Dodge Pickup R3500 (1996-2010) batt fd Wiring diagrams

2 1 11 CAN IHS BUS(-) CAN IHS BUS(+) LIN BUS COMPUTER DATA LINES SYSTEM 29 9 10 9 14 23 65 66 BRK SIG 2 BRK SIG 1 35 34 18 35 COMPUTER DATA LINES SYSTEM CAN BUS (-) CAN BUS (+) 5.7L 5.7L 6.7L ANTI-LOCK BRAKES MODULE (LEFT REAR OF ENGINE COMPT) B (+) CAN BUS (-) BUS (+) BATT FD BLK WIRE BLK/DK GRN WIRE BLK/TAN WIRE BRAKE FLUID LEVEL SENSOR (LEFT REAR OF ENGINE COMPT) BRK FLUID LEVEL SW SENSE CAN BUS (+) 2 CLUSTER COMPUTER DATA LINES SYSTEM DK DK DK GRN WIRE DK GRN/LT GRN WIRE DK GRN/ORG WIRE DK GRN/RED WIRE DK GRN/TAN WIRE DK GRN/VIO WIRE DK GRN/WHT WIRE DK GRN/YEL WIRE FUSE FUSED B (+) IGN RS PNK WIRE FUSED B(+) CAN BUS 2 (+) GND (LEFT SIDE OF DASH) GRN WIRE GROUND HOT AT ALL TIMES IGN RS LEFT FRONT ABS WHEEL SPEED SENSOR (LEFT FRONT WHEEL HUB ASSEMBLY) LF WHEEL SPD SENSOR (+) LF WHEEL SPD SENSOR (-) LT BLU WIRE LT BLU/DK GRN WIRE LT GRN WIRE LT GRN/RED WIRE ORG/ WIRE PARKING BRAKE SWITCH (TOP OF PARKING BRAKE PEDAL) PNK PNK IGN RUN/START BRK SIG 1 BRK SIG 2 11 12 WIRE PNK WIRE POWERTRAIN CONTROL MODULE PRK BRK SW SIG REAR ABS WHEEL SPEED SENSOR REAR WHEEL SPD SENS (-) REAR WHEEL SPD SENS (+) RED WIRE RF WHEEL SPD SENSOR (+) RF WHEEL SPD SENSOR (-) RIGHT FRONT ABS WHEEL SPEED SENSOR (RIGHT FRONT WHEEL HUB ASSEMBLY) STOP LAMP SWITCH (ON BRAKE PEDAL SUPPORT) STP LMP SIG TAN WIRE TAN/RED WIRE TOTALLY INTEGRATED POWER MODULE (LEFT FRONT OF ENGINE COMPT) CIRCUIT BOARD VIO WIRE WHT WIRE WHT/DK GRN WIRE WHT/GRY WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE WHT/ORG WIRE WIRELESS IGNITION NODE YEL WIRE

17 18 TRANS CTRL OUT ASD RLY CTRL 20 21 22 23 24 25 26 FUSED IGN RUN/ST CTRL A/C CLUTCH COIL A/C PRESS SNSE RTN A/C PRESS SIG A/C PRESS SNSR FD AIR CONDITIONING SYSTEM AIR CONDITIONING, NAVIGATION SYSTEMS ANTI-LOCK BRAKES SYSTEM BATT FD BATT FD 9 BLK WIRE BLK/BRN WIRE BLK/LT BLU WIRE BRK LVL SW SIG BRN WIRE BRN/BLK WIRE BRN/GRY WIRE BRN/WHT WIRE CAN-BUS CAN-BUS COMPUTER DATA LINES SYSTEM DEFOGGER SYSTEM SEATS SYSTEM EXTERIOR LIGHTS SYSTEM DK BLU WIRE DK BLU/YEL WIRE DK GRN/ORG WIRE DK GRN/RED WIRE DOOR LOCKS SYSTEM DR LK RT FT ELEC BKLT FD IGN R TTOW PRK LMP SIG FUSED ASD RLY OUT FUSED ASD RLY OUT BATT FD ENG CTRL DRCT BATT FD ENG CTRL RUN/STRT IGN STP LMP SIG IGN ULK/RUN/STRT A/C CLUTCH FD ENGINE CONTROLS SYSTEM EXTERIOR LIGHTS SYSTEM SEATS SYSTEM POWER TOPS SYSTEM EXTERIOR LIGHTS SYSTEM FUEL PUMP CTRL GND BATT FD IGN (RUN) IGN R IGN RS LT BLU/BRN WIRE LT BLU/ORG WIRE LT GRN/GRY WIRE PNK/GRY WIRE PNK/LT GRN WIRE PNK/VIO WIRE PNK/WHT WIRE PNK/YEL WIRE POWER DISTRIBUTION SYSTEM POWER WINDOWS SYSTEM RED WIRE RED/GRY WIRE RED/LT BLU WIRE RED/LT GRN WIRE RED/VIO WIRE RED/YEL WIRE RT TTOW RLY CTRL IGN R BATT FD BATT FD 3 STARTING/CHARGING SYSTEM STARTING/CHARGING SYSTEM EXTERIOR LIGHTS SYSTEM STRTR OVRDE RLY COIL RTN SUPPLEMENTAL RESTRAINTS SYSTEM (LEFT SIDE OF ENGINE COMPT) TAN/BRN WIRE TAN/DK BLU WIRE TAN/LT BLU WIRE TAN/LT GRN WIRE TAN/ORG WIRE TAN/VIO WIRE TAN/WHT WIRE TOTALLY INTEGRATED POWER MODULE (LEFT FRONT OF ENGINE COMPT) TRANSMISSION CTRL OUT TRANSMISSIONS SYSTEM TRANSMISSIONS SYSTEM ENGINE CONTROLS SYSTEM WHT/DK BLU WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE WHT/VIO WIRE YEL/BRN WIRE YEL/GRY WIRE YEL/ORG WIRE YEL/RED WIRE

3 2 1 SPD CTRL SW FD SW SPD CTRL RDNT SW SPD CTRL RTN A/T ACCELERATOR PEDAL POSITION SENSOR (LEFT SIDE OF DASH) ACCL PED POSTN SNSE ACCL PED POSTN 1 SIG BATT FD BATT RUN/START BLK WIRE BLK/TAN WIRE BRK SNSE SIG BRK SNSE SIG 2 BRN/LT GRN WIRE BRN/VIO WIRE BRN/YEL WIRE CIRCUIT BOARD CLUTCH INTERLOCK SWITCH (M/T) (LEFT SIDE OF DASH) COMPUTER DATA LINES SYSTEM DK GRN/BRN WIRE DK GRN/ORG WIRE DK GRN/RED WIRE DK GRN/VIO WIRE FUSE ENGINE COMPT) HOT AT ALL TIMES INPUT SPEED SENSOR LT BLU/DK GRN WIRE LT GRN/RED WIRE M/T OUTPUT SPEED SENSOR PARK/NUET SIG PED POS SNSE RTN PNK/WHT WIRE PNK/YEL WIRE POWERTRAIN CONTROL MODULE SPD CTRL SW FD SPEED CONTROL SWITCH STEERING CONTROL MODULE (LEFT SIDE OF DASH) STOP LAMP SWITCH (ON BRAKE PEDAL SUPPORT) SW CTRL RDNT FD SW SPD CTRL RTN TOTALLY INTEGRATED POWER MODULE (LEFT FRONT OF TRANS PRK/NEUT SIG TRANSMISSION SOLENOID ASSEMBLY (TRS) VIO WIRE VIO/BRN WIRE VIO/ORG WIRE WHT/BRN WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE YEL/DK BLU WIRE YEL/PNK WIRE

1 2 3 CAN IHS BUS (-) CAN IHS BUS (+) OUTSDE MRR SIG 3 4 5 6 7 8 DRV HEATED MRR RTN DRV HEATED MRR FD 3 4 5 6 7 8 PASS HEATED MRR RTN PASS HEATED MRR FD 9 16 14 BKUP LMPS FD EC MRR RTN OUTSDE EC MRR SIG BACKUP LAMP FEED BATT FD BLK WIRE BLK/DK GRN WIRE BLK/WHT WIRE CIRCUIT BOARD COMPUTER DATA LINES SYSTEM DK BLU WIRE DRIVER DOOR MODULE DRIVER OUTSIDE REARVIEW MIRROR DRV HEATED DRV PWR MRR DRV PWR MRR MTR VERT DRV PWR MRR MTR COM DRV PWR MRR MTR HORZ EC MRR RTN FUSE FUSE GROUND HOT AT ALL TIMES INSIDE REARVIEW MIRROR IOD FD MRR FD MRR RTN MTR COM MTR HORZ MTR VERT PASS HEATED PASS PWR MRR PASS PWR MRR MTR VERT PASS PWR MRR MTR COM PASS PWR MRR MTR HORZ PASSENGER DOOR MODULE PASSENGER OUTSIDE REARVIEW MIRROR RED WIRE RED/LT BLU WIRE RED/LT GRN WIRE TAN/ORG WIRE TAN/WHT WIRE TOTALLY INTEGRATED POWER MODULE (LEFT FRONT OF ENGINE COMPT) VIO WIRE WHT/GRY WIRE WHT/LT GRN WIRE WHT/ORG WIRE WHT/RED WIRE

18 35 35 34 CAN C BUS (-) CAN C BUS (+) 5.7L 6.7L 5.7L ASTK UP BATT FD BATT FD (5.7L) RUN/START (6.7L) BLK/LT GRN WIRE BLK/TAN WIRE BRAKE TRANSMISSION SHIFT INTERLOCK BRK SIG BRK SIG 2 BRN/YEL WIRE BTSI CTRL CAN-BUS CLUSTER COMPUTER DATA LINES SYSTEM DK GRN/DK BLU WIRE DK GRN/LT BLU WIRE DK GRN/RED WIRE DK GRN/YEL WIRE ERS AUTOSTICK SWITCH FUSE GROUND HEAD- LAMP SWITCH HOT AT ALL TIMES HOT AT ALL TIMES CIRCUIT BOARD IGN FD LT BLU/DK GRN WIRE LT GRN/RED WIRE PNK/TAN WIRE PNK/WHT WIRE POWERTRAIN CONTROL MODULE (RIGHT REAR OF ENGINE COMPT) PRK/NEUT SIG RED WIRE RUN/START IGN RUN/START SOLENOID STOP LAMP SWITCH (ON BRAKE PEDAL SUPPORT) SW RTN TOTALLY INTEGRATED POWER MODULE (LEFT FRONT OF ENGINE COMPT) TRANSMISSION SOLENOID/TRS ASSEMBLY TRS PARK SIG WHT/GRY WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE WHT/ORG WIRE WHT/YEL WIRE WIN WIRELESS IGNITION NODE YEL/DK BLU WIRE

5.7L CREW CAB) 7 WAY TRAILER TOW WIRING (AT TRAILER HITCH) B(+) BACKUP LAMPS CIRCUIT BATT FD BLK WIRE BLK/DK GRN WIRE BLK/TAN WIRE BRAKE PROVISION MODULE (LEFT SIDE OF DASH) BRN WIRE CAN BUS (+) 2 CARGO LAMP CENTER HIGH MOUNTED CENTER HIGH MOUNTED STOP CIRCUIT BOARD COMPUTER DATA LINES SYSTEM CTRL RT TTOW RLY DK GRN WIRE ELEC BRK FD ENGINE COMPT) FUSE FUSE HOT AT ALL TIMES HOT W/ RUN/ START RELAY ENERGIZED IGN RS ITBM BRAKE PROVISION MODULE LMP SIG TTOW PRK LT GRN/RED WIRE PNK/LT GRN WIRE RED/VIO WIRE STOP LAMP (AFTERMARKET) STOP LAMP SWITCH (ON BRAKE PEDAL SUPPORT) STOP LP SIG STP LMP SIG TOTALLY INTEGRATED POWER MODULE (LEFT FRONT OF TRAILER TOW MODULE TTOW RLY CTRL LT WHT WIRE WHT/DK GRN WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE WHT/ORG WIRE WHT/RED WIRE WHT/VIO WIRE WIRELESS IGNITION NODE YEL/RED WIRE

10 19 11 20 GND IGN RS LIN CCN IOD FD 2 1 CAN IHS BUS(-) CAN IHS BUS(+) ABMT TEMP/ FCM SSR RTN 1 ABMT TEMP/FCM SSR RTN 1 LO WSH SW SNSE AMBIENT AIR TEMPERATURE SENSOR (LEFT FRONT OF ENGINE COMPT) BATT FD BLK WIRE BLK/DK GRN WIRE BLK/LT GRN WIRE BRN WIRE BRN/GRY WIRE BRN/ORG WIRE BRN/TAN WIRE BRN/WHT WIRE BRN/YEL WIRE CIRCUIT BOARD CLUSTER COMPUTER DATA LINES SYSTEM DK GRN WIRE FRONT WASHER FLUID LEVEL SENSOR FRONT WASHER PUMP RELAY FRONT WIPER MOTOR FT WPR MTR HI SPD FD FT WPR MTR LO SPD FD FT WPR MTR PRK SIG FT WSH MTR CTRL FUSE HOOD AJAR SWITCH (LEFT FRONT OF ENGINE COMPT) HOT AT ALL TIMES HOT W/ RUN/START RELAY ENERGIZED IGN RS IOD FD LIN CCN LO WSH SW SNSE PNK/LT GRN WIRE REAR WASHER PUMP RELAY REAR WIPER RELAY RED WIRE RED/GRY WIRE RR WSH CTRL SCCM MULTI-FUNCTION SWITCH TOTALLY INTEGRATED POWER MODULE (LEFT VIO/BRN WIRE WHT/DK GRN WIRE WHT/GRY WIRE WHT/ORG WIRE WINDSHIELD WASHER PUMP (LEFT FRONT OF ENGINE COMPT) WIPER HIGH/LOW RELAY WIPER ON/OFF RELAY WSH PMP MTR FD

ACTV SNSE SIG 2 ASD CTRL FD 3 BATT FD BLK WIRE BLK/TAN WIRE BRK ACTV BRK ACTV SNSE SIG BRN/DK BLU WIRE BRN/DK GRN WIRE BRN/GRY WIRE BRN/LT BLU WIRE BRN/ORG WIRE BRN/VIO WIRE BRN/YEL WIRE BYPASS STAT CAT OUT TEMP CLSTR/CHMSL CRANKSHAFT POSITION SENSOR CRK SPD SNSR O/P CRKSHFT POS SNSR FD CRKSHFT POS SNSR RTN CTRL RUN/STRT IGN DIFF PRESS SNSE DK BLU/GRY WIRE DK BLU/LT BLU WIRE DK GRN/BRN WIRE DK GRN/RED WIRE DK GRN/TAN WIRE EGR BYPSS STAT EGR COOLER BY-PASS ACTUATOR EGR MTR POS SIG EGR MTR POS SIG 3 ENG FAN SPD OUT FUEL INJ 4 RTN FUEL SNSE SIG IGN RS IGN ULK/RUN/STRT LT BLU/DK GRN WIRE LT GRN/RED WIRE MODULE OUT SPD SIG OVRDRV PRESS SW PNK WIRE PNK/GRY WIRE PNK/WHT WIRE POSTN SNSR FD POSTN SNSR RTN POWERTRAIN CONTROL PRE TURBINE SIG PRESS TRANS SIG RLY 1 CTRL SIG SNSE SIG SNSE SIG 2 SNSR TO PCM SPD CTRL SW FD STEERING CONTROL MODULE (LEFT SIDE OF DASH) STOP LAMP SWITCH (ON BRAKE PEDAL SUPPORT) STP LMP SIG SW SPD CTRL RDNT SW SPD CTRL RTN TURBO VAR IN VLV VALVE (+) SIG VIO WIRE VIO/BRN WIRE VIO/LT GRN WIRE VIO/ORG WIRE WATER IN WHT WIRE WHT/BRN WIRE YEL/BRN WIRE YEL/LT GRN WIRE