Dodge Pickup R2500 (1996-2010) fuse fuse Wiring diagrams

1 2 3 4 AUTO HEADLAMPS SIG SUN SENSOR SIG 1 SUN SENSOR SIG 2 SENSOR GROUND 1 4 3 IGN RUN CTRL OUT IR SENSOR RETURN IR SENSOR SIGNAL 10 9 34 35 FUSED B(+) GND CAN BUS (+) CAN BUS (-) 27 20 SENS GND ECT SIG 4 2 3 1 BLWR MTR HI DRV FT BLW FD BLWR CTRL GND A/C CLUTCH COIL A/C CLUTCH CTRL OUT A/C COMPRESSOR CLUTCH (3.7L, 4.7L: FRONT OF ENGINE) A/C HEATER CONTROL A/C PRESS A/C PRESS SNSE RTN A/C PRESS SNSR FD A/C PRESS SIG A/C PRESS SNSR FD B(+) BLK WIRE BLK/LT BLU WIRE BLK/LT GRN WIRE BLK/TAN WIRE BLOWER MODULE BLOWER MOTOR (RIGHT SIDE BRN WIRE CAN 2 BUS (-) CAN IHS BUS (-) CAN IHS BUS (+) IOD FD FUSED IGN RUN CTRL OUT CIRCUIT BOARD CLUTCH A/C COIL COMPUTER DATA LINES SYSTEM DK BLU WIRE DK BLU/DK GRN WIRE DK BLU/GRY WIRE DK BLU/LT BLU WIRE DK BLU/LT GRN WIRE DK BLU/ORG WIRE DK BLU/PNK WIRE DK BLU/RED WIRE DK BLU/TAN WIRE DK BLU/WHT WIRE DK BLU/YEL WIRE DK GRN/DK BLU WIRE DRIVER BLEND MODE DOOR DOOR ACTUATOR ACTUATOR 1 (ON HVAC UNIT) (ON HVAC UNIT) ENGINE CONTROLS SYSTEM EVAP SIG EVAP SNSE RTN EVAPORATOR TEMPERATURE SENSOR (CENTER OF DASH) FAN RADIATOR HIGH RELAY FAN RADIATOR LOW RELAY FUSE FUSE FUSE HI SPD RAD FAN HOT AT ALL TIMES HOT W/ RUN RELAY ENERGIZED INFRARED SENSOR LOW SPD SIG LT BLU WIRE LT BLU/BRN WIRE LT BLU/ORG WIRE LT BLU/RED WIRE LT GRN WIRE MODE DOOR ACTUATOR 2 (ON HVAC UNIT) NAVIGATION SYSTEM OF DASH) ORG/ WIRE PASSENGER BLEND DOOR ACTUATOR (ON HVAC UNIT) PNK/YEL WIRE POWERTRAIN CONTROL MODULE (3.7L, 4.7L: REAR OF ENGINE) RAD FAN RADIATOR FAN RECIRCULATION DOOR ACTUATOR RED WIRE RED/WHT WIRE SIG SNSE RTN A/C PRESS SPLY BLW MTR SUN SENSOR TAN WIRE TOP OF ENGINE) TOTALLY INTEGRATED POWER MODULE (LEFT FRONT OF ENGINE COMPT) TRANSDUCER) VIO/LT BLU WIRE VIO/ORG WIRE WHT/GRY WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE WHT/ORG WIRE WHT/VIO WIRE

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 GND 1 2 SENS GND SENS SIG 10 34 35 9 BATT FD C BUS (+) C BUS (-) GND 27 20 ECT SIG SENS GND A/C A/C CLUTCH A/C A/C PRESS CTRL PRESS CLUTCH OUTPUT COIL A/C CLUTCH COIL A/C COMPRESSOR CLUTCH (3.7L, 4.7L: FRONT OF ENGINE) A/C HEATER CONTROL A/C PRESS SIG A/C PRESS SNS RTN A/C PRESS SNS SNS SIGNAL RTN FD A/C PRESS SNSR FD A/C PRESSURE TRANSDUCER (3.7L, 4.7L: TOP FRONT OF ENGINE) AUTO HDLP SIG B(+) BLK WIRE BLK/LT BLU WIRE BLK/LT GRN WIRE BLK/TAN WIRE BLOWER MOTOR (RIGHT SIDE OF DASH) BLOWER MOTOR RESISTOR (RIGHT SIDE OF DASH) BLWR CAN 2 CAN 2 MTR BUS (+) BUS (-) SPLY CIRCUIT BOARD COMMON DOOR DRIVER 2 MODE DOOR 2 DRIVER COMPUTER DATA LINES SYSTEM DK BLU WIRE DK BLU/BRN WIRE DK BLU/DK GRN WIRE DK BLU/GRY WIRE DK BLU/LT BLU WIRE DK BLU/LT GRN WIRE DK BLU/ORG WIRE DK BLU/PNK WIRE DK BLU/RED WIRE DK BLU/TAN WIRE DK BLU/VIO WIRE DK BLU/YEL WIRE DK GRN/DK BLU WIRE DRIVER BLEND DOOR ACTUATOR (ON HVAC UNIT) ENGINE CONTROLS SYSTEM EVAP SNSE RTN EVAP SNSE RTN AUTO HDLP SIG EVAP TEMP SENS SIG EVAP SNSE RTN EVAPORATOR TEMPERATURE SENSOR (CENTER OF DASH) FAN RADIATOR HIGH RELAY FAN RADIATOR LOW RELAY FRONT MODE DOOR ACTUATOR FUSE FUSE FUSE HOT AT ALL TIMES HOT W/ RUN RELAY ENERGIZED IOD FD IGN R LT BLU/BRN WIRE LT BLU/ORG WIRE LT BLU/RED WIRE MODE DOOR ACTUATOR 2 (ON HVAC UNIT) PNK/YEL WIRE POWER MODULE (LEFT FRONT OF ENGINE COMPT) POWERTRAIN CONTROL MODULE (3.7L, 4.7L: REAR OF ENGINE) RAD FAN HI SPD SIG RAD FAN LOW SPD SIG RADIATOR FAN RED WIRE RED/WHT WIRE SUN SENSOR TOP OF ENGINE) TOTALLY INTEGRATED VIO/ORG WIRE WHT/GRY WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE WHT/ORG WIRE WHT/VIO WIRE

3 1 BTSI SOL ULK TRS RNG PRK ABMT TEMP/FCM SSR RTN 1 AMBIENT AIR TEMPERATURE SENSOR (LEFT FRONT OF ENGINE COMPT) BATT FEED BLK WIRE BLK/WHT WIRE BRAKE TRANSMISSION SHIFT INTERLOCK SOLENOID BRN/YEL WIRE BUS BAR CIRCUIT FT BOARD DRV DR ULK DIODE DK GRN WIRE DOOR LOCK RELAY DR AJAR LT RR SIG DR AJAR RT RR SIG DR LK LT FT DR LK RT FT DR ULK RT FT DRIVER DOOR LATCH DRIVER DOOR UNLOCK RELAY DRV DR AJAR SW SNS DRV FT DR AJAR SW IN DRV RR UNLK CTRL FRONT WASHER FLUID LEVEL SENSOR FT LT DR ULK FUSE FUSE FUSE GRY/LT BLU WIRE GRY/YEL WIRE HOOD ABMT/ AJAR FCM SW SSR SNS RTN 1 HOOD AJAR SWITCH (LEFT FRONT OF ENGINE COMPT) HORN RELAY HORN RLY COIL DRV HORN SW SIG HORNS SYSTEM HOT AT ALL TIMES LEFT REAR DOOR LATCH (EXCEPT REGULAR CAB) LT GRN/GRY WIRE LT RR LK LT RR ULK PASS DR DR LOCK AJAR RLY SW SNS CTRL PASS FT DR AJAR SW IN PASSENGER DOOR LATCH PASSENGER DOOR UNLOCK RELAY POWER MODULE (LEFT FRONT OF ENGINE COMPT) RIGHT REAR DOOR LATCH (EXCEPT REGULAR CAB) RT RR LK RT RR LT RR DR DR AJAR AJAR SIG SIG RT RR ULK TAN/BRN WIRE TAN/DK BLU WIRE TAN/LT BLU WIRE TAN/LT GRN WIRE TAN/ORG WIRE TAN/VIO WIRE TAN/WHT WIRE TOTALLY INTEGRATED VIO WIRE VIO/BRN WIRE VIO/GRY WIRE VIO/LT BLU WIRE VIO/WHT WIRE VIO/YEL WIRE YEL/DK BLU WIRE

B(+) CAN CAN HORN BUS BUS SW RLY (+) (-) SIG COIL BLK WIRE CIRCUIT BOARD CLUSTER COMPUTER DATA LINES SYSTEM DK GRN WIRE DK GRN/VIO WIRE FUSE FUSE FUSE GRY WIRE GRY/LT BLU WIRE GRY/ORG WIRE GRY/YEL WIRE HORN HORN 2 (LEFT FRONT FENDER) HORN RELAY HORN SW SIG HORN SW SIG (OR) BATT FD 9 HORN SWITCH HOT AT ALL TIMES LEFT REMOTE RADIO SWITCH LIN LIN CCN LT BLU WIRE LT GRN WIRE ORG/ WIRE RADIO SW RED WIRE RED/GRY WIRE RIGHT REMOTE RADIO SWITCH STEERING CONTROL MODULE (LEFT SIDE OF DASH) TOTALLY INTEGRATED POWER MODULE (LEFT FRONT OF ENGINE COMPT) VIO WIRE WHT WIRE WHT/DK GRN WIRE YEL WIRE

1 2 3 4 IOD FD GND LIN CCN AUTO STICK UP SW FUSED IGN RUN/START IOD FD B(+) BLK WIRE BLK/BRN WIRE BLK/DK GRN WIRE BLK/LT GRN WIRE BLK/WHT WIRE BRAKE FLUID LEVEL SENSOR (LEFT REAR OF ENGINE COMPT) BRN WIRE BRN/WHT WIRE CAN-BUS CARGO LP SW SIG CIRCUIT BOARD CLUSTER COMPASS MODULE COMPT) COMPUTER DATA LINES SYSTEM DK BLU/WHT WIRE DK GRN/ORG (OR DK GRN/RED) WIRE DK GRN/RED WIRE DK GRN/VIO WIRE DK GRN/WHT WIRE DK GRN/YEL WIRE DRIVER COURTESY LAMPS GROUND DRIVER DOOR LATCH DRV DR AJAR SW SENS ERS AUTO STICK SWITCH EXCEPT 6.7L EXCEPT 6.7L 6.7L FUEL LVL SENS SIG FUEL PUMP MODULE FUSE FUSE FUSE GROUND GROUND LIN CCN HDLP POS FOG LMP SW MODE SELECT HDLP SW MUX RTN HEADLIGHTS SYSTEM HEADLIGHTS SYSTEM TRANSMISSIONS SYSTEM HORN SW SNS HORNS SYSTEM HOT AT ALL TIMES HOT W/ RUN/START RELAY ENERGIZED IGN RUN/ START CTRL IND DRV INVERTER MODULE LEFT REAR DOOR LATCH (QUAD, CREW CAB) LR DR AJAR SW SENS LT GRN WIRE LT GRN/DK BLU WIRE LT GRN/GRY WIRE LT GRN/LT BLU WIRE LT GRN/ORG WIRE LT GRN/TAN WIRE LT GRN/WHT WIRE LT GRN/YEL WIRE LVL SW SENS BRK FLUID OIL PRESS SW OIL PRESSURE SENSOR OIL PRESSURE SWITCH ORG/BRN WIRE ORG/GRY WIRE PANEL LP DIMMER SIG PARK BRAKE SW SNS LR HEATED SEAT SW SENS RR HEATED SEAT SW SENS PARKING BRAKE SWITCH (TOP OF PARKING BRAKE PEDAL) PASS DR AJAR SW SENS PASSENGER DOOR LATCH PNK/LT GRN WIRE POWERTRAIN CONTROL MODULE (3.7L, 4.7L: REAR OF ENGINE) RAIL LAMP FDS DRIVER CARGO LAMPS RED WIRE RED/GRY WIRE RIGHT REAR DOOR LATCH (QUAD, CREW CAB) RR DR AJAR SW SENS RR HEATED SEAT LO IND RR HEATED SEAT HI IND SEATS SYSTEM SEATS SYSTEM SEATS SYSTEM SENS RTN FUEL LVL TOTALLY INTEGRATED POWER MODULE (LEFT FRONT OF ENGINE COMPT) TRANSFER CASE POS SENS TRANSMISSIONS SYSTEM VIO WIRE VIO/BRN WIRE VIO/GRY WIRE VIO/WHT WIRE VIO/YEL WIRE WHT WIRE WHT/DK GRN WIRE WHT/GRY WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE WHT/ORG WIRE WHT/TAN WIRE WHT/YEL WIRE YEL/LT BLU WIRE YEL/WHT WIRE

7-WAY TRAILER TOW WIRING A/C HEATER CONTROL ANTI-LOCK BRAKES MODULE AUXILIARY BATTERY (6.7L) BASE PREMIUM AUDIO AUDIO BATTERY BRN/RED WIRE BUS BAR CIRCUIT BOARD IOD FD CLUSTER COMPASS MODULE DK GRN WIRE DK GRN/RED WIRE DRIVER DOOR MODULE EXCEPT RAM BOX RAM BOX FUSE FUSE FUSE FUSE FUSE FUSE FUSIBLE LINK (8 GA- GENERATOR GENERATOR (EXCEPT 6.7L) GRY WIRE HANDS FREE MODULE INTAKE AIR HEATER RELAY LEFT BIN RIGHT BIN BRAKE STORAGE STORAGE PROVISION MODULE LT BLU RED/ WIRE LT BLU WIRE LT GRN/RED WIRE MULTI- FUNCTION SWITCH PASSENGER DOOR MODULE PASSENGER DOOR UNLOCK RELAY RADIATOR FAN HIGH RELAY RADIO RADIO, AMPLIFIER RED WIRE RED YEL/ WIRE RED/ LT BLU WIRE RED/ VIO WIRE RED/ WHT WIRE RED/LT BLU WIRE RED/LT GRN WIRE RED/VIO WIRE RED/WHT WIRE RED/YEL WIRE STARTER STARTER RELAY STOP LAMP SWITCH SUNROOF MODULE (IF EQUIPPED) TAN/RED WIRE TOTALLY INTEGRATED POWER MODULE TRANSMISSION CONTROL RELAY UNDERHOOD LAMP (IF EQUIPPED) VIDEO VIDEO SCREEN SATELLITE MODULE MODULE VIO RED/ WIRE VIO WIRE WHT RED/ WIRE WHT WIRE YEL/RED WIRE

A/C OCCUPANT HEATER RESTRAINT CONTROL CONTROLLER MODULE ADJUSTABLE DRIVER PEDALS HEATED SWITCH SEAT SWITCH AWAL BACKUP LAMP SWITCH (M/T) BASE BLK/YEL WIRE BLOWER MOTOR CLUSTER POWERTRAIN CONTROL MODULE DIESEL DIESEL/ SRT-10 DK GRN WIRE ELECTRONICS ENGINE CONTROL MODULE ENGINE OIL DRIVER TEMPERATURE WINDOW/ GAUGE DOOR LOCK SWITCH (SRT-10) EVAP/ ANTI-LOCK PURGE BRAKES SOLENOID MODULE EXCEPT BASE EXCEPT BASE BASE EXCEPT SRT-10 EXCEPT SRT-10 SRT-10 FROM FUSE 22 (DIAGRAM 1 OF 2) FROM IGNITION SWITCH (DIAGRAM 1 OF 2) FUSE FUSE 29 FUSE 40 FUSE FUSE FUSED IGNITION SWITCH OUTPUT (OFF-RUN-START) FUSED IGNITION SWITCH OUTPUT (RUN) FUSED IGNITION SWITCH OUTPUT (RUN-ACC) FUSED IGNITION SWITCH OUTPUT (RUN-START) GATEWAY FINAL DRIVE MODULE CONTROL MODULE GRY WIRE GRY/PNK WIRE IGNITION SWITCH OUTPUT (RUN-START) IGNITION SWITCH OUTPUT (START) INSIDE REARVIEW MIRROR INSTRUMENT PANEL POWER OUTLET LT GRN WIRE M/T NGC PASSENGER HEATED SEAT SWITCH PASSENGER OCCUPANT AIR BAG RESTRAINT CONTROLLER ON/OFF MODULE SWITCH PASSENGER TRANSFER DOOR LOCK CASE SWITCH SELECTOR SWITCH (A/T) PNK WIRE PNK/DK GRN WIRE PNK/GRY WIRE PNK/LT GRN WIRE PNK/ORG WIRE PNK/RED WIRE PNK/VIO WIRE PNK/WHT WIRE PNK/YEL WIRE POWER SLIDING BACKLITE SWITCH (QUAD CAB/ EXCEPT BASE) POWER WAGON POWERTRAIN CONTROL MODULE QUAD CAB QUAD STANDARD CAB CAB RWAL SENTRY KEY STOP REMOTE LAMP SWITCH ENTRY MODULE SRT-10 SRT-10 EXCEPT STANDARD CAB SUBWOOFER DRIVER AMPLIFIER SEAT BELT TENSION (SRT-10) REDUCER (STANDARD CAB) TOTALLY INTEGRATED POWER MODULE (AT LEFT FRONT FENDER) VIO/WHT WIRE WHT/GRY WIRE YEL WIRE

2 OF 3) A/C HEATER CONTROL ANTI-LOCK BRAKES MODULE BASE BLK WIRE BRAKE PROVISION MODULE DATA LINK CONNECTOR DK GRN WIRE DRIVER HEATED SEAT SWITCH DRIVER WINDOW/ DOOR LOCK SWITCH ELECTRONIC OVERHEAD MODULE ENGINE CONTROL MODULE EXCEPT BASE FROM ELECTRONICS (DIAGRAM 1 OF 3) FROM FUSE 26 (DIAGRAM 2 OF 3) FROM TOTALLY INTEGRATED POWER MODULE (DIAGRAM 1 OF 3) FRONT FENDER) FUSE FUSE 11 FUSE 12 (TRAILER TOW) FUSE 22 FUSE 24 (RAM 3500) (CAB CHASSIS) FUSE 26 FUSE 42 (DIESEL) FUSE FUSE GRY WIRE HANDS EXCEPT FREE HANDS FREE HANDS SATELLITE FREE RECEIVER MODULE HEAVY DUTY LIGHT DUTY LT BLU WIRE MONITOR/ DVD MEDIA SYSTEM ORG/ WIRE PASSENGER DRIVER SEAT SWITCH SEAT SWITCH PASSENGER HEATED SEAT SWITCH POWER (NEAR ENGINE CONTROL MODULE) OUTLET POWER MODULE (LEFT FRONT FENDER) POWERTRAIN CLUSTER CONTROL MODULE RADIO RADIO AMPLIFIER (PREMIUM) RAM GAS (RIGHT REAR OF ENGINE (LEFT SIDE COMPT) OF DASH) RED WIRE SLT- SLT+ STOP LAMP SWITCH TAN WIRE TO FUSE 27 (DIAGRAM TO IGNITION SWITCH (DIAGRAM 3 OF 3) TOTALLY INTEGRATED TOTALLY INTEGRATED POWER MODULE (LEFT TRANSMISSION RELAY UNDERHOOD LAMP W/ HEATED SEATS W/ SATELLITE WIRELESS CONTROL CLUSTER MODULE (WCM) YEL WIRE

3 1 BTSI SOL ULK TRS RNG PRK ABMT TEMP/FCM SSR RTN 1 AMBIENT AIR TEMPERATURE SENSOR (LEFT FRONT OF ENGINE COMPT) BATT FEED BLK WIRE BLK/WHT WIRE BRAKE TRANSMISSION SHIFT INTERLOCK SOLENOID BRN/YEL WIRE BUS BAR CIRCUIT FT BOARD DRV DR ULK DIODE DK GRN WIRE DOOR LOCK RELAY DR AJAR LT RR SIG DR AJAR RT RR SIG DR LK LT FT DR LK RT FT DR ULK RT FT DRIVER DOOR LATCH DRIVER DOOR UNLOCK RELAY DRV DR AJAR SW SNS DRV FT DR AJAR SW IN DRV RR UNLK CTRL FRONT WASHER FLUID LEVEL SENSOR FT LT DR ULK FUSE FUSE FUSE GRY/LT BLU WIRE GRY/YEL WIRE HOOD ABMT/ AJAR FCM SW SSR SNS RTN 1 HOOD AJAR SWITCH (LEFT FRONT OF ENGINE COMPT) HORN RELAY HORN RLY COIL DRV HORN SW SIG HORNS SYSTEM HOT AT ALL TIMES LEFT REAR DOOR LATCH (EXCEPT REGULAR CAB) LT GRN/GRY WIRE LT RR LK LT RR ULK PASS DR DR LOCK AJAR RLY SW SNS CTRL PASS FT DR AJAR SW IN PASSENGER DOOR LATCH PASSENGER DOOR UNLOCK RELAY POWER MODULE (LEFT FRONT OF ENGINE COMPT) RIGHT REAR DOOR LATCH (EXCEPT REGULAR CAB) RT RR LK RT RR LT RR DR DR AJAR AJAR SIG SIG RT RR ULK TAN/BRN WIRE TAN/DK BLU WIRE TAN/LT BLU WIRE TAN/LT GRN WIRE TAN/ORG WIRE TAN/VIO WIRE TAN/WHT WIRE TOTALLY INTEGRATED VIO WIRE VIO/BRN WIRE VIO/GRY WIRE VIO/LT BLU WIRE VIO/WHT WIRE VIO/YEL WIRE YEL/DK BLU WIRE

A/C CLTCH IGN COIL RUN/STRT RS FUSE ANTI-LOCK BRAKES SYSTEM AUTO SHUTDOWN RELAY BLK/GRY WIRE BRN WIRE BRN/BLK WIRE BRN/DK GRN WIRE BRN/GRY WIRE BRN/LT BLU WIRE BRN/WHT WIRE BRN/YEL WIRE CAN BUS IHS(-) CAT INTK CAT OUT CIRCUIT BOARD COMPUTER DATA LINES SYSTEM CTRL COM DK BLU/DK GRN WIRE DK BLU/ORG WIRE DK BLU/WHT WIRE DK GRN WIRE DK GRN/BRN WIRE DK GRN/DK BLU WIRE DK GRN/LT BLU WIRE DK GRN/ORG WIRE DK GRN/WHT WIRE DK GRN/YEL WIRE ENG CTRL RUN/ STP STRT IGN ULK/ LVL LMP IGN RTN SIG RS SIG EXHAUST TEMPERATURE SENSOR 1/1 EXHAUST TEMPERATURE SENSOR 1/2 EXHAUST TEMPERATURE SENSOR 1/3 EXHAUST TEMPERATURE SENSOR 1/4 EXHST GAS FUEL FUEL LVL SNDR SNSR IGN FUEL LVL FUEL PMP FUEL PMP RLY FD ASD TO CTRL SEC FD 4 RLY FUEL PUMP MODULE FUEL PUMP RELAY FUEL SNDR FUSE FUSE FUSE HOT AT ALL TIMES HOT AT ALL TIMES TOTALLY INTEGRATED POWER MODULE (LEFT FRONT OF ENGINE COMPT) LT BLU/ORG WIRE LT GRN/RED WIRE LT GRN/TAN WIRE LVL SIG MTR FD ORG RED/ WIRE PNK WIRE PNK/ LT GRN WIRE PNK/GRY WIRE PNK/LT GRN WIRE PNK/WHT WIRE RED WIRE RED/ORG WIRE SNSR RTN TEMP TEMP 4 PRE TEMP POST TRANSMISSION CONTROL RELAY TURBINE SIG VIO/ORG WIRE WHT WIRE WHT/GRY WIRE WHT/ORG WIRE YEL WIRE YEL/BRN WIRE YEL/DK BLU WIRE YEL/DK GRN WIRE YEL/GRY WIRE YEL/LT BLU WIRE YEL/ORG WIRE YEL/TAN WIRE YEL/WHT WIRE