Dodge Pickup R2500 (1996-2010) dk blu/pnk Wiring diagrams

1 2 3 4 AUTO HEADLAMPS SIG SUN SENSOR SIG 1 SUN SENSOR SIG 2 SENSOR GROUND 1 4 3 IGN RUN CTRL OUT IR SENSOR RETURN IR SENSOR SIGNAL 10 9 34 35 FUSED B(+) GND CAN BUS (+) CAN BUS (-) 27 20 SENS GND ECT SIG 4 2 3 1 BLWR MTR HI DRV FT BLW FD BLWR CTRL GND A/C CLUTCH COIL A/C CLUTCH CTRL OUT A/C COMPRESSOR CLUTCH (3.7L, 4.7L: FRONT OF ENGINE) A/C HEATER CONTROL A/C PRESS A/C PRESS SNSE RTN A/C PRESS SNSR FD A/C PRESS SIG A/C PRESS SNSR FD B(+) BLK WIRE BLK/LT BLU WIRE BLK/LT GRN WIRE BLK/TAN WIRE BLOWER MODULE BLOWER MOTOR (RIGHT SIDE BRN WIRE CAN 2 BUS (-) CAN IHS BUS (-) CAN IHS BUS (+) IOD FD FUSED IGN RUN CTRL OUT CIRCUIT BOARD CLUTCH A/C COIL COMPUTER DATA LINES SYSTEM DK BLU WIRE DK BLU/DK GRN WIRE DK BLU/GRY WIRE DK BLU/LT BLU WIRE DK BLU/LT GRN WIRE DK BLU/ORG WIRE DK BLU/PNK WIRE DK BLU/RED WIRE DK BLU/TAN WIRE DK BLU/WHT WIRE DK BLU/YEL WIRE DK GRN/DK BLU WIRE DRIVER BLEND MODE DOOR DOOR ACTUATOR ACTUATOR 1 (ON HVAC UNIT) (ON HVAC UNIT) ENGINE CONTROLS SYSTEM EVAP SIG EVAP SNSE RTN EVAPORATOR TEMPERATURE SENSOR (CENTER OF DASH) FAN RADIATOR HIGH RELAY FAN RADIATOR LOW RELAY FUSE FUSE FUSE HI SPD RAD FAN HOT AT ALL TIMES HOT W/ RUN RELAY ENERGIZED INFRARED SENSOR LOW SPD SIG LT BLU WIRE LT BLU/BRN WIRE LT BLU/ORG WIRE LT BLU/RED WIRE LT GRN WIRE MODE DOOR ACTUATOR 2 (ON HVAC UNIT) NAVIGATION SYSTEM OF DASH) ORG/ WIRE PASSENGER BLEND DOOR ACTUATOR (ON HVAC UNIT) PNK/YEL WIRE POWERTRAIN CONTROL MODULE (3.7L, 4.7L: REAR OF ENGINE) RAD FAN RADIATOR FAN RECIRCULATION DOOR ACTUATOR RED WIRE RED/WHT WIRE SIG SNSE RTN A/C PRESS SPLY BLW MTR SUN SENSOR TAN WIRE TOP OF ENGINE) TOTALLY INTEGRATED POWER MODULE (LEFT FRONT OF ENGINE COMPT) TRANSDUCER) VIO/LT BLU WIRE VIO/ORG WIRE WHT/GRY WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE WHT/ORG WIRE WHT/VIO WIRE

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 GND 1 2 SENS GND SENS SIG 10 34 35 9 BATT FD C BUS (+) C BUS (-) GND 27 20 ECT SIG SENS GND A/C A/C CLUTCH A/C A/C PRESS CTRL PRESS CLUTCH OUTPUT COIL A/C CLUTCH COIL A/C COMPRESSOR CLUTCH (3.7L, 4.7L: FRONT OF ENGINE) A/C HEATER CONTROL A/C PRESS SIG A/C PRESS SNS RTN A/C PRESS SNS SNS SIGNAL RTN FD A/C PRESS SNSR FD A/C PRESSURE TRANSDUCER (3.7L, 4.7L: TOP FRONT OF ENGINE) AUTO HDLP SIG B(+) BLK WIRE BLK/LT BLU WIRE BLK/LT GRN WIRE BLK/TAN WIRE BLOWER MOTOR (RIGHT SIDE OF DASH) BLOWER MOTOR RESISTOR (RIGHT SIDE OF DASH) BLWR CAN 2 CAN 2 MTR BUS (+) BUS (-) SPLY CIRCUIT BOARD COMMON DOOR DRIVER 2 MODE DOOR 2 DRIVER COMPUTER DATA LINES SYSTEM DK BLU WIRE DK BLU/BRN WIRE DK BLU/DK GRN WIRE DK BLU/GRY WIRE DK BLU/LT BLU WIRE DK BLU/LT GRN WIRE DK BLU/ORG WIRE DK BLU/PNK WIRE DK BLU/RED WIRE DK BLU/TAN WIRE DK BLU/VIO WIRE DK BLU/YEL WIRE DK GRN/DK BLU WIRE DRIVER BLEND DOOR ACTUATOR (ON HVAC UNIT) ENGINE CONTROLS SYSTEM EVAP SNSE RTN EVAP SNSE RTN AUTO HDLP SIG EVAP TEMP SENS SIG EVAP SNSE RTN EVAPORATOR TEMPERATURE SENSOR (CENTER OF DASH) FAN RADIATOR HIGH RELAY FAN RADIATOR LOW RELAY FRONT MODE DOOR ACTUATOR FUSE FUSE FUSE HOT AT ALL TIMES HOT W/ RUN RELAY ENERGIZED IOD FD IGN R LT BLU/BRN WIRE LT BLU/ORG WIRE LT BLU/RED WIRE MODE DOOR ACTUATOR 2 (ON HVAC UNIT) PNK/YEL WIRE POWER MODULE (LEFT FRONT OF ENGINE COMPT) POWERTRAIN CONTROL MODULE (3.7L, 4.7L: REAR OF ENGINE) RAD FAN HI SPD SIG RAD FAN LOW SPD SIG RADIATOR FAN RED WIRE RED/WHT WIRE SUN SENSOR TOP OF ENGINE) TOTALLY INTEGRATED VIO/ORG WIRE WHT/GRY WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE WHT/ORG WIRE WHT/VIO WIRE

1 2 3 4 5 6 DSL HIGH SIDE DRVR RTN ENG CTRL COM SNSR RTN RAD FAN MTR SPD SIG 1 2 3 4 AUTO HEADLAMPS SIG SUN SENSOR SIG 1 SUN SENSOR SIG 2 SENSOR GROUND 1 4 3 IGN RUN CTRL OUT IR SENSOR RETURN IR SENSOR SIGNAL 30 53 17 52 ENG CTRL COM SNSR RTN ENG CTRL COM SNSR RTN 4 RAD FAN MTR SPD SIG 4 2 3 1 BLWR MTR HI DRV FT BLW FD BLWR CTRL GND 70 16 33 6 IGN ULK/RUN/STRT A/C CLUTCH A/C CLUTCH COIL A/C COMPRESSOR, CLUTCH (LEFT SIDE OF ENGINE) A/C HEATER CONTROL A/C PRESS SIG A/C PRESS SNSE RTN A/C PRESS SNSE RTN A/C PRESS SNSR FD A/C PRESS SIG 1 2 3 A/C PRESS SNSR FD A/C PRESSURE TRANSDUCER B(+) BLK WIRE BLK/LT BLU WIRE BLK/LT GRN WIRE BLK/TAN WIRE BLOWER MODULE BLOWER MOTOR (RIGHT SIDE OF DASH) BLW MTR SPLY BRN WIRE BRN/LT BLU WIRE BRN/ORG WIRE BRN/PNK WIRE BRN/WHT WIRE BUS (-) CAN CAN IHS BUS (-) CAN IHS BUS (+) IOD FD FUSED IGN RUN CTRL OUT COIL COMPUTER DATA LINES SYSTEM CTRL OUT DK BLU WIRE DK BLU/DK GRN WIRE DK BLU/GRY WIRE DK BLU/LT BLU WIRE DK BLU/LT GRN WIRE DK BLU/ORG WIRE DK BLU/PNK WIRE DK BLU/RED WIRE DK BLU/TAN WIRE DK BLU/WHT WIRE DK BLU/YEL WIRE DK GRN WIRE DRIVER BLEND DOOR ACTUATOR (ON HVAC UNIT) ENGINE CONTROLS SYSTEM ENGINE COOLANT TEMPERATURE SENSOR EVAP SIG EVAP SNSE RTN EVAPORATOR TEMPERATURE SENSOR (CENTER OF DASH) FAN RADIATOR HIGH RELAY FAN RADIATOR LOW RELAY FUSE HALLEFCT ELECN ENG SPD OUT HALLEFCT ELECN ENG SPD OUT ENG CTRL COM SNSR RTN 2 COOL TEMP SNSR SIG 65 20 40 HOT AT ALL TIMES HOT AT ALL TIMES FUSE HOT W/ RUN RELAY ENERGIZED INFRARED SENSOR LT BLU WIRE LT BLU/BRN WIRE LT BLU/ORG WIRE LT BLU/RED WIRE LT GRN WIRE MODE DOOR ACTUATOR 1 (ON HVAC UNIT) MODE DOOR ACTUATOR 2 (ON HVAC UNIT) NAVIGATION SYSTEM ORG/ WIRE PASSENGER BLEND DOOR ACTUATOR (ON HVAC UNIT) PNK/WHT WIRE PNK/YEL WIRE POWERTRAIN CONTROL MODULE RAD FAN RAD FAN LOW SPD SIG RADIATOR FAN RADIATOR FAN DRIVE RECIRCULATION DOOR ACTUATOR RED/WHT WIRE RUN/START SIG HI SPD SUN SENSOR TAN WIRE TOTALLY INTEGRATED POWER MODULE (LEFT FRONT OF ENGINE COMPT) CIRCUIT BOARD VIO/LT BLU WIRE VIO/ORG WIRE WHT/DK BLU WIRE WHT/GRY WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE WHT/ORG WIRE WHT/VIO WIRE

1 2 SENSOR GROUND SENSOR SIGNAL A/C COMPRESSOR CLUTCH RELAY A/C HEATER CONTROL A/C INDICATOR A/C SELECT BLEND DOOR DRIVER BLK/DK BLU WIRE BLK/TAN WIRE BLOWER MOTOR (BENEATH LOWER RIGHT SIDE OF DASH, ON HVAC ASSEMBLY) BLOWER MOTOR RESISTOR BLOCK (BENEATH LOWER RIGHT SIDE OF DASH, ON HVAC ASSEMBLY) BLU WIRE COMMON DOOR DRIVER CONDENSER FAN RELAY DATA LINK CONNECTOR (BELOW LEFT SIDE OF DASH) DIESEL DK BLU WIRE DK BLU/BLK WIRE DK BLU/GRY WIRE DK BLU/ORG WIRE DK BLU/PNK WIRE DK BLU/RED WIRE DK BLU/WHT WIRE DK BLU/YEL WIRE DK DK DK DK DK DK DK DK DK LT PNK W/DUAL ZONE A/C WIRE DK GRN WIRE DK GRN/YEL WIRE EVAPORATOR TEMPERATURE SENSOR (BEHIND RIGHT SIDE OF DASH, INSIDE HVAC ASSEMBLY) FUSE 16 FUSE 12 PTC 1 FUSE 36 GRN WIRE GRY WIRE GRY/DK BLU WIRE HEATED MIRROR RELAY HEATER MIRROR INDICATOR HOT AT ALL TIMES HOT IN HOT IN RUN OR START HVAC MICRO CONTROLLER IGNITION SWITCH INSTRUMENT CLUSTER INTEGRATED POWER MODULE (ON LEFT FRONT OF ENGINE COMPARTMENT) LOCK OFF LT BLU WIRE LT BLU/VIO WIRE LT BLU/YEL WIRE LT GRN WIRE LT GRN/BLK WIRE OFF OFF HEATED MIRROR ORG/YEL WIRE PANEL LAMPS DRIVER PASS BLEND DOOR DRIVER RECIRC RECIRCULATION DOOR ACTUATOR (BEHIND RIGHT SIDE OF DASH, ON HVAC ASSEMBLY) RECIRCULATION DOOR DRIVER RECIRCULATION INDICATOR RED WIRE RED/BLK WIRE RUN WIRE TAN WIRE VIO/LT GRN WIRE WHT WIRE WHT/BLK WIRE YEL WIRE YEL/LT GRN WIRE

ABMT TEMP/FCM ABS PMP FD ADJ PED SW FD AMBIENT AIR TEMPERATURE SENSOR (LEFT FRONT OF ENGINE COMPT) AMBT TEMP SIG ANTI-LOCK BRAKES SYSTEM B(+) BATT FD 1 GND WDW RUN/ACCY IGN BATT FD 7 IOD FD TO DR NODE-PASS GND FT WPR MTR HI SPD FD FUEL PUMP MTR FD BATTERY BLK WIRE BLK/LT BLU WIRE BLK/LT GRN WIRE BRN WIRE BRN/GRY WIRE BRN/ORG WIRE BRN/TAN WIRE BRN/WHT WIRE BRN/YEL WIRE CAN BUS C DIAG (+) CAN BUS C DIAG (-) CAN IHS BUS (+) CAN IHS BUS (-) COMPUTER DATA LINES SYSTEM COOLING FANS SYSTEM DK BLU/DK GRN WIRE DK BLU/ORG WIRE DK BLU/PNK WIRE DK BLU/WHT WIRE DK GRN/DK BLU WIRE DK GRN/RED WIRE DOOR LOCKS SYSTEM DOOR LOCKS, ANTI-THEFT SYSTEMS ENGINE COMPT) ENGINE CONTROLS SYSTEM FRONT WASHER FLUID LEVEL SENSOR FT WPR MTR PRK SIG FUEL LVL SENS SIG FUSED HORN CTRL OUT GRY WIRE GRY/LT BLU WIRE GRY/YEL WIRE HEADLIGHTS SYSTEM HEADLIGHTS SYSTEM WIPER/WASHER SYSTEM HOOD AJAR SWITCH (LEFT FRONT OF ENGINE COMPT) HORNS SYSTEM IGN RUN/ST CTRL OUT IOD FD IGN SW FD IGN RUN ACC BKUP LMPS FD TTOW IGN MOD FSED BATT FD IOD FD IOD FD IOD FD LO SPD RAD FAN CTRL LT BLU WIRE LT BLU/PNK WIRE LT BLU/RED WIRE LT GRN/LT BLU WIRE LT GRN/RED WIRE LT GRN/TAN WIRE NAVIGATION SYSTEM INSTRUMENT CLUSTER SYSTEM POWER DISTRIBUTION SYSTEM ORC MOD RUN/STRT IGN CLSTR/CHMSL BATT FD BATT FD 4 ABS MOD BATT FD IOD FD ORG/RED WIRE PNK IGN RUN/STRT CTRL OUT WIRE PNK/LT GRN WIRE PNK/ORG WIRE PNK/TAN WIRE PNK/WHT WIRE PNK/YEL WIRE POWER DISTRIBUTION SYSTEM POWER WINDOWS SYSTEM PWR ENABLE TO SW RED WIRE RED/LT BLU WIRE RED/LT GRN WIRE RED/ORG WIRE RED/PNK WIRE RED/WHT WIRE RR WSH CTRL FT WSH MTR CTRL RT HI BEAM FD HDLP RT RTN LT LO BEAM FD LO WSH SW SNSE SEATS SYSTEM SEATS, MEMORY SYSTEMS DOOR LOCKS SYSTEM SSR RTN 1 TAN/RED WIRE TOTALLY INTEGRATED POWER MODULE (LEFT FRONT OF TOTALLY INTEGRATED POWER MODULE (LEFT FRONT OF ENGINE COMPT) VIO WIRE VIO/BRN WIRE VIO/GRY WIRE VIO/LT BLU WIRE VIO/LT GRN WIRE VIO/WHT WIRE VIO/YEL WIRE WHT WIRE WHT/BRN WIRE WHT/DK BLU WIRE WHT/DK GRN WIRE WHT/GRY WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE WHT/ORG WIRE WHT/RED WIRE WHT/TAN WIRE WHT/VIO WIRE WHT/YEL WIRE WIPER/WASHER SYSTEM WIPER/WASHER SYSTEM ENGINE CONTROLS SYSTEM YEL/RED WIRE

5 VOLT SPLY ASCD CTRL ASD CTRL OUT AUTO SHUTDOWN RELAY B(+) BLK WIRE BRN WIRE BRN/BLK WIRE BRN/DK BLU WIRE BRN/DK GRN WIRE BRN/GRY WIRE BRN/LT BLU WIRE BRN/LT GRN WIRE BRN/ORG WIRE BRN/TAN WIRE BRN/VIO WIRE BRN/WHT WIRE BRN/YEL WIRE CAN-BUS CAN-BUS CIRCUIT BOARD CMP SIG CKP SIG KNOCK SENS 2 SIG KNOCK SENS 2 RETURN ETC MOTOR (-) COIL CTRL 7 INJECTOR CTRL 8 INJECTOR CTRL 7 COMPUTER DATA LINES SYSTEM DK BLU BRN/ WIRE DK BLU/DK GRN WIRE DK BLU/GRY WIRE DK BLU/LT BLU WIRE DK BLU/LT GRN WIRE DK BLU/ORG WIRE DK BLU/PNK WIRE DK BLU/RED WIRE DK BLU/TAN WIRE DK BLU/WHT WIRE DK BLU/YEL WIRE DK GRN BRN/ WIRE FUSE FUSED B (+) GEN FIELD CTRL ECT SIG TP 1 SIG GEN SNS GROUND FUSED B(+) IGN SW OUT (RUN-START) IGN SW OUT (OFF-RUN-START) GROUND GROUND OIL PRESSURE SIG SRV SEN OUT GRY WIRE HOT AT ALL TIMES KNOCK SENS 1 (-) KNOCK SENS 1 RETURN KNOCK SENS 2 (-) KNOCK SENS 2 RETURN LEFT KNOCK SENSOR 1 MAP SIG KNOCK SENS 1 RETURN KNOCK SENS 1 SIG PNK/GRY WIRE PNK/WHT WIRE PNK/YEL WIRE POWERTRAIN CONTROL MODULE RED WIRE RED/GRY WIRE RIGHT KNOCK SENSOR 2 RUN-START) IGN (OFF- SENS GROUND TP 2 SIG 5 VOLT SPLY IAT SIG SIG SRV ACTR CTRL SIG STARTING/ CHARGING SYSTEM TAN/ORG WIRE TAN/YEL WIRE TOTALLY INTEGRATED POWER MODULE (LEFT FRONT OF ENGINE COMPT) VIO/BRN WIRE VIO/GRY WIRE VIO/ORG WIRE WHT WIRE WHT/BRN WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE YEL/DK BLU WIRE YEL/PNK WIRE

ASD CTRL B(+) BATT FD BLK WIRE BLK/GRY WIRE BLK/TAN WIRE BRK ACTV BRN WIRE BRN/BLK WIRE BRN/DK BLU WIRE BRN/DK GRN WIRE BRN/GRY WIRE BRN/LT BLU WIRE BRN/LT GRN WIRE BRN/ORG WIRE BRN/TAN WIRE BRN/VIO WIRE BRN/WHT WIRE BRN/YEL WIRE CLSTR/CHMSL CTRL SIG DK BLU/DK GRN WIRE DK BLU/GRY WIRE DK BLU/LT BLU WIRE DK BLU/LT GRN WIRE DK BLU/ORG WIRE DK BLU/PNK WIRE DK BLU/RED WIRE DK BLU/TAN WIRE DK BLU/WHT WIRE DK BLU/YEL WIRE DK GRN/RED WIRE ENGINE COOLANT TEMPERATURE SENSOR FD 3 FUEL LVL SNSR RTN FUEL PUMP MODULE FUEL PUMP RELAY FUEL SNDR LVL SIG PRI FUSE HOT AT ALL TIMES HOT AT ALL TIMES CIRCUIT BOARD IGN SW OUT (RUN-START) INTAKE AIR TEMPERATURE SENSOR LT BLU/DK GRN WIRE LT GRN/RED WIRE LT GRN/TAN WIRE LVL SNSR RTN MANIFOLD ABSOLUTE PRESSURE (MAP) SENSOR OF ENGINE COMPT) OXYGEN SENSOR 1/1 (IN EXHAUST, LEFT OF TRANSMISSION) OXYGEN SENSOR 1/2 (IN EXHAUST, LEFT OF TRANSMISSION) OXYGEN SENSOR 2/1 (IN EXHAUST, LEFT OF TRANSMISSION) OXYGEN SENSOR 2/2 (IN EXHAUST, LEFT OF TRANSMISSION) PMP MTR FD PMP RLY FD PNK/GRY WIRE PNK/YEL WIRE PRIMARY SHORT RUNNER VALVE SOLENOID (REAR OF ENGINE) SNDR LVL SIG SNSE SIG SNSE SIG 2 SRV ACTR SRV SEN OUT STOP LAMP SWITCH (ON BRAKE PEDAL SUPPORT) TOP OF ENGINE) TOTALLY INTEGRATED POWER MODULE (LEFT FRONT VIO/BRN WIRE VIO/GRY WIRE VIO/ORG WIRE YEL/DK BLU WIRE YEL/PNK WIRE