Dodge Pickup R2500 (1996-2010) instrument cluster Wiring diagrams

BLK WIRE BLK/GRY WIRE BLK/LT BLU WIRE BLK/ORG WIRE BLK/TAN WIRE BLK/WHT WIRE BRN WIRE CONTROLLER ANTI-LOCK BRAKE (CENTER OF I/P) CRUISE CONTROL SYSTEM DATA LINK CONNECTOR (PARTIAL) (UNDER LEFT SIDE OF I/P) DK BLU WIRE DK BLU/BLK WIRE DK BLU/WHT WIRE DK GRN WIRE FOG LAMP SWITCH FUSE 11 FUSE 12 FUSE 13 FUSE BLOCK FUSED B(+) TP SENS SIG GND GND FUSED IGN (ST/RUN) SENSOR GND PNP SW SENSE ECT SENS SIG GRY WIRE HOT IN RUN OR START HOT W/HEADLAMP SWITCH IN PARK OR HEAD POSITION (REHOSTAT CONTROLLED) ILLUM IND INSTRUMENT CLUSTER JOINT CONNECTOR JOINT CONNECTOR C (BEHIND KNEE BOLSTER) JOINT CONNECTOR C (PIN 5) LT GRN WIRE LT GRN/BLK WIRE LT GRN/ORG WIRE LT GRN/RED WIRE LT GRN/WHT WIRE ORG/ WIRE ORG/BLK WIRE ORG/DK BLU WIRE ORG/WHT WIRE OUTPUT SHAFT SPD SENS GND OUTPUT SHAFT SPD SENS SIG OVERDRIVE SWITCH PNK 10 11 12 WIRE PNK WIRE PNK/DK BLU WIRE POWERTRAIN CONTROL MODULE (RIGHT SIDE OF SAFETY WALL) RED/LT GRN WIRE RED/WHT WIRE SENSE SPD CTRL SW SIG STOP LAMP SWITCH (TOP OF BRAKE PEDAL ARM) SWITCH (ON FRONT OF FRAME) TAN WIRE TAN/BLK WIRE TAN/RED WIRE TRANSMISSION OUTPUT SHAFT SPEED SENSOR (LEFT SIDE OF TRANSMISSION) VIO WIRE VIO/WHT WIRE W/ANTI-LOCK BRAKES SYSTEM W/O ANTI-LOCK BRAKES SYSTEM W/O ANTI- LOCK BRAKES SYSTEM W/ANTI-LOCK BRAKES SYSTEM WHT WIRE WHT/ORG WIRE WHT/PNK WIRE YEL WIRE YEL/RED WIRE

AIR BAG CONTROL MODULE (BEHIND LOWER CENTER OF DASH) BLK WIRE BLK/LT GRN WIRE BLK/TAN WIRE BLK/WHT WIRE CCD BUS (-) CENTRAL TIMER MODULE (ON LEFT SIDE OF DASH) CONTROLLER ANTI-LOCK BRAKE (RWAL: LEFT FRONT INNER FENDER) CUMMINS BUS (-) CUMMINS BUS (DIESEL) (LEFT FRONT OF ENGINE) CUMMINS BUS SHIELD DASH) DATA LINK CONNECTOR (DLC) (ON LEFT BOTTOM OF DASH) DIESEL DK BLU WIRE DK GRN WIRE DRAIN WIRE ENGINE CONTROL MODULE (ON LEFT SIDE OF ENGINE, BEHIND FUEL FILTER) FUSE 12 GAS GAS DIESEL GROUND HOT AT ALL TIMES HYDRAULIC CONTROL UNIT INSTRUMENT CLUSTER J/C 5 (BEHIND LEFT SIDE OF DASH) JUNCTION BLOCK (ON LEFT END OF NCA WIRE OVERHEAD CONSOLE (HIGHLINE) PNK WIRE PNK/DK BLU WIRE POWERTRAIN CONTROL MODULE (ON RIGHT SIDE OF FIREWALL) RADIO SCI RECEIVE SCI TRANSMIT VIO/BRN WIRE WHT/BLK WIRE WHT/VIO WIRE YEL/DK BLU WIRE YEL/DK GRN WIRE

1 2 3 4 5 6 7 8 9 10 HI BEAM OUT ANTI-THEFT SYSTEM BLK WIRE BLK/ORG WIRE BLK/YEL WIRE BRN/LT GRN WIRE BRN/WHT WIRE BRN/YEL WIRE DAYTIME RUNNING LAMP MODULE (IN ENG COMPT, IN LEFT INNER FENDER PANEL) FOG LAMP RELAY 1 (ON POWER DISTRIBUTION CENTER) FOG LAMP RELAY 2 (ON POWER DISTRIBUTION CENTER) FOG LAMP SWITCH FUSE 1 FUSE 7 FUSE 5 FUSE GROUND HEAD HEADLAMP DIMMER SWITCH HEADLAMP SWITCH HI BEAM INDICATOR HOT AT ALL TIMES INSTRUMENT CLUSTER J/C 1 (IN PDC) J/C 4 J/C 5 (BEHIND LEFT SIDE OF DASH) J/C 5 (IN PDC) J/C 6 JUNCTION BLOCK (RIGHT END OF DASH) LEFT HEADLAMP LO HI LT BLU WIRE LT GRN WHT/ WIRE LT GRN WIRE LT GRN/ BLK WIRE LT GRN/WHT WIRE OFF OFF HEAD ORG/ WIRE PARK PARK BRAKE SW INDICATOR CTRL IGNITION BATTERY PARK BRAKE SWITCH (ON PARK BRAKE MECHANISM) PNK/RED WIRE RED/GRY WIRE RED/ORG WIRE RED/WHT WIRE RIGHT FOG LAMP LEFT FOG LAMP RIGHT HEADLAMP VIO WIRE VIO/WHT WIRE WHT/LT GRN WIRE

ANTI-THEFT SYSTEM BLK WIRE BLK/ORG WIRE BLK/YEL WIRE BRN/WHT WIRE BRN/YEL WIRE FOG LAMP RELAY 1 (ON POWER DISTRIBUTION CENTER) FOG LAMP RELAY 2 (ON POWER DISTRIBUTION CENTER) FOG LAMP SWITCH FUSE FUSE 1 FUSE 5 HEAD HEADLAMP DIMMER SWITCH HEADLAMP SWITCH HI BEAM INDICATOR HOT AT ALL TIMES INSTRUMENT CLUSTER J/C 1 (IN PDC) J/C 4 J/C 5 (BEHIND LEFT SIDE OF DASH) J/C 5 (IN PDC) JUNCTION BLOCK (RIGHT END OF DASH) LEFT HEADLAMP LO HI LT BLU WIRE LT GRN WIRE LT GRN/BLK WIRE OFF ORG/ WIRE PARK PNK/RED WIRE RED/GRY WIRE RED/ORG WIRE RED/WHT WIRE RIGHT FOG LAMP LEFT FOG LAMP RIGHT HEADLAMP VIO WIRE VIO/WHT WIRE

6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 LINE 1 LINE 1 LINE 2 9 10 CCD (-) CCD (+) AIR BAG CONTROL MODULE (BEHIND LOWER CENTER OF DASH) AIR BAG WARNING INDICATOR BLK WIRE BLK/LT BLU WIRE BLK/PNK WIRE BLU WIRE BRN WIRE BRN/YEL WIRE BUS (-) BUS (+) CLOCKSPRING DATA LINK CONNECTOR (DLC) (PARTIAL) (ON LEFT BOTTOM OF DASH) DK BLU WIRE DK BLU/YEL WIRE DK GRN WIRE DRIVER AIR BAG FUSE 19 GRN WIRE GROUND LINE 2 HOT IN RUN JUNCTION BLOCK (ON LEFT END OF DASH) FUSE 18 HOT IN RUN OR START IGNITION IGNITION INDICATOR DRIVER INSTRUMENT CLUSTER J/C 7 (LEFT SIDE OF DASH) J/C 8 (CENTER OF DASH) LINE 1 LINE 2 LINE 2 LT BLU WIRE LT GRN WIRE LT GRN/YEL WIRE NCA WIRE OFF INDICATOR PASSENGER AIR BAG LINE 1 PASSENGER AIR BAG ON/OFF SWITCH PNK WIRE RESISTOR FUSED VIO WIRE VIO/BRN WIRE VIO/YEL WIRE WHT WIRE WHT/BLK WIRE YEL WIRE

1 2 3 4 5 6 7 8 TRANS RLY OUT A/C COMP CL RLY A/C HIGH PRESSURE CUTOUT SWITCH (A/C HIGH PRESSURE LINE) A/C LOW PRESSURE CUTOUT SWITCH (A/C LOW PRESSURE LINE) A/C REQUEST A/C SELECT STOP LP SWITCH A/C SYSTEM A/T ASD RELAY SENS OD OFF SWITCH ASD RLY CTRL CRUISE VAC SOL CRUISE VNT SOL OD LAMP DRVR TRANS TEMP LAMP DRVR BATT TEMP SENS GEN IND DRVR MIL IND DRVR SRI LAMP DRVR BLK/LT BLU WIRE BLK/PNK WIRE BLK/WHT WIRE BRN WIRE BRN/WHT WIRE CRANKSHAFT POSITION SENSOR CAMSHAFT POSITION SENSOR CRUISE CONTROL SYSTEM DATA LINK CONNECTOR (LEFT I/P) DK BLU WIRE DK BLU/ORG WIRE DK BLU/YEL WIRE DK GRN WIRE DK GRN/ORG WIRE FUEL PRESS. GAUGE TACHO- METER FUSE 12 FUSE BLOCK GRN WIRE GRY/BLK WIRE GRY/LT BLU WIRE GRY/PNK WIRE HI PRESS FUEL SHUTOFF RLY CTRL HOT IN RUN OR START INSTRUMENT CLUSTER J/C C (BEHIND LEFT KNEE BOLSTER) LT GRN WIRE LT GRN/BLK WIRE LT GRN/ORG WIRE LT GRN/RED WIRE LT GRN/WHT WIRE M/T (NOT USED) MAINT REQ IND. MESSAGE CENTER ORG/ WIRE ORG/BLK WIRE ORG/DK BLU WIRE ORG/WHT WIRE OVERDRIVE SWITCH PNK WIRE PNK/BLK WIRE PNK/DK BLU WIRE PNK/YEL WIRE POWER DISTRI- BUTION CENTER POWERTRAIN CONTROL MODULE (RIGHT SIDE SAFETY WALL) RED WIRE RED/LT GRN WIRE RED/WHT WIRE SCI RECEIVE SCI TRANSMIT SENSOR GRD GOV PRESS SIG VAR FORCE SOL OVERDRV SOL TCC SOL CTRL TRANS TEMP SNS STOP LAMP SWITCH TACH SIGNAL SPD CTRL RESUME TAN/RED WIRE TAN/YEL WIRE THROTTLE POSITION SENSOR (SIDE OF THROTTLE BODY) TRANS- MISSION RELAY TRANSMISSION SOLENOID ASSEMBLY (ON TRANSMISSION) UPSHIFT IND. MIL IND. VEHICLE SPEED SENSOR VIO WIRE VIO/WHT WIRE W/ A/T WHT/ORG WIRE WHT/PNK WIRE YEL WIRE YEL/RED WIRE

1 2 3 4 5 6 7 8 TRANS RLY OUT A/C COMP RLY A/C HIGH PRESSURE CUTOUT SWITCH (A/C HIGH PRESSURE LINE) A/C LOW PRESSURE CUTOUT SWITCH (A/C LOW PRESSURE LINE) A/C REQUEST A/C SELECT IN BRAKE SW IN A/C SYSTEM AIR CONDITIONING SYSTEM AUTO SHT RLY CRUISE VAC SOL CRUISE VNT SOL OVERDRV IND TRANS TEMP IND BATT TEMP SENS GEN IND DRVR MIL IND DRVR SRI DRIVER FUEL PMP RLY EVAP SOL DRVR BATTERY TEMPER- ATURE SENSOR (BELOW BATTERY) BLK WIRE BLK/LT BLU WIRE BLK/ORG WIRE BLK/PNK WIRE BLK/RED WIRE BLK/WHT WIRE BRN WIRE BRN/WHT WIRE CAMSHAFT POSITION SENSOR (IN DISTRIBUTOR) CRUISE CONTROL SYSTEM CRUISE CONTROL SYSTEM CRUISE CONTROL SYSTEM CRUISE FEED ASD RELAY SENS TRANS OVERDRV DATA LINK CONNECTOR (LEFT I/P) DK BLU WIRE DK BLU/ORG WIRE DK BLU/WHT WIRE DK BLU/YEL WIRE DK GRN WIRE DK GRN/ORG WIRE DUTY CYCLE/ EVAP PURGE SOLENOID (REAR OF INTAKE MANIFOLD) ENGINE DIAGNOSTIC CONNECTOR FUEL LEVEL IN FUSE 8 FUSE 4 GEN IND LAMP GENERATOR GRY/LT BLU WIRE GRY/PNK WIRE GRY/WHT WIRE HOT AT ALL TIMES HOT IN RUN OR START FUSE BLOCK FUSE 11 INSTRUMENT CLUSTER INTAKE AIR TEMPER- ATURE SENSOR (RIGHT SIDE OF INTAKE MANIFOLD) JOINT CONNECTOR C (BEHIND LEFT KNEE BOLSTER) LOW FUEL SENS SCI TRANSMIT LT GRN WIRE LT GRN/BLK WIRE LT GRN/ORG WIRE LT GRN/RED WIRE LT GRN/WHT WIRE MESSAGE CENTER MIL IND LAMP ORG/ WIRE ORG/BLK WIRE ORG/DK BLU WIRE ORG/WHT WIRE OVERDRIVE SWITCH PNK WIRE PNK/BLK WIRE PNK/DK BLU WIRE PNK/YEL WIRE POWER DISTRIBUTION CENTER POWERTRAIN CONTROL MODULE (RIGHT SIDE SAFETY WALL) RED WIRE RED/LT GRN WIRE RED/WHT WIRE SCI RECEIVE SENSOR GRD GOV PRESS SIG VAR FORCE SOL OVERDRV SOL TCC SOL CTRL TRANS TEMP SNS STOP LAMP SWITCH (UNDER LEFT SIDE OF I/P) TACH SIGNAL TACH SIGNAL CRUISE SW IN TAN/RED WIRE TAN/YEL WIRE THROTTLE POSITION SENSOR (SIDE OF THROTTLE BODY) TRANS- MISSION RELAY TRANSMISSION SOLENOID ASSEMBLY (TRANSMISSION) UP SHIF IND VIO WIRE VIO/WHT WIRE WHT WIRE WHT/DK BLU WIRE WHT/PNK WIRE YEL/RED WIRE

1 2 3 4 5 6 7 8 TRANS RLY OUT AIR CONDI- TIONING SYSTEM AUTO SHT RLY CRUISE VAC SOL CRUISE VNT SOL BLK/LT BLU WIRE BLK/LT GRN WIRE BLK/RED WIRE BRN WIRE BRN/WHT WIRE CCD(-) CRUISE CONTROL SYSTEM CRUISE SW IN DATA LINK CONNECTOR (LEFT BOTTOM OF DASH) DK BLU WIRE DK BLU/ORG WIRE DK BLU/WHT WIRE DK BLU/YEL WIRE DK GRN WIRE DK GRN/ORG WIRE FUEL PMP RLY EVAP SOL DRVR FUSE 11 FUSE I GENERATOR HOT AT ALL TIMES HOT IN RUN OR START INSTRUMENT CLUSTER INTAKE AIR TEMPERATURE SENSOR (IN RIGHT FRONT SIDE OF INTAKE MANIFOLD) JOINT CONNECTOR 1 (IN PDC) JOINT CONNECTOR 11 9 2 14 6 5 JUNCTION BLOCK (RIGHT END OF DASH) LEAK DETECTION PUMP (RIGHT FRONT OF INNER FENDER) LT GRN/RED WIRE LT GRN/WHT WIRE NCA WIRE ORG/ WIRE ORG/BLK WIRE ORG/DK BLU WIRE ORG/WHT WIRE OVERDRIVE SWITCH PNK 1 2 WIRE PNK WIRE PNK/DK BLU WIRE PNK/WHT WIRE PNK/YEL WIRE POWER DISTRIBUTION CENTER (IN ENG COMPT, ON LEFT INNER FENDER PANEL) POWERTRAIN CONTROL MODULE (IN ENG COMPT, ON RIGHT SIDE OF FIREWALL) RED WIRE RED/LT GRN WIRE SENSOR GRD GOV PRESS SIG VAR FORCE SOL OVERDRV SOL TCC SOL CTRL TRANS TEMP SNS STOP LAMP SWITCH (ON BRAKE PEDAL BRACKET) TAN/RED WIRE THROTTLE POSITION SENSOR (ON THROTTLE BODY) TRANS- MISSION RELAY TRANSMISSION SOLENOID ASSEMBLY (ON LEFT SIDE OF TRANSMISSION) VIO WIRE VIO/BRN WIRE VIO/WHT WIRE WHT/BLK WIRE WHT/DK GRN WIRE WHT/PNK WIRE YEL/RED WIRE

A/C COMP RLY A/C HIGH PRESSURE CUTOUT SWITCH (A/C HIGH PRESSURE LINE) A/C LOW PRESSURE CUTOUT SWITCH (A/C LOW PRESSURE LINE) A/C REQUEST A/C SELECT IN BRAKE SW IN GENERATOR A/C SYSTEM AIR CONDITIONING SYSTEM (A/C-HEATER CONTROL SWITCH) AUTO SHT RLY CRUISE VAC SOL CRUISE VNT SOL OVERDRV IND TRANS TEMP IND BATT TEMP SENS GEN IND DRVR MIL IND DRVR WATER IN FUEL BATTERY TEMPER- ATURE SENSOR (BELOW BATTERY) BLK/LT BLU WIRE BLK/ORG WIRE BLK/PNK WIRE BLK/RED WIRE BLK/WHT WIRE BRN WIRE CRUISE CONTROL SYSTEM CRUISE FEED ASD RELAY SENS TRANS OVERDRV DATA LINK CONNECTOR DK BLU/ORG WIRE DK BLU/WHT WIRE DK BLU/YEL WIRE DK GRN WIRE DK GRN/ORG WIRE DK GRN/RED WIRE EGR DIAG FUSE 11 FUSE BLOCK GEN IND LAMP GENERATOR GRY/LT BLU WIRE HOT IN START OR RUN INSTRUMENT CLUSTER INSTRUMENT CLUSTER SYSTEM INTAKE AIR TEMPER- ATURE SENSOR (RIGHT SIDE OF INTAKE MANIFOLD) JOINT CONNECTOR C (BEHIND LEFT KNEE BOLSTER) LT GRN WIRE LT GRN/ORG WIRE LT GRN/RED WIRE LT GRN/WHT WIRE MIL IND LAMP NCA WIRE ORG/ WIRE ORG/BLK WIRE ORG/WHT WIRE OVERDRIVE SWITCH PNK 13 14 WIRE PNK WIRE PNK/BLK WIRE PNK/DK BLU WIRE PNK/DK GRN WIRE PNK/YEL WIRE POWER DISTRIBUTION CENTER POWERTRAIN CONTROL MODULE (RIGHT SIDE SAFETY WALL) RED WIRE RED/LT GRN WIRE SCI RECEIVE SCI TRANSMIT SPEEDOMETER STOP LAMP SWITCH (UNDER LEFT SIDE OF I/P) TACH SIGNAL TACH SIGNAL CRUISE SW IN TAN/ORG WIRE TAN/RED WIRE TAN/YEL WIRE TRANS- MISSION RELAY WATER IN FUEL SENSOR (BOTTOM OF FUEL FILTER) WHT/DK BLU WIRE WHT/ORG WIRE WHT/PNK WIRE YEL/RED WIRE

1 2 3 4 5 6 7 8 TRANS RLY OUT AIR CONDI- TIONING SYSTEM AIR CONDITIONING SYSTEM AUTO SHT RLY CRUISE VAC SOL CRUISE VNT SOL BLK/LT BLU WIRE BLK/LT GRN WIRE BLK/RED WIRE BRN WIRE BRN/VIO WIRE BRN/WHT WIRE CCD(-) CRUISE CONTROL SYSTEM CRUISE SW IN DATA LINK CONNECTOR (LEFT BOTTOM OF DASH) DK BLU WIRE DK BLU/ORG WIRE DK BLU/WHT WIRE DK BLU/YEL WIRE DK GRN WIRE DK GRN/ORG WIRE DK GRN/PNK WIRE DK GRN/WHT WIRE DK GRN/YEL WIRE DOWNSTREAM OXYGEN SENSOR RELAY FUEL PMP RLY EVAP SOL DRVR FUSE GENERATOR HOT AT ALL TIMES INSTRUMENT CLUSTER INTAKE AIR TEMPERATURE SENSOR (IN LEFT FRONT SIDE OF INTAKE MANIFOLD) JOINT CONNECTOR 1 (IN PDC) JOINT CONNECTOR 11 9 2 14 6 5 LEAK DETECTION PUMP (ON RIGHT FRONT OF INNER FENDER) LT GRN/RED WIRE LT GRN/WHT WIRE M/T ONLY ORG/ WIRE ORG/BLK WIRE ORG/DK BLU WIRE ORG/WHT WIRE OVERDRIVE SWITCH PNK WIRE PNK/DK BLU WIRE PNK/WHT WIRE PNK/YEL WIRE POWERTRAIN CONTROL MODULE (IN ENG COMPT, ON RIGHT SIDE OF FIREWALL) RED WIRE RED/LT GRN WIRE SENSOR GRD GOV PRESS SIG VAR FORCE SOL OVERDRV SOL TCC SOL CTRL TRANS TEMP SNS STOP LAMP SWITCH (ON BRAKE PEDAL BRACKET) TAN/RED WIRE THROTTLE POSITION SENSOR (ON THROTTLE BODY) TRANSMISSION RELAY FUSE I TRANSMISSION SOLENOID ASSEMBLY (ON LEFT SIDE OF TRANSMISSION) VIO WIRE VIO/BRN WIRE VIO/WHT WIRE WHT/BLK WIRE WHT/DK GRN WIRE WHT/PNK WIRE YEL WIRE YEL/RED WIRE