Dodge Pickup R2500 (1996-2010) rad fan Wiring diagrams

1 2 3 4 AUTO HEADLAMPS SIG SUN SENSOR SIG 1 SUN SENSOR SIG 2 SENSOR GROUND 1 4 3 IGN RUN CTRL OUT IR SENSOR RETURN IR SENSOR SIGNAL 10 9 34 35 FUSED B(+) GND CAN BUS (+) CAN BUS (-) 27 20 SENS GND ECT SIG 4 2 3 1 BLWR MTR HI DRV FT BLW FD BLWR CTRL GND A/C CLUTCH COIL A/C CLUTCH CTRL OUT A/C COMPRESSOR CLUTCH (3.7L, 4.7L: FRONT OF ENGINE) A/C HEATER CONTROL A/C PRESS A/C PRESS SNSE RTN A/C PRESS SNSR FD A/C PRESS SIG A/C PRESS SNSR FD B(+) BLK WIRE BLK/LT BLU WIRE BLK/LT GRN WIRE BLK/TAN WIRE BLOWER MODULE BLOWER MOTOR (RIGHT SIDE BRN WIRE CAN 2 BUS (-) CAN IHS BUS (-) CAN IHS BUS (+) IOD FD FUSED IGN RUN CTRL OUT CIRCUIT BOARD CLUTCH A/C COIL COMPUTER DATA LINES SYSTEM DK BLU WIRE DK BLU/DK GRN WIRE DK BLU/GRY WIRE DK BLU/LT BLU WIRE DK BLU/LT GRN WIRE DK BLU/ORG WIRE DK BLU/PNK WIRE DK BLU/RED WIRE DK BLU/TAN WIRE DK BLU/WHT WIRE DK BLU/YEL WIRE DK GRN/DK BLU WIRE DRIVER BLEND MODE DOOR DOOR ACTUATOR ACTUATOR 1 (ON HVAC UNIT) (ON HVAC UNIT) ENGINE CONTROLS SYSTEM EVAP SIG EVAP SNSE RTN EVAPORATOR TEMPERATURE SENSOR (CENTER OF DASH) FAN RADIATOR HIGH RELAY FAN RADIATOR LOW RELAY FUSE FUSE FUSE HI SPD RAD FAN HOT AT ALL TIMES HOT W/ RUN RELAY ENERGIZED INFRARED SENSOR LOW SPD SIG LT BLU WIRE LT BLU/BRN WIRE LT BLU/ORG WIRE LT BLU/RED WIRE LT GRN WIRE MODE DOOR ACTUATOR 2 (ON HVAC UNIT) NAVIGATION SYSTEM OF DASH) ORG/ WIRE PASSENGER BLEND DOOR ACTUATOR (ON HVAC UNIT) PNK/YEL WIRE POWERTRAIN CONTROL MODULE (3.7L, 4.7L: REAR OF ENGINE) RAD FAN RADIATOR FAN RECIRCULATION DOOR ACTUATOR RED WIRE RED/WHT WIRE SIG SNSE RTN A/C PRESS SPLY BLW MTR SUN SENSOR TAN WIRE TOP OF ENGINE) TOTALLY INTEGRATED POWER MODULE (LEFT FRONT OF ENGINE COMPT) TRANSDUCER) VIO/LT BLU WIRE VIO/ORG WIRE WHT/GRY WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE WHT/ORG WIRE WHT/VIO WIRE

10 9 34 35 BATT FD GND CAN 2 BUS (+) CAN 2 BUS (-) 27 20 SENS GND ECT SIGNAL 5 V SPLY A/C PRESS A/C PRESS GND A/C PRESS SIG A/C PRESS SNSR FD A/C PRESS SNSR RTN A/C PRESSURE TRANSDUCER (3.7L, 4.7L: TOP FRONT OF ENGINE) B(+) BLK WIRE BLK/LT BLU WIRE CAN 2 BUS (-) COMPUTER DATA LINES SYSTEM DK BLU WIRE DK BLU/DK GRN WIRE DK GRN DK BLU/ WIRE DK GRN WIRE DK GRN/DK BLU WIRE ENGINE CONTROLS SYSTEM FAN HIGH RADI- ATOR RELAY FUSE FAN LOW RADI- ATOR RELAY FAN RADIATOR HOT AT ALL TIMES HOT AT ALL TIMES FUSE LOW SPD LT BLU/BRN WIRE LT BLU/ORG WIRE POWERTRAIN CONTROL MODULE (3.7L, 4.7L: REAR OF ENGINE) RAD FAN RED WIRE SIG SIG HI SPD RAD FAN TOP OF ENGINE) TOTALLY INTEGRATED CIRCUIT BOARD POWER MODULE (LEFT FRONT OF ENGINE COMPT) VIO/ORG WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE

1 2 3 4 5 6 DSL HIGH SIDE DRVR RTN ENG CTRL COM SNSR RTN RAD FAN MTR SPD SIG 1 2 3 4 AUTO HEADLAMPS SIG SUN SENSOR SIG 1 SUN SENSOR SIG 2 SENSOR GROUND 1 4 3 IGN RUN CTRL OUT IR SENSOR RETURN IR SENSOR SIGNAL 30 53 17 52 ENG CTRL COM SNSR RTN ENG CTRL COM SNSR RTN 4 RAD FAN MTR SPD SIG 4 2 3 1 BLWR MTR HI DRV FT BLW FD BLWR CTRL GND 70 16 33 6 IGN ULK/RUN/STRT A/C CLUTCH A/C CLUTCH COIL A/C COMPRESSOR, CLUTCH (LEFT SIDE OF ENGINE) A/C HEATER CONTROL A/C PRESS SIG A/C PRESS SNSE RTN A/C PRESS SNSE RTN A/C PRESS SNSR FD A/C PRESS SIG 1 2 3 A/C PRESS SNSR FD A/C PRESSURE TRANSDUCER B(+) BLK WIRE BLK/LT BLU WIRE BLK/LT GRN WIRE BLK/TAN WIRE BLOWER MODULE BLOWER MOTOR (RIGHT SIDE OF DASH) BLW MTR SPLY BRN WIRE BRN/LT BLU WIRE BRN/ORG WIRE BRN/PNK WIRE BRN/WHT WIRE BUS (-) CAN CAN IHS BUS (-) CAN IHS BUS (+) IOD FD FUSED IGN RUN CTRL OUT COIL COMPUTER DATA LINES SYSTEM CTRL OUT DK BLU WIRE DK BLU/DK GRN WIRE DK BLU/GRY WIRE DK BLU/LT BLU WIRE DK BLU/LT GRN WIRE DK BLU/ORG WIRE DK BLU/PNK WIRE DK BLU/RED WIRE DK BLU/TAN WIRE DK BLU/WHT WIRE DK BLU/YEL WIRE DK GRN WIRE DRIVER BLEND DOOR ACTUATOR (ON HVAC UNIT) ENGINE CONTROLS SYSTEM ENGINE COOLANT TEMPERATURE SENSOR EVAP SIG EVAP SNSE RTN EVAPORATOR TEMPERATURE SENSOR (CENTER OF DASH) FAN RADIATOR HIGH RELAY FAN RADIATOR LOW RELAY FUSE HALLEFCT ELECN ENG SPD OUT HALLEFCT ELECN ENG SPD OUT ENG CTRL COM SNSR RTN 2 COOL TEMP SNSR SIG 65 20 40 HOT AT ALL TIMES HOT AT ALL TIMES FUSE HOT W/ RUN RELAY ENERGIZED INFRARED SENSOR LT BLU WIRE LT BLU/BRN WIRE LT BLU/ORG WIRE LT BLU/RED WIRE LT GRN WIRE MODE DOOR ACTUATOR 1 (ON HVAC UNIT) MODE DOOR ACTUATOR 2 (ON HVAC UNIT) NAVIGATION SYSTEM ORG/ WIRE PASSENGER BLEND DOOR ACTUATOR (ON HVAC UNIT) PNK/WHT WIRE PNK/YEL WIRE POWERTRAIN CONTROL MODULE RAD FAN RAD FAN LOW SPD SIG RADIATOR FAN RADIATOR FAN DRIVE RECIRCULATION DOOR ACTUATOR RED/WHT WIRE RUN/START SIG HI SPD SUN SENSOR TAN WIRE TOTALLY INTEGRATED POWER MODULE (LEFT FRONT OF ENGINE COMPT) CIRCUIT BOARD VIO/LT BLU WIRE VIO/ORG WIRE WHT/DK BLU WIRE WHT/GRY WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE WHT/ORG WIRE WHT/VIO WIRE