Dodge Pickup R2500 (1996-2010) powertrain control module Wiring diagrams

B(+) BLK WIRE BRN/YEL WIRE BUS (-) CAN CAN-BUS CIRCUIT BOARD CLUTCH INTERLOCK SWITCH (LEFT SIDE OF DASH) COMPUTER DATA LINES SYSTEM DK BLU/DK GRN WIRE DK GRN WIRE DK GRN/BRN WIRE DK GRN/DK BLU WIRE DK GRN/LT BLU WIRE DK GRN/LT GRN WIRE DK GRN/ORG WIRE DK GRN/PNK WIRE DK GRN/RED WIRE DK GRN/TAN WIRE DK GRN/VIO WIRE DK GRN/WHT WIRE FS- FUSE FUSED B (+) FUSED B (+) CAN BUS (+) CAN BUS (-) GAS HOT AT ALL TIMES INPUT SPEED SENSOR (LEFT SIDE OF TRANSMISSION) L/R PRESS LINE PRESSURE SENSOR LINE PRS SENS OUTPT SPD SENS INPT SPD SENS SPD SENS GND TRNS TMP SNS MS SOL CTRL OD SOL CTRL ODC SOL UD LR SOL SOL UD PRESS OD PRESS OUTPUT SPEED SENSOR (LEFT REAR OF TRANSMISSION) POWERTRAIN CONTROL MODULE PRESS PRESS PRESS. RED WIRE SNSR GND SOL + TEMPERATURE SENSOR TOP OF ENGINE) TOTALLY INTEGRATED POWER MODULE (LEFT FRONT FENDER) TRANSMISSION CONTROL RELAY TRANSMISSION SOLENOID/TRS ASSEMBLY (LEFT SIDE OF TRANSMISSION) TRNS CTRL OUT TRNS CTRL OUT L/R PRESS SW TRNS CTRL TRNS CTRL OUT TRS TRS TRS UD PRESS SW OD PRESS SW UD SOL CTRL L/R SOL CTRL PRESS CTRL SOL UDC LR/LU LP SOL VFS SOL VOLT SIG GND WHT/LT BLU WIRE WHT/LT GRN WIRE YEL/BLK WIRE YEL/BRN WIRE YEL/DK BLU WIRE YEL/DK GRN WIRE YEL/GRY WIRE YEL/LT BLU WIRE YEL/LT GRN WIRE YEL/ORG WIRE YEL/PNK WIRE YEL/TAN WIRE YEL/WHT WIRE

2 1 11 CAN IHS BUS(-) CAN IHS BUS(+) LIN BUS COMPUTER DATA LINES SYSTEM 29 9 10 9 14 23 65 66 BRK SIG 2 BRK SIG 1 35 34 18 35 COMPUTER DATA LINES SYSTEM CAN BUS (-) CAN BUS (+) 5.7L 5.7L 6.7L ANTI-LOCK BRAKES MODULE (LEFT REAR OF ENGINE COMPT) B (+) CAN BUS (-) BUS (+) BATT FD BLK WIRE BLK/DK GRN WIRE BLK/TAN WIRE BRAKE FLUID LEVEL SENSOR (LEFT REAR OF ENGINE COMPT) BRK FLUID LEVEL SW SENSE CAN BUS (+) 2 CLUSTER COMPUTER DATA LINES SYSTEM DK DK DK GRN WIRE DK GRN/LT GRN WIRE DK GRN/ORG WIRE DK GRN/RED WIRE DK GRN/TAN WIRE DK GRN/VIO WIRE DK GRN/WHT WIRE DK GRN/YEL WIRE FUSE FUSED B (+) IGN RS PNK WIRE FUSED B(+) CAN BUS 2 (+) GND (LEFT SIDE OF DASH) GRN WIRE GROUND HOT AT ALL TIMES IGN RS LEFT FRONT ABS WHEEL SPEED SENSOR (LEFT FRONT WHEEL HUB ASSEMBLY) LF WHEEL SPD SENSOR (+) LF WHEEL SPD SENSOR (-) LT BLU WIRE LT BLU/DK GRN WIRE LT GRN WIRE LT GRN/RED WIRE ORG/ WIRE PARKING BRAKE SWITCH (TOP OF PARKING BRAKE PEDAL) PNK PNK IGN RUN/START BRK SIG 1 BRK SIG 2 11 12 WIRE PNK WIRE POWERTRAIN CONTROL MODULE PRK BRK SW SIG REAR ABS WHEEL SPEED SENSOR REAR WHEEL SPD SENS (-) REAR WHEEL SPD SENS (+) RED WIRE RF WHEEL SPD SENSOR (+) RF WHEEL SPD SENSOR (-) RIGHT FRONT ABS WHEEL SPEED SENSOR (RIGHT FRONT WHEEL HUB ASSEMBLY) STOP LAMP SWITCH (ON BRAKE PEDAL SUPPORT) STP LMP SIG TAN WIRE TAN/RED WIRE TOTALLY INTEGRATED POWER MODULE (LEFT FRONT OF ENGINE COMPT) CIRCUIT BOARD VIO WIRE WHT WIRE WHT/DK GRN WIRE WHT/GRY WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE WHT/ORG WIRE WIRELESS IGNITION NODE YEL WIRE

A/C COM- PRESSOR CLUTCH A/C FUEL COM- SHUT PRESSOR DOWN FUEL CLUTCH SOLENOID HEATER AIRBAG CONTROL MODULE RADIO BLK WIRE BLK/DK BLU WIRE BLK/LT GRN WIRE BLK/PNK WIRE BLK/TAN WIRE BLK/VIO WIRE BLK/WHT WIRE BLOWER MOTOR RELAY BRAKE UNDER- HOOD WIPER PRESSURE LAMP MOTOR SWITCH CONTROLLER GENERATOR ANTI-LOCK BRAKE DATA LINK CONNECTOR DAYTIME RUNNING LAMP MODULE DIESEL DIESEL ONLY ENGINE STARTER MOTOR RELAY FOG LAMP RELAY FUEL HEATER RELAY FUEL PUMP MODULE FUEL PUMP RELAY FUEL SHUT DOWN RELAY GAS HIGH NOTE HORN J/C 1 (IN PDC) J/C 3 J/C 4 LEFT BACK-UP LAMP LEFT FOG LAMP LEFT HEADLAMP LEFT PARK/TURN SIGNAL LAMP LEFT RIGHT FRONT FRONT DOOR DOOR SPEAKER SPEAKER LEFT UPSTREAM HEATED OXYGEN POWERTRAIN SENSOR CONTROL MODULE LOW NOTE HORN LOW WASHER FLUID SWITCH POWER DISTRIBUTION CENTER POWERTRAIN CONTROL MODULE PREMIUM RADIO CHOKE RELAY RIGHT HEADLAMP RIGHT PARK/TURN SIGNAL LAMP RIGHT RIGHT BACK-UP LICENSE TRAILER LAMP LAMP TOW CON- NECTOR RIGHT TAIL/ STOP/TURN SIGNAL LAMP SWITCH TOP OF TRANSMISSION) TRAILER TOW RELAY VEHICLE SPEED CONTROL SERVO RIGHT FOG LAMP WINDSHIELD WASHER PUMP MOTOR

ANTI-LOCK BRAKES MODULE AUXILIARY BATTERY (6.7L) BATTERY BLK WIRE BLK/DK GRN WIRE BLK/TAN WIRE BRAKE PROVISION MODULE CENTER HIGH MOUNTED STOP/CARGO LAMP CENTER RIGHT CLEARANCE CLEARANCE LAMP LAMP 1 CUP HOLDER LAMP DATA LINK CONNECTOR DK GRN WIRE DRIVER DOOR LATCH EGR BYPASS COOLING ACTUATOR EXCEPT REGULAR CAB REGULAR CAB FRONT WIPER MOTOR HEADLAMP SWITCH LEFT LEFT CLEARANCE CLEARANCE LAMP 2 LAMP 1 MASS AIR FLOW SENSOR MODULE ORG/ WIRE POWERTRAIN CONTROL MODULE RADIO RIGHT CLEARANCE LAMP 2 RIGHT FRONT OCCUPANT PARK/TURN RESTRAINT LAMP HORN 1 CONTROLLER MODULE TAN WIRE

A/C COMPRESSOR CLUTCH A/C HEATER CONTROL ASH RECEIVER LAMP BLK ORG/ WIRE BLK TAN/ WIRE BLK WIRE BLK/LT GRN WIRE BLK/ORG WIRE BLK/PNK WIRE BLK/TAN WIRE BLK/WHT WIRE CENTER HIGH CENTER HIGH MOUNTED MOUNTED STOP LAMP STOP LAMP CENTRAL TIMER MODULE CLUB CAB ONLY COMBINATION FLASHER CUMMINS BUS POWER DATA LINK CONNECTOR DAY/ OVER- NIGHT HEAD MIRROR CONSOLE DRIVER PASSENGER SEAT SEAT SOLENOID SOLENOID ELECTRIC BRAKE CUP HOLDER LAMP ENGINE CONTROL MODULE ENGINE STARTER MOTOR RELAY EXCEPT CLUB CAB FOG LAMP SWITCH FROM FUEL HEATER FUEL INJECTOR PUMP FUEL TRANSFER PUMP GLOVE BOX LAMP) HEATED MIRROR SWITCH INSTRU- CIGAR MENT LIGHTER CLUSTER INSTRU- MENT CLUSTER INTAKE AIR HEATER RELAY 1 INTAKE AIR HEATER RELAY 2 INTEGRATED ELECTRONIC MODULE J/C 5 (BEHIND LEFT SIDE OF DASH) JUNCTION BLOCK LEFT CENTER OUTBOARD IDENTI- IDENTIFICATION FICATION LAMP LAMP LEFT DOOR DISARM SWITCH LEFT DOOR LEFT WINDOW/ POWER LOCK MIRROR SWITCH MOTORS LEFT DOOR WINDOW/ LOCK SWITCH LEFT OUTBOARD CLEARANCE LAMP LEFT RIGHT VISOR/ VISOR/ VANITY VANITY LAMP LAMP LEFT SEAT DOOR BELT JAMB CONTROL SWITCH MODULE ORG BLK WIRE OVER DRIVE SWITCH OVER- HEAD CONSOLE OVERHEAD MAP/ COURTESY LAMPS POWER DISTRIBUTION CENTER POWER MIRROR SWITCH POWER OUTLET POWER SEAT SWITCH POWERTRAIN CONTROL MODULE RIGHT DOOR JAMB SWITCH RIGHT OUTBOARD CLEARANCE LAMP RIGHT OUTBOARD IDENTIFICATION LAMP STOP LAMP SWITCH

5.7L POWER WAGON 6.7L DIESEL 6.7L DIESEL 5.7L GAS A/C PNK/ HEATER CONTROL WIRE A/T ANTI-LOCK BRAKES MODULE AUXILIARY BATTERY (DIESEL) AUXILIARY PDC BOX (LEFT REAR OF ENGINE COMPT) BASE BATTERY BENCH BLK WIRE BRN WIRE CIGAR LIGHTER CLUSTER CLUTCH INTERLOCK/ UPSTOP SWITCH CONSOLE CONSOLE POWER POWER OUTLET OUTLET (UPPER CONSOLE) DIESEL DK BLU WIRE DK GRN WIRE DK GRN/ORG WIRE DRIVER SEAT BELT TENSION REDUCER (STANDARD CAB) ENGINE COMPARTMENT UPFITTER ACCESSORIES EXCEPT 5.7L POWER WAGON EXCEPT BASE EXCEPT BASE TO SPLICE PNK/ (DIAGRAM 2 OF 3) WIRE EXCEPT BENCH EXCEPT RAM 2500 FINAL DRIVE CONTROL MODULE FINAL DRIVE CONTROL MODULE (5.7L OFF ROAD) FROM FUSE 4 (DIAGRAM 1 OF 3) B(+) FUSE FUSE 1 FUSE 2 FUSE 30 FUSE 33 FUSE 39 FUSE 4 (RAM 3500 (CAB CHASSIS)) FUSE 40 FUSE 9 (POWER WAGON) FUSED B (+) FUSED IGNITION SWITCH OUTPUT (RUN) FUSED IGNITION SWITCH OUTPUT (RUN-ACC) FUSED IGNITION SWITCH OUTPUT (RUN-START) FUSIBLE LINK (10 GA- FUSIBLE LINK (16 GA- FUSIBLE LINK (8 GA- GAS GENERATOR GROUND GRY/PNK WIRE IGN SW RUN INSTRUMENT PANEL POWER OUTLET INTAKE AIR HEATER MODULE RELAY (6.7L DIESEL, (DIESEL) EXCEPT SHIFT ON THE FLY) JUMPER KIT UPFITTER ACCESSORIES LEFT CHASSIS LT BLU WIRE LT GRN WIRE M/T (LEFT REAR OF ENGINE 6.7L COMPT) (6.7L DIESEL) DIESEL ORG/ WIRE ORG/LT GRN WIRE PNK PNK WIRE PNK UPFITTER ACCESSORIES WIRE PNK WIRE PNK/RED WIRE PNK/YEL WIRE POWER MODULE (LEFT FRONT FENDER) POWER MODULE (LEFT FRONT FENDER) ELECTRONICS POWERTRAIN CONTROL MODULE RADIATOR FAN DRIVE (5.9L) RAM 2500 REAR OF ENGINE COMPT) RED WIRE RED/YEL WIRE STANDARD QUAD CAB CAB STARTER SUNROOF MOTOR/ MODULE TO ELECTRONICS (DIAGRAM 1 OF 3) TO FUSE 11 (DIAGRAM 2 OF 3) TO FUSE 32 (DIAGRAM 3 OF 3) TOTALLY INTEGRATED TRANSMISSION CONTROL MODULE TRANSMISSION CONTROL MODULE (RC) VIO WIRE VIO/BRN WIRE VIO/YEL WIRE W/ HEATED SEATS WASTEGATE SOLENOID (5.9L) WINCH ASSEMBLY (POWER WAGON) YEL WIRE

A/C OCCUPANT HEATER RESTRAINT CONTROL CONTROLLER MODULE ADJUSTABLE DRIVER PEDALS HEATED SWITCH SEAT SWITCH AWAL BACKUP LAMP SWITCH (M/T) BASE BLK/YEL WIRE BLOWER MOTOR CLUSTER POWERTRAIN CONTROL MODULE DIESEL DIESEL/ SRT-10 DK GRN WIRE ELECTRONICS ENGINE CONTROL MODULE ENGINE OIL DRIVER TEMPERATURE WINDOW/ GAUGE DOOR LOCK SWITCH (SRT-10) EVAP/ ANTI-LOCK PURGE BRAKES SOLENOID MODULE EXCEPT BASE EXCEPT BASE BASE EXCEPT SRT-10 EXCEPT SRT-10 SRT-10 FROM FUSE 22 (DIAGRAM 1 OF 2) FROM IGNITION SWITCH (DIAGRAM 1 OF 2) FUSE FUSE 29 FUSE 40 FUSE FUSE FUSED IGNITION SWITCH OUTPUT (OFF-RUN-START) FUSED IGNITION SWITCH OUTPUT (RUN) FUSED IGNITION SWITCH OUTPUT (RUN-ACC) FUSED IGNITION SWITCH OUTPUT (RUN-START) GATEWAY FINAL DRIVE MODULE CONTROL MODULE GRY WIRE GRY/PNK WIRE IGNITION SWITCH OUTPUT (RUN-START) IGNITION SWITCH OUTPUT (START) INSIDE REARVIEW MIRROR INSTRUMENT PANEL POWER OUTLET LT GRN WIRE M/T NGC PASSENGER HEATED SEAT SWITCH PASSENGER OCCUPANT AIR BAG RESTRAINT CONTROLLER ON/OFF MODULE SWITCH PASSENGER TRANSFER DOOR LOCK CASE SWITCH SELECTOR SWITCH (A/T) PNK WIRE PNK/DK GRN WIRE PNK/GRY WIRE PNK/LT GRN WIRE PNK/ORG WIRE PNK/RED WIRE PNK/VIO WIRE PNK/WHT WIRE PNK/YEL WIRE POWER SLIDING BACKLITE SWITCH (QUAD CAB/ EXCEPT BASE) POWER WAGON POWERTRAIN CONTROL MODULE QUAD CAB QUAD STANDARD CAB CAB RWAL SENTRY KEY STOP REMOTE LAMP SWITCH ENTRY MODULE SRT-10 SRT-10 EXCEPT STANDARD CAB SUBWOOFER DRIVER AMPLIFIER SEAT BELT TENSION (SRT-10) REDUCER (STANDARD CAB) TOTALLY INTEGRATED POWER MODULE (AT LEFT FRONT FENDER) VIO/WHT WIRE WHT/GRY WIRE YEL WIRE

6.7L A/T 6.7L DIESEL 6.7L MANUAL TRANSFER CASE ADJUSTABLE PEDALS SWITCH BACKUP LAMP SWITCH (M/T) BASE BLK WIRE BLOWER MOTOR BRN WIRE CLUSTER DIESEL DK GRN WIRE ELECTRONICS EXCEPT 6.7L A/T EXCEPT BASE EXCEPT RAM 2500 EXCEPT SHIFT ON THE FLY FROM FUSE 22 (DIAGRAM (ON STEERING COLUMN) 2 OF 3) FROM PNK AUXILIARY PDC BOX (DIAGRAM 1 OF 3) WIRE FUSE 20 FUSE 21 FUSE 28 FUSE 37 FUSE 29 FUSE 32 FUSED B (+) GROUND FUSED IGNITION SWITCH OUTPUT (OFF-RUN-START) FUSED IGNITION SWITCH OUTPUT (RUN) FUSED IGNITION SWITCH OUTPUT (RUN-START) GAS GAS DIESEL GAS/6.7L ELECTRONIC TRANSFER CASE GRY WIRE IGNITION SWITCH IGNITION SWITCH OUTPUT (RUN-START) IGNITION SWITCH OUTPUT (RUN-START) IGNITION SWITCH SENSE IGNITION SWITCH OUTPUT (START) INSIDE REARVIEW MIRROR LEFT FRONT TIRE PRESSURE TRANSPONDER LT BLU WIRE LT GRN WIRE OCCUPANT RESTRAINT CONTROLLER MODULE RAM 2500 ORG/ WIRE PASSENGER DOOR LOCK SWITCH PNK 5.7L MTC/ 5.7L ETC 6.7L DIESEL WIRE PNK PNK PNK PNK WIRE PNK PNK PNK WIRE PNK PNK WIRE PNK WIRE POWERTRAIN CONTROL MODULE POWERTRAIN ENGINE CONTROL CONTROL MODULE MODULE RED WIRE RIGHT FRONT TIRE PRESSURE TRANSPONDER SHIFT ON THE FLY SMART POWER RELAY (6.7L) STOP TRANSFER LAMP CASE SWITCH SELECTOR SWITCH (W/ ETC) TRANSMISSION RANGE SENSOR VIO WIRE WHT WIRE WIRELESS CONTROL MODULE (WCM) YEL WIRE

5 VOLT SPLY ASCD CTRL ASD CTRL OUT AUTO SHUTDOWN RELAY B(+) BLK WIRE BRN WIRE BRN/BLK WIRE BRN/DK BLU WIRE BRN/DK GRN WIRE BRN/GRY WIRE BRN/LT BLU WIRE BRN/LT GRN WIRE BRN/ORG WIRE BRN/TAN WIRE BRN/VIO WIRE BRN/WHT WIRE BRN/YEL WIRE CAN-BUS CAN-BUS CIRCUIT BOARD CMP SIG CKP SIG KNOCK SENS 2 SIG KNOCK SENS 2 RETURN ETC MOTOR (-) COIL CTRL 7 INJECTOR CTRL 8 INJECTOR CTRL 7 COMPUTER DATA LINES SYSTEM DK BLU BRN/ WIRE DK BLU/DK GRN WIRE DK BLU/GRY WIRE DK BLU/LT BLU WIRE DK BLU/LT GRN WIRE DK BLU/ORG WIRE DK BLU/PNK WIRE DK BLU/RED WIRE DK BLU/TAN WIRE DK BLU/WHT WIRE DK BLU/YEL WIRE DK GRN BRN/ WIRE FUSE FUSED B (+) GEN FIELD CTRL ECT SIG TP 1 SIG GEN SNS GROUND FUSED B(+) IGN SW OUT (RUN-START) IGN SW OUT (OFF-RUN-START) GROUND GROUND OIL PRESSURE SIG SRV SEN OUT GRY WIRE HOT AT ALL TIMES KNOCK SENS 1 (-) KNOCK SENS 1 RETURN KNOCK SENS 2 (-) KNOCK SENS 2 RETURN LEFT KNOCK SENSOR 1 MAP SIG KNOCK SENS 1 RETURN KNOCK SENS 1 SIG PNK/GRY WIRE PNK/WHT WIRE PNK/YEL WIRE POWERTRAIN CONTROL MODULE RED WIRE RED/GRY WIRE RIGHT KNOCK SENSOR 2 RUN-START) IGN (OFF- SENS GROUND TP 2 SIG 5 VOLT SPLY IAT SIG SIG SRV ACTR CTRL SIG STARTING/ CHARGING SYSTEM TAN/ORG WIRE TAN/YEL WIRE TOTALLY INTEGRATED POWER MODULE (LEFT FRONT OF ENGINE COMPT) VIO/BRN WIRE VIO/GRY WIRE VIO/ORG WIRE WHT WIRE WHT/BRN WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE YEL/DK BLU WIRE YEL/PNK WIRE

A/C CLUTCH CTRL APP 1 SIG ASD CTRL ASD CTRL OUT EVAP PURGE SOL SIG BLK WIRE BRN WIRE BRN/BLK WIRE BRN/GRY WIRE BRN/LT GRN WIRE BRN/TAN WIRE BRN/VIO WIRE BRN/WHT WIRE BRN/YEL WIRE BUS - CAN-BUS CIRCUIT BOARD CLUTCH INTERLOCK SWITCH PARK/ (M/T) NEU (LEFT SIDE SIG GND OF DASH) COMPUTER DATA LINES SYSTEM CRUISE CONTROL SYSTEM DK BLU WIRE DK BLU/ YEL WIRE DK BLU/BRN WIRE DK BLU/WHT WIRE DK GRN WIRE DK GRN/BRN WIRE DK GRN/DK BLU WIRE DK GRN/LT BLU WIRE DK GRN/LT GRN WIRE DK GRN/ORG WIRE DK GRN/PNK WIRE DK GRN/RED WIRE DK GRN/TAN WIRE DK GRN/VIO WIRE DK GRN/WHT WIRE FUSE HOT AT ALL TIMES L/R CTRL PRESSURE CTRL SOLENOID GROUND GROUND GROUND LT BLU/DK GRN WIRE LT BLU/RED WIRE MS SOLENOID CTRL POWERTRAIN CONTROL MODULE STARTING/ CHARGING SYSTEM TOTALLY INTEGRATED POWER MODULE (LEFT FRONT OF ENGINE COMPT) TRANSMISSION CONTROL RELAY TRANSMISSION CTRL OUT TRANSMISSION CTRL OUT L/R PRESSURE SW SNS TRANSMISSION CTRL TRANSMISSION CTRL OUT UD PRESSURE SW SNS OD PRESSURE SW SNS UD SOLENOID CTRL VARIABLE CAMSHAFT TIMING SOLENOID VCT CTRL VIO WIRE VIO/BLK WIRE VIO/BRN WIRE VIO/DK BLU WIRE VIO/ORG WIRE VIO/WHT WIRE WHT/BRN WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE YEL WIRE YEL/BLK WIRE YEL/BRN WIRE YEL/DK BLU WIRE YEL/DK GRN WIRE YEL/GRY WIRE YEL/LT BLU WIRE YEL/LT GRN WIRE YEL/ORG WIRE YEL/TAN WIRE YEL/WHT WIRE