Dodge Pickup R2500 (1996-2010) pnk/yel Wiring diagrams

14 23 SPEED CTRL BRAKE SW 27 29 21 15 28 6 38 SENS GND 5.7L 6 9 AWAL RWAL ACCEL ANTI-LOCK BRAKES MODULE (LEFT REAR BRAKE SW 1 SIG BLK WIRE BRAKE SW 1 SIG BRN WIRE BRN/DK BLU WIRE BRN/DK GRN WIRE BRN/ORG WIRE CLOCKSPRING (ON STEERING COLUMN) DECEL DK BLU WIRE DK BLU/DK GRN WIRE DK GRN WIRE DK GRN/WHT WIRE DUMP ENGINE COMPT) ENGINE CONTROL MODULE (5.9L DIESEL) (LOWER LEFT FRONT OF ENGINE BLOCK) EXCEPT 5.7L EXCEPT SRT-10 FUSE 26 FUSE 28 GAS DIESEL GRN WIRE GRY WIRE HOT AT ALL TIMES HOT IN ON OR START IGN SW OUT SENS GND LEFT SPEED CONTROL SWITCH OF ENGINE COMPT) OFF ORG/ WIRE PNK WIRE PNK/GRY WIRE PNK/YEL WIRE POWERTRAIN CONTROL MODULE (RIGHT REAR OF ENGINE COMPT) RED WIRE RES- UME RIGHT SPEED CONTROL SWITCH S/C SW 1 SIG SENSOR GND SPEED CONTROL SERVO (EXCEPT 5.7L) (LEFT SIDE OF SRT-10 SRT-10 DIESEL STOP LAMP SWITCH (ON BRAKE PEDAL SUPPORT) TAN WIRE TAN/ORG WIRE TAN/YEL WIRE THROTTLE BODY (5.7L) (ON TOP OF ENGINE) TOP OF TRANSMISSION) TOTALLY INTEGRATED POWER MODULE (AT LEFT FRONT FENDER) TP 1 SIG TP SENSOR TP 2 SIG ETC MOTOR(+) ETC MOTOR(-) VACUUM VENT VIO WIRE VIO/BRN WIRE VIO/ORG WIRE VIO/WHT WIRE VIO/YEL WIRE WHT WIRE YEL WIRE

1 2 3 4 5 6 7 8 9 10 11 12 FUSED B(+) A/C HEATER CONTROL AUTOMATIC A/C BATT TTOW PRE 3 PRK BLK/LT GRN WIRE BRN/YEL WIRE BTSI CTRL BUS BAR CIRCUIT BOARD COMPUTER DATA LINES SYSTEM EXCEPT PARK ASSIST EXCEPT REGULAR CAB FUSE IGNITION RUN/START CONTROL OUTPUT IGNITION WIRELESS NODE INFRARED PARK ASSIST SENSOR MODULE LT BLU/RED WIRE MANUAL A/C OCCUPANT RESTRAINT CONTROLLER MODULE PARK ASSIST PNK/ YEL WIRE PNK/ORG WIRE PNK/TAN WIRE PNK/VIO WIRE PNK/WHT WIRE PNK/YEL WIRE REAR VIDEO CAMERA (IF EQUIPPED) RELAY RUN WIRE RUN/START GND CAN C BUS + CAN C BUS - BTSI CONTROL STP LMP SIG STOP LAMP SWITCH STP LMP SIG TOTALLY INTEGRATED POWER MODULE TRANSMISSION SHIFT INTERLOCK BRAKE SOLENOID TRS PRK SIG WHT WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE YEL PNK/ WIRE YEL/DK BLU WIRE

31 32 33 PNK WIRE BATTERY TEMPERATURE SENSOR (BELOW BATTERY) BLK/LT BLU WIRE BLK/RED WIRE BLK/WHT WIRE BRN WIRE BRN/WHT WIRE DK BLU WIRE DK BLU/ORG WIRE DK BLU/YEL WIRE DK GRN/LT BLU WIRE DK GRN/ORG WIRE DK GRN/RED WIRE DOWNSTREAM HEATED OXYGEN SENSOR (BEHIND CONVERTER) ENGINE COOLANT TEMPERATURE SENSOR (NEAR THERMOSTAT) FUEL GAUGE PRESSURE SENSOR FUEL PRESSURE SENSOR FUEL TEMPERATURE SENSOR FUSE 9 FUSE BLOCK GRY/BLK WIRE GRY/RED WIRE HOT IN RUN OR START IDLE AIR CONTROL MOTOR (ON SIDE OF THROTTLE BODY) INSTRUMENT CLUSTER SYSTEM (SPEEDOMETER) INTAKE AIR TEMPERATURE SENSOR (RIGHT SIDE OF INTAKE MANIFOLD) LT GRN/BLK WIRE LT GRN/WHT WIRE MANIFOLD ABSOLUTE PRESSURE SENSOR NCA WIRE ORG/ WIRE ORG/BLK WIRE ORG/DK BLU WIRE PNK WIRE PNK/YEL WIRE RED/WHT WIRE TAN/BLK WIRE TAN/PNK WIRE TAN/WHT WIRE TAN/YEL WIRE UPSTREAM HEATED OXYGEN SENSOR VEHICLE SPEED CONTROL SWITCHES VIO WIRE VIO/BLK WIRE VIO/WHT WIRE WHT/ORG WIRE YEL/BLK WIRE

1 2 3 4 5 6 7 8 TRANS RLY OUT A/C COMP CL RLY A/C HIGH PRESSURE CUTOUT SWITCH (A/C HIGH PRESSURE LINE) A/C LOW PRESSURE CUTOUT SWITCH (A/C LOW PRESSURE LINE) A/C REQUEST A/C SELECT STOP LP SWITCH A/C SYSTEM A/T ASD RELAY SENS OD OFF SWITCH ASD RLY CTRL CRUISE VAC SOL CRUISE VNT SOL OD LAMP DRVR TRANS TEMP LAMP DRVR BATT TEMP SENS GEN IND DRVR MIL IND DRVR SRI LAMP DRVR BLK/LT BLU WIRE BLK/PNK WIRE BLK/WHT WIRE BRN WIRE BRN/WHT WIRE CRANKSHAFT POSITION SENSOR CAMSHAFT POSITION SENSOR CRUISE CONTROL SYSTEM DATA LINK CONNECTOR (LEFT I/P) DK BLU WIRE DK BLU/ORG WIRE DK BLU/YEL WIRE DK GRN WIRE DK GRN/ORG WIRE FUEL PRESS. GAUGE TACHO- METER FUSE 12 FUSE BLOCK GRN WIRE GRY/BLK WIRE GRY/LT BLU WIRE GRY/PNK WIRE HI PRESS FUEL SHUTOFF RLY CTRL HOT IN RUN OR START INSTRUMENT CLUSTER J/C C (BEHIND LEFT KNEE BOLSTER) LT GRN WIRE LT GRN/BLK WIRE LT GRN/ORG WIRE LT GRN/RED WIRE LT GRN/WHT WIRE M/T (NOT USED) MAINT REQ IND. MESSAGE CENTER ORG/ WIRE ORG/BLK WIRE ORG/DK BLU WIRE ORG/WHT WIRE OVERDRIVE SWITCH PNK WIRE PNK/BLK WIRE PNK/DK BLU WIRE PNK/YEL WIRE POWER DISTRI- BUTION CENTER POWERTRAIN CONTROL MODULE (RIGHT SIDE SAFETY WALL) RED WIRE RED/LT GRN WIRE RED/WHT WIRE SCI RECEIVE SCI TRANSMIT SENSOR GRD GOV PRESS SIG VAR FORCE SOL OVERDRV SOL TCC SOL CTRL TRANS TEMP SNS STOP LAMP SWITCH TACH SIGNAL SPD CTRL RESUME TAN/RED WIRE TAN/YEL WIRE THROTTLE POSITION SENSOR (SIDE OF THROTTLE BODY) TRANS- MISSION RELAY TRANSMISSION SOLENOID ASSEMBLY (ON TRANSMISSION) UPSHIFT IND. MIL IND. VEHICLE SPEED SENSOR VIO WIRE VIO/WHT WIRE W/ A/T WHT/ORG WIRE WHT/PNK WIRE YEL WIRE YEL/RED WIRE

1 2 3 4 5 6 7 8 TRANS RLY OUT A/C COMP RLY A/C HIGH PRESSURE CUTOUT SWITCH (A/C HIGH PRESSURE LINE) A/C LOW PRESSURE CUTOUT SWITCH (A/C LOW PRESSURE LINE) A/C REQUEST A/C SELECT IN BRAKE SW IN A/C SYSTEM AIR CONDITIONING SYSTEM AUTO SHT RLY CRUISE VAC SOL CRUISE VNT SOL OVERDRV IND TRANS TEMP IND BATT TEMP SENS GEN IND DRVR MIL IND DRVR SRI DRIVER FUEL PMP RLY EVAP SOL DRVR BATTERY TEMPER- ATURE SENSOR (BELOW BATTERY) BLK WIRE BLK/LT BLU WIRE BLK/ORG WIRE BLK/PNK WIRE BLK/RED WIRE BLK/WHT WIRE BRN WIRE BRN/WHT WIRE CAMSHAFT POSITION SENSOR (IN DISTRIBUTOR) CRUISE CONTROL SYSTEM CRUISE CONTROL SYSTEM CRUISE CONTROL SYSTEM CRUISE FEED ASD RELAY SENS TRANS OVERDRV DATA LINK CONNECTOR (LEFT I/P) DK BLU WIRE DK BLU/ORG WIRE DK BLU/WHT WIRE DK BLU/YEL WIRE DK GRN WIRE DK GRN/ORG WIRE DUTY CYCLE/ EVAP PURGE SOLENOID (REAR OF INTAKE MANIFOLD) ENGINE DIAGNOSTIC CONNECTOR FUEL LEVEL IN FUSE 8 FUSE 4 GEN IND LAMP GENERATOR GRY/LT BLU WIRE GRY/PNK WIRE GRY/WHT WIRE HOT AT ALL TIMES HOT IN RUN OR START FUSE BLOCK FUSE 11 INSTRUMENT CLUSTER INTAKE AIR TEMPER- ATURE SENSOR (RIGHT SIDE OF INTAKE MANIFOLD) JOINT CONNECTOR C (BEHIND LEFT KNEE BOLSTER) LOW FUEL SENS SCI TRANSMIT LT GRN WIRE LT GRN/BLK WIRE LT GRN/ORG WIRE LT GRN/RED WIRE LT GRN/WHT WIRE MESSAGE CENTER MIL IND LAMP ORG/ WIRE ORG/BLK WIRE ORG/DK BLU WIRE ORG/WHT WIRE OVERDRIVE SWITCH PNK WIRE PNK/BLK WIRE PNK/DK BLU WIRE PNK/YEL WIRE POWER DISTRIBUTION CENTER POWERTRAIN CONTROL MODULE (RIGHT SIDE SAFETY WALL) RED WIRE RED/LT GRN WIRE RED/WHT WIRE SCI RECEIVE SENSOR GRD GOV PRESS SIG VAR FORCE SOL OVERDRV SOL TCC SOL CTRL TRANS TEMP SNS STOP LAMP SWITCH (UNDER LEFT SIDE OF I/P) TACH SIGNAL TACH SIGNAL CRUISE SW IN TAN/RED WIRE TAN/YEL WIRE THROTTLE POSITION SENSOR (SIDE OF THROTTLE BODY) TRANS- MISSION RELAY TRANSMISSION SOLENOID ASSEMBLY (TRANSMISSION) UP SHIF IND VIO WIRE VIO/WHT WIRE WHT WIRE WHT/DK BLU WIRE WHT/PNK WIRE YEL/RED WIRE

1/1 (LEFT BANK UP) (5.9L H/D) (IN LEFT EXHAUST MANIFOLD DOWNPIPE) 1/1 (UPSTREAM) (3.9L, 5.2L) (AT INLET OF CATALYTIC CONVERTER) 29 30 31 PNK WIRE BATTERY TEMPER- ATURE SENSOR (BELOW BATTERY TRAY) BLK WIRE BLK/LT BLU WIRE BLK/RED WIRE BLK/WHT WIRE BRN WIRE BRN/WHT WIRE CAMSHAFT POSITION SENSOR (IN DISTRIBUTOR) CRANKSHAFT POSITION SENSOR (RIGHT REAR OF ENG BLOCK) DK BLU/WHT WIRE DK BLU/YEL WIRE DK GRN/BLK WIRE DK GRN/ORG WIRE DK GRN/RED WIRE DK GRN/WHT WIRE DUTY CYCLE EVAP/ PURGE SOLENOID (ON BRACKET, MOUNTED ON RIGHT INNER FENDER) ENGINE COOLANT TEMPERATURE SENSOR (AT FRONT OF INTAKE MANIFOLD) FUEL INJ + FUEL PUMP MODULE (TOP OF FUEL TANK) GROUND GRY/BLK WIRE GRY/ORG WIRE GRY/RED WIRE HEATED OXYGEN SENSOR HEATED OXYGEN SENSOR 1/2 (PRE- CATALYST) (5.9L M/D) IAC MTR 1 IAC MTR 2 IAC MTR 3 IAC MTR 4 LT GRN/RED WIRE LT GRN/WHT WIRE MANIFOLD ABSOLUTE PRESSURE SENSOR (ON THROTTLE BODY) NCA WIRE ORG/ WIRE ORG/BLK WIRE ORG/DK BLU WIRE PNK 1 2 WIRE PNK/WHT WIRE PNK/YEL WIRE RLY OUT (B+) FUEL PUMP SENSOR RETURN SENSOR SIG TAN/BLK WIRE TAN/WHT (OR ORG/BLK) WIRE TAN/WHT WIRE TAN/YEL WIRE VIO WIRE VIO/BLK WIRE VIO/WHT WIRE YEL/BLK WIRE

1 2 3 4 5 6 7 8 TRANS RLY OUT AIR CONDI- TIONING SYSTEM AUTO SHT RLY CRUISE VAC SOL CRUISE VNT SOL BLK/LT BLU WIRE BLK/LT GRN WIRE BLK/RED WIRE BRN WIRE BRN/WHT WIRE CCD(-) CRUISE CONTROL SYSTEM CRUISE SW IN DATA LINK CONNECTOR (LEFT BOTTOM OF DASH) DK BLU WIRE DK BLU/ORG WIRE DK BLU/WHT WIRE DK BLU/YEL WIRE DK GRN WIRE DK GRN/ORG WIRE FUEL PMP RLY EVAP SOL DRVR FUSE 11 FUSE I GENERATOR HOT AT ALL TIMES HOT IN RUN OR START INSTRUMENT CLUSTER INTAKE AIR TEMPERATURE SENSOR (IN RIGHT FRONT SIDE OF INTAKE MANIFOLD) JOINT CONNECTOR 1 (IN PDC) JOINT CONNECTOR 11 9 2 14 6 5 JUNCTION BLOCK (RIGHT END OF DASH) LEAK DETECTION PUMP (RIGHT FRONT OF INNER FENDER) LT GRN/RED WIRE LT GRN/WHT WIRE NCA WIRE ORG/ WIRE ORG/BLK WIRE ORG/DK BLU WIRE ORG/WHT WIRE OVERDRIVE SWITCH PNK 1 2 WIRE PNK WIRE PNK/DK BLU WIRE PNK/WHT WIRE PNK/YEL WIRE POWER DISTRIBUTION CENTER (IN ENG COMPT, ON LEFT INNER FENDER PANEL) POWERTRAIN CONTROL MODULE (IN ENG COMPT, ON RIGHT SIDE OF FIREWALL) RED WIRE RED/LT GRN WIRE SENSOR GRD GOV PRESS SIG VAR FORCE SOL OVERDRV SOL TCC SOL CTRL TRANS TEMP SNS STOP LAMP SWITCH (ON BRAKE PEDAL BRACKET) TAN/RED WIRE THROTTLE POSITION SENSOR (ON THROTTLE BODY) TRANS- MISSION RELAY TRANSMISSION SOLENOID ASSEMBLY (ON LEFT SIDE OF TRANSMISSION) VIO WIRE VIO/BRN WIRE VIO/WHT WIRE WHT/BLK WIRE WHT/DK GRN WIRE WHT/PNK WIRE YEL/RED WIRE

A/C COMP RLY A/C HIGH PRESSURE CUTOUT SWITCH (A/C HIGH PRESSURE LINE) A/C LOW PRESSURE CUTOUT SWITCH (A/C LOW PRESSURE LINE) A/C REQUEST A/C SELECT IN BRAKE SW IN GENERATOR A/C SYSTEM AIR CONDITIONING SYSTEM (A/C-HEATER CONTROL SWITCH) AUTO SHT RLY CRUISE VAC SOL CRUISE VNT SOL OVERDRV IND TRANS TEMP IND BATT TEMP SENS GEN IND DRVR MIL IND DRVR WATER IN FUEL BATTERY TEMPER- ATURE SENSOR (BELOW BATTERY) BLK/LT BLU WIRE BLK/ORG WIRE BLK/PNK WIRE BLK/RED WIRE BLK/WHT WIRE BRN WIRE CRUISE CONTROL SYSTEM CRUISE FEED ASD RELAY SENS TRANS OVERDRV DATA LINK CONNECTOR DK BLU/ORG WIRE DK BLU/WHT WIRE DK BLU/YEL WIRE DK GRN WIRE DK GRN/ORG WIRE DK GRN/RED WIRE EGR DIAG FUSE 11 FUSE BLOCK GEN IND LAMP GENERATOR GRY/LT BLU WIRE HOT IN START OR RUN INSTRUMENT CLUSTER INSTRUMENT CLUSTER SYSTEM INTAKE AIR TEMPER- ATURE SENSOR (RIGHT SIDE OF INTAKE MANIFOLD) JOINT CONNECTOR C (BEHIND LEFT KNEE BOLSTER) LT GRN WIRE LT GRN/ORG WIRE LT GRN/RED WIRE LT GRN/WHT WIRE MIL IND LAMP NCA WIRE ORG/ WIRE ORG/BLK WIRE ORG/WHT WIRE OVERDRIVE SWITCH PNK 13 14 WIRE PNK WIRE PNK/BLK WIRE PNK/DK BLU WIRE PNK/DK GRN WIRE PNK/YEL WIRE POWER DISTRIBUTION CENTER POWERTRAIN CONTROL MODULE (RIGHT SIDE SAFETY WALL) RED WIRE RED/LT GRN WIRE SCI RECEIVE SCI TRANSMIT SPEEDOMETER STOP LAMP SWITCH (UNDER LEFT SIDE OF I/P) TACH SIGNAL TACH SIGNAL CRUISE SW IN TAN/ORG WIRE TAN/RED WIRE TAN/YEL WIRE TRANS- MISSION RELAY WATER IN FUEL SENSOR (BOTTOM OF FUEL FILTER) WHT/DK BLU WIRE WHT/ORG WIRE WHT/PNK WIRE YEL/RED WIRE

1/2 (PRE- CATALYST) (ON INLET OF CATALYTIC CONVERTER) (CALIF) 28 29 30 PNK WIRE BATTERY TEMPER- ATURE SENSOR (BELOW BATTERY TRAY) BLK WIRE BLK/DK GRN WIRE BLK/LT BLU WIRE BLK/RED WIRE BLK/WHT WIRE BRN WIRE BRN/VIO WIRE BRN/WHT WIRE CAMSHAFT POSITION SENSOR (IN TIMING CHAIN CASE/COVER ON LEFT FRONT SIDE OF ENG) CRANKSHAFT POSITION SENSOR DK BLU/WHT WIRE DK BLU/YEL WIRE DK GRN WIRE DK GRN/BLK WIRE DK GRN/ORG WIRE DK GRN/RED WIRE DK GRN/WHT WIRE DK GRN/YEL WIRE ENGINE COOLANT TEMPERATURE SENSOR (ON THERMOSTAT HOUSING) EVAP PURGE SOLENOID (ON BRACKET, MOUNTED ON RIGHT INNER FENDER) FUEL PUMP MODULE (ON TOP OF FUEL TANK) FUEL PUMP RLY OUT (B+) FUSE 11 FUSE 9 GROUND GRY/BLK WIRE GRY/ORG WIRE GRY/RED WIRE HEATED OXYGEN SENSOR HEATED OXYGEN SENSOR 11 HEATED OXYGEN SENSOR 21 HEATED OXYGEN SENSOR 22 HOT IN RUN OR START IAC MTR 1 IAC MTR 2 IAC MTR 3 IAC MTR 4 JUNCTION BLOCK (ON LEFT END OF DASH) LT BLU WIRE LT GRN/BLK WIRE LT GRN/RED WIRE LT GRN/WHT WIRE MANIFOLD ABSOLUTE PRESSURE SENSOR (ON RIGHT UPPER SIDE OF INTAKE MANIFOLD) NCA WIRE ORG/ WIRE ORG/BLK WIRE ORG/DK BLU WIRE PNK WIRE PNK/WHT WIRE PNK/YEL WIRE SENSOR RETURN SENSOR SIG TAN/BLK WIRE TAN/WHT WIRE TAN/YEL WIRE VIO WIRE VIO/BLK WIRE VIO/WHT WIRE WHT WIRE YEL WIRE YEL/BLK WIRE

1 2 3 4 5 6 7 8 TRANS RLY OUT AIR CONDI- TIONING SYSTEM AIR CONDITIONING SYSTEM AUTO SHT RLY CRUISE VAC SOL CRUISE VNT SOL BLK/LT BLU WIRE BLK/LT GRN WIRE BLK/RED WIRE BRN WIRE BRN/VIO WIRE BRN/WHT WIRE CCD(-) CRUISE CONTROL SYSTEM CRUISE SW IN DATA LINK CONNECTOR (LEFT BOTTOM OF DASH) DK BLU WIRE DK BLU/ORG WIRE DK BLU/WHT WIRE DK BLU/YEL WIRE DK GRN WIRE DK GRN/ORG WIRE DK GRN/PNK WIRE DK GRN/WHT WIRE DK GRN/YEL WIRE DOWNSTREAM OXYGEN SENSOR RELAY FUEL PMP RLY EVAP SOL DRVR FUSE GENERATOR HOT AT ALL TIMES INSTRUMENT CLUSTER INTAKE AIR TEMPERATURE SENSOR (IN LEFT FRONT SIDE OF INTAKE MANIFOLD) JOINT CONNECTOR 1 (IN PDC) JOINT CONNECTOR 11 9 2 14 6 5 LEAK DETECTION PUMP (ON RIGHT FRONT OF INNER FENDER) LT GRN/RED WIRE LT GRN/WHT WIRE M/T ONLY ORG/ WIRE ORG/BLK WIRE ORG/DK BLU WIRE ORG/WHT WIRE OVERDRIVE SWITCH PNK WIRE PNK/DK BLU WIRE PNK/WHT WIRE PNK/YEL WIRE POWERTRAIN CONTROL MODULE (IN ENG COMPT, ON RIGHT SIDE OF FIREWALL) RED WIRE RED/LT GRN WIRE SENSOR GRD GOV PRESS SIG VAR FORCE SOL OVERDRV SOL TCC SOL CTRL TRANS TEMP SNS STOP LAMP SWITCH (ON BRAKE PEDAL BRACKET) TAN/RED WIRE THROTTLE POSITION SENSOR (ON THROTTLE BODY) TRANSMISSION RELAY FUSE I TRANSMISSION SOLENOID ASSEMBLY (ON LEFT SIDE OF TRANSMISSION) VIO WIRE VIO/BRN WIRE VIO/WHT WIRE WHT/BLK WIRE WHT/DK GRN WIRE WHT/PNK WIRE YEL WIRE YEL/RED WIRE