Dodge Pickup R2500 (1996-2010) grn Wiring diagrams

AUTOMATIC SHUT DOWN RELAY BLK WIRE BLK/LT BLU WIRE BLK/WHT WIRE BLU WIRE BRN WIRE ENGINE COOLANT TEMPERATURE SENSOR (NEAR THERMOSTAT) ENGINE STARTER MOTOR RELAY FUEL PUMP RELAY FUSE 3 FUSE 8 FUSE 9 FUSE BLOCK GOVERNOR PRESSURE SIGNAL VARIABLE FORCE SOLENOID CONTROL GRN WIRE HOT AT ALL TIMES IGNITION SWITCH INSTRUMENT CLUSTER (SPEEDOMETER) LT BLU WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/WHT WIRE OFF ORG/ WIRE ORG/BLK WIRE ORG/DK BLU WIRE OVERDRIVE SOLENOID CONTROL TORQUE CONVERTER CLUTCH SOLENOID CONTROL PNK WIRE POWER DISTRIBUTION CENTER RED WIRE RED/WHT WIRE RUN WIRE SENSOR GROUND 5 VOLT SUPPLY TAN WIRE TAN/BLK WIRE THROTTLE POSITION SENSOR (ON THROTTLE BODY) TRANS CTRL RLY OUTPUT PARK/ NEUTRAL POSITION SWITCH (LEFT SIDE OF TRANSMISSION) TRANSMISSION RELAY TRANSMISSION SOLENOID ASSEMBLY (ON SIDE OF TRANSMISSION) TRANSMISSION TEMPERATURE SENSOR SIGNAL VEHICLE SPEED CONTROL/HORN SWITCH VEHICLE SPEED SENSOR (REAR OF TRANSMISSION) VIO WIRE VIO/WHT WIRE WHT WIRE WHT/ORG WIRE

3.7L/4.7L/5.7L 4.7L,5.7L 3.7L,5.9L,8.0L 5.9L/8.0L B(+) BATTERY BLK WIRE BLK/GRY WIRE BLU WIRE DK BLU WIRE DK DK DK GRN WIRE FUSE 19 FUSED B (+) FUSIBLE LINK (4 GA- GEN FIELD GEN FIELD GEN SOURCE GENERATOR GRN WIRE GRY WIRE INTEGRATED POWER MODULE (ON LEFT FRONT FENDER) LEAK DETECTION PUMP (LEFT MIDDLE OF CHASSIS) LT GRN WIRE POWERTRAIN CONTROL MODULE (ON RIGHT SIDE OF FIREWALL) RED WIRE STARTER MOTOR TRANSMISSION CONTROL RELAY WHT WIRE WHT/DK BLU WIRE

3.7L 4.7L/5.7L 5.9L/8.0L 8.0L A/T BATTERY BLK WIRE BRN WIRE BRN/YEL WIRE CLUTCH INTERLOCK BRAKE SWITCH (M/T) (ABOVE CLUTCH PEDAL, ON SUPPORT BRACKET) EXCEPT 8.0L FUSE 14 FUSE 20 GRN WIRE HOLD-IN IGNITION SWITCH INTEGRATED POWER MODULE LEFT FRONT FENDER) LOCK OFF M/T ORG/ WIRE POWERTRAIN CONTROL MODULE (ON RIGHT SIDE OF FIREWALL) RELAY CTRL P/N SW SNS PULL- IN RED WIRE RUN WIRE STARTER MOTOR STARTER MOTOR RELAY TRANSFER CASE CONTROL MODULE P/N SW SNS TRANSMISSION RANGE SENSOR (ON LEFT SIDE OF TRANSMISSION) P/N SW SNS TRANSMISSION SOLENOID/ TRS ASSEMBLY (INSIDE TRANSMISSION) P/N SW SNS YEL WIRE

1 2 3 4 GROUND PANEL LAMPS DRIVER ESP ON/OFF SENSE SENSOR GROUND 1 2 3 6 IGN SW OUT (RUN-START) DYNAMICS HIGH DATA DYNAMICS LOW DATA GROUND 17 18 10 CAN B BUS (+) CAN B BUS (-) SENSOR GROUND 35 34 CAN C BUS (-) CAN C BUS (+) 43 44 45 46 RH RR WHEEL SPD SENS (+) RH RR WHEEL SPD SENS (-) GROUND 5.9L 6.7L ANTI-LOCK BRAKES MODULE (LEFT REAR OF ENGINE COMPT) B(+) BLK WIRE BLK/DK GRN WIRE BLK/LT GRN WIRE BLK/ORG WIRE BLK/PNK WIRE BRAKE FLUID LEVEL SENSOR (LEFT REAR OF ENGINE COMPT) BRAKE SWITCH 1 SIGNAL BRAKE SWITCH 1 SIGNAL CAN C BUS (+) BRK FLUID LEVEL SW SENSE CAN B CAN B BUS (+) BUS (-) CAN C BUS (+) CAN C CAN C BUS (+) BUS (-) CLUSTER COMPUTER DATA LINES SYSTEM DIESEL DK DK DK GRN WIRE DK GRN/BRN WIRE DK GRN/LT BLU WIRE DK GRN/LT GRN WIRE DK GRN/ORG WIRE DK GRN/RED WIRE DK GRN/TAN WIRE DK GRN/VIO WIRE DK GRN/WHT WIRE DK GRN/YEL WIRE DYNAMICS SENS HIGH DATA DYNAMICS SENS LOW DATA DYNAMICS SENSOR (W/ ESP) (UNDER FRONT OF CENTER CONSOLE) ELECTRONICS ENGINE CONTROL MODULE (LOWER LEFT FRONT OF ENGINE BLOCK) ESP ON/OFF SENSE ESP SWITCH (IF EQUIPPED) FUSE 13 FUSE 18 FUSE 28 FUSE 30 FUSED B (+) CAN C BUS + FUSED B (+) IGN SW OUT (RUN-START) FUSED IGN SW OUT (RUN-START) GAS GRN WIRE GRN/GRY WIRE GROUND GRY WIRE HOT AT ALL TIMES HOT IN RUN OR START IGN SW OUT (RUN-START) CAN C BUS (+) CAN C BUS (-) GROUND LEFT FRONT ABS WHEEL SPEED SENSOR (LEFT REAR OF ENGINE COMPT) LEFT REAR ABS WHEEL SPEED SENSOR LF WHEEL SPD SENSOR (+) LF WHEEL SPD SENSOR (-) LT BLU WIRE LT GRN WIRE ORG/ WIRE ORG/DK BLU WIRE PANEL LAMPS DRIVER PNK WIRE PNK/ (EXCEPT ESP/5.7L POWER WAGON, 6.7L EXCEPT SHIFT ON THE FLY) WIRE PNK/GRY WIRE PNK/LT GRN WIRE POWERTRAIN CONTROL MODULE (RIGHT REAR OF ENGINE COMPT) REAR ABS WHEEL SPEED SENSOR (W/O ESP) (NEAR RIGHT REAR FRAME RAIL) RED WIRE RF WHEEL SPD SENSOR (+) RF WHEEL SPD SENSOR (-) RIGHT FRONT ABS WHEEL SPEED SENSOR (ON KNUCKLE SPINDLE ASSEMBLY) RIGHT REAR ABS WHEEL SPEED SENSOR (W/ ESP) (AT RIGHT REAR WHEEL ASSEMBLY) STEERING ANGLE SENSOR (W/ ESP) STOP LAMP SWITCH (ON BRAKE PEDAL SUPPORT) TAN WIRE TAN/RED WIRE TOTALLY INTEGRATED POWER MODULE (AT LEFT FRONT FENDER) TRAILER TOW DAMPING RLY CTRL VIO WIRE VIO/DK BLU WIRE W/ ESP W/O ESP WHT WIRE WHT/GRY WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE WHT/ORG WIRE YEL WIRE

14 23 SPEED CTRL BRAKE SW 27 29 21 15 28 6 38 SENS GND 5.7L 6 9 AWAL RWAL ACCEL ANTI-LOCK BRAKES MODULE (LEFT REAR BRAKE SW 1 SIG BLK WIRE BRAKE SW 1 SIG BRN WIRE BRN/DK BLU WIRE BRN/DK GRN WIRE BRN/ORG WIRE CLOCKSPRING (ON STEERING COLUMN) DECEL DK BLU WIRE DK BLU/DK GRN WIRE DK GRN WIRE DK GRN/WHT WIRE DUMP ENGINE COMPT) ENGINE CONTROL MODULE (5.9L DIESEL) (LOWER LEFT FRONT OF ENGINE BLOCK) EXCEPT 5.7L EXCEPT SRT-10 FUSE 26 FUSE 28 GAS DIESEL GRN WIRE GRY WIRE HOT AT ALL TIMES HOT IN ON OR START IGN SW OUT SENS GND LEFT SPEED CONTROL SWITCH OF ENGINE COMPT) OFF ORG/ WIRE PNK WIRE PNK/GRY WIRE PNK/YEL WIRE POWERTRAIN CONTROL MODULE (RIGHT REAR OF ENGINE COMPT) RED WIRE RES- UME RIGHT SPEED CONTROL SWITCH S/C SW 1 SIG SENSOR GND SPEED CONTROL SERVO (EXCEPT 5.7L) (LEFT SIDE OF SRT-10 SRT-10 DIESEL STOP LAMP SWITCH (ON BRAKE PEDAL SUPPORT) TAN WIRE TAN/ORG WIRE TAN/YEL WIRE THROTTLE BODY (5.7L) (ON TOP OF ENGINE) TOP OF TRANSMISSION) TOTALLY INTEGRATED POWER MODULE (AT LEFT FRONT FENDER) TP 1 SIG TP SENSOR TP 2 SIG ETC MOTOR(+) ETC MOTOR(-) VACUUM VENT VIO WIRE VIO/BRN WIRE VIO/ORG WIRE VIO/WHT WIRE VIO/YEL WIRE WHT WIRE YEL WIRE

1 2 CCD BUS (+) CCD BUS (-) 14 16 17 MUX CTRL CCD (+) CCD (-) AMP L REAR SPKR (+) AMP R REAR SPKR (-) AMP TWEETER SPKR (+) ANTENNA BLK WIRE BLK/LT GRN WIRE BLK/RED WIRE BLK/VIO WIRE BLK/YEL WIRE BRN/LT BLU WIRE BRN/RED WIRE BRN/YEL WIRE CENTRAL TIMER MODULE (LEFT SIDE OF DASH, INBOARD OF STEERING COLUMN OPENING) CLOCK SPRING 1 DK BLU WIRE DK BLU/ORG WIRE DK BLU/RED WIRE DK BLU/WHT WIRE DK GRN WIRE FUSE 12 FUSE 4 FUSE 8 GRN WIRE GROUND HOT AT ALL TIMES HOT IN RUN OR ACC JOINT CONNECTOR 5 (LEFT SIDE OF DASH) JOINT CONNECTOR 6 (LEFT SIDE OF DASH) JOINT CONNECTOR 7 (BEHIND LEFT SIDE OF DASH) JUNCTION BLOCK (LEFT END OF DASH) L FRONT SPKR - L REAR SPKR - LEFT FRONT DOOR SPEAKER LEFT REAR SPEAKER LEFT REMOTE RADIO SWITCH LEFT TWEETER SPEAKER LF SPKR (-) RF SPKR (-) DAY SENSE ILLUMINATION FUSED IGN FUSED B(+) LT BLU/BLK WIRE LT BLU/RED WIRE LT GRN WIRE NCA WIRE ORG/ WIRE PNK WIRE PRESET R FRONT SPKR - R REAR SPKR - RADIO RADIO CHOKE RADIO CHOKE RELAY (BEHIND CENTER OF DASH) RED WIRE RED/BLK WIRE RED/WHT WIRE RIGHT FRONT DOOR SPEAKER RIGHT REAR SPEAKER RIGHT TWEETER SPEAKER SEEK DN SEEK UP TAN/BLK WIRE TAN/VIO WIRE VIO WIRE VIO/BRN WIRE VOL DN RIGHT REMOTE RADIO SWITCH VOL UP WHT WIRE WHT/BLK WIRE WHT/DK GRN WIRE WHT/VIO WIRE YEL/BLK WIRE YEL/RED WIRE

5.9L 6.7L B(+) CAN C BUS (+) BLK WIRE BLK/DK GRN WIRE BLK/ORG WIRE BRAKE SWITCH 1 SIGNAL BRAKE SWITCH 1 SIGNAL 34 35 C BUS (+) C BUS (-) BRK FLUID LEVEL SW SENSE CAN C BUS (+) COMPUTER DATA LINES SYSTEM DIESEL DK DK DK GRN WIRE DK GRN/LT GRN WIRE DK GRN/ORG WIRE DK GRN/RED WIRE DK GRN/TAN WIRE DK GRN/WHT WIRE DK GRN/YEL WIRE ELECTRONICS FUSED IGN SW OUT (RUN-START) ENGINE CONTROL MODULE FUSE 13 FUSE 30 GAS GRN WIRE HOT AT ALL TIMES LF WHEEL SPD SENSOR (-) LT BLU WIRE LT GRN WIRE ORG/ WIRE PNK WIRE PNK/LT GRN WIRE RED WIRE TAN WIRE TOTALLY INTEGRATED POWER MODULE (AT LEFT FRONT FENDER) WHT WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE YEL WIRE

6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 LINE 1 LINE 1 LINE 2 9 10 CCD (-) CCD (+) AIR BAG CONTROL MODULE (BEHIND LOWER CENTER OF DASH) AIR BAG WARNING INDICATOR BLK WIRE BLK/LT BLU WIRE BLK/PNK WIRE BLU WIRE BRN WIRE BRN/YEL WIRE BUS (-) BUS (+) CLOCKSPRING DATA LINK CONNECTOR (DLC) (PARTIAL) (ON LEFT BOTTOM OF DASH) DK BLU WIRE DK BLU/YEL WIRE DK GRN WIRE DRIVER AIR BAG FUSE 19 GRN WIRE GROUND LINE 2 HOT IN RUN JUNCTION BLOCK (ON LEFT END OF DASH) FUSE 18 HOT IN RUN OR START IGNITION IGNITION INDICATOR DRIVER INSTRUMENT CLUSTER J/C 7 (LEFT SIDE OF DASH) J/C 8 (CENTER OF DASH) LINE 1 LINE 2 LINE 2 LT BLU WIRE LT GRN WIRE LT GRN/YEL WIRE NCA WIRE OFF INDICATOR PASSENGER AIR BAG LINE 1 PASSENGER AIR BAG ON/OFF SWITCH PNK WIRE RESISTOR FUSED VIO WIRE VIO/BRN WIRE VIO/YEL WIRE WHT WIRE WHT/BLK WIRE YEL WIRE

1 2 3 4 5 6 7 8 TRANS RLY OUT A/C COMP CL RLY A/C HIGH PRESSURE CUTOUT SWITCH (A/C HIGH PRESSURE LINE) A/C LOW PRESSURE CUTOUT SWITCH (A/C LOW PRESSURE LINE) A/C REQUEST A/C SELECT STOP LP SWITCH A/C SYSTEM A/T ASD RELAY SENS OD OFF SWITCH ASD RLY CTRL CRUISE VAC SOL CRUISE VNT SOL OD LAMP DRVR TRANS TEMP LAMP DRVR BATT TEMP SENS GEN IND DRVR MIL IND DRVR SRI LAMP DRVR BLK/LT BLU WIRE BLK/PNK WIRE BLK/WHT WIRE BRN WIRE BRN/WHT WIRE CRANKSHAFT POSITION SENSOR CAMSHAFT POSITION SENSOR CRUISE CONTROL SYSTEM DATA LINK CONNECTOR (LEFT I/P) DK BLU WIRE DK BLU/ORG WIRE DK BLU/YEL WIRE DK GRN WIRE DK GRN/ORG WIRE FUEL PRESS. GAUGE TACHO- METER FUSE 12 FUSE BLOCK GRN WIRE GRY/BLK WIRE GRY/LT BLU WIRE GRY/PNK WIRE HI PRESS FUEL SHUTOFF RLY CTRL HOT IN RUN OR START INSTRUMENT CLUSTER J/C C (BEHIND LEFT KNEE BOLSTER) LT GRN WIRE LT GRN/BLK WIRE LT GRN/ORG WIRE LT GRN/RED WIRE LT GRN/WHT WIRE M/T (NOT USED) MAINT REQ IND. MESSAGE CENTER ORG/ WIRE ORG/BLK WIRE ORG/DK BLU WIRE ORG/WHT WIRE OVERDRIVE SWITCH PNK WIRE PNK/BLK WIRE PNK/DK BLU WIRE PNK/YEL WIRE POWER DISTRI- BUTION CENTER POWERTRAIN CONTROL MODULE (RIGHT SIDE SAFETY WALL) RED WIRE RED/LT GRN WIRE RED/WHT WIRE SCI RECEIVE SCI TRANSMIT SENSOR GRD GOV PRESS SIG VAR FORCE SOL OVERDRV SOL TCC SOL CTRL TRANS TEMP SNS STOP LAMP SWITCH TACH SIGNAL SPD CTRL RESUME TAN/RED WIRE TAN/YEL WIRE THROTTLE POSITION SENSOR (SIDE OF THROTTLE BODY) TRANS- MISSION RELAY TRANSMISSION SOLENOID ASSEMBLY (ON TRANSMISSION) UPSHIFT IND. MIL IND. VEHICLE SPEED SENSOR VIO WIRE VIO/WHT WIRE W/ A/T WHT/ORG WIRE WHT/PNK WIRE YEL WIRE YEL/RED WIRE

28 29 30 PNK WIRE AUTOMATIC SHUTDOWN RELAY BLK/DK GRN WIRE BLK/GRY WIRE BLK/LT BLU WIRE BLK/RED WIRE BLK/TAN WIRE BLK/WHT WIRE BRN WIRE BRN/DK BLU WIRE BRN/WHT WIRE CALIF CAM POS SNS IDLE AIR 1 IDLE AIR 4 CAPACITOR CONTROLLER ANTI-LOCK BRAKE DK BLU WIRE DK BLU/BLK WIRE DK BLU/WHT WIRE DK BLU/YEL WIRE DK GRN BLK/ WIRE DK GRN WIRE DK GRN/BLK WIRE DK GRN/GRY WIRE DK GRN/ORG WIRE DK GRN/RED WIRE FUEL INJECTORS FUEL PUMP RELAY FUSE 6 FUSE 3 FUSED B(+) TPS SENS IN GRN WIRE GROUND GROUND GRY WIRE GRY/BLK WIRE GRY/LT BLU WIRE GRY/ORG WIRE GRY/RED WIRE HOT AT ALL TIMES IAT SENS IN ECT SENS IN IGNITION COIL 4-PACK IGNITION COIL 6-PACK LT BLU WIRE LT BLU/BRN WIRE LT GRN/ BLK WIRE LT GRN/BLK WIRE LT GRN/RED WIRE LT GRN/WHT WIRE MAP SENS IN NCA WIRE OIL PRESS SIG ORG/ WIRE ORG/BLK WIRE ORG/DK BLU WIRE OUTPUT SENS OUTPUT SPEED SENSOR (ON LEFT SIDE OF TRANSMISSION) OVERDRV SOL PARK/NEUTRAL POSITION SWITCH (ON LEFT SIDE OF TRANSMISSION) PNK WIRE POWERTRAIN CONTROL MODULE (IN ENG COMPT, ON RIGHT SIDE OF FIREWALL) RED WIRE RED/BLK WIRE RED/LT BLU WIRE RED/WHT WIRE STARTING/ CHARGING SYSTEM TAN WIRE TAN/BLK WIRE TAN/WHT WIRE TAN/YEL WIRE TO SPARK PLUGS TO SPARK PLUGS TO SPARK PLUGS TO SPARK PLUGS TO SPARK PLUGS VAR FRCE SOL VIO WIRE VIO/BLK WIRE VIO/TAN WIRE VIO/WHT WIRE VSS IN OUTPUT SENS GOV PRESS SIG TRANS RELAY WHT WIRE WHT/DK BLU WIRE WHT/ORG WIRE YEL WIRE YEL/BLK WIRE YEL/GRY WIRE YEL/WHT WIRE