Dodge Pickup R2500 (1996-2010) hot at all times Wiring diagrams

10 9 34 35 BATT FD GND CAN 2 BUS (+) CAN 2 BUS (-) 27 20 SENS GND ECT SIGNAL 5 V SPLY A/C PRESS A/C PRESS GND A/C PRESS SIG A/C PRESS SNSR FD A/C PRESS SNSR RTN A/C PRESSURE TRANSDUCER (3.7L, 4.7L: TOP FRONT OF ENGINE) B(+) BLK WIRE BLK/LT BLU WIRE CAN 2 BUS (-) COMPUTER DATA LINES SYSTEM DK BLU WIRE DK BLU/DK GRN WIRE DK GRN DK BLU/ WIRE DK GRN WIRE DK GRN/DK BLU WIRE ENGINE CONTROLS SYSTEM FAN HIGH RADI- ATOR RELAY FUSE FAN LOW RADI- ATOR RELAY FAN RADIATOR HOT AT ALL TIMES HOT AT ALL TIMES FUSE LOW SPD LT BLU/BRN WIRE LT BLU/ORG WIRE POWERTRAIN CONTROL MODULE (3.7L, 4.7L: REAR OF ENGINE) RAD FAN RED WIRE SIG SIG HI SPD RAD FAN TOP OF ENGINE) TOTALLY INTEGRATED CIRCUIT BOARD POWER MODULE (LEFT FRONT OF ENGINE COMPT) VIO/ORG WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE

1 2 3 4 5 6 DSL HIGH SIDE DRVR RTN ENG CTRL COM SNSR RTN RAD FAN MTR SPD SIG 1 2 3 4 AUTO HEADLAMPS SIG SUN SENSOR SIG 1 SUN SENSOR SIG 2 SENSOR GROUND 1 4 3 IGN RUN CTRL OUT IR SENSOR RETURN IR SENSOR SIGNAL 30 53 17 52 ENG CTRL COM SNSR RTN ENG CTRL COM SNSR RTN 4 RAD FAN MTR SPD SIG 4 2 3 1 BLWR MTR HI DRV FT BLW FD BLWR CTRL GND 70 16 33 6 IGN ULK/RUN/STRT A/C CLUTCH A/C CLUTCH COIL A/C COMPRESSOR, CLUTCH (LEFT SIDE OF ENGINE) A/C HEATER CONTROL A/C PRESS SIG A/C PRESS SNSE RTN A/C PRESS SNSE RTN A/C PRESS SNSR FD A/C PRESS SIG 1 2 3 A/C PRESS SNSR FD A/C PRESSURE TRANSDUCER B(+) BLK WIRE BLK/LT BLU WIRE BLK/LT GRN WIRE BLK/TAN WIRE BLOWER MODULE BLOWER MOTOR (RIGHT SIDE OF DASH) BLW MTR SPLY BRN WIRE BRN/LT BLU WIRE BRN/ORG WIRE BRN/PNK WIRE BRN/WHT WIRE BUS (-) CAN CAN IHS BUS (-) CAN IHS BUS (+) IOD FD FUSED IGN RUN CTRL OUT COIL COMPUTER DATA LINES SYSTEM CTRL OUT DK BLU WIRE DK BLU/DK GRN WIRE DK BLU/GRY WIRE DK BLU/LT BLU WIRE DK BLU/LT GRN WIRE DK BLU/ORG WIRE DK BLU/PNK WIRE DK BLU/RED WIRE DK BLU/TAN WIRE DK BLU/WHT WIRE DK BLU/YEL WIRE DK GRN WIRE DRIVER BLEND DOOR ACTUATOR (ON HVAC UNIT) ENGINE CONTROLS SYSTEM ENGINE COOLANT TEMPERATURE SENSOR EVAP SIG EVAP SNSE RTN EVAPORATOR TEMPERATURE SENSOR (CENTER OF DASH) FAN RADIATOR HIGH RELAY FAN RADIATOR LOW RELAY FUSE HALLEFCT ELECN ENG SPD OUT HALLEFCT ELECN ENG SPD OUT ENG CTRL COM SNSR RTN 2 COOL TEMP SNSR SIG 65 20 40 HOT AT ALL TIMES HOT AT ALL TIMES FUSE HOT W/ RUN RELAY ENERGIZED INFRARED SENSOR LT BLU WIRE LT BLU/BRN WIRE LT BLU/ORG WIRE LT BLU/RED WIRE LT GRN WIRE MODE DOOR ACTUATOR 1 (ON HVAC UNIT) MODE DOOR ACTUATOR 2 (ON HVAC UNIT) NAVIGATION SYSTEM ORG/ WIRE PASSENGER BLEND DOOR ACTUATOR (ON HVAC UNIT) PNK/WHT WIRE PNK/YEL WIRE POWERTRAIN CONTROL MODULE RAD FAN RAD FAN LOW SPD SIG RADIATOR FAN RADIATOR FAN DRIVE RECIRCULATION DOOR ACTUATOR RED/WHT WIRE RUN/START SIG HI SPD SUN SENSOR TAN WIRE TOTALLY INTEGRATED POWER MODULE (LEFT FRONT OF ENGINE COMPT) CIRCUIT BOARD VIO/LT BLU WIRE VIO/ORG WIRE WHT/DK BLU WIRE WHT/GRY WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE WHT/ORG WIRE WHT/VIO WIRE

1 2 3 4 5 6 DSL HIGH SIDE DRVR RTN ENG CTRL COM SNSR RTN RAD FAN MTR SPD SIG 30 53 17 ENG CTRL COM SNSR RTN ENG CTRL COM SNSR RTN 4 RAD FAN MTR SPD SIG A/C PRESS PRESS SNS SNS SIG RTN FD A/C PRESS SIG A/C PRESS SNSE RTN A/C PRESS SNSR FD A/C PRESSURE TRANSDUCER BLK WIRE BLK/LT BLU WIRE BRN/LT BLU WIRE BRN/ORG WIRE BRN/PNK WIRE BRN/WHT WIRE BUS (-) CAN COMPUTER DATA LINES SYSTEM DK BLU/DK GRN WIRE DK BLU/GRY WIRE DK GRN/DK BLU WIRE ENGINE CONTROLS SYSTEM ENGINE COOLANT TEMPERATURE SENSOR FAN RADIATOR FUSE HALLEFCT ELECN ENG SPD OUT HALLEFCT ELECN ENG SPD OUT ENG CTRL COM SNSR RTN 2 COOL TEMP SNSR SIG HOT AT ALL TIMES IGN ULK/RUN/STRT 16 33 6 LT BLU/BRN WIRE LT BLU/ORG WIRE PNK/WHT WIRE PNK/YEL WIRE POWER MODULE (LEFT FRONT OF ENGINE COMPT) CIRCUIT BOARD POWERTRAIN CONTROL MODULE PRESS. RAD FAN HI SPD SIG RAD FAN LOW SPD SIG RADIATOR FAN DRIVE RADIATOR FAN HIGH RELAY RADIATOR FAN LOW RELAY RUN/START TOTALLY INTEGRATED VIO/ORG WIRE WHT/DK BLU WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE

3 1 BTSI SOL ULK TRS RNG PRK ABMT TEMP/FCM SSR RTN 1 AMBIENT AIR TEMPERATURE SENSOR (LEFT FRONT OF ENGINE COMPT) BATT FEED BLK WIRE BLK/WHT WIRE BRAKE TRANSMISSION SHIFT INTERLOCK SOLENOID BRN/YEL WIRE BUS BAR CIRCUIT FT BOARD DRV DR ULK DIODE DK GRN WIRE DOOR LOCK RELAY DR AJAR LT RR SIG DR AJAR RT RR SIG DR LK LT FT DR LK RT FT DR ULK RT FT DRIVER DOOR LATCH DRIVER DOOR UNLOCK RELAY DRV DR AJAR SW SNS DRV FT DR AJAR SW IN DRV RR UNLK CTRL FRONT WASHER FLUID LEVEL SENSOR FT LT DR ULK FUSE FUSE FUSE GRY/LT BLU WIRE GRY/YEL WIRE HOOD ABMT/ AJAR FCM SW SSR SNS RTN 1 HOOD AJAR SWITCH (LEFT FRONT OF ENGINE COMPT) HORN RELAY HORN RLY COIL DRV HORN SW SIG HORNS SYSTEM HOT AT ALL TIMES LEFT REAR DOOR LATCH (EXCEPT REGULAR CAB) LT GRN/GRY WIRE LT RR LK LT RR ULK PASS DR DR LOCK AJAR RLY SW SNS CTRL PASS FT DR AJAR SW IN PASSENGER DOOR LATCH PASSENGER DOOR UNLOCK RELAY POWER MODULE (LEFT FRONT OF ENGINE COMPT) RIGHT REAR DOOR LATCH (EXCEPT REGULAR CAB) RT RR LK RT RR LT RR DR DR AJAR AJAR SIG SIG RT RR ULK TAN/BRN WIRE TAN/DK BLU WIRE TAN/LT BLU WIRE TAN/LT GRN WIRE TAN/ORG WIRE TAN/VIO WIRE TAN/WHT WIRE TOTALLY INTEGRATED VIO WIRE VIO/BRN WIRE VIO/GRY WIRE VIO/LT BLU WIRE VIO/WHT WIRE VIO/YEL WIRE YEL/DK BLU WIRE

ACCY DLY RLY CTRL B(+) BATT PRE 2 BLK/LT GRN WIRE BRN/YEL WIRE BTSI SOL ULK CAN-BUS CIRCUIT BOARD CIRCUIT BREAKER 2 COMPUTER DATA LINES SYSTEM DK GRN/RED WIRE DRIVER DOOR MODULE DRIVER WINDOW/ DOOR LOCK SWITCH FT PASS DR LK SW SIG FT PASS SW ILLM/SNS RTN FT PASS UP SW SNSE FUSE HDLP RT RTN HEADLIGHTS SYSTEM HOT AT ALL TIMES IGN (RUN-START) IGN RUN ACC IGN SW IGN SW FD IGNITION WIRELESS NODE LIN BUS LIN SLVE RTN LT BLU/RED WIRE ORG/GRY WIRE ORG/LT GRN WIRE ORG/TAN WIRE PASSENGER DOOR MODULE PASSENGER WINDOW/ DOOR LOCK SWITCH PNK/WHT WIRE PNK/YEL WIRE REGULAR CAB EXCEPT RT LO BEAM FD RUN/ ACCESSORY DELAY RELAY STOP LAMP SWITCH (ON BRAKE PEDAL SUPPORT) STP LMP SIG SW ILLM FT PASS TOTALLY INTEGRATED POWER MODULE (LEFT FRONT OF ENGINE COMPT) TRANS RNG PARK VIO/LT GRN WIRE W/ SUNROOF WDW RUN/ACCY IGN WHT WIRE WHT/GRY WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE WHT/ORG WIRE WHT/TAN WIRE YEL/DK BLU WIRE

1 2 CAN IHS BUS (-) CAN IHS BUS (+) 1 7 3 9 CAN IHS BUS (-) CAN IHS BUS (+) CAN IHS BUS (-) CAN IHS BUS (+) 2 1 CAN IHS BUS(-) CAN IHS BUS(+) B(+) BLK/LT GRN WIRE BLK/TAN WIRE BUS - CAN C (-) DIAGNOSTIC CAN IHS (-) CAN IHS BUS (+) CAN IHS BUS (-) CAN IHS BUS (-) CAN-BUS CIRCUIT BOARD DRIVER DOOR MODULE EXCEPT 6.7L FUSE HEATED SEATS MODULE HOT AT ALL TIMES LT BLU WIRE MEMORY SEAT MODULE OCCUPANT RESTRAINT CONTROLLER MODULE (CENTER FRONT OF BODY) PASSENGER DOOR MODULE RADIO AMPLIFIER (IF EQUIPPED) RED/PNK WIRE STEERING ANGLE SENSOR (IF EQUIPPED) TOTALLY INTEGRATED POWER MODULE (LEFT FRONT OF ENGINE COMPT) TRAILER TOW MODULE W/ MEMORY W/O HEATED SEATS, MEMORY W/ HEATED SEATS, MEMORY WHT WIRE WHT/DK BLU WIRE WHT/DK GRN WIRE WHT/GRY WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE WHT/ORG WIRE WIRELESS IGNITION NODE

1 2 CAN IHS BUS (-) CAN IHS BUS (+) 3 4 DRV HEATED MIR RTN DRV HEATED MIR FD 3 4 PASS HEATED MIR RTN PASS HEATED MIR FD A/C HEATER CONTROL B(+) BLK WIRE CAN C IHS BUS (+) CAN IHS BUS (-) CIRCUIT BOARD COMPUTER DATA LINES SYSTEM DRIVER DOOR MODULE DRIVER OUTSIDE REARVIEW MIRROR (LEFT SIDE OF DASH) ELECTRIC CAN BKLT IHS FD BUS (+) ELECTRIC HEATED BACKLITE GRY WIRE HOT AT ALL TIMES ORG/ WIRE PASSENGER DOOR MODULE PASSENGER OUTSIDE REARVIEW MIRROR TOTALLY INTEGRATED POWER MODULE (LEFT FRONT OF ENGINE COMPT) WHT WIRE WHT/GRY WIRE WHT/ORG WIRE

1 2 3 4 5 6 7 8 9 10 LIN BUS LIN BUS RTN EC MRR RTN 1 2 3 4 5 6 7 8 9 10 MRR PDDLE LMP DRV MRR TURN PUDDLE BATT FD DRIV BATT FD DRIV 1 2 3 4 5 6 7 8 9 10 BLK WIRE BLK/DK GRN WIRE BLK/GRY WIRE BLK/ORG WIRE BRN WIRE BRN/BLK WIRE COMPUTER DATA LINES SYSTEM DK BLU WIRE DK GRN WIRE DK GRN/BLK WIRE DRIV HEATD MRR FD DRIV HEATD MRR RTN DRIV HEATD MRR FD DRIVER DOOR MODULE DRIVER OUTSIDE REARVIEW MIRROR DRIVER WINDOW DN DRIVER WINDOW MOTOR DRV MEM MRR VERT SNSE DRV MEM MRR SNSE COM DRV MEM MRR HORZ SNSE DRV MRR MEM HORZ SNSE DRV PWR MRR DRV WINDOW EC MRR RTN FUSE FUSE POWER MODULE (LEFT FRONT OF ENGINE COMPT) GRY WIRE GRY/BLK WIRE HOT AT ALL TIMES INSIDE REARVIEW MIRROR MEM SEL MUX MEM SEL MUX MEM SEL SNSE RTN MEM SEL SNSE RTN MEMORY SET SWITCH (IF EQUIPPED) MRR PDDLE LMP DRV MRR RTN DRIV HEATD MRR SIG OUTSDE EC MRR TURN MRR TURN PUDDLE RTN DRIV MTR COM MTR HORZ MTR VERT ORG/ WIRE ORG/LT GRN WIRE ORG/WHT WIRE RED WIRE RED/LT BLU WIRE RED/LT GRN WIRE RTN DRIV RTN DRIV 1 2 3 4 CAN IHS BUS (-) CAN IHS BUS (+) OUTSDE EC MRR SIG GND SENS RTN SENS SIG DRV WINDOW SENS SPLY DRV WINDOW SIG DRIV SNSE COM DRV MEM MRR TAN/ORG WIRE TAN/WHT WIRE TOTALLY INTEGRATED VERT SNSE DRV MEM MRR VIO WIRE VIO/BRN WIRE VIO/YEL WIRE WHT WIRE WHT/GRY WIRE WHT/LT GRN WIRE WHT/ORG WIRE WINDOW UP

5.7L CREW CAB) 7 WAY TRAILER TOW WIRING (AT TRAILER HITCH) B(+) BACKUP LAMPS CIRCUIT BATT FD BLK WIRE BLK/DK GRN WIRE BLK/TAN WIRE BRAKE PROVISION MODULE (LEFT SIDE OF DASH) BRN WIRE CAN BUS (+) 2 CARGO LAMP CENTER HIGH MOUNTED CENTER HIGH MOUNTED STOP CIRCUIT BOARD COMPUTER DATA LINES SYSTEM CTRL RT TTOW RLY DK GRN WIRE ELEC BRK FD ENGINE COMPT) FUSE FUSE HOT AT ALL TIMES HOT W/ RUN/ START RELAY ENERGIZED IGN RS ITBM BRAKE PROVISION MODULE LMP SIG TTOW PRK LT GRN/RED WIRE PNK/LT GRN WIRE RED/VIO WIRE STOP LAMP (AFTERMARKET) STOP LAMP SWITCH (ON BRAKE PEDAL SUPPORT) STOP LP SIG STP LMP SIG TOTALLY INTEGRATED POWER MODULE (LEFT FRONT OF TRAILER TOW MODULE TTOW RLY CTRL LT WHT WIRE WHT/DK GRN WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE WHT/ORG WIRE WHT/RED WIRE WHT/VIO WIRE WIRELESS IGNITION NODE YEL/RED WIRE

A/C CLTCH IGN COIL RUN/STRT RS FUSE ANTI-LOCK BRAKES SYSTEM AUTO SHUTDOWN RELAY BLK/GRY WIRE BRN WIRE BRN/BLK WIRE BRN/DK GRN WIRE BRN/GRY WIRE BRN/LT BLU WIRE BRN/WHT WIRE BRN/YEL WIRE CAN BUS IHS(-) CAT INTK CAT OUT CIRCUIT BOARD COMPUTER DATA LINES SYSTEM CTRL COM DK BLU/DK GRN WIRE DK BLU/ORG WIRE DK BLU/WHT WIRE DK GRN WIRE DK GRN/BRN WIRE DK GRN/DK BLU WIRE DK GRN/LT BLU WIRE DK GRN/ORG WIRE DK GRN/WHT WIRE DK GRN/YEL WIRE ENG CTRL RUN/ STP STRT IGN ULK/ LVL LMP IGN RTN SIG RS SIG EXHAUST TEMPERATURE SENSOR 1/1 EXHAUST TEMPERATURE SENSOR 1/2 EXHAUST TEMPERATURE SENSOR 1/3 EXHAUST TEMPERATURE SENSOR 1/4 EXHST GAS FUEL FUEL LVL SNDR SNSR IGN FUEL LVL FUEL PMP FUEL PMP RLY FD ASD TO CTRL SEC FD 4 RLY FUEL PUMP MODULE FUEL PUMP RELAY FUEL SNDR FUSE FUSE FUSE HOT AT ALL TIMES HOT AT ALL TIMES TOTALLY INTEGRATED POWER MODULE (LEFT FRONT OF ENGINE COMPT) LT BLU/ORG WIRE LT GRN/RED WIRE LT GRN/TAN WIRE LVL SIG MTR FD ORG RED/ WIRE PNK WIRE PNK/ LT GRN WIRE PNK/GRY WIRE PNK/LT GRN WIRE PNK/WHT WIRE RED WIRE RED/ORG WIRE SNSR RTN TEMP TEMP 4 PRE TEMP POST TRANSMISSION CONTROL RELAY TURBINE SIG VIO/ORG WIRE WHT WIRE WHT/GRY WIRE WHT/ORG WIRE YEL WIRE YEL/BRN WIRE YEL/DK BLU WIRE YEL/DK GRN WIRE YEL/GRY WIRE YEL/LT BLU WIRE YEL/ORG WIRE YEL/TAN WIRE YEL/WHT WIRE