Dodge Pickup R2500 (1996-2010) tan Wiring diagrams

1 2 3 4 AUTO HEADLAMPS SIG SUN SENSOR SIG 1 SUN SENSOR SIG 2 SENSOR GROUND 1 4 3 IGN RUN CTRL OUT IR SENSOR RETURN IR SENSOR SIGNAL 10 9 34 35 FUSED B(+) GND CAN BUS (+) CAN BUS (-) 27 20 SENS GND ECT SIG 4 2 3 1 BLWR MTR HI DRV FT BLW FD BLWR CTRL GND A/C CLUTCH COIL A/C CLUTCH CTRL OUT A/C COMPRESSOR CLUTCH (3.7L, 4.7L: FRONT OF ENGINE) A/C HEATER CONTROL A/C PRESS A/C PRESS SNSE RTN A/C PRESS SNSR FD A/C PRESS SIG A/C PRESS SNSR FD B(+) BLK WIRE BLK/LT BLU WIRE BLK/LT GRN WIRE BLK/TAN WIRE BLOWER MODULE BLOWER MOTOR (RIGHT SIDE BRN WIRE CAN 2 BUS (-) CAN IHS BUS (-) CAN IHS BUS (+) IOD FD FUSED IGN RUN CTRL OUT CIRCUIT BOARD CLUTCH A/C COIL COMPUTER DATA LINES SYSTEM DK BLU WIRE DK BLU/DK GRN WIRE DK BLU/GRY WIRE DK BLU/LT BLU WIRE DK BLU/LT GRN WIRE DK BLU/ORG WIRE DK BLU/PNK WIRE DK BLU/RED WIRE DK BLU/TAN WIRE DK BLU/WHT WIRE DK BLU/YEL WIRE DK GRN/DK BLU WIRE DRIVER BLEND MODE DOOR DOOR ACTUATOR ACTUATOR 1 (ON HVAC UNIT) (ON HVAC UNIT) ENGINE CONTROLS SYSTEM EVAP SIG EVAP SNSE RTN EVAPORATOR TEMPERATURE SENSOR (CENTER OF DASH) FAN RADIATOR HIGH RELAY FAN RADIATOR LOW RELAY FUSE FUSE FUSE HI SPD RAD FAN HOT AT ALL TIMES HOT W/ RUN RELAY ENERGIZED INFRARED SENSOR LOW SPD SIG LT BLU WIRE LT BLU/BRN WIRE LT BLU/ORG WIRE LT BLU/RED WIRE LT GRN WIRE MODE DOOR ACTUATOR 2 (ON HVAC UNIT) NAVIGATION SYSTEM OF DASH) ORG/ WIRE PASSENGER BLEND DOOR ACTUATOR (ON HVAC UNIT) PNK/YEL WIRE POWERTRAIN CONTROL MODULE (3.7L, 4.7L: REAR OF ENGINE) RAD FAN RADIATOR FAN RECIRCULATION DOOR ACTUATOR RED WIRE RED/WHT WIRE SIG SNSE RTN A/C PRESS SPLY BLW MTR SUN SENSOR TAN WIRE TOP OF ENGINE) TOTALLY INTEGRATED POWER MODULE (LEFT FRONT OF ENGINE COMPT) TRANSDUCER) VIO/LT BLU WIRE VIO/ORG WIRE WHT/GRY WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE WHT/ORG WIRE WHT/VIO WIRE

17 18 CAN B BUS(+) CAN B BUS(-) 33 42 28 27 APPS 1 RTN 36 37 6 25 SPEED CTRL BRAKE SW 4 5 1 21 CAN C BUS (+) CAN C BUS (-) 44 45 33 35 48 3 SPD SENS SIG SENS GND 6.7L 5.9L ACCEL ACCELERATOR PEDAL POSITION SENSOR (LEFT SIDE OF DASH) APPS 1 SIG APPS 1 RTN APPS 2 RTN APPS 2 SIG APPS 2 SIG APPS 2 RTN APPS 1 SIG BLK WIRE BLU WIRE BRN WIRE BRN/VIO WIRE BRN/WHT WIRE BRN/YEL WIRE CAN C BUS (+) CLUSTER COMPUTER DATA LINES SYSTEM DECEL DK BLU WIRE DK BLU/DK GRN WIRE DK GRN WIRE DK GRN/BRN WIRE DK GRN/ORG WIRE DK GRN/VIO WIRE DK GRN/WHT WIRE ENGINE CONTROL MODULE (LOWER LEFT FRONT OF ENGINE BLOCK) FUSE 28 GRN WIRE GRY WIRE HOT AT ALL TIMES HOT AT ALL TIMES TOTALLY INTEGRATED POWER MODULE (LEFT FRONT FENDER) FUSE 26 INPUT SPEED SENSOR (LEFT SIDE OF TRANSMISSION) LEFT SPEED CONTROL SWITCH OFF ORG/ WIRE OUTPUT SPEED SENSOR (5.9L) (BOTTOM OF TRANSMISSION) OUTPUT SPEED SENSOR (LEFT REAR OF TRANSMISSION) PNK EXTERIOR LIGHTS SYSTEM WIRE PNK WIRE REAR OF ENGINE COMPT) RED WIRE RESUME RIGHT SPEED CONTROL SWITCH SENS GND SENS GND S/C SW RTN S/C SW 1 SIG S/C SW 2 SIG 33 40 56 46 56 SENS SIG STEERING CONTROL MODULE (ON STEERING COLUMN) STOP LAMP SWITCH (ON BRAKE PEDAL SUPPORT) TAN WIRE TRANSMISSION CONTROL MODULE VIO WIRE VIO/BRN WIRE VIO/ORG WIRE VIO/YEL WIRE WHT WIRE WHT/BRN WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE WHT/ORG WIRE YEL WIRE YEL/DK BLU WIRE

6 10 (5.9L) (6.7L) A/T AAT RETURN AUXILIARY BATTERY B(+) BATTERY BLK WIRE BLK/GRY WIRE BRN WIRE CAN B BUS (+) CHARGING CIRCUIT CLUTCH INTERLOCK SWITCH (LEFT SIDE OF DASH) COMPUTER DATA LINES SYSTEM DK BLU WIRE ELECTRONICS ENGINE CONTROL MODULE (LOWER LEFT FRONT OF ENGINE BLOCK) EXCEPT RAM 3500 (CAB CHASSIS) FUSE 10 FUSE 11 FUSE 22 FUSED FUSED B (+) GRY WIRE GRY/RED WIRE HOLD-IN HOOD AJAR SWITCH HOOD AJAR SWITCH SENSE HOT AT ALL TIMES IGN SW GND B(+) OUT (START) IGN SW SENSE IGNITION SWITCH LEFT FRONT FENDER) LT BLU WIRE M/T ORG/ WIRE PULL- IN RAM 3500 (CAB CHASSIS) RED WIRE SENSE SNS STARTER STARTER MTR CTRL OUTPUT TAN WIRE TOTALLY INTEGRATED POWER MODULE TRANSMISSION RANGE SENSOR (LEFT SIDE OF TRANSMISSION) TRANSMISSION SOLENOID/TRS ASSEMBLY (RFE) (LEFT SIDE OF TRANSMISSION) TRS VIO WIRE VIO/BRN WIRE VIO/LT BLU WIRE VIO/TAN WIRE WHT WIRE WHT/ORG WIRE WIRELESS CONTROL MODULE YEL WIRE

1 2 3 4 5 6 DSL HIGH SIDE DRVR RTN ENG CTRL COM SNSR RTN RAD FAN MTR SPD SIG 1 2 3 4 AUTO HEADLAMPS SIG SUN SENSOR SIG 1 SUN SENSOR SIG 2 SENSOR GROUND 1 4 3 IGN RUN CTRL OUT IR SENSOR RETURN IR SENSOR SIGNAL 30 53 17 52 ENG CTRL COM SNSR RTN ENG CTRL COM SNSR RTN 4 RAD FAN MTR SPD SIG 4 2 3 1 BLWR MTR HI DRV FT BLW FD BLWR CTRL GND 70 16 33 6 IGN ULK/RUN/STRT A/C CLUTCH A/C CLUTCH COIL A/C COMPRESSOR, CLUTCH (LEFT SIDE OF ENGINE) A/C HEATER CONTROL A/C PRESS SIG A/C PRESS SNSE RTN A/C PRESS SNSE RTN A/C PRESS SNSR FD A/C PRESS SIG 1 2 3 A/C PRESS SNSR FD A/C PRESSURE TRANSDUCER B(+) BLK WIRE BLK/LT BLU WIRE BLK/LT GRN WIRE BLK/TAN WIRE BLOWER MODULE BLOWER MOTOR (RIGHT SIDE OF DASH) BLW MTR SPLY BRN WIRE BRN/LT BLU WIRE BRN/ORG WIRE BRN/PNK WIRE BRN/WHT WIRE BUS (-) CAN CAN IHS BUS (-) CAN IHS BUS (+) IOD FD FUSED IGN RUN CTRL OUT COIL COMPUTER DATA LINES SYSTEM CTRL OUT DK BLU WIRE DK BLU/DK GRN WIRE DK BLU/GRY WIRE DK BLU/LT BLU WIRE DK BLU/LT GRN WIRE DK BLU/ORG WIRE DK BLU/PNK WIRE DK BLU/RED WIRE DK BLU/TAN WIRE DK BLU/WHT WIRE DK BLU/YEL WIRE DK GRN WIRE DRIVER BLEND DOOR ACTUATOR (ON HVAC UNIT) ENGINE CONTROLS SYSTEM ENGINE COOLANT TEMPERATURE SENSOR EVAP SIG EVAP SNSE RTN EVAPORATOR TEMPERATURE SENSOR (CENTER OF DASH) FAN RADIATOR HIGH RELAY FAN RADIATOR LOW RELAY FUSE HALLEFCT ELECN ENG SPD OUT HALLEFCT ELECN ENG SPD OUT ENG CTRL COM SNSR RTN 2 COOL TEMP SNSR SIG 65 20 40 HOT AT ALL TIMES HOT AT ALL TIMES FUSE HOT W/ RUN RELAY ENERGIZED INFRARED SENSOR LT BLU WIRE LT BLU/BRN WIRE LT BLU/ORG WIRE LT BLU/RED WIRE LT GRN WIRE MODE DOOR ACTUATOR 1 (ON HVAC UNIT) MODE DOOR ACTUATOR 2 (ON HVAC UNIT) NAVIGATION SYSTEM ORG/ WIRE PASSENGER BLEND DOOR ACTUATOR (ON HVAC UNIT) PNK/WHT WIRE PNK/YEL WIRE POWERTRAIN CONTROL MODULE RAD FAN RAD FAN LOW SPD SIG RADIATOR FAN RADIATOR FAN DRIVE RECIRCULATION DOOR ACTUATOR RED/WHT WIRE RUN/START SIG HI SPD SUN SENSOR TAN WIRE TOTALLY INTEGRATED POWER MODULE (LEFT FRONT OF ENGINE COMPT) CIRCUIT BOARD VIO/LT BLU WIRE VIO/ORG WIRE WHT/DK BLU WIRE WHT/GRY WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE WHT/ORG WIRE WHT/VIO WIRE

BLK WIRE BRN WIRE DK GRN WIRE DRIVER FRONT VERTICAL SEAT ADJUSTER MOTOR (UNDER DRIVER SEAT) DRIVER HORIZONTAL SEAT ADJUSTER MOTOR DRIVER REAR VERTICAL SEAT ADJUSTER MOTOR (UNDER DRIVER SEAT) DRIVER SEAT SWITCH F DN F UP FUSE 27 GRN WIRE HOT AT ALL TIMES LT BLU WIRE LT LT NCA WIRE ORG/ WIRE ORG/RED WIRE R DN R UP RWD TAN WIRE TOTALLY INTEGRATED POWER MODULE (LEFT FRONT FENDER) WHT WIRE YEL WIRE

BLK WIRE DK GRN WIRE DRIVER FRONT VERTICAL SEAT ADJUSTER MOTOR (UNDER DRIVER SEAT) DRIVER HORIZONTAL SEAT ADJUSTER MOTOR DRIVER REAR VERTICAL SEAT ADJUSTER MOTOR (UNDER DRIVER SEAT) DRIVER SEAT SWITCH F DN F UP FUSE 27 GRN WIRE HOT AT ALL TIMES LT BLU WIRE LT LT NCA WIRE ORG/ WIRE ORG/RED WIRE R DN R UP RWD TAN WIRE TOTALLY INTEGRATED POWER MODULE (LEFT FRONT FENDER) WHT WIRE YEL WIRE

BLK WIRE BLK/WHT WIRE CLUSTER COMPUTER DATA LINES SYSTEM CTRL OUTPUT DK GRN/ WHT WIRE DRIVER'S SEAT CUSHION HEATER EXCEPT REAR HEATED SEATS GROUND HIGH IND DRV IGN (RUN) LEFT REAR HEATED SEAT SWITCH LEFT SEAT BACK HEATER LIN BUS LOW IND DRV LR HEATED SEAT LR HEATED SEAT HI IND LR HEATED SEAT LO IND LT GRN WIRE LT GRN/BRN WIRE LT GRN/DK BLU WIRE LT GRN/GRY WIRE LT GRN/LT BLU WIRE LT GRN/ORG WIRE LT GRN/VIO WIRE LT GRN/YEL WIRE ORG/ WIRE ORG/GRY WIRE PASSENGER'S SEAT CUSHION HEATER PNK/YEL WIRE REAR HEATED SEATS RIGHT REAR HEATED SEAT SWITCH RIGHT REAR SEAT CUSHION HEATER RIGHT SEAT BACK HEATER RR HEATED RR HEATED SEAT SEAT HI IND LR HEATED SEAT SW SENS LR HEATED SEAT SW SNS SW SENSE TAN WIRE TAN/DK BLU WIRE TAN/ORG WIRE TAN/WHT WIRE TAN/YEL WIRE WHT WIRE

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 AUDIO RTN 3 1 2 ANTENNA SIG ANTENNA SHLD 8 9 10 RIGHT AUDIO OUT LEFT AUDIO OUT COM AUDIO OUT BLK WIRE BLK/ORG WIRE BRN WIRE BRN/ORG DK BLU WIRE BRN/ORG WIRE COM AUDIO OUT MICRO IN (-) SENS GND DATA+ COMPUTER DATA LINES SYSTEM DATA DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE DK GRN/BLK WIRE DK GRN/BRN WIRE DK GRN/DK BLU WIRE DK GRN/LT BLU WIRE DK GRN/ORG WIRE DK GRN/TAN WIRE DK GRN/VIO WIRE DK GRN/WHT WIRE DK GRN/YEL WIRE FUSE FUSE MODULE (LEFT FRONT OF ENGINE CMOPT) GND UCI AUDIO REF UCI AUDIO LH IN UCI AUDIO RH IN GRY WIRE GRY/BRN WIRE GRY/DK BLU WIRE GRY/LT BLU WIRE GRY/ORG WIRE GRY/PNK WIRE GRY/VIO WIRE GRY/YEL WIRE HANDSFREE MODULE (EXCEPT 5.7L CREW CAB) (RIGHT SIDE OF DASH) HOT AT ALL TIMES INSIDE REARVIEW MIRROR LEFT AUDIO 1 AUDIO RTN 1 RIGHT AUDIO 1 LEFT AUDIO 2 RIGHT AUDIO 2 LR SPKR (+) LR SPKR (-) RR SPKR (+) RR SPKR (-) GROUND CAN IHS BUS (+) LT BLU/DK GRN WIRE MEDIA SHIELD 2 MICRO 2 IN (+) MICRO IN (+) MICRO FEED MICRO IN (-) SENS GND NAVIGATION SYSTEM NCA WIRE ORG/GRY WIRE PWR FD 2 PASSTH PWR FD 2 PASSTH UCI EXT RX FROM UCI UCI EXT TX TO UCI UCI DEVICE DETECT PWR FEED PASSTH RADIO RADIO ANTENNA RED WIRE RED/LT BLU WIRE SHIELD SHLD SIG TAN WIRE TOTALLY INTEGRATED POWER UCI AUDIO LH IN UCI AUDIO REF UCI AUDIO RH IN UCI DEVICE DETECT UCI EXT RX FROM USI UCI EXT TX TO USI UCI ID W/ HANDS FREE W/O HANDS FREE WHT WIRE WHT/GRY WIRE WHT/ORG WIRE WHT/YEL WIRE YEL WIRE YEL/RED WIRE

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 AUDIO RTN 3 1 2 ANTENNA SIG ANTENNA SHLD 8 9 10 RIGHT AUDIO OUT LEFT AUDIO OUT COM AUDIO OUT BLK WIRE BLK/ORG WIRE BRN WIRE BRN/ORG DK BLU WIRE BRN/ORG WIRE COM AUDIO OUT MICRO IN (-) SENS GND DATA+ COMPUTER DATA LINES SYSTEM DATA DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE DK GRN/BLK WIRE DK GRN/BRN WIRE DK GRN/DK BLU WIRE DK GRN/LT BLU WIRE DK GRN/ORG WIRE DK GRN/TAN WIRE DK GRN/VIO WIRE DK GRN/WHT WIRE DK GRN/YEL WIRE FUSE FUSE MODULE (LEFT FRONT OF ENGINE CMOPT) GND UCI AUDIO REF UCI AUDIO LH IN UCI AUDIO RH IN GRY WIRE GRY/BRN WIRE GRY/DK BLU WIRE GRY/LT BLU WIRE GRY/ORG WIRE GRY/PNK WIRE GRY/VIO WIRE GRY/YEL WIRE HANDSFREE MODULE (EXCEPT 5.7L CREW CAB) (RIGHT SIDE OF DASH) HOT AT ALL TIMES INSIDE REARVIEW MIRROR LEFT AUDIO 1 AUDIO RTN 1 RIGHT AUDIO 1 LEFT AUDIO 2 RIGHT AUDIO 2 LR SPKR (+) LR SPKR (-) RR SPKR (+) RR SPKR (-) GROUND CAN IHS BUS (+) LT BLU/DK GRN WIRE MEDIA SHIELD 2 MICRO 2 IN (+) MICRO IN (+) MICRO FEED MICRO IN (-) SENS GND NAVIGATION SYSTEM NCA WIRE ORG/GRY WIRE PWR FD 2 PASSTH PWR FD 2 PASSTH UCI EXT RX FROM UCI UCI EXT TX TO UCI UCI DEVICE DETECT PWR FEED PASSTH RADIO RADIO ANTENNA RED WIRE RED/LT BLU WIRE SHIELD SHLD SIG TAN WIRE TOTALLY INTEGRATED POWER UCI AUDIO LH IN UCI AUDIO REF UCI AUDIO RH IN UCI DEVICE DETECT UCI EXT RX FROM USI UCI EXT TX TO USI UCI ID W/ HANDS FREE W/O HANDS FREE WHT WIRE WHT/GRY WIRE WHT/ORG WIRE WHT/YEL WIRE YEL WIRE YEL/RED WIRE