Dodge Pickup R3500 (1996-2010) blk Wiring diagrams

33 42 28 27 APP 1 RET 36 37 6 25 SPEED CTRL BRAKE SW 6.7L 5.9L ACCEL ACCELERATOR PEDAL POSITION SENSOR (BEHIND LEFT SIDE OF DASH) ANTI-LOCK BRAKES MODULE (LEFT REAR OF ENGINE COMPT) APP 1 SIG APP 1 RET APP 2 RET APP 2 SIG APP 2 SIG APP 2 RET APP 1 SIG BLK WIRE BLU WIRE BRAKE SW 1 SIG BRN WIRE BRN/VIO WIRE BRN/WHT WIRE BRN/YEL WIRE DECEL DK BLU WIRE DK BLU/DK GRN WIRE DK GRN WIRE DK GRN/WHT WIRE ENGINE CONTROL MODULE (LOWER LEFT FRONT OF ENGINE BLOCK) FUSE 28 GRN WIRE GRY WIRE HOT AT ALL TIMES LEFT SPEED CONTROL SWITCH OFF ORG/ WIRE PNK EXTERIOR LIGHTS SYSTEM WIRE PNK WIRE REAR OF ENGINE COMPT) RED WIRE RESUME RIGHT SPEED CONTROL SWITCH RWAL AWAL SENS GND S/C SW RET S/C SW 1 SIG S/C SW 2 SIG 33 40 56 46 56 STEERING CONTROL MODULE (ON STEERING COLUMN) STOP LAMP SWITCH (ON BRAKE PEDAL SUPPORT) TAN WIRE TOTALLY INTEGRATED POWER MODULE (AT LEFT FRONT FENDER) FUSE 26 VIO WIRE VIO/BRN WIRE VIO/ORG WIRE VIO/YEL WIRE WHT WIRE WHT/BRN WIRE YEL WIRE

ABMT TEMP/FCM ABS PMP FD ADJ PED SW FD AMBIENT AIR TEMPERATURE SENSOR (LEFT FRONT OF ENGINE COMPT) AMBT TEMP SIG ANTI-LOCK BRAKES SYSTEM B(+) BATT FD 1 GND WDW RUN/ACCY IGN BATT FD 7 IOD FD TO DR NODE-PASS GND FT WPR MTR HI SPD FD FUEL PUMP MTR FD BATTERY BLK WIRE BLK/LT BLU WIRE BLK/LT GRN WIRE BRN WIRE BRN/GRY WIRE BRN/ORG WIRE BRN/TAN WIRE BRN/WHT WIRE BRN/YEL WIRE CAN BUS C DIAG (+) CAN BUS C DIAG (-) CAN IHS BUS (+) CAN IHS BUS (-) COMPUTER DATA LINES SYSTEM COOLING FANS SYSTEM DK BLU/DK GRN WIRE DK BLU/ORG WIRE DK BLU/PNK WIRE DK BLU/WHT WIRE DK GRN/DK BLU WIRE DK GRN/RED WIRE DOOR LOCKS SYSTEM DOOR LOCKS, ANTI-THEFT SYSTEMS ENGINE COMPT) ENGINE CONTROLS SYSTEM FRONT WASHER FLUID LEVEL SENSOR FT WPR MTR PRK SIG FUEL LVL SENS SIG FUSED HORN CTRL OUT GRY WIRE GRY/LT BLU WIRE GRY/YEL WIRE HEADLIGHTS SYSTEM HEADLIGHTS SYSTEM WIPER/WASHER SYSTEM HOOD AJAR SWITCH (LEFT FRONT OF ENGINE COMPT) HORNS SYSTEM IGN RUN/ST CTRL OUT IOD FD IGN SW FD IGN RUN ACC BKUP LMPS FD TTOW IGN MOD FSED BATT FD IOD FD IOD FD IOD FD LO SPD RAD FAN CTRL LT BLU WIRE LT BLU/PNK WIRE LT BLU/RED WIRE LT GRN/LT BLU WIRE LT GRN/RED WIRE LT GRN/TAN WIRE NAVIGATION SYSTEM INSTRUMENT CLUSTER SYSTEM POWER DISTRIBUTION SYSTEM ORC MOD RUN/STRT IGN CLSTR/CHMSL BATT FD BATT FD 4 ABS MOD BATT FD IOD FD ORG/RED WIRE PNK IGN RUN/STRT CTRL OUT WIRE PNK/LT GRN WIRE PNK/ORG WIRE PNK/TAN WIRE PNK/WHT WIRE PNK/YEL WIRE POWER DISTRIBUTION SYSTEM POWER WINDOWS SYSTEM PWR ENABLE TO SW RED WIRE RED/LT BLU WIRE RED/LT GRN WIRE RED/ORG WIRE RED/PNK WIRE RED/WHT WIRE RR WSH CTRL FT WSH MTR CTRL RT HI BEAM FD HDLP RT RTN LT LO BEAM FD LO WSH SW SNSE SEATS SYSTEM SEATS, MEMORY SYSTEMS DOOR LOCKS SYSTEM SSR RTN 1 TAN/RED WIRE TOTALLY INTEGRATED POWER MODULE (LEFT FRONT OF TOTALLY INTEGRATED POWER MODULE (LEFT FRONT OF ENGINE COMPT) VIO WIRE VIO/BRN WIRE VIO/GRY WIRE VIO/LT BLU WIRE VIO/LT GRN WIRE VIO/WHT WIRE VIO/YEL WIRE WHT WIRE WHT/BRN WIRE WHT/DK BLU WIRE WHT/DK GRN WIRE WHT/GRY WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE WHT/ORG WIRE WHT/RED WIRE WHT/TAN WIRE WHT/VIO WIRE WHT/YEL WIRE WIPER/WASHER SYSTEM WIPER/WASHER SYSTEM ENGINE CONTROLS SYSTEM YEL/RED WIRE

17 18 TRANS CTRL OUT ASD RLY CTRL 20 21 22 23 24 25 26 FUSED IGN RUN/ST CTRL A/C CLUTCH COIL A/C PRESS SNSE RTN A/C PRESS SIG A/C PRESS SNSR FD AIR CONDITIONING SYSTEM AIR CONDITIONING, NAVIGATION SYSTEMS ANTI-LOCK BRAKES SYSTEM BATT FD BATT FD 9 BLK WIRE BLK/BRN WIRE BLK/LT BLU WIRE BRK LVL SW SIG BRN WIRE BRN/BLK WIRE BRN/GRY WIRE BRN/WHT WIRE CAN-BUS CAN-BUS COMPUTER DATA LINES SYSTEM DEFOGGER SYSTEM SEATS SYSTEM EXTERIOR LIGHTS SYSTEM DK BLU WIRE DK BLU/YEL WIRE DK GRN/ORG WIRE DK GRN/RED WIRE DOOR LOCKS SYSTEM DR LK RT FT ELEC BKLT FD IGN R TTOW PRK LMP SIG FUSED ASD RLY OUT FUSED ASD RLY OUT BATT FD ENG CTRL DRCT BATT FD ENG CTRL RUN/STRT IGN STP LMP SIG IGN ULK/RUN/STRT A/C CLUTCH FD ENGINE CONTROLS SYSTEM EXTERIOR LIGHTS SYSTEM SEATS SYSTEM POWER TOPS SYSTEM EXTERIOR LIGHTS SYSTEM FUEL PUMP CTRL GND BATT FD IGN (RUN) IGN R IGN RS LT BLU/BRN WIRE LT BLU/ORG WIRE LT GRN/GRY WIRE PNK/GRY WIRE PNK/LT GRN WIRE PNK/VIO WIRE PNK/WHT WIRE PNK/YEL WIRE POWER DISTRIBUTION SYSTEM POWER WINDOWS SYSTEM RED WIRE RED/GRY WIRE RED/LT BLU WIRE RED/LT GRN WIRE RED/VIO WIRE RED/YEL WIRE RT TTOW RLY CTRL IGN R BATT FD BATT FD 3 STARTING/CHARGING SYSTEM STARTING/CHARGING SYSTEM EXTERIOR LIGHTS SYSTEM STRTR OVRDE RLY COIL RTN SUPPLEMENTAL RESTRAINTS SYSTEM (LEFT SIDE OF ENGINE COMPT) TAN/BRN WIRE TAN/DK BLU WIRE TAN/LT BLU WIRE TAN/LT GRN WIRE TAN/ORG WIRE TAN/VIO WIRE TAN/WHT WIRE TOTALLY INTEGRATED POWER MODULE (LEFT FRONT OF ENGINE COMPT) TRANSMISSION CTRL OUT TRANSMISSIONS SYSTEM TRANSMISSIONS SYSTEM ENGINE CONTROLS SYSTEM WHT/DK BLU WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE WHT/VIO WIRE YEL/BRN WIRE YEL/GRY WIRE YEL/ORG WIRE YEL/RED WIRE

BLK WIRE BLK/LT GRN WIRE BLK/PNK WIRE CAN C BUS (+) CAN C CAN C BUS (+) BUS (-) COMPUTER DATA LINES SYSTEM DYN SENS HIGH LNK DYN SENS LOW LNK DYNAMICS SENSOR (W/ ESP) (UNDER FRONT OF CENTER CONSOLE) ELECTRONICS B(+) FUSE 28 FUSE 30 FUSED IGN SW OUT (RUN-START) GRY WIRE GRY/ PNK WIRE HIGH LNK DYN SENS HOT AT ALL TIMES HOT IN ON OR START IGN SW OUT (RUN-START) LOW LNK DYN SENS LT BLU/ WHT WIRE LT GRN PNK/ WIRE LT GRN WHT/ WIRE ORG/ WIRE PNK/ LT GRN WIRE PNK/GRY WIRE PNK/LT GRN WIRE STEERING ANGLE SENSOR (W/ ESP) (ON STEERING COLUMN) TOTALLY INTEGRATED POWER MODULE (AT LEFT FRONT FENDER) WHT LT GRN/ WIRE WHT WIRE WHT/GRY WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE WHT/ORG WIRE

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 FUSED B(+) 1 2 6 LH AUDIO OUT RH AUDIO OUT COM AUDIO OUT 2 13 CAN IHS BUS (-) CAN IHS BUS (+) BLK WIRE BLK/ORG WIRE BRN WIRE BRN/ORG WIRE CAN IHS BUS (-) CAN IHS BUS (-) MICROPHONE 2 IN (+) COMPUTER DATA LINES SYSTEM DATA DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE DK GRN/BLK WIRE DK GRN/LT BLU WIRE DK GRN/ORG WIRE DK GRN/YEL WIRE FUSE INTEGRATED POWER MODULE (LEFT FRONT OF ENGINE COMPT) GRY WIRE HANDS FREE MODULE (RIGHT SIDE OF DASH) HOT AT ALL TIMES INSIDE REARVIEW MIRROR IPOD MEDIA MODULE (IF EQUIPPED) LEFT AUDIO OUTPUT RIGHT AUDIO OUTPUT COMMON AUDIO OUTPUT LT BLU/DK GRN WIRE MEDIA SHIELD 1 MICROPHONE 2 IN (+) MICROPHONE FEED MICROPHONE FEED SENS GND GND MICROPHONE IN (+) MICROPHONE IN (-) MICROPHONE IN (-) NCA WIRE ORG/GRY WIRE PWR FD 2 PASSTH PWR FEED PASSTH RADIO RED WIRE SENS GND SHIELD TAN WIRE TOTALLY UCI AUDIO LH IN UCI AUDIO REF UCI AUDIO RH IN UCI DEVICE DETECT UCI EXT RX FROM USI UCI EXT TX TO USI UCI ID WHT WIRE WHT/GRY WIRE WHT/ORG WIRE YEL WIRE

A/T A/T ANTI-LOCK ENGINE BRAKES MODULE CONTROL MODULE ASSEMBLY WINCH (POWER WAGON) AUXILIARY BATTERY (DIESEL) BATTERY BLK WIRE BLK/LT BLU WIRE BRAKE PROVISION MODULE BRN WIRE BRN/RED WIRE CLUSTER FREE HANDS MODULE CLUSTER MOTOR/ SUNROOF MODULE DASH) DATA LINK CONNECTOR DIESEL DK GRN WIRE DK GRN/RED WIRE DK GRN/YEL WIRE DRIVER DRIVER SEAT WINDOW/ SWITCH DOOR LOCK SWITCH ELECTRONIC A/C OVERHEAD HEATER MODULE CONTROL (EXCEPT BASE) EXCEPT BASE EXCEPT SRT-10 EXCEPT SRT-10 SRT-10 FINAL DRIVE CONTROL MODULE FUSE FUSE 1 FUSE 11 FUSE 12 FUSE 13 (TRAILER TOW) (AWAL) FUSE 2 FUSE 25 FUSE 26 FUSE 27 FUSE 31 (EXCEPT SRT-10) FUSE 38 (EXCEPT SRT-10) FUSE 5 FUSE 35 (EXCEPT BASE) FUSE 6 (DIESEL) FUSE 7 (SRT-10) FUSE 9 (POWER WAGON) FUSE FUSE 18 42 (DIESEL) (AWAL) FUSED B (+) FUSIBLE LINK (12 GA- FUSIBLE LINK (8 GA- GAS GENERATOR GRY/RED WIRE IGNITION IGNITION SWITCH SWITCH OUTPUT MUX (START) SENSE IGNITION SWITCH IGNITION SWITCH OUTPUT (RUN-START) IGNITION SWITCH SENSE RETURN INTAKE AIR HEATER RELAY (DIESEL) LT BLU WIRE LT BLU/RED WIRE NCA WIRE NEAR ENGINE CONTROL MODULE) OF ENGINE) ORG/RED WIRE PASSENGER SEAT SWITCH PNK/WHT WIRE PNK/YEL WIRE POWER OUTLET POWER OUTLET CONSOLE (EXCEPT BASE) PUSH BUTTON STARTER SWITCH RADIATOR FAN DRIVE RADIO AMPLIFIER (PREMIUM) RADIO CLUSTER RED WIRE RED/DK BLU WIRE RED/LT BLU WIRE RED/ORG WIRE RED/YEL WIRE REVERSE LOCKOUT SOLENOID SATELLITE MONITOR/ RECEIVER DVD MEDIA SYSTEM SENTRY KEY REMOTE ENTRY MODULE SHIFT MOTOR/MODE SENSOR ASSEMBLY SLT+/ SRT-10 SRT-10 SRT-10 EXCEPT SRT-10 SLT+/ STARTER STARTER MOTOR RELAY (EXCEPT SRT-10) STOP LAMP SWITCH SUBWOOFER AMPLIFIER (SRT-10) TAN/RED WIRE TO TOTALLY INTEGRATED POWER MODULE (DIAGRAM 2 OF 2) TOTALLY INTEGRATED POWER MODULE (AT LEFT FRONT FENDER) UNDERHOOD LAMP (SRT-10) (BEHIND LEFT SIDE OF DASH) POWERTRAIN CONTROL MODULE VIO/BRN WIRE VIO/ORG WIRE W/ SATELLITE W/ W/O HANDS HANDS FREE FREE WASTEGATE SOLENOID YEL/RED WIRE

BLK WIRE DRIVER FRONT VERTICAL ADJUSTER SEAT MOTOR (AT DRIVER SEAT) DRIVER HORIZONTAL ADJUSTER SEAT MOTOR (AT DRIVER SEAT) DRIVER REAR VERTICAL ADJUSTER SEAT MOTOR (AT DRIVER SEAT) DRIVER SEAT SWITCH F DN F UP FUSE 27 HOT AT ALL TIMES LT GRN/BRN WIRE LT GRN/DK GRN WIRE LT GRN/LT BLU WIRE LT GRN/ORG WIRE LT GRN/TAN WIRE LT GRN/WHT WIRE LT GRN/YEL WIRE NCA WIRE ORG/RED WIRE PASSENGER FRONT VERTICAL ADJUSTER SEAT MOTOR PASSENGER HORIZONTAL ADJUSTER SEAT MOTOR (AT PASSENGER SEAT) PASSENGER REAR VERTICAL ADJUSTER SEAT MOTOR PASSENGER SEAT SWITCH (STANDARD CAB) R DN R UP RWD TOTALLY INTEGRATED POWER MODULE (AT LEFT FRONT FENDER) W/ PASSENGER POWER SEAT

1 2 3 4 5 5 V SPLY MODE SENSOR A SENSOR RETURN SHIFT CTRL B SHIFT CTRL A 17 18 CAN B BUS(+) CAN B BUS(-) B(+) SHIFT SHIFT MTR MTR MODE SENS 5 V CTRL CTRL BUS BUS SENS RTN SPLY BLK WIRE BRN/WHT WIRE CAN (-) CAN (+) CLUSTER COMPUTER DATA LINES SYSTEM DK GRN WIRE ELECTRONICS EXCEPT BASE FUSE 29 HOT AT ALL TIMES HOT IN ON OR START TOTALLY INTEGRATED POWER MODULE (LEFT FRONT FENDER) MODE SELECT NEUTRAL IND ORG/DK BLU WIRE PNK/DK GRN WIRE SENS IN TRANSFER CASE SELECTOR SWITCH (5.9L DIESEL: LEFT SIDE OF TRANSFER CASE) VIO/BRN WIRE VIO/YEL WIRE WHT WIRE WHT/DK GRN WIRE WHT/ORG WIRE YEL WIRE YEL/ORG WIRE

B(+) MODE SNS A SNS RTN BLK WIRE EXCEPT POWER WAGON HOT AT ALL TIMES MODE SNS A POWER WAGON SNS RTN TOTALLY INTEGRATED POWER MODULE (AT LEFT FRONT FENDER) TRANSFER CASE POSITION SENSOR (TOP OF TRANSFER CASE) VIO/YEL WIRE WHT/DK GRN WIRE

AIR CONDITIONING SYSTEM AUXILIARY BATTERY BATTERY TEMPERATURE SENSOR (UNDER BATTERY TRAY) BLK WIRE BRAKE LAMP SIG HTR RLY CTRL S/C SW 2 SIG GROUND BRN WIRE BRN/BLK WIRE BRN/DK BLU WIRE BRN/DK GRN WIRE BRN/LT BLU WIRE BRN/ORG WIRE BRN/VIO WIRE BRN/WHT WIRE BRN/YEL WIRE CLUTCH INTERLOCK/ UPSTOP SWITCH (M/T) (LEFT SIDE OF DASH) COMPUTER DATA LINES SYSTEM DIAGNOSTIC PORT (TOP LEFT SIDE OF ENGINE) DK BLU/DK GRN WIRE DK BLU/LT GRN WIRE DK BLU/VIO WIRE DK GRN WIRE DK GRN/ORG WIRE DK GRN/WHT WIRE ENGINE CONTROL MODULE (LOWER LEFT FRONT OF ENGINE BLOCK) EXHAUST PRESSURE SENSOR 1/2 (RIGHT SIDE OF TRANSMISSION) EXHAUST TEMPERATURE SENSOR 1/1 (IN EXHAUST, FORWARD OF CATALYTIC CONVERTER) EXHAUST TEMPERATURE SENSOR 1/2 (IN EXHAUST, AT REAR OF CATALYTIC CONVERTER) EXHAUST TEMPERATURE SENSOR 1/3 (IN EXHAUST, DOWNSTREAM OF CATALYTIC CONVERTER) FUSED B (+) FUSIBLE LINK (10 GA- GROUND GROUND FUSED B(+) FUSED B(+) LOW DATA LINK INTAKE AIR HEATER INTAKE AIR HEATER RELAY (LEFT FRONT BUMPER) LT BLU WIRE LT GRN/BLK WIRE ORG/BRN WIRE PNK WIRE PNK/GRY WIRE RAM 2500 RED WIRE RED/YEL (OR BLK) WIRE RED/YEL (OR DK GRN) WIRE RED/YEL WIRE RLY CTRL RTN S/C SW 1 SIG RMT THROTTLE SIG S/C SW RTN PRES SENS SIG APPS 1 SIG SMT PWR RLY RTN A/C CLUTCH CTRL IGN SW OUT (RUN-START) TEMP 1 SENS SIG CAN C BUS (-) APPS 2 RTN UPSTOP SW SIG TAKEOFF SW IN INTERLOCK SW SIG SW RLY SIG VIO WIRE VIO/BRN WIRE VIO/DK GRN WIRE VIO/ORG WIRE VIO/YEL WIRE WHT WIRE WHT/BRN WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE WHT/ORG WIRE