Dodge Pickup R2500 (1996-2010) org/ Wiring diagrams

5.7L ANTI-LOCK BRAKES MODULE (LEFT REAR OF ENGINE COMPT) B(+) CAN C BUS (+) BLK WIRE BLK/DK GRN WIRE BLK/ORG WIRE BRAKE FLUID LEVEL SENSOR (LEFT REAR OF ENGINE COMPT) BRAKE SWITCH 1 SIGNAL POWERTRAIN CONTROL MODULE (RIGHT REAR OF ENGINE COMPT) BRK FLUID LEVEL SW SENSE CAN C BUS (+) COMPUTER DATA LINES SYSTEM DK GRN WIRE DK GRN/GRY WIRE DK GRN/LT GRN WIRE DK GRN/ORG WIRE DK GRN/RED WIRE DK GRN/TAN WIRE DK GRN/WHT WIRE DK GRN/YEL WIRE ELECTRONICS FUSED IGN SW OUT (RUN-START) FUSE 13 FUSE 28 GRY WIRE HOT AT ALL TIMES LT BLU WIRE LT GRN WIRE ORG/ WIRE PNK WIRE PNK/GRY WIRE RED WIRE STOP LAMP SWITCH (ON BRAKE PEDAL SUPPORT) TAN WIRE TOTALLY INTEGRATED POWER MODULE (AT LEFT FRONT FENDER) WHT WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE YEL WIRE

17 18 CAN B BUS(+) CAN B BUS(-) 33 42 28 27 APPS 1 RTN 36 37 6 25 SPEED CTRL BRAKE SW 4 5 1 21 CAN C BUS (+) CAN C BUS (-) 44 45 33 35 48 3 SPD SENS SIG SENS GND 6.7L 5.9L ACCEL ACCELERATOR PEDAL POSITION SENSOR (LEFT SIDE OF DASH) APPS 1 SIG APPS 1 RTN APPS 2 RTN APPS 2 SIG APPS 2 SIG APPS 2 RTN APPS 1 SIG BLK WIRE BLU WIRE BRN WIRE BRN/VIO WIRE BRN/WHT WIRE BRN/YEL WIRE CAN C BUS (+) CLUSTER COMPUTER DATA LINES SYSTEM DECEL DK BLU WIRE DK BLU/DK GRN WIRE DK GRN WIRE DK GRN/BRN WIRE DK GRN/ORG WIRE DK GRN/VIO WIRE DK GRN/WHT WIRE ENGINE CONTROL MODULE (LOWER LEFT FRONT OF ENGINE BLOCK) FUSE 28 GRN WIRE GRY WIRE HOT AT ALL TIMES HOT AT ALL TIMES TOTALLY INTEGRATED POWER MODULE (LEFT FRONT FENDER) FUSE 26 INPUT SPEED SENSOR (LEFT SIDE OF TRANSMISSION) LEFT SPEED CONTROL SWITCH OFF ORG/ WIRE OUTPUT SPEED SENSOR (5.9L) (BOTTOM OF TRANSMISSION) OUTPUT SPEED SENSOR (LEFT REAR OF TRANSMISSION) PNK EXTERIOR LIGHTS SYSTEM WIRE PNK WIRE REAR OF ENGINE COMPT) RED WIRE RESUME RIGHT SPEED CONTROL SWITCH SENS GND SENS GND S/C SW RTN S/C SW 1 SIG S/C SW 2 SIG 33 40 56 46 56 SENS SIG STEERING CONTROL MODULE (ON STEERING COLUMN) STOP LAMP SWITCH (ON BRAKE PEDAL SUPPORT) TAN WIRE TRANSMISSION CONTROL MODULE VIO WIRE VIO/BRN WIRE VIO/ORG WIRE VIO/YEL WIRE WHT WIRE WHT/BRN WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE WHT/ORG WIRE YEL WIRE YEL/DK BLU WIRE

BLK WIRE BRN WIRE DK GRN WIRE DRIVER FRONT VERTICAL SEAT ADJUSTER MOTOR (UNDER DRIVER SEAT) DRIVER HORIZONTAL SEAT ADJUSTER MOTOR DRIVER REAR VERTICAL SEAT ADJUSTER MOTOR (UNDER DRIVER SEAT) DRIVER SEAT SWITCH F DN F UP FUSE 27 GRN WIRE HOT AT ALL TIMES LT BLU WIRE LT LT NCA WIRE ORG/ WIRE ORG/RED WIRE R DN R UP RWD TAN WIRE TOTALLY INTEGRATED POWER MODULE (LEFT FRONT FENDER) WHT WIRE YEL WIRE

BLK WIRE DK GRN WIRE DRIVER FRONT VERTICAL SEAT ADJUSTER MOTOR (UNDER DRIVER SEAT) DRIVER HORIZONTAL SEAT ADJUSTER MOTOR DRIVER REAR VERTICAL SEAT ADJUSTER MOTOR (UNDER DRIVER SEAT) DRIVER SEAT SWITCH F DN F UP FUSE 27 GRN WIRE HOT AT ALL TIMES LT BLU WIRE LT LT NCA WIRE ORG/ WIRE ORG/RED WIRE R DN R UP RWD TAN WIRE TOTALLY INTEGRATED POWER MODULE (LEFT FRONT FENDER) WHT WIRE YEL WIRE

BLK WIRE BLK/LT GRN WIRE BLK/PNK WIRE CAN C BUS (+) CAN C CAN C BUS (+) BUS (-) COMPUTER DATA LINES SYSTEM DYN SENS HIGH LNK DYN SENS LOW LNK DYNAMICS SENSOR (W/ ESP) (UNDER FRONT OF CENTER CONSOLE) ELECTRONICS B(+) FUSE 28 FUSE 30 FUSED IGN SW OUT (RUN-START) GRY WIRE GRY/ PNK WIRE HIGH LNK DYN SENS HOT AT ALL TIMES HOT IN ON OR START IGN SW OUT (RUN-START) LOW LNK DYN SENS LT BLU/ WHT WIRE LT GRN PNK/ WIRE LT GRN WHT/ WIRE ORG/ WIRE PNK/ LT GRN WIRE PNK/GRY WIRE PNK/LT GRN WIRE STEERING ANGLE SENSOR (W/ ESP) (ON STEERING COLUMN) TOTALLY INTEGRATED POWER MODULE (AT LEFT FRONT FENDER) WHT LT GRN/ WIRE WHT WIRE WHT/GRY WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE WHT/ORG WIRE

1 2 SENS GND SENS SIG A/C CLUTCH CTRL A/C CLUTCH CTRL OUTPUT A/C HEATER CONTROL A/C INDICATOR A/C PRES 5 VOLT SPLY A/C PRES GND A/C PRES SIG A/C SELECT B(+) BLEND DOOR DRIVER BLK WIRE BLK/LT BLU WIRE BLK/LT GRN WIRE BLK/ORG WIRE BLOWER MOTOR RESISTOR (RIGHT SIDE OF DASH) BLU WIRE BRN WIRE CLUSTER COMMON DOOR DRIVER COMPUTER DATA LINES SYSTEM CONDENSER FAN CTRL OUTPUT DK BLU WIRE DK BLU/BRN WIRE DK BLU/DK GRN WIRE DK BLU/LT BLU WIRE DK BLU/LT GRN WIRE DK BLU/ORG WIRE DK BLU/TAN WIRE DK BLU/VIO WIRE DK BLU/YEL WIRE DK DK DRIVER BLEND DOOR ACTUATOR (ON HVAC UNIT) ELECTRONICS EVAPORATOR TEMPERATURE SENSOR (RIGHT SIDE OF HVAC) EXCEPT BASE FENDER) FUSE 23 FUSE 33 FUSED IGN SW OUT (RUN) FUSED IGN SW OUT (RUN-START) HEATER MIRROR INDICATOR HOT AT ALL TIMES HVAC MICRO CONTROLLER LT BLU WIRE LT BLU/BRN WIRE LT BLU/ORG WIRE LT BLU/WHT WIRE LT GRN WIRE MODE DOOR ACTUATOR 1 (PANEL TO FLOOR) (ON HVAC UNIT) MODE DOOR ACTUATOR 2 (DEFROST TO FLOOR) (ON HVAC UNIT) OFF OFF HEATED MIRROR ORG/ WIRE ORG/GRY WIRE PANEL LAMPS DRIVER PASS BLEND DOOR DRIVER PASSENGER BLEND DOOR ACTUATOR (EXCEPT BASE) (ON HVAC UNIT) PNK WIRE PNK/LT BLU WIRE PNK/LT GRN WIRE RECIRC RECIRCULATION DOOR ACTUATOR (ON HVAC UNIT) RECIRCULATION DOOR DRIVER RECIRCULATION INDICATOR RED WIRE TAN WIRE TOTALLY INTEGRATED POWER MODULE (LEFT FRONT WHT WIRE WHT/ORG WIRE YEL WIRE

34 35 CAN C BUS (+) CAN C BUS (-) 5 4 CAN C BUS (-) CAN C BUS (+) 6.7L 5.9L A/C CLUTCH CTRL A/C COMPRESSOR CLUTCH (FRONT OF A/C COMPRESSOR) A/C PRES 5 VOLT SPLY A/C PRES GND BLK WIRE BLK/GRY WIRE BLK/LT BLU WIRE BLK/WHT WIRE BLU WIRE BRN WIRE BRN/WHT WIRE BRN/YEL WIRE COMPUTER DATA LINES SYSTEM CONDENSER FAN MOTOR (GAS) (LEFT FRONT OF ENGINE COMPT) DIESEL DK BLU WIRE DK BLU/DK GRN WIRE DK BLU/YEL WIRE DK GRN WIRE ECT SIG ENGINE BLOCK) ENGINE CONTROL MODULE (LOWER LEFT FRONT OF ENGINE CONTROLS SYSTEM ENGINE COOLANT TEMPERATURE GAS LT BLU WIRE LT BLU/BRN WIRE LT BLU/ORG WIRE LT BLU/WHT WIRE ORG/ WIRE POWERTRAIN CONTROL MODULE (RIGHT REAR OF ENGINE COMPT) SENS GND SENSOR (5.7L: FRONT OF ENGINE) (6.7L: TOP FRONT OF ENGINE) VIO WIRE VIO/ORG WIRE WHT WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE YEL WIRE

2 1 UP PASS DN PASS 4 6 7 8 PASS HORI RR RD FUSED B (+) GND PASS HORI FR RD BLK/WHT WIRE CIRCUIT BREAKER HOT AT ALL TIMES LT GRN/BRN WIRE LT GRN/GRY WIRE LT GRN/ORG WIRE LT GRN/VIO WIRE LT GRN/WHT WIRE ORG LT GRN/ WIRE ORG/ WIRE ORG/RED WIRE PASS REC DN SW PASS REC UP SW PASSENGER SEAT HORIZONTAL ADJUSTER MOTOR PASSENGER SEAT RECLINER ADJUSTER MOTOR PASSENGER SEAT SWITCH RED WIRE TOTALLY INTEGRATED POWER MODULE (LEFT FRONT OF ENGINE COMPT) WHT LT GRN/ WIRE

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 FUSED B(+) 1 2 3 4 5 6 7 8 9 10 11 12 LEFT AUDIO SIG (+) 1 2 3 4 5 6 7 8 9 10 11 12 RIGHT AUDIO AUX SDARS AUDIO RETURN LEFT AUDIO AUX 1 2 3 4 5 6 7 8 9 10 RIGHT AUDIO SIG (+) AUDIO SIG COMMON 12 11 (NOT USED) ANTENNA BLK WIRE BLK/LT GRN WIRE BRN WIRE CAN B BUS (-) CAN B BUS (+) CAN B FUSED CLUSTER RADIO CAN B CTRL BUS BUS MUX B(+) (+) (-) COMPUTER DATA LINES SYSTEM DK GRN WIRE DK GRN/DK BLU WIRE DK GRN/LT BLU WIRE DK GRN/ORG WIRE DK GRN/YEL WIRE FUSE 36 FUSED B (+) RIGHT AUDIO SIG (+) COMMON AUDIO SIG GROUND GROUND FUSED B(+) GRY WIRE GRY/DK BLU WIRE GRY/DK GRN WIRE GRY/LT BLU WIRE GRY/LT GRN WIRE GRY/ORG WIRE GRY/RED WIRE GRY/TAN WIRE GRY/WHT WIRE HANDS FREE MODULE (IF EQUIPPED) HOT AT ALL TIMES HOT AT ALL TIMES TOTALLY INTEGRATED LEFT AUDIO OUTPUT CAN B BUS (+) CAN B BUS (-) LEFT AUDIO SIG(+) AUX AUDIO RTN LEFT AUDIO AUX LEFT AUDIO AUX RIGHT AUDIO AUX LEFT REMOTE RADIO SWITCH MONITOR/DVD MEDIA SYSTEM NCA WIRE ORG/ WIRE POWER MODULE FUSE (AT LEFT FRONT FENDER) PRESET RADIO RED WIRE RIGHT AUDIO AUX SDARS AUDIO RTN SATELLITE RECEIVER (SLT+) (RIGHT SIDE OF DASH) SEEK DN SEEK UP STEERING CONTROL MODULE (ON STEERING COLUMN) TAN/GRY WIRE VOL DN RIGHT REMOTE RADIO SWITCH VOL UP W/ HANDS FREE WHT WIRE WHT/BRN WIRE WHT/ORG WIRE YEL WIRE YEL/RED WIRE

A/C HEATER CONTROL B(+) BLK WIRE CAN B BUS (+) CAN B BUS (-) CAN B BUS (+) COMPUTER DATA LINES SYSTEM DK BLU WIRE DK BLU/WHT WIRE ELECTRIC HEATED BACKLITE ELECTRONICS REAR WINDOW DEFOGGER CTRL OUT EXCEPT BASE HOT AT ALL TIMES NCA WIRE ORG/ WIRE REAR WINDOW DEFOG SWITCH TOTALLY INTEGRATED POWER MODULE (LEFT FRONT FENDER) WHT WIRE WHT/ORG WIRE