Dodge Pickup R2500 (1996-2010) dk grn/red Wiring diagrams

1 2 CAN IHS BUS (-) CAN IHS BUS (+) 1 4 6 5 BATT FD BRK SIG 2 BRK SIG 1 GND 10 29 34 35 BATT FD BATT FD CAN BUS (+) CAN BUS (-) 14 23 BRAKE SIGNAL 2 BRAKE SIGNAL 1 3.7L 3.7L/ 4.7L 32 33 34 OUTPUT SPEED SIG INPUT SPEED SIG SPEED SENS RTN 5 VOL FD 5 VOLT SUPPLY 5.7L 5.7L/4.7L A/T ACCELERATOR PEDAL POSITION SENSOR (LEFT SIDE OF DASH) APP SENS RTN APP SENS RTN 2 APP SIG (1) APP SIG (2) BLK WIRE BLK/TAN WIRE BRN/DK BLU WIRE BRN/DK GRN WIRE BRN/LT GRN WIRE BRN/ORG WIRE BRN/VIO WIRE BRN/YEL WIRE CLUSTER COMPUTER DATA LINES SYSTEM DK BLU WIRE DK BLU/ YEL WIRE DK GRN/BRN WIRE DK GRN/ORG WIRE DK GRN/RED WIRE DK GRN/VIO WIRE EXCEPT 3.7L FUSE FUSE POWER MODULE (LEFT FRONT OF ENGINE COMPT) GROUND HOT AT ALL TIMES LT BLU/DK GRN WIRE LT GRN/RED WIRE NEUT SIG OUTPUT SPEED SENSOR (3.7L: LEFT REAR OF TRANSMISSION) PARK PARK/NEUT SIG PNK/YEL WIRE POWERTRAIN CONTROL MODULE (3.7L, 4.7L: REAR OF ENGINE) RED WIRE S/C SIG 1 S/C SIG 2 S/C SW GND SPEED CONTROL SWITCH STEERING CONTROL MODULE (LEFT SIDE OF DASH) STOP LAMP SWITCH (ON BRAKE PEDAL SUPPORT) TAN/ORG WIRE TAN/YEL WIRE THROTTLE BODY (3.7L, 4.7L) (TOP OF ENGINE) TOP OF ENGINE) TOTALLY INTEGRATED TRANSMISSION RANGE SENSOR (3.7L: LEFT SIDE OF TRANSMISSION) TRANSMISSION SOLENIOD/TRS ASSEMBLY (LEFT SIDE OF TRANSMISSION) VIO WIRE VIO/BRN WIRE VIO/ORG WIRE WHT/BRN WIRE WHT/GRY WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE WHT/ORG WIRE YEL WIRE YEL/DK BLU WIRE YEL/PNK WIRE

2 1 11 CAN IHS BUS(-) CAN IHS BUS(+) LIN BUS COMPUTER DATA LINES SYSTEM 29 9 10 9 14 23 65 66 BRK SIG 2 BRK SIG 1 35 34 18 35 COMPUTER DATA LINES SYSTEM CAN BUS (-) CAN BUS (+) 5.7L 5.7L 6.7L ANTI-LOCK BRAKES MODULE (LEFT REAR OF ENGINE COMPT) B (+) CAN BUS (-) BUS (+) BATT FD BLK WIRE BLK/DK GRN WIRE BLK/TAN WIRE BRAKE FLUID LEVEL SENSOR (LEFT REAR OF ENGINE COMPT) BRK FLUID LEVEL SW SENSE CAN BUS (+) 2 CLUSTER COMPUTER DATA LINES SYSTEM DK DK DK GRN WIRE DK GRN/LT GRN WIRE DK GRN/ORG WIRE DK GRN/RED WIRE DK GRN/TAN WIRE DK GRN/VIO WIRE DK GRN/WHT WIRE DK GRN/YEL WIRE FUSE FUSED B (+) IGN RS PNK WIRE FUSED B(+) CAN BUS 2 (+) GND (LEFT SIDE OF DASH) GRN WIRE GROUND HOT AT ALL TIMES IGN RS LEFT FRONT ABS WHEEL SPEED SENSOR (LEFT FRONT WHEEL HUB ASSEMBLY) LF WHEEL SPD SENSOR (+) LF WHEEL SPD SENSOR (-) LT BLU WIRE LT BLU/DK GRN WIRE LT GRN WIRE LT GRN/RED WIRE ORG/ WIRE PARKING BRAKE SWITCH (TOP OF PARKING BRAKE PEDAL) PNK PNK IGN RUN/START BRK SIG 1 BRK SIG 2 11 12 WIRE PNK WIRE POWERTRAIN CONTROL MODULE PRK BRK SW SIG REAR ABS WHEEL SPEED SENSOR REAR WHEEL SPD SENS (-) REAR WHEEL SPD SENS (+) RED WIRE RF WHEEL SPD SENSOR (+) RF WHEEL SPD SENSOR (-) RIGHT FRONT ABS WHEEL SPEED SENSOR (RIGHT FRONT WHEEL HUB ASSEMBLY) STOP LAMP SWITCH (ON BRAKE PEDAL SUPPORT) STP LMP SIG TAN WIRE TAN/RED WIRE TOTALLY INTEGRATED POWER MODULE (LEFT FRONT OF ENGINE COMPT) CIRCUIT BOARD VIO WIRE WHT WIRE WHT/DK GRN WIRE WHT/GRY WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE WHT/ORG WIRE WIRELESS IGNITION NODE YEL WIRE

10 15 14 34 B(+) PARK RLY CTRL TRLR L TURN TRLR R TURN 19 43 44 38 2 17 18 4 RR TURN SIGNAL LEFT BRAKE LP LR TURN SIGNAL PCI BUS 45 42 19 16 RF TURN SIGNAL LF TURN SIGNAL 5 8 HDLP SW SIG TURN SW FEED 9 21 HDLP SW RTN PCI BUS BACK-UP LAMPS CIRCUIT BLK WIRE BLK/ORG WIRE BLK/YEL WIRE BRAKE LAMP SWITCH (ABOVE BRAKE PEDAL, ON SUPPORT BRACKET) BRAKE SW INPUT BRN WIRE BRN/RED WIRE CENTER HIGH MOUNTED STOP LAMP (AFTER- MARKET) CENTER HIGH MOUNTED STOP LAMP/ CARGO LAMP DK BLU WIRE DK GRN WIRE DK GRN/BLK WIRE DK GRN/RED WIRE ELECTRIC BRAKE PROVISION EXCEPT ABS ABS FRONT CONTROL MODULE FUSE 15 FUSE 24 FUSE 32 FUSE 33 FUSE 34 FUSE 46 FUSE 47 HAZARD HEADLAMP SWITCH HOT AT ALL TIMES INSTRUMENT CLUSTER INTEGRATED POWER MODULE (LEFT FRONT OF ENGINE COMPT) FUSE 1 L TURN LEFT FRONT PARK/ TURN SIGNAL LAMP LEFT TAIL/STOP, TURN SIGNAL LAMP LT BLU WIRE LT BLU/WHT WIRE LT GRN WIRE LT GRN/TAN WIRE MULTI- FUNCTION SWITCH OFF HEAD ORG/ WIRE PARK PARK LAMP RELAY PARK/ TURN SIGNAL LAMP PNK PNK WIRE PNK WIRE PNK/ (LEFT FRONT FENDER) WIRE PNK/ RIGHT FRONT FENDER LAMP (DUAL REAR WHEELS) WIRE PNK/ RIGHT REAR FENDER LAMP (DUAL REAR WHEELS) WIRE PNK/VIO WIRE PTC 5 R TURN RED WIRE RED/ORG WIRE RIGHT BRAKE LP RIGHT FRONT RIGHT INSTRUMENT PANEL RIGHT TAIL/ STOP/ TURN SIGNAL LAMP RIGHT LICENSE LAMP TAIL/ STOP LAMP TAIL/ TURN LAMP TAIL/ TURN LAMP TAIL/ STOP LAMP TAILGATE LAMP ASSEMBLY TAN WIRE TRAILER TOW CONNECTOR (BENEATH CENTER OF REAR BUMPER) TRAILER TOW CONNECTOR- ADD ON TRAILER TOW LEFT TURN RELAY TRAILER TOW RIGHT TURN RELAY TURN SW SENSE VIO WIRE VIO/BLK WIRE VIO/BRN WIRE VIO/PNK WIRE VIO/YEL WIRE W/ TRAILER TOW CONNECTOR ADD ON WHT WIRE WHT/LT GRN WIRE WHT/PNK WIRE WHT/RED WIRE WHT/TAN WIRE WHT/VIO WIRE YEL WIRE YEL/PNK WIRE

1 2 3 4 5 6 FT DRV WIND SENS RTN 1 2 3 4 5 6 FT PASS WDO SENS RTN 1 2 LIN BUS LIN BUS RTN 2 3 4 5 6 SLIDING BACKLITE OPEN (+) 3 4 LEFT REAR WIN DOWN LEFT REAR WIN UP 3 4 RT RR WDO DWN RT RR WDO UP 4 5 1 2 GND IOD FD TO DR NODE-DRV CAN BUS (-) CAN BUS (+) 5 1 2 4 IOD FD TO DR NODE PASS CAN BUS - CAN BUS + GROUND 5 2 GROUND PWR WIN SW LK OUT FD BATT FD LIN BUS RTN LIN BUS BLK WIRE BLK/DK GRN WIRE BLK/LT GRN WIRE BLK/ORG WIRE BLK/WHT WIRE CIRCUIT BREAKER FUSE COMPUTER DATA LINES LINES SYSTEM COMPUTER DATA LINES SYSTEM DK GRN WIRE DK GRN/RED WIRE DRIVER DOOR MODULE DRIVER WINDOW MOTOR DRIVER WINDOW/DOOR LOCK SWITCH DRV FT WDO DWN DRV WIND HALL SENS FD DRV FT HALL SENS A DRV FT WDO UP EXCEPT PICKUP EXCEPT REGULAR CAB FT PASS DR LOCK SW SIG FT PASS SW SENS UP FT PASS SW ILLM IGN RUN/ACC FT PASS SW ILLM/SNS RTN FT PASS WDO DWN FT PASS HALL SENS FD FT PASS HALL SENS A FT PASS WIND UP FUSE GROUND HOT AT ALL TIMES IGN WDW RUN/ACC DIM 3 IP SLIDING BACKLITE OPEN (-) LEFT REAR MSTR CTRL DOWN LEFT REAR MSTR CTRL UP LEFT REAR POWER WINDOW SWITCH (EXCEPT REGULAR CAB) LEFT REAR WIN DOWN LEFT REAR WIN UP LEFT REAR WINDOW MOTOR LIN BUS LT BLU WIRE LT GRN WIRE ORG/ WIRE ORG/BRN WIRE ORG/DK BLU WIRE ORG/GRY WIRE ORG/LT BLU WIRE ORG/LT GRN WIRE ORG/TAN WIRE ORG/VIO WIRE ORG/WHT WIRE PASSENGER DOOR MODULE PASSENGER WINDOW MOTOR PASSENGER WINDOW/DOOR LOCK SWITCH PICKUP PNK PNK WIRE PNK/ 1 5 6 3 WIRE PNK/YEL WIRE POWER SLIDING BACKLITE MOTOR POWER SLIDING BACKLITE SWITCH (IF EQUIPPED) RED WIRE RED/LT BLU WIRE RED/LT GRN WIRE RIGHT REAR MSTR CTRL DOWN RIGHT REAR MSTR CTRL UP RIGHT REAR POWER WINDOW SWITCH (EXCEPT REGULAR CAB) RIGHT REAR WINDOW MOTOR RT RR WDO DWN RT RR WDO UP RUN/ ACCESSORY DELAY RELAY SLIDING BACKLITE OPEN (+) TAN/LT BLU WIRE TAN/YEL WIRE TOTALLY INTEGRATED POWER MODULE (LEFT FRONT OF ENGINE COMPT) VIO/LT GRN WIRE WHT WIRE WHT/GRY WIRE WHT/LT GRN WIRE WHT/ORG WIRE YEL WIRE

18 35 35 34 CAN C BUS (-) CAN C BUS (+) 5.7L 6.7L 5.7L ASTK UP BATT FD BATT FD (5.7L) RUN/START (6.7L) BLK/LT GRN WIRE BLK/TAN WIRE BRAKE TRANSMISSION SHIFT INTERLOCK BRK SIG BRK SIG 2 BRN/YEL WIRE BTSI CTRL CAN-BUS CLUSTER COMPUTER DATA LINES SYSTEM DK GRN/DK BLU WIRE DK GRN/LT BLU WIRE DK GRN/RED WIRE DK GRN/YEL WIRE ERS AUTOSTICK SWITCH FUSE GROUND HEAD- LAMP SWITCH HOT AT ALL TIMES HOT AT ALL TIMES CIRCUIT BOARD IGN FD LT BLU/DK GRN WIRE LT GRN/RED WIRE PNK/TAN WIRE PNK/WHT WIRE POWERTRAIN CONTROL MODULE (RIGHT REAR OF ENGINE COMPT) PRK/NEUT SIG RED WIRE RUN/START IGN RUN/START SOLENOID STOP LAMP SWITCH (ON BRAKE PEDAL SUPPORT) SW RTN TOTALLY INTEGRATED POWER MODULE (LEFT FRONT OF ENGINE COMPT) TRANSMISSION SOLENOID/TRS ASSEMBLY TRS PARK SIG WHT/GRY WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE WHT/ORG WIRE WHT/YEL WIRE WIN WIRELESS IGNITION NODE YEL/DK BLU WIRE

A/C PRESSURE TRANSDUCER (NEAR A/C COMPRESSOR) A/C SIG AMBIENT TEMPERATURE SENSOR (LEFT UNDERSIDE OF HOOD) ANTI-LOCK BRAKES SYSTEM BLK/LT BLU WIRE BLK/TAN WIRE BRN WIRE BRN/DK BLU WIRE BRN/DK GRN WIRE BRN/PNK WIRE BRN/WHT WIRE COIL DRIVER 2 COIL DRIVER 1 COIL DRIVER 7 INJ 8 DRIVER INJ 7 DRIVER DATA LINK CONNECTOR (BELOW LEFT SIDE OF DASH) DK BLU WIRE DK GRN WIRE DK GRN/RED WIRE DK GRN/WHT WIRE DK GRN/YEL WIRE ENGINE COOLANT TEMPERATURE SENSOR ENGINE OIL PRESSURE SWITCH FUSE 19 FUSED B(+) IGN (START) GEN FIELD ECT SENS IN TP SENS SIG GROUND GRY WIRE GRY/LT BLU WIRE GRY/YEL WIRE HOT AT ALL TIMES HOT IN RUN OR START IGN (RUN-STRT) IGN (RUN-STRT) VSS IGNITION SWITCH INJ 4 DRIVER INJ 3 DRIVER INJ 2 DRIVER INJ 1 DRIVER TP SENS RET INTEGRATED POWER MODULE (ON LEFT FRONT OF ENGINE COMPT) LEFT KNOCK SENSOR LOCK OFF LT BLU/BRN WIRE LT BLU/RED WIRE LT BLU/VIO WIRE LT GRN WIRE LT GRN/BLK WIRE MAP SENS SIG KNOCK 1 RET KNOCK 1 SIG OIL PRES SIG A/C PRES SIG IDLE AIR 1 ORG/ WIRE ORG/DK BLU WIRE PCI BUS PNK SCI TRANSMIT WIRE PNK WIRE PNK/LT BLU WIRE POWERTRAIN CONTROL MODULE (ON RIGHT SIDE OF FIREWALL) PTC 1 RED/WHT WIRE RUN WIRE SCI RECEIVE SCI TRANSMIT SENS GND SENSOR GND STARTING/CHARGING SYSTEM SWITCH TAN WIRE TAN/BLK WIRE TAN/DK GRN WIRE TAN/LT BLU WIRE TAN/LT GRN WIRE TAN/ORG WIRE TAN/PNK WIRE TAN/RED WIRE TAN/WHT WIRE TRANSMISSIONS SYSTEM VIO/BRN WIRE VIO/LT GRN WIRE VIO/TAN WIRE VIO/WHT WIRE VSS SIG 2 GROUND WHT WIRE WHT/DK BLU WIRE YEL WIRE YEL/BLK WIRE YEL/WHT WIRE

AUTO SHUTDOWN RELAY BLK/LT BLU WIRE BRN WIRE BRN/DK BLU WIRE BRN/DK GRN WIRE BRN/PNK WIRE COIL ON PLUG DK BLU/YEL WIRE DK GRN WIRE DK GRN/ORG WIRE DK GRN/RED WIRE DK GRN/WHT WIRE FUEL INJECTOR FUEL PUMP RELAY FUSE 17 FUSE 2 GRY WIRE GRY/LT BLU WIRE HOT AT ALL TIMES HOT IN RUN OR START INTEGRATED POWER MODULE (ON LEFT FRONT OF ENGINE COMPT) LT BLU/BRN WIRE LT BLU/RED WIRE ORG/ WIRE ORG/DK BLU WIRE PNK/LT BLU WIRE PTC 1 TAN WIRE TAN/DK GRN WIRE TAN/LT BLU WIRE TAN/LT GRN WIRE TAN/ORG WIRE TAN/PNK WIRE TAN/RED WIRE TAN/WHT WIRE VIO/TAN WIRE VIO/WHT WIRE WHT WIRE WHT/DK BLU WIRE YEL/WHT WIRE

BLK/LT BLU WIRE BLK/RED WIRE BLK/WHT WIRE BRN WIRE BRN/DK GRN WIRE BRN/ORG WIRE BRN/PNK WIRE BRN/VIO WIRE CAMSHAFT POSITION SENSOR (LOWER FRONT OF RIGHT CYL HEAD) CRANKSHAFT POSITION SENSOR (LOWER RIGHT SIDE OF ENG BLOCK) DK BLU/YEL WIRE DK GRN/ORG WIRE DK GRN/RED WIRE DK GRN/WHT WIRE GRY/BLK WIRE INTAKE AIR TEMPERATURE SENSOR (ON INTAKE MANIFOLD, NEAR THROTTLE BODY) MANIFOLD ABSOLUTE PRESSURE SENSOR (ON FRONT OF INTAKE MANIFOLD) NCA WIRE ORG/ WIRE ORG/DK BLU WIRE OXYGEN SENSOR 1/1 (UPSTREAM) (NEAR LEFT FRONT SIDE OF TRANSMISSION) OXYGEN SENSOR 1/2 (DOWNSTREAM) (NEAR LEFT REAR SIDE OF TRANSMISSION) PNK/LT BLU WIRE TAN/WHT WIRE TAN/YEL WIRE VIO/WHT WIRE WHT WIRE

A/C PRESS SIG AUTO SHUT DOWN RELAY BLK/DK GRN WIRE BLK/GRY WIRE BLK/LT BLU WIRE BLK/RED WIRE BLK/TAN WIRE BRN WIRE BRN/DK BLU WIRE BRN/WHT WIRE BRN/YEL WIRE CALIF CAM POS SNS IDLE AIR 4 IDLE AIR 1 CAPACITOR CONTROLLER ANTI-LOCK BRAKE (LEFT REAR OF ENG COMPT) DK BLU WIRE DK BLU/BLK WIRE DK BLU/TAN WIRE DK BLU/YEL WIRE DK GRN WIRE DK GRN/GRY WIRE DK GRN/ORG WIRE DK GRN/RED WIRE DK GRN/WHT WIRE FUEL INJECTORS FUEL PUMP RELAY FUSE 19 FUSE 17 FUSE 2 FUSED B(+) TPS SENS IN GROUND GROUND GRY WIRE GRY/BLK WIRE GRY/LT BLU WIRE GRY/RED WIRE GRY/YEL WIRE HOT AT ALL TIMES IAT SENS IN ECT SENS IN IGNITION COIL (LEFT) IGNITION COIL (RIGHT) INTEGRATED POWER MODULE (LEFT FRONT OF ENG COMPT) LEFT FRONT FENDER) LT BLU/BRN WIRE LT GRN/BLK WIRE LT GRN/RED WIRE LT GRN/WHT WIRE MAP SENS IN NO 1 DRVR NO 2 DRVR NO 3 DRVR NO 4 DRVR NO 5 DRVR OIL PRESS SIG ORG/ WIRE ORG/BLK WIRE ORG/DK BLU WIRE OUTPUT SENS OUTPUT SPEED SENSOR (ON LEFT REAR OF TRANSMISSION) OVERDRV SOL PNK WIRE POWERTRAIN CONTROL MODULE (ON RIGHT SIDE OF FIREWALL) PTO SW SENS RED/WHT WIRE RED/YEL WIRE RLY OUT STARTING/CHARGING SYSTEM SWITCH TAN WIRE TAN/BLK WIRE TAN/WHT WIRE TAN/YEL WIRE TO FUSE 49 (DIAGRAM 3 OF 3) TRANSMISSION RANGE SENSOR (ON LEFT SIDE OF TRANSMISSION) VAR FRCE SOL VIO WIRE VIO/BLK WIRE VIO/TAN WIRE VIO/WHT WIRE VSS IN OUTPUT SENS GOV PRESS SIG TRANS RELAY WHT/DK BLU WIRE WHT/ORG WIRE YEL/BLK WIRE YEL/GRY WIRE YEL/WHT WIRE

2/2 (DOWN- STREAM) (RIGHT EXHAUST DOWNPIPE, DOWNSTREAM OF CONVERTER) (CALIF) BATTERY TEMPER- ATURE SENSOR (BELOW BATTERY TRAY) BLK WIRE BLK/DK GRN WIRE BLK/LT BLU WIRE BLK/RED WIRE BLK/WHT WIRE BRN WIRE BRN/VIO WIRE BRN/WHT WIRE CAMSHAFT POSITION SENSOR (RIGHT FRONT SIDE OF ENGINE) CLOCKSPRING CRANKSHAFT POSITION SENSOR DK BLU WIRE DK BLU/YEL WIRE DK GRN WIRE DK GRN/BLK WIRE DK GRN/ORG WIRE DK GRN/RED WIRE DK GRN/WHT WIRE DRVR 1 DRVR 2 DRVR 3 DRVR 4 ENGINE COOLANT TEMPERATURE SENSOR (ON THERMOSTAT HOUSING) ENGINE OIL PRESSURE SWITCH (LOWER LEFT SIDE OF ENG) EVAP/ PURGE SOLENOID (LEFT FRONT OF ENGINE COMPT) FRONT SIDE OF TRANS) FRONT SIDE OF TRANSMISSION) FUEL PUMP MODULE (INSIDE FUEL TANK) FUSE 50 GRY/BLK WIRE GRY/RED WIRE GRY/YEL WIRE HEATED OXYGEN SENSOR HEATED OXYGEN SENSOR 11 HEATED OXYGEN SENSOR 12 HEATED OXYGEN SENSOR 21 HOT IN RUN OR START INTEGRATED POWER MODULE (LEFT FRONT OF ENGINE COMPT) LT BLU/BLK WIRE LT GRN/BLK WIRE LT GRN/RED WIRE MANIFOLD ABSOLUTE PRESSURE SENSOR (ON RIGHT UPPER SIDE OF INTAKE MANIFOLD) NCA WIRE ORG/ WIRE ORG/BLK WIRE ORG/DK BLU WIRE PNK WIRE PNK/BLK WIRE PNK/YEL WIRE PTC 1 PTO SWITCH RED WIRE TAN/BLK WIRE TAN/WHT WIRE TAN/YEL WIRE VIO WIRE VIO/BLK WIRE VIO/WHT WIRE WHT WIRE YEL/BLK WIRE