Dodge Pickup R2500 (1996-2010) hot at all times Wiring diagrams

1 2 3 4 AUTO HEADLAMPS SIG SUN SENSOR SIG 1 SUN SENSOR SIG 2 SENSOR GROUND 1 4 3 IGN RUN CTRL OUT IR SENSOR RETURN IR SENSOR SIGNAL 10 9 34 35 FUSED B(+) GND CAN BUS (+) CAN BUS (-) 27 20 SENS GND ECT SIG 4 2 3 1 BLWR MTR HI DRV FT BLW FD BLWR CTRL GND A/C CLUTCH COIL A/C CLUTCH CTRL OUT A/C COMPRESSOR CLUTCH (3.7L, 4.7L: FRONT OF ENGINE) A/C HEATER CONTROL A/C PRESS A/C PRESS SNSE RTN A/C PRESS SNSR FD A/C PRESS SIG A/C PRESS SNSR FD B(+) BLK WIRE BLK/LT BLU WIRE BLK/LT GRN WIRE BLK/TAN WIRE BLOWER MODULE BLOWER MOTOR (RIGHT SIDE BRN WIRE CAN 2 BUS (-) CAN IHS BUS (-) CAN IHS BUS (+) IOD FD FUSED IGN RUN CTRL OUT CIRCUIT BOARD CLUTCH A/C COIL COMPUTER DATA LINES SYSTEM DK BLU WIRE DK BLU/DK GRN WIRE DK BLU/GRY WIRE DK BLU/LT BLU WIRE DK BLU/LT GRN WIRE DK BLU/ORG WIRE DK BLU/PNK WIRE DK BLU/RED WIRE DK BLU/TAN WIRE DK BLU/WHT WIRE DK BLU/YEL WIRE DK GRN/DK BLU WIRE DRIVER BLEND MODE DOOR DOOR ACTUATOR ACTUATOR 1 (ON HVAC UNIT) (ON HVAC UNIT) ENGINE CONTROLS SYSTEM EVAP SIG EVAP SNSE RTN EVAPORATOR TEMPERATURE SENSOR (CENTER OF DASH) FAN RADIATOR HIGH RELAY FAN RADIATOR LOW RELAY FUSE FUSE FUSE HI SPD RAD FAN HOT AT ALL TIMES HOT W/ RUN RELAY ENERGIZED INFRARED SENSOR LOW SPD SIG LT BLU WIRE LT BLU/BRN WIRE LT BLU/ORG WIRE LT BLU/RED WIRE LT GRN WIRE MODE DOOR ACTUATOR 2 (ON HVAC UNIT) NAVIGATION SYSTEM OF DASH) ORG/ WIRE PASSENGER BLEND DOOR ACTUATOR (ON HVAC UNIT) PNK/YEL WIRE POWERTRAIN CONTROL MODULE (3.7L, 4.7L: REAR OF ENGINE) RAD FAN RADIATOR FAN RECIRCULATION DOOR ACTUATOR RED WIRE RED/WHT WIRE SIG SNSE RTN A/C PRESS SPLY BLW MTR SUN SENSOR TAN WIRE TOP OF ENGINE) TOTALLY INTEGRATED POWER MODULE (LEFT FRONT OF ENGINE COMPT) TRANSDUCER) VIO/LT BLU WIRE VIO/ORG WIRE WHT/GRY WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE WHT/ORG WIRE WHT/VIO WIRE

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 GND 1 2 SENS GND SENS SIG 10 34 35 9 BATT FD C BUS (+) C BUS (-) GND 27 20 ECT SIG SENS GND A/C A/C CLUTCH A/C A/C PRESS CTRL PRESS CLUTCH OUTPUT COIL A/C CLUTCH COIL A/C COMPRESSOR CLUTCH (3.7L, 4.7L: FRONT OF ENGINE) A/C HEATER CONTROL A/C PRESS SIG A/C PRESS SNS RTN A/C PRESS SNS SNS SIGNAL RTN FD A/C PRESS SNSR FD A/C PRESSURE TRANSDUCER (3.7L, 4.7L: TOP FRONT OF ENGINE) AUTO HDLP SIG B(+) BLK WIRE BLK/LT BLU WIRE BLK/LT GRN WIRE BLK/TAN WIRE BLOWER MOTOR (RIGHT SIDE OF DASH) BLOWER MOTOR RESISTOR (RIGHT SIDE OF DASH) BLWR CAN 2 CAN 2 MTR BUS (+) BUS (-) SPLY CIRCUIT BOARD COMMON DOOR DRIVER 2 MODE DOOR 2 DRIVER COMPUTER DATA LINES SYSTEM DK BLU WIRE DK BLU/BRN WIRE DK BLU/DK GRN WIRE DK BLU/GRY WIRE DK BLU/LT BLU WIRE DK BLU/LT GRN WIRE DK BLU/ORG WIRE DK BLU/PNK WIRE DK BLU/RED WIRE DK BLU/TAN WIRE DK BLU/VIO WIRE DK BLU/YEL WIRE DK GRN/DK BLU WIRE DRIVER BLEND DOOR ACTUATOR (ON HVAC UNIT) ENGINE CONTROLS SYSTEM EVAP SNSE RTN EVAP SNSE RTN AUTO HDLP SIG EVAP TEMP SENS SIG EVAP SNSE RTN EVAPORATOR TEMPERATURE SENSOR (CENTER OF DASH) FAN RADIATOR HIGH RELAY FAN RADIATOR LOW RELAY FRONT MODE DOOR ACTUATOR FUSE FUSE FUSE HOT AT ALL TIMES HOT W/ RUN RELAY ENERGIZED IOD FD IGN R LT BLU/BRN WIRE LT BLU/ORG WIRE LT BLU/RED WIRE MODE DOOR ACTUATOR 2 (ON HVAC UNIT) PNK/YEL WIRE POWER MODULE (LEFT FRONT OF ENGINE COMPT) POWERTRAIN CONTROL MODULE (3.7L, 4.7L: REAR OF ENGINE) RAD FAN HI SPD SIG RAD FAN LOW SPD SIG RADIATOR FAN RED WIRE RED/WHT WIRE SUN SENSOR TOP OF ENGINE) TOTALLY INTEGRATED VIO/ORG WIRE WHT/GRY WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE WHT/ORG WIRE WHT/VIO WIRE

B(+) MODE SENS SENS A RTN BLK WIRE BLK/YEL WIRE HOT AT ALL TIMES MODE SENS A POWER WAGON EXCEPT HD HD EXCEPT POWER WAGON SENS RTN GND TOTALLY INTEGRATED POWER MODULE (AT LEFT FRONT FENDER) ELECTRONICS TRANSFER CASE POSITION SENSOR VIO/YEL WIRE WHT/DK GRN WIRE

B(+) MODE SENS A BLK WIRE BLK/YEL WIRE GROUND HOT AT ALL TIMES MODE SENS A SENS RTN TOTALLY INTEGRATED POWER MODULE (LEFT FRONT FENDER) ELECTRONICS TRANSFER CASE POSITION SENSOR VIO/YEL WIRE WHT/DK GRN WIRE

17 18 CAN B BUS(+) CAN B BUS(-) 33 42 28 27 APPS 1 RTN 36 37 6 25 SPEED CTRL BRAKE SW 4 5 1 21 CAN C BUS (+) CAN C BUS (-) 44 45 33 35 48 3 SPD SENS SIG SENS GND 6.7L 5.9L ACCEL ACCELERATOR PEDAL POSITION SENSOR (LEFT SIDE OF DASH) APPS 1 SIG APPS 1 RTN APPS 2 RTN APPS 2 SIG APPS 2 SIG APPS 2 RTN APPS 1 SIG BLK WIRE BLU WIRE BRN WIRE BRN/VIO WIRE BRN/WHT WIRE BRN/YEL WIRE CAN C BUS (+) CLUSTER COMPUTER DATA LINES SYSTEM DECEL DK BLU WIRE DK BLU/DK GRN WIRE DK GRN WIRE DK GRN/BRN WIRE DK GRN/ORG WIRE DK GRN/VIO WIRE DK GRN/WHT WIRE ENGINE CONTROL MODULE (LOWER LEFT FRONT OF ENGINE BLOCK) FUSE 28 GRN WIRE GRY WIRE HOT AT ALL TIMES HOT AT ALL TIMES TOTALLY INTEGRATED POWER MODULE (LEFT FRONT FENDER) FUSE 26 INPUT SPEED SENSOR (LEFT SIDE OF TRANSMISSION) LEFT SPEED CONTROL SWITCH OFF ORG/ WIRE OUTPUT SPEED SENSOR (5.9L) (BOTTOM OF TRANSMISSION) OUTPUT SPEED SENSOR (LEFT REAR OF TRANSMISSION) PNK EXTERIOR LIGHTS SYSTEM WIRE PNK WIRE REAR OF ENGINE COMPT) RED WIRE RESUME RIGHT SPEED CONTROL SWITCH SENS GND SENS GND S/C SW RTN S/C SW 1 SIG S/C SW 2 SIG 33 40 56 46 56 SENS SIG STEERING CONTROL MODULE (ON STEERING COLUMN) STOP LAMP SWITCH (ON BRAKE PEDAL SUPPORT) TAN WIRE TRANSMISSION CONTROL MODULE VIO WIRE VIO/BRN WIRE VIO/ORG WIRE VIO/YEL WIRE WHT WIRE WHT/BRN WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE WHT/ORG WIRE YEL WIRE YEL/DK BLU WIRE

6 10 (5.9L) (6.7L) A/T AAT RETURN AUXILIARY BATTERY B(+) BATTERY BLK WIRE BLK/GRY WIRE BRN WIRE CAN B BUS (+) CHARGING CIRCUIT CLUTCH INTERLOCK SWITCH (LEFT SIDE OF DASH) COMPUTER DATA LINES SYSTEM DK BLU WIRE ELECTRONICS ENGINE CONTROL MODULE (LOWER LEFT FRONT OF ENGINE BLOCK) EXCEPT RAM 3500 (CAB CHASSIS) FUSE 10 FUSE 11 FUSE 22 FUSED FUSED B (+) GRY WIRE GRY/RED WIRE HOLD-IN HOOD AJAR SWITCH HOOD AJAR SWITCH SENSE HOT AT ALL TIMES IGN SW GND B(+) OUT (START) IGN SW SENSE IGNITION SWITCH LEFT FRONT FENDER) LT BLU WIRE M/T ORG/ WIRE PULL- IN RAM 3500 (CAB CHASSIS) RED WIRE SENSE SNS STARTER STARTER MTR CTRL OUTPUT TAN WIRE TOTALLY INTEGRATED POWER MODULE TRANSMISSION RANGE SENSOR (LEFT SIDE OF TRANSMISSION) TRANSMISSION SOLENOID/TRS ASSEMBLY (RFE) (LEFT SIDE OF TRANSMISSION) TRS VIO WIRE VIO/BRN WIRE VIO/LT BLU WIRE VIO/TAN WIRE WHT WIRE WHT/ORG WIRE WIRELESS CONTROL MODULE YEL WIRE

B(+) MODE SENS SENS A RTN BLK WIRE BLK/YEL WIRE HOT AT ALL TIMES MODE SENS A RAM 2500 RAM 3500 (CAB CHASSIS) SENS RTN GND TOTALLY INTEGRATED POWER MODULE (AT LEFT FRONT FENDER) ELECTRONICS TRANSFER CASE POSITION SENSOR (TOP OF TRANSFER CASE) VIO/YEL WIRE WHT/DK GRN WIRE

34 35 35 18 CAN BUS(+) CAN BUS(-) 7 WAY TRAILER TOW WIRING (AT TRAILER HITCH) B(+) CAN CAN LAMP BUS 2 BUS 2 FEED (+) (-) BLK WIRE COMPUTER DATA LINES SYSTEM DK GRN/DK BLU WIRE DK GRN/LT BLU WIRE DK GRN/RED WIRE DK GRN/YEL WIRE EXCEPT 6.7L 6.7L GRY WIRE HOT AT ALL TIMES INSIDE REAR VIEW MIRROR LEFT TAIL LAMP ASSEMBLY LT BLU WIRE LT GRN WIRE POWERTRAIN CONTROL MODULE (RIGHT REAR OF ENGINE COMPT) RED WIRE RIGHT BACKUP LAMP RIGHT TAIL LEFT LAMP BACKUP ASSEMBLY LAMP WHT WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE WHT/RED WIRE

2 1 CAN IHS BUS(-) CAN IHS BUS(+) B(+) BLK WIRE BLK/BRN WIRE BLK/LT GRN WIRE BLK/TAN WIRE BLK/WHT WIRE BRAKE FLUID LEVEL SENSOR (LEFT REAR OF ENGINE COMPT) CAN IHS CAN IHS SW SIG BUS (-) BUS (+) CAN-BUS CLUSTER COMPUTER DATA LINES SYSTEM DK GRN/ORG WIRE DK GRN/WHT WIRE DRIVER DOOR LATCH DRIVER SEAT BELT BUCKLE SWITCH DRV SEAT BELT BUCKLE SW GND DRV SEAT BELT BUCKLE SW SEN ERS AUTOSTIC SWITCH (W/ COLUMN SHIFT) EXCEPT 6.7L FUSE FUSED B(+) FUSED IGN RUN/START CONT OUT GROUND HDLP FOG LAMP SW HEADLAMP SWITCH HOT AT ALL TIMES LEFT REAR DOOR LATCH (EXCEPT REGULAR CAB) LT GRN WIRE LT GRN/ BLK WIRE LT GRN/GRY WIRE LT GRN/TAN WIRE MLFNCT SW RTN OCCUPANT RESTRAINT CONTROLLER MODULE (CENTER FRONT OF BODY) PARK BRK SW PARKING BRAKE SWITCH (TOP OF PARKING BRAKE PEDAL) PASS AJAR SW JN PASSENGER DOOR LATCH PNK/LT GRN WIRE RED/GRY WIRE RIGHT REAR DOOR LATCH (EXCEPT REGULAR CAB) RR LR BRAKE AJAR AJAR FLUID SW SW SIG SW RTN VIO WIRE VIO/GRY WIRE VIO/WHT WIRE VIO/YEL WIRE WHT WIRE WHT/GRY WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE WHT/ORG WIRE WHT/YEL WIRE

BLK WIRE CAN IHS BUS (-) CLUSTER COMPUTER DATA LINES SYSTEM FUSE HOT AT ALL TIMES MOD FSED BATT FD RED/LT BLU WIRE TIRE PRESSURE MODULE TOTALLY INTEGRATED POWER MODULE (LEFT FRONT OF ENGINE COMPT) WHT/GRY WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE WHT/ORG WIRE