Dodge Pickup R3500 (1996-2010) dk blu Wiring diagrams

2 4 6 16 17 22 23 31 32 FUSED IGN (ST/RUN) SENSOR GND PNP SW SENSE ECT SENS SIG 28 30 CCD (-) CCD (+) 6 13 24 25 OD LAMP DRIVER TRANS OD SW SENSE BRAKE SW SENSE GENERATOR OUTPUT 8 9 10 11 PNK WIRE BLK WIRE BLK/LT BLU WIRE BLK/LT GRN WIRE BLK/TAN WIRE BLK/WHT WIRE BRN WIRE CCD(-) DATA LINK CONNECTOR (PARTIAL) (LEFT BOTTOM OF DASH) DK BLU WIRE DK BLU/BLK WIRE FUEL PUMP, AUTOMATIC SHUTDOWN RELAYS FUSE 14 FUSE 9 FUSED B(+) TP SENS SIG GND GND GRY WIRE HOT AT ALL TIMES HOT IN RUN OR START IND INSTRUMENT CLUSTER JOINT CONNECTOR 1 JOINT CONNECTOR 3 JOINT CONNECTOR 7 JUNCTION BLOCK LT GRN WIRE LT GRN/BLK WIRE LT GRN/ORG WIRE LT GRN/WHT WIRE MIL IND ORG/ WIRE ORG/BLK WIRE ORG/DK BLU WIRE ORG/WHT WIRE OVER- DRIVE OFF IND OVERDRIVE SWITCH PNK WIRE POWERTRAIN CONTROL MODULE (IN ENG COMPT, ON RIGHT SIDE OF FIREWALL) RED/WHT WIRE STOP LAMP SWITCH (TOP OF BRAKE PEDAL BRACKET) SWITCH (ON FRONT AXLE TUBE) TAN/BLK WIRE TL GRN WIRE TRANSMISSION OUTPUT SHAFT SPEED SENSOR (ON LEFT SIDE OF TRANSMISSION) VIO WIRE VIO/BRN WIRE VIO/WHT WIRE WHT WIRE WHT/BLK WIRE WHT/DK BLU WIRE WHT/ORG WIRE WHT/PNK WIRE YEL WIRE

5 VOLT SUPPLY 8 9 10 11 PNK WIRE BLK WIRE BLK/LT BLU WIRE BLK/WHT WIRE BRN WIRE CONTROLLER ANTI-LOCK BRAKE DK BLU WIRE ENG HARN, NEAR FUEL INJ 5 BREAKOUT) ENGINE CONTROLS SYSTEM ENGINE COOLANT TEMPERATURE SENSOR (ON THERMOSTAT HOUSING) ENGINE STARTER MOTOR RELAY FUSE FUSE 3 GENERATOR GOVERNOR PRESSURE SIGNAL GRN WIRE HOT AT ALL TIMES INNER FENDER) JOINT CONNECTOR 2 LT BLU WIRE LT GRN/WHT WIRE OF HYDRAULIC CONTROL UNIT) ORG/ WIRE ORG/BLK WIRE ORG/DK BLU WIRE OVERDRIVE SOLENOID CONTROL VARIABLE FORCE SOLENOID CONTROL PARK/ NEUTRAL POSITION SWITCH (ON LEFT SIDE OF TRANSMISSION) PNK WIRE POWER DISTRIBUTION CENTER RED WIRE RED/WHT WIRE SENSOR GROUND TAN WIRE TAN/BLK WIRE THROTTLE POSITION SENSOR (ON THROTTLE BODY) TORQUE CONVERTER CLUTCH SOLENOID CONTROL TRANS CTRL RLY OUTPUT TRANSMISSION CONTROL RELAY TRANSMISSION SOLENOID ASSEMBLY (TRANSMISSION) TRANSMISSION TEMPERATURE SENSOR SIGNAL VIO WIRE VIO/WHT WIRE WHT WIRE WHT/DK BLU WIRE WHT/ORG WIRE YEL WIRE

10 11 12 13 PNK WIRE BLK WIRE BLK/LT BLU WIRE BLK/WHT WIRE BRN WIRE DK BLU WIRE EGR CONTROL MODULE ENGINE CONTROLS SYSTEM ENGINE COOLANT TEMPERATURE SENSOR (BETWEEN GENERATOR, A/C COMPRESSOR) ENGINE SPEED SENSOR (ON FRONT OF ENG, IN TIMING CHAIN CASE/COVER) ENGINE STARTER MOTOR RELAY FUEL PUMP RELAY FUSE 8 GENERATOR GOVERNOR PRESSURE SIGNAL GRN WIRE GRY/BLK WIRE HOT AT ALL TIMES INSTRUMENT CLUSTER (SPEEDOMETER) LT BLU WIRE LT GRN/WHT WIRE OF TRANSFER CASE) OF TRANSMISSION EXTENSION HOUSING, ORG/ WIRE ORG/BLK WIRE ORG/DK BLU WIRE PARK/ NEUTRAL POSITION SWITCH (ON LEFT SIDE OF TRANSMISSION) PNK WIRE POWER DISTRIBUTION CENTER RED WIRE RED/WHT WIRE SENSOR GROUND 5 VOLT SUPPLY TAN/BLK WIRE THROTTLE POSITION SENSOR (ON TOP OF INJECTOR PUMP) TRANS CTRL RLY OUTPUT TRANSMISSION CONTROL RELAY TRANSMISSION SOLENOID ASSEMBLY (TRANSMISSION) TRANSMISSION TEMPERATURE SENSOR SIGNAL VEHICLE SPEED SENSOR VIO WIRE VIO/WHT WIRE W/ EGR COTROL MODULE W/O EGR COTROL MODULE WHT WIRE WHT/DK BLU WIRE WHT/ORG WIRE

2 4 6 16 17 22 23 31 32 FUSED IGN (ST/RUN) SENSOR GND PNP SW SENSE ECT SENS SIG 28 30 CCD (-) CCD (+) 6 13 24 25 OD LAMP DRIVER TRANS OD SW SENSE BRAKE SW SENSE GENERATOR OUTPUT 8 9 10 11 PNK WIRE BLK WIRE BLK/LT BLU WIRE BLK/LT GRN WIRE BLK/TAN WIRE BLK/WHT WIRE BRN WIRE CCD(-) DATA LINK CONNECTOR (PARTIAL) (LEFT BOTTOM OF DASH) DK BLU WIRE DK BLU/BLK WIRE FUEL PUMP, AUTOMATIC SHUTDOWN RELAYS FUSE 14 FUSE 9 FUSED B(+) TP SENS SIG GND GND GRY WIRE HOT AT ALL TIMES HOT IN RUN OR START IND INSTRUMENT CLUSTER JOINT CONNECTOR 1 JOINT CONNECTOR 3 JOINT CONNECTOR 7 JUNCTION BLOCK LT GRN WIRE LT GRN/BLK WIRE LT GRN/ORG WIRE LT GRN/WHT WIRE MIL IND ORG/ WIRE ORG/BLK WIRE ORG/DK BLU WIRE ORG/WHT WIRE OVER- DRIVE OFF IND OVERDRIVE SWITCH PNK WIRE POWERTRAIN CONTROL MODULE (IN ENG COMPT, ON RIGHT SIDE OF FIREWALL) RED/WHT WIRE STOP LAMP SWITCH (TOP OF BRAKE PEDAL BRACKET) SWITCH (ON FRONT AXLE TUBE) TAN/BLK WIRE TL GRN WIRE TRANSMISSION OUTPUT SHAFT SPEED SENSOR (ON LEFT SIDE OF TRANSMISSION) VIO WIRE VIO/BRN WIRE VIO/WHT WIRE WHT WIRE WHT/BLK WIRE WHT/DK BLU WIRE WHT/ORG WIRE WHT/PNK WIRE YEL WIRE

5 VOLT SUPPLY 8 9 10 11 PNK WIRE BLK WIRE BLK/LT BLU WIRE BLK/WHT WIRE BRN WIRE CONTROLLER ANTI-LOCK BRAKE DK BLU WIRE ENG HARN, NEAR FUEL INJ 5 BREAKOUT) ENGINE CONTROLS SYSTEM ENGINE COOLANT TEMPERATURE SENSOR (ON THERMOSTAT HOUSING) ENGINE STARTER MOTOR RELAY FUSE FUSE 3 GENERATOR GOVERNOR PRESSURE SIGNAL GRN WIRE HOT AT ALL TIMES INNER FENDER) JOINT CONNECTOR 2 LT BLU WIRE LT GRN/WHT WIRE OF HYDRAULIC CONTROL UNIT) ORG/ WIRE ORG/BLK WIRE ORG/DK BLU WIRE OVERDRIVE SOLENOID CONTROL VARIABLE FORCE SOLENOID CONTROL PARK/ NEUTRAL POSITION SWITCH (ON LEFT SIDE OF TRANSMISSION) PNK WIRE POWER DISTRIBUTION CENTER RED WIRE RED/WHT WIRE SENSOR GROUND TAN WIRE TAN/BLK WIRE THROTTLE POSITION SENSOR (ON THROTTLE BODY) TORQUE CONVERTER CLUTCH SOLENOID CONTROL TRANS CTRL RLY OUTPUT TRANSMISSION CONTROL RELAY TRANSMISSION SOLENOID ASSEMBLY (TRANSMISSION) TRANSMISSION TEMPERATURE SENSOR SIGNAL VIO WIRE VIO/WHT WIRE WHT WIRE WHT/DK BLU WIRE WHT/ORG WIRE YEL WIRE

BASE MIDLINE BATTERY BLK WIRE BLK/LT BLU WIRE BLK/LT GRN WIRE BLK/ORG WIRE BLK/RED WIRE BRN WIRE CCD BUS (+) CCD BUS (-) HORN RLY CTRL CENTRAL TIMER MODULE (LEFT SIDE OF DASH) DATA LINK CONNECTOR (LEFT BOTTOM OF DASH) DK BLU (OR DK BLU/WHT) WIRE DK BLU WIRE DK BLU/RED WIRE DK BLU/WHT WIRE DK GRN WIRE DOOR LOCKS SYSTEM DOOR LOCKS SYSTEM INTERIOR LIGHTS SYSTEM DOOR LOCKS SYSTEM SOUND SYSTEM DR LK MOTOR RADIO CTRL MUX FUSE 11 FUSE 6 HORNS SYSTEM HOT AT ALL TIMES HOT IN ACC OR RUN HOT IN RUN OR START IGNITION KEY-IN IGN SW WSHR SW SENSE WPR PARK SW WPR SW SIG INTERIOR LIGHTS SYSTEM WARNING SYSTEMS J/C 5 (LEFT SIDE OF DASH) J/C 7 (LEFT KICK PANEL) JUNCTION BLOCK (LEFT END OF DASH) FUSE 13 LT BLU WIRE LT GRN WIRE LT GRN/ORG WIRE ORG/ WIRE ORG/BLK WIRE ORG/DK GRN WIRE PNK/BLK WIRE PNK/DK GRN WIRE PNK/LT BLU WIRE RED WIRE RED/BLK WIRE RED/DK BLU WIRE TAN WIRE VIO WIRE VIO/BRN WIRE WARNING SYSTEMS WHT WIRE WHT/BLK WIRE WHT/DK BLU WIRE WIPER/ WASHER SYSTEM WIPER/WASHER SYSTEM YEL/DK GRN WIRE

BASE BLK/LT BLU WIRE BLK/LT GRN WIRE BRN WIRE DK BLU (OR DK BLU/WHT) WIRE DK BLU WIRE DK BLU/RED WIRE DK GRN WIRE FUSE 11 FUSE 6 HOT AT ALL TIMES HOT IN ACC OR RUN HOT IN START OR RUN INTEGRATED ELECTRONIC MODULE (LEFT SIDE OF DASH) JUNCTION BLOCK (LEFT END OF DASH) FUSE 13 LT BLU WIRE RED WIRE TAN WIRE VIO WIRE WARNING SYSTEMS WARNING SYSTEMS WIPER/WASHER SYSTEM WHT WIRE WHT/DK BLU WIRE WIPER/ WASHER SYSTEM WPR PARK KEY IN IGN WSHR PMP WPR SW WPR SW KEY IN LP BATTERY YEL/DK GRN WIRE YEL/RED WIRE

ABMT TEMP/ CAN FCM BUS (-) ABMT TEMP/FCM B(+) BATTERY BLK WIRE BLK/LT GRN WIRE BRN WIRE CAN CAN BUS (-) BUS (+) CAN-BUS CHARGING CIRCUIT CIRCUIT BOARD COMPUTER DATA LINES SYSTEM DK BLU WIRE DK GRN WIRE FUSE GRY WIRE HOLD-IN HOOD AJAR SWITCH (LEFT FRONT OF ENGINE COMPT) HOT AT ALL TIMES IGN RUN ST IGN SW FD LT BLU WIRE LT BLU/RED WIRE LT GRN WIRE ORG/ WIRE PNK WIRE PNK/TAN WIRE POWER MODULE (LEFT FRONT OF ENGINE COMPT) POWERTRAIN CONTROL MODULE (LEFT REAR OF ENGINE) PRK NEUT SIG PRK/NEUT SIG PULL- IN RED WIRE STARTER STARTER RELAY STARTER RLY COIL STARTER RLY RTN TOTALLY INTEGRATED TRANSMISSION SOLENOID/TRS ASSEMBLY (LEFT SIDE OF TRANSMISSION) UHOOD SW SIG VIO WIRE VIO/BRN WIRE VIO/LT BLU WIRE WHT WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE WIRELESS IGNITION NODE YEL WIRE YEL/DK BLU WIRE

BASE/MIDLINE BLK WIRE BLK/LT GRN WIRE BLU WIRE CENTRAL TIMER MODULE (LEFT SIDE OF DASH) DK BLU WIRE DK BLU/RED WIRE DK BLU/WHT WIRE DRIVER DOOR AJAR SWITCH FUSE 11 FUSE 13 FUSE 6 FUSED B (+) FUSED IGN GROUND HEADLAMP SWITCH HOT AT ALL TIMES HOT IN RUN OR ACC HOT IN RUN OR START IGNITION SWITCH INSTRUMENT CLUSTER J/C 6 (BEHIND LEFT SIDE OF DASH) J/C 8 (CENTER OF DASH) JUNCTION BLOCK (LEFT END OF DASH) KEY-IN SWITCH (LEFT KICK PANEL) KEY-IN/LIGHTS ON WARNING KEY-IN/ LF DR AJAR SWITCH SENSE LT BLU WIRE LT GRN WIRE OFF RED WIRE SEAT BELT IND SEAT BELT SWITCH SEAT- BELT SW SENSE TONE REQUEST STANDARD CAB TAN WIRE TONE REQUEST WHT WIRE

1 2 3 4 5 6 7 8 TRANS RLY OUT 1 2 3 4 5 6 A/C CLUTCH RLY 31 32 GROUND GROUND A/T A/T (TRANS HARN, IN BREAKOUT TO PDC) AIR CONDI- TIONING SYSTEM AUTO SHT RLY CRUISE VAC SOL CRUISE VNT SOL AUTOMATIC SHUTDOWN RELAY BATTERY TEMPER- ATURE SENSOR (BELOW BATTERY TRAY) BLK WIRE BLK/LT BLU WIRE BLK/LT GRN WIRE BLK/TAN WIRE BLK/WHT WIRE BRAKE LAMP SWITCH (ON BRAKE PEDAL BRACKET) BRN WIRE CKP ENG SIG (PINS 9-21 NOT USED) 22 23 FUSED B(+) ACC PEDAL POS CONTROLLER ANTI-LOCK BRAKE CRUISE CONTROL SYSTEM CRUISE FEED ASD RELAY SENS TRANS OVERDRV 12 13 14 15 CRUISE SW IN DK BLU WIRE DK BLU/BLK WIRE DK BLU/ORG WIRE DK BLU/WHT WIRE DK BLU/YEL WIRE DK GRN WIRE DK GRN/ORG WIRE FUEL TANK MODULE (TOP OF FUEL TANK) FUSE 6 FUSE I GEN FIELD DRV TCC DRVR GENERATOR GRY/BLK WIRE HOT AT ALL TIMES IGN (POWER) JOINT CONNECTOR 1 (IN PDC) JOINT CONNECTOR 2 (IN PCD) LT BLU WIRE LT GRN/BLK WIRE LT GRN/RED WIRE LT GRN/WHT WIRE M/T ORG/ WIRE ORG/BLK WIRE ORG/DK BLU WIRE ORG/WHT WIRE OUTPUT SENS OUTPUT SPEED SENSOR (ON LEFT SIDE OF TRANSMISSION) OVERDRV SOL PARK/NEUTRAL POSITION SWITCH (ON LEFT SIDE OF TRANSMISSION) PNK WIRE PNK/DK BLU WIRE PNK/YEL WIRE POWERTRAIN CONTROL MODULE (IN ENG COMPT, ON RIGHT SIDE OF FIREWALL) PRK/NEUTRAL RED WIRE RED/LT BLU WIRE RED/LT GRN WIRE RED/WHT WIRE SENSOR GRD SENSOR GRD GOV PRESS SIG VAR FORCE SOL OVERDRV SOL TCC SOL CTRL TRANS TEMP SNS STARTING/ CHARGING SYSTEM TAN/RED WIRE TRANS- MISSION RELAY TRANSMISSION SOLENOID ASSEMBLY (ON LEFT SIDE OF TRANSMISSION) VAR FRCE SOL VIO WIRE VIO/BRN WIRE VIO/WHT WIRE VSS IN OUTPUT SENS GOV PRESS SIG TRANS RELAY WHT/BLK WIRE WHT/ORG WIRE WHT/PNK WIRE WHT/VIO WIRE YEL WIRE YEL/RED WIRE