASH) DATA LINK CONNECTOR (LEFT BOTTOM OF DASH) DK BLU WIRE DK BLU/RED WIRE DK BLU/WHT WIRE DK GRN WIRE DOOR LOCKS SYSTEM DOOR LOCKS SYSTEM INTERIOR LIGHTS SYSTEM DOOR LOCKS SYSTEM SOUND SYSTEM FUSE 11 FUSE 6 HORNS SYSTEM HOT AT ALL TIMES HOT IN ACC OR RUN HOT IN RUN OR START IGN RUN/ACCY IGN RUN/START INTERIOR LIGHTS SYSTEM WARNING SYSTEMS J/C 5 (LEFT SIDE OF DASH) J/C 7 (LEFT KICK PANEL) JUNCTION BLOCK (LEFT END OF DASH) FUSE 13 LT BLU WIRE LT GRN WIRE LT GRN/ORG WIRE ORG/ WIRE ORG/BLK WIRE ORG/DK GRN WIRE PASS DR LK MTR RADIO CTRL MUX PNK/BLK WIRE PNK/DK GRN WIRE PNK/LT BLU WIRE RED WIRE RED/BLK WIRE RED/DK BLU WIRE TAN WIRE VIO WIRE VIO/BRN WIRE WARNING SYSTEMS WHT WIRE WHT/BLK WIRE WHT/DK BLU WIRE WIPER/ WASHER SYSTEM WIPER/WASHER SYSTEM YEL/DK GRN WIRE

1 21 4 5 CAN C BUS (+) CAN C BUS (-) 27 29 SENS GND 5 VOLT SPLY 35 34 CAN C BUS (-) CAN C BUS (+) 5.9L DIESEL 6.7L DIESEL BLK WIRE COMPUTER DATA LINES SYSTEM DK BLU/DK GRN WIRE DK BLU/WHT WIRE DK GRN/YEL WIRE DRIVER DOOR LATCH (DRIVER'S DOOR) ENGINE CONTROL MODULE (DIESEL) FUEL PUMP MODULE (IN FUEL TANK) LEFT REAR DOOR LATCH (LEFT REAR DOOR) LT GRN/BLK WIRE OIL PRESSURE SENSOR (5.7L A/T) (LOWER RIGHT FRONT OF ENGINE) OIL PRESSURE SIG PASSENGER DOOR LATCH (FRONT PASSENGER'S DOOR PNK/YEL WIRE RIGHT REAR DOOR LATCH (RIGHT REAR DOOR) TRANS RANGE TRANS RANGE SENS MUX TRANSMISSION RANGE SENSOR (A/T) (EXCEPT 4.7L, 5.7L: LEFT SIDE OF TRANSMISSION) VIO WIRE VIO/GRY WIRE VIO/WHT WIRE VIO/YEL WIRE W/ POWER LOCKS WHT/LT BLU WIRE WHT/LT GRN WIRE YEL/TAN WIRE

1 2 CCD BUS (+) CCD BUS (-) 14 16 17 MUX CTRL CCD (+) CCD (-) AMP L REAR SPKR (+) AMP R REAR SPKR (-) AMP TWEETER SPKR (+) ANTENNA BLK WIRE BLK/LT GRN WIRE BLK/RED WIRE BLK/VIO WIRE BLK/YEL WIRE BRN/LT BLU WIRE BRN/RED WIRE BRN/YEL WIRE CENTRAL TIMER MODULE (LEFT SIDE OF DASH, INBOARD OF STEERING COLUMN OPENING) CLOCK SPRING 1 DK BLU WIRE DK BLU/ORG WIRE DK BLU/RED WIRE DK BLU/WHT WIRE DK GRN WIRE FUSE 12 FUSE 4 FUSE 8 GRN WIRE GROUND HOT AT ALL TIMES HOT IN RUN OR ACC JOINT CONNECTOR 5 (LEFT SIDE OF DASH) JOINT CONNECTOR 6 (LEFT SIDE OF DASH) JOINT CONNECTOR 7 (BEHIND LEFT SIDE OF DASH) JUNCTION BLOCK (LEFT END OF DASH) L FRONT SPKR - L REAR SPKR - LEFT FRONT DOOR SPEAKER LEFT REAR SPEAKER LEFT REMOTE RADIO SWITCH LEFT TWEETER SPEAKER LF SPKR (-) RF SPKR (-) DAY SENSE ILLUMINATION FUSED IGN FUSED B(+) LT BLU/BLK WIRE LT BLU/RED WIRE LT GRN WIRE NCA WIRE ORG/ WIRE PNK WIRE PRESET R FRONT SPKR - R REAR SPKR - RADIO RADIO CHOKE RADIO CHOKE RELAY (BEHIND CENTER OF DASH) RED WIRE RED/BLK WIRE RED/WHT WIRE RIGHT FRONT DOOR SPEAKER RIGHT REAR SPEAKER RIGHT TWEETER SPEAKER SEEK DN SEEK UP TAN/BLK WIRE TAN/VIO WIRE VIO WIRE VIO/BRN WIRE VOL DN RIGHT REMOTE RADIO SWITCH VOL UP WHT WIRE WHT/BLK WIRE WHT/DK GRN WIRE WHT/VIO WIRE YEL/BLK WIRE YEL/RED WIRE

1 2 CCD BUS (+) CCD BUS (-) 14 16 17 MUX CTRL CCD (+) CCD (-) ANTENNA BLK WIRE BLK/DK BLU WIRE BLK/LT GRN WIRE BLK/VIO WIRE BLK/YEL WIRE BRN/LT BLU WIRE BRN/RED WIRE BRN/YEL WIRE CENTRAL TIMER MODULE (LEFT SIDE OF DASH, RIGHT OF STEERING COLUMN) CLOCK SPRING 1 DAY BRIGHTNESS SENSE DIMMER DK BLU/ORG WIRE DK BLU/RED WIRE DK BLU/WHT WIRE DK GRN WIRE FUSE 1 FUSE 12 FUSE 5 FUSE 8 GROUND HEAD OFF HEADLAMP SWITCH HOT AT ALL TIMES HOT IN RUN OR ACC INSTRUMENT CLUSTER JOINT CONNECTOR 5 (LEFT SIDE OF DASH) JOINT CONNECTOR 6 (LEFT SIDE OF DASH) JOINT CONNECTOR 7 (BEHIND LEFT SIDE OF DASH) JOINT CONNECTOR 8 (LEFT END OF DASH, NEAR JUNCTION BLOCK) JUNCTION BLOCK (LEFT END OF DASH) LEFT FRONT DOOR SPEAKER LEFT REAR SPEAKER LEFT REMOTE RADIO SWITCH LF SPKR (-) RF SPKR (-) DAY SENSE DIMMER SIG FUSED IGN FUSED B(+) LR SPKR (+) RR SPKR (+) LF SPKR (+) RF SPKR (+) LR SPKR (-) RR SPKR (-) NCA WIRE ORG/ WIRE PNK WIRE PRESET RADIO RED WIRE RED/BLK WIRE RED/WHT WIRE RIGHT FRONT DOOR SPEAKER RIGHT REAR SPEAKER SEEK DN SEEK UP TAN WIRE VIO WIRE VIO/BRN WIRE VOL DN RIGHT REMOTE RADIO SWITCH VOL UP WHT WIRE WHT/BLK WIRE YEL WIRE

1/1 (LEFT BANK UP) (5.9L H/D, 5.2L/5.9L CALIF) 1/1 (UPSTREAM) (3.9L, 5.2L, 5.9L) 1/2 (LEFT BANK DN) (5.2L/5.9L CALIF) BLK WIRE BLK/LT BLU WIRE BLK/RED WIRE BLK/WHT WIRE BRN WIRE BRN/VIO WIRE BRN/WHT WIRE CALIF CALIF: ON RIGHT EXHAUST DOWNPIPE, BEFORE MINI- CATALYTIC CONVERTER) CAMSHAFT POSITION SENSOR (IN DISTRIBUTOR) DK BLU/WHT WIRE DK BLU/YEL WIRE DK GRN WIRE DK GRN/BLK WIRE DK GRN/ORG WIRE DK GRN/PNK WIRE DK GRN/WHT WIRE DK GRN/YEL WIRE EXCEPT CALIF FUEL PUMP MODULE (TOP OF FUEL TANK) FUEL PUMP RLY OUT (B+) GOV PRESS SIG GROUND HEATED OXYGEN SENSOR HEATED OXYGEN SENSOR 1/2 (DOWNSTREAM) (3.9L, 5.2L, 5.9L) HEATED OXYGEN SENSOR 2/2 (RIGHT BANK DOWN) (5.2L/5.9L CALIF) INTAKE AIR TEMPERATURE SENSOR (IN RIGHT FRONT SIDE OF INTAKE MANIFOLD) LT GRN/RED WIRE LT GRN/WHT WIRE NCA WIRE ORG/ WIRE ORG/BLK WIRE ORG/DK BLU WIRE ORG/TAN WIRE OTHERS OVERDRV SOL PNK 6 7 WIRE PNK WIRE RED WIRE SENSOR GRD SENSOR RETURN SENSOR SIG TAN/WHT (OR BLK/DK GRN) WIRE TAN/WHT WIRE TAN/YEL WIRE TCC SOL. CTRL THROTTLE POSITION SENSOR (ON THROTTLE BODY) TRANS RLY OUT TRANS TEMP SNS TRANSMISSION SOLENOID ASSEMBLY (AT LEFT SIDE OF TRANSMISSION) VAR FORCE SOL VIO WIRE VIO/WHT WIRE WHT WIRE

AIR CONDI- TIONING SYSTEM AUTO SHT RLY CRUISE VAC SOL CRUISE VNT SOL BATTERY TEMPER- ATURE SENSOR (BELOW BATTERY TRAY) BLK/LT BLU WIRE BLK/LT GRN WIRE BRN WIRE BRN/VIO WIRE BRN/WHT WIRE CCD(-) CONNECTOR CRUISE CONTROL SYSTEM CRUISE SW IN DATA LINK CONNECTOR (LEFT BOTTOM OF DASH) DK BLU WIRE DK BLU/ORG WIRE DK BLU/WHT WIRE DK BLU/YEL WIRE DK GRN WIRE DK GRN/ORG WIRE DK GRN/PNK WIRE EVAP PURGE SOLENOID (ON BRACKET, MOUNTED ON RIGHT INNER FENDER) FUEL PMP RLY EVAP SOL DRVR FUSE I GENERATOR HOT AT ALL TIMES HOT IN RUN OR START JUNCTION BLOCK (ON LEFT END OF DASH) FUSE 11 INSTRUMENT CLUSTER JOINT JOINT CONNECTOR 11 9 2 14 6 5 JOINT CONNECTOR NO 1 (IN PDC) LEAK DETECTION PUMP (ON RIGHT FRONT INNER FENDER) LT GRN/RED WIRE LT GRN/WHT WIRE ORG/ WIRE ORG/WHT WIRE OVERDRIVE SWITCH PNK 6 7 WIRE PNK WIRE PNK/DK BLU WIRE PNK/WHT WIRE PNK/YEL WIRE POWERTRAIN CONTROL MODULE (IN ENG COMPT, ON RIGHT SIDE OF FIREWALL) RED WIRE RED/LT GRN WIRE STOPLIGHT SWITCH (ON BRAKE PEDAL BRACKET) TAN/RED WIRE TRANSMISSION RELAY VIO/BRN WIRE WHT/BLK WIRE WHT/DK GRN WIRE WHT/PNK WIRE YEL WIRE YEL/RED WIRE

15 16 17 18 19 20 21 22 23 24 PNK WIRE BLK WIRE BLK/LT BLU WIRE BLK/RED WIRE BLK/WHT WIRE BRN WIRE BRN/VIO WIRE BRN/WHT WIRE CAMSHAFT POSITION SENSOR (IN DISTRIBUTOR) DK BLU/WHT WIRE DK BLU/YEL WIRE DK GRN/BLK WIRE DK GRN/ORG WIRE DK GRN/PNK WIRE DK GRN/WHT WIRE DK GRN/YEL WIRE FUEL PUMP MODULE (TOP OF FUEL TANK) FUEL PUMP RLY OUT (B+) GOV PRESS SIG GROUND HEATED OXYGEN SENSOR 1/1 (LEFT BANK UP) HEATED OXYGEN SENSOR 1/2 (LEFT BANK DOWN) HEATED OXYGEN SENSOR 2/1 (RIGHT BANK UP) HEATED OXYGEN SENSOR 2/2 (RIGHT BANK DOWN) (ON OUTLET END INTAKE AIR TEMPERATURE SENSOR (IN RIGHT FRONT SIDE OF INTAKE MANIFOLD) LT GRN/RED WIRE LT GRN/WHT WIRE NCA WIRE OF RIGHT MINI- CATALYTIC CONVERTER) ORG/ WIRE ORG/BLK WIRE ORG/DK BLU WIRE ORG/TAN WIRE OVERDRV SOL PNK 6 7 WIRE RED WIRE SENSOR GRD SENSOR RETURN SENSOR SIG TAN/WHT WIRE TAN/YEL WIRE TCC SOL. CTRL THROTTLE POSITION SENSOR (ON THROTTLE BODY) TRANS RLY OUT TRANS TEMP SNS TRANSMISSION SOLENOID ASSEMBLY (AT LEFT SIDE OF TRANSMISSION) VAR FORCE SOL VIO WIRE VIO/WHT WIRE

AIR CONDI- TIONING SYSTEM AUTO SHT RLY CRUISE VAC SOL CRUISE VNT SOL BATTERY TEMPER- ATURE SENSOR (BELOW BATTERY TRAY) BLK/LT BLU WIRE BLK/LT GRN WIRE BRN WIRE BRN/VIO WIRE BRN/WHT WIRE CCD(-) CONNECTOR CRUISE CONTROL SYSTEM CRUISE SW IN DATA LINK CONNECTOR (LEFT BOTTOM OF DASH) DK BLU WIRE DK BLU/ORG WIRE DK BLU/WHT WIRE DK BLU/YEL WIRE DK GRN WIRE DK GRN/ORG WIRE DK GRN/PNK WIRE EVAP PURGE SOLENOID (ON BRACKET, MOUNTED ON RIGHT INNER FENDER) FUEL PMP RLY EVAP SOL DRVR FUSE I GENERATOR HOT AT ALL TIMES HOT IN RUN OR START JUNCTION BLOCK (ON LEFT END OF DASH) FUSE 11 INSTRUMENT CLUSTER JOINT JOINT CONNECTOR 11 9 2 14 6 5 JOINT CONNECTOR NO 1 (IN PDC) LEAK DETECTION PUMP (ON RIGHT FRONT INNER FENDER) LT GRN/RED WIRE LT GRN/WHT WIRE ORG/ WIRE ORG/WHT WIRE OVERDRIVE SWITCH PNK 6 7 WIRE PNK WIRE PNK/DK BLU WIRE PNK/WHT WIRE PNK/YEL WIRE POWERTRAIN CONTROL MODULE (IN ENG COMPT, ON RIGHT SIDE OF FIREWALL) RED WIRE RED/LT GRN WIRE STOPLIGHT SWITCH (ON BRAKE PEDAL BRACKET) TAN/RED WIRE TRANSMISSION RELAY VIO/BRN WIRE WHT/BLK WIRE WHT/DK GRN WIRE WHT/PNK WIRE YEL WIRE YEL/RED WIRE

1/1 (UPSTREAM) (ON INLET OF 10 11 12 13 14 15 16 17 18 19 PNK WIRE BLK WIRE BLK/LT BLU WIRE BLK/RED WIRE BRN WIRE BRN/VIO WIRE BRN/WHT WIRE CAMSHAFT POSITION SENSOR (IN DISTRIBUTOR) CATALYTIC CONVERTER) DK BLU/WHT WIRE DK BLU/YEL WIRE DK GRN/BLK WIRE DK GRN/ORG WIRE DK GRN/WHT WIRE FUEL PUMP MODULE (TOP OF FUEL TANK) FUEL PUMP RLY OUT (B+) GOV PRESS SIG GROUND HEATED OXYGEN SENSOR HEATED OXYGEN SENSOR 1/2 (DOWNSTREAM) (NEAR OUTLET END INTAKE AIR TEMPERATURE SENSOR (IN RIGHT FRONT SIDE OF INTAKE MANIFOLD) LT GRN/WHT WIRE NCA WIRE OF CATALYTIC CONVERTER) ORG/ WIRE ORG/BLK WIRE ORG/DK BLU WIRE OVERDRV SOL PNK 5 6 WIRE RED WIRE SENSOR GRD SENSOR RETURN SENSOR SIG TAN/WHT WIRE TAN/YEL WIRE TCC SOL. CTRL THROTTLE POSITION SENSOR (ON THROTTLE BODY) TRANS RLY OUT TRANS TEMP SNS TRANSMISSION SOLENOID ASSEMBLY (AT LEFT SIDE OF TRANSMISSION) VAR FORCE SOL VIO WIRE VIO/WHT WIRE