Dodge Pickup R2500 (1996-2010) dk blu/gry Wiring diagrams

1 2 3 4 AUTO HEADLAMPS SIG SUN SENSOR SIG 1 SUN SENSOR SIG 2 SENSOR GROUND 1 4 3 IGN RUN CTRL OUT IR SENSOR RETURN IR SENSOR SIGNAL 10 9 34 35 FUSED B(+) GND CAN BUS (+) CAN BUS (-) 27 20 SENS GND ECT SIG 4 2 3 1 BLWR MTR HI DRV FT BLW FD BLWR CTRL GND A/C CLUTCH COIL A/C CLUTCH CTRL OUT A/C COMPRESSOR CLUTCH (3.7L, 4.7L: FRONT OF ENGINE) A/C HEATER CONTROL A/C PRESS A/C PRESS SNSE RTN A/C PRESS SNSR FD A/C PRESS SIG A/C PRESS SNSR FD B(+) BLK WIRE BLK/LT BLU WIRE BLK/LT GRN WIRE BLK/TAN WIRE BLOWER MODULE BLOWER MOTOR (RIGHT SIDE BRN WIRE CAN 2 BUS (-) CAN IHS BUS (-) CAN IHS BUS (+) IOD FD FUSED IGN RUN CTRL OUT CIRCUIT BOARD CLUTCH A/C COIL COMPUTER DATA LINES SYSTEM DK BLU WIRE DK BLU/DK GRN WIRE DK BLU/GRY WIRE DK BLU/LT BLU WIRE DK BLU/LT GRN WIRE DK BLU/ORG WIRE DK BLU/PNK WIRE DK BLU/RED WIRE DK BLU/TAN WIRE DK BLU/WHT WIRE DK BLU/YEL WIRE DK GRN/DK BLU WIRE DRIVER BLEND MODE DOOR DOOR ACTUATOR ACTUATOR 1 (ON HVAC UNIT) (ON HVAC UNIT) ENGINE CONTROLS SYSTEM EVAP SIG EVAP SNSE RTN EVAPORATOR TEMPERATURE SENSOR (CENTER OF DASH) FAN RADIATOR HIGH RELAY FAN RADIATOR LOW RELAY FUSE FUSE FUSE HI SPD RAD FAN HOT AT ALL TIMES HOT W/ RUN RELAY ENERGIZED INFRARED SENSOR LOW SPD SIG LT BLU WIRE LT BLU/BRN WIRE LT BLU/ORG WIRE LT BLU/RED WIRE LT GRN WIRE MODE DOOR ACTUATOR 2 (ON HVAC UNIT) NAVIGATION SYSTEM OF DASH) ORG/ WIRE PASSENGER BLEND DOOR ACTUATOR (ON HVAC UNIT) PNK/YEL WIRE POWERTRAIN CONTROL MODULE (3.7L, 4.7L: REAR OF ENGINE) RAD FAN RADIATOR FAN RECIRCULATION DOOR ACTUATOR RED WIRE RED/WHT WIRE SIG SNSE RTN A/C PRESS SPLY BLW MTR SUN SENSOR TAN WIRE TOP OF ENGINE) TOTALLY INTEGRATED POWER MODULE (LEFT FRONT OF ENGINE COMPT) TRANSDUCER) VIO/LT BLU WIRE VIO/ORG WIRE WHT/GRY WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE WHT/ORG WIRE WHT/VIO WIRE

1 2 SENSOR GROUND SENSOR SIGNAL A/C COMPRESSOR CLUTCH RELAY A/C HEATER CONTROL A/C INDICATOR A/C SELECT BLEND DOOR DRIVER BLK/DK BLU WIRE BLK/TAN WIRE BLOWER MOTOR (BENEATH LOWER RIGHT SIDE OF DASH, ON HVAC ASSEMBLY) BLOWER MOTOR RESISTOR BLOCK (BENEATH LOWER RIGHT SIDE OF DASH, ON HVAC ASSEMBLY) BLU WIRE COMMON DOOR DRIVER CONDENSER FAN RELAY DATA LINK CONNECTOR (BELOW LEFT SIDE OF DASH) DIESEL DK BLU WIRE DK BLU/BLK WIRE DK BLU/GRY WIRE DK BLU/ORG WIRE DK BLU/PNK WIRE DK BLU/RED WIRE DK BLU/WHT WIRE DK BLU/YEL WIRE DK DK DK DK DK DK DK DK DK LT PNK W/DUAL ZONE A/C WIRE DK GRN WIRE DK GRN/YEL WIRE EVAPORATOR TEMPERATURE SENSOR (BEHIND RIGHT SIDE OF DASH, INSIDE HVAC ASSEMBLY) FUSE 16 FUSE 12 PTC 1 FUSE 36 GRN WIRE GRY WIRE GRY/DK BLU WIRE HEATED MIRROR RELAY HEATER MIRROR INDICATOR HOT AT ALL TIMES HOT IN HOT IN RUN OR START HVAC MICRO CONTROLLER IGNITION SWITCH INSTRUMENT CLUSTER INTEGRATED POWER MODULE (ON LEFT FRONT OF ENGINE COMPARTMENT) LOCK OFF LT BLU WIRE LT BLU/VIO WIRE LT BLU/YEL WIRE LT GRN WIRE LT GRN/BLK WIRE OFF OFF HEATED MIRROR ORG/YEL WIRE PANEL LAMPS DRIVER PASS BLEND DOOR DRIVER RECIRC RECIRCULATION DOOR ACTUATOR (BEHIND RIGHT SIDE OF DASH, ON HVAC ASSEMBLY) RECIRCULATION DOOR DRIVER RECIRCULATION INDICATOR RED WIRE RED/BLK WIRE RUN WIRE TAN WIRE VIO/LT GRN WIRE WHT WIRE WHT/BLK WIRE YEL WIRE YEL/LT GRN WIRE

15 16 CAN B BUS (-) CAN B BUS (+) A/C HEATER CONTROL B(+) BLK WIRE CAN B CAN B BUS (+) BUS (-) COMPUTER DATA LINES SYSTEM DK BLU/GRY WIRE DRIVER OUTSIDE REARVIEW MIRROR (DRIVER'S DOOR) ELECTRONICS EXCEPT BASE FUSE 8 HOT AT ALL TIMES ORG/ WIRE PASSENGER (LEFT KICK OUTSIDE PANEL) REARVIEW MIRROR (FRONT PASSENGER'S DOOR) REAR WINDOW DEFOG SWITCH REAR WINDOW DEFOGGER CTRL OUT TOTALLY INTEGRATED POWER MODULE (LEFT FRONT FENDER) WHT WIRE WHT/ORG WIRE

5 VOLT SPLY ASCD CTRL ASD CTRL OUT AUTO SHUTDOWN RELAY B(+) BLK WIRE BRN WIRE BRN/BLK WIRE BRN/DK BLU WIRE BRN/DK GRN WIRE BRN/GRY WIRE BRN/LT BLU WIRE BRN/LT GRN WIRE BRN/ORG WIRE BRN/TAN WIRE BRN/VIO WIRE BRN/WHT WIRE BRN/YEL WIRE CAN-BUS CAN-BUS CIRCUIT BOARD CMP SIG CKP SIG KNOCK SENS 2 SIG KNOCK SENS 2 RETURN ETC MOTOR (-) COIL CTRL 7 INJECTOR CTRL 8 INJECTOR CTRL 7 COMPUTER DATA LINES SYSTEM DK BLU BRN/ WIRE DK BLU/DK GRN WIRE DK BLU/GRY WIRE DK BLU/LT BLU WIRE DK BLU/LT GRN WIRE DK BLU/ORG WIRE DK BLU/PNK WIRE DK BLU/RED WIRE DK BLU/TAN WIRE DK BLU/WHT WIRE DK BLU/YEL WIRE DK GRN BRN/ WIRE FUSE FUSED B (+) GEN FIELD CTRL ECT SIG TP 1 SIG GEN SNS GROUND FUSED B(+) IGN SW OUT (RUN-START) IGN SW OUT (OFF-RUN-START) GROUND GROUND OIL PRESSURE SIG SRV SEN OUT GRY WIRE HOT AT ALL TIMES KNOCK SENS 1 (-) KNOCK SENS 1 RETURN KNOCK SENS 2 (-) KNOCK SENS 2 RETURN LEFT KNOCK SENSOR 1 MAP SIG KNOCK SENS 1 RETURN KNOCK SENS 1 SIG PNK/GRY WIRE PNK/WHT WIRE PNK/YEL WIRE POWERTRAIN CONTROL MODULE RED WIRE RED/GRY WIRE RIGHT KNOCK SENSOR 2 RUN-START) IGN (OFF- SENS GROUND TP 2 SIG 5 VOLT SPLY IAT SIG SIG SRV ACTR CTRL SIG STARTING/ CHARGING SYSTEM TAN/ORG WIRE TAN/YEL WIRE TOTALLY INTEGRATED POWER MODULE (LEFT FRONT OF ENGINE COMPT) VIO/BRN WIRE VIO/GRY WIRE VIO/ORG WIRE WHT WIRE WHT/BRN WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE YEL/DK BLU WIRE YEL/PNK WIRE

ASD CTRL B(+) BATT FD BLK WIRE BLK/GRY WIRE BLK/TAN WIRE BRK ACTV BRN WIRE BRN/BLK WIRE BRN/DK BLU WIRE BRN/DK GRN WIRE BRN/GRY WIRE BRN/LT BLU WIRE BRN/LT GRN WIRE BRN/ORG WIRE BRN/TAN WIRE BRN/VIO WIRE BRN/WHT WIRE BRN/YEL WIRE CLSTR/CHMSL CTRL SIG DK BLU/DK GRN WIRE DK BLU/GRY WIRE DK BLU/LT BLU WIRE DK BLU/LT GRN WIRE DK BLU/ORG WIRE DK BLU/PNK WIRE DK BLU/RED WIRE DK BLU/TAN WIRE DK BLU/WHT WIRE DK BLU/YEL WIRE DK GRN/RED WIRE ENGINE COOLANT TEMPERATURE SENSOR FD 3 FUEL LVL SNSR RTN FUEL PUMP MODULE FUEL PUMP RELAY FUEL SNDR LVL SIG PRI FUSE HOT AT ALL TIMES HOT AT ALL TIMES CIRCUIT BOARD IGN SW OUT (RUN-START) INTAKE AIR TEMPERATURE SENSOR LT BLU/DK GRN WIRE LT GRN/RED WIRE LT GRN/TAN WIRE LVL SNSR RTN MANIFOLD ABSOLUTE PRESSURE (MAP) SENSOR OF ENGINE COMPT) OXYGEN SENSOR 1/1 (IN EXHAUST, LEFT OF TRANSMISSION) OXYGEN SENSOR 1/2 (IN EXHAUST, LEFT OF TRANSMISSION) OXYGEN SENSOR 2/1 (IN EXHAUST, LEFT OF TRANSMISSION) OXYGEN SENSOR 2/2 (IN EXHAUST, LEFT OF TRANSMISSION) PMP MTR FD PMP RLY FD PNK/GRY WIRE PNK/YEL WIRE PRIMARY SHORT RUNNER VALVE SOLENOID (REAR OF ENGINE) SNDR LVL SIG SNSE SIG SNSE SIG 2 SRV ACTR SRV SEN OUT STOP LAMP SWITCH (ON BRAKE PEDAL SUPPORT) TOP OF ENGINE) TOTALLY INTEGRATED POWER MODULE (LEFT FRONT VIO/BRN WIRE VIO/GRY WIRE VIO/ORG WIRE YEL/DK BLU WIRE YEL/PNK WIRE

5 VOLT SPLY ACCELERATOR PEDAL POSITION SENSOR (LEFT SIDE OF DASH) APP 1 RTN APP 1 SIG APP 2 RTN APP 2 SIG BRN WIRE BRN/BLK WIRE BRN/DK BLU WIRE BRN/GRY WIRE BRN/LT BLU WIRE BRN/LT GRN WIRE BRN/ORG WIRE BRN/TAN WIRE BRN/VIO WIRE BRN/WHT WIRE BRN/YEL WIRE CAMSHAFT POSITION SENSOR CRANKSHAFT POSITION SENSOR DK BLU/DK GRN WIRE DK BLU/GRY WIRE DK BLU/ORG WIRE DK BLU/RED WIRE DK BLU/TAN WIRE DK BLU/YEL WIRE DK GRN/RED WIRE LINE PRESSURE SENSOR LINE SENS LT BLU/DK GRN WIRE OIL PRESSURE SENSOR OIL TEMPERATURE SENSOR PNK/YEL WIRE SENS GND TOP OF ENGINE) VIO/BLK WIRE VIO/GRY WIRE WHT/BRN WIRE YEL/DK BLU WIRE YEL/PNK WIRE

28 29 30 31 32 33 34 35 36 37 38 TP 2 SIG 5 VOLT SUPPLY IAT SIG 3 5 7 9 11 TPS 1 OUT APP 1 OUT REQ SENS SENS GRD RPM SIG 5-VOLT AC COMP CLTCH ACCELERATOR PEDAL POSITION SENSOR AIR CONDITIONING SYSTEM APPS 1 RET APPS 1 RET APPS 2 RET S/C SW 2 SIG ASD RELAY OUT SOL CTRL APPS 1 SIG APPS 2 RET APPS 2 SIG ASD RELAY OUT SOL CTRL PRS SW SIG AUTO SHT RLY BATTERY TEMPERATURE SENSOR (UNDER BATTERY TRAY) BLK WIRE BLK/DK GRN WIRE BLK/LT BLU WIRE BLK/PNK WIRE BLK/RED WIRE BLK/VIO WIRE BRAKE LAMP SWITCH (ABOVE BRAKE PEDAL) BRK SW 2 SIG BRN WIRE BRN/DK GRN WIRE BRN/ORG WIRE BRN/PNK WIRE BRN/VIO WIRE CLOCKSPRING CMP SIG CKP SENS SIG KNOCK 2 SIG KNOCK 2 RET ETC MTR CTRL COOLING FANS SYSTEM CRUISE CONTROL SYSTEM DK BLU/DK GRN WIRE DK BLU/GRY WIRE DK BLU/ORG WIRE DK BLU/VIO WIRE DK BLU/YEL WIRE DK GRN/ORG WIRE DK GRN/WHT WIRE ELECTRONIC THROTTLE CONTROL MODULE EVAP/PURGE SOLENOID (LEFT FRONT OF ENGINE COMPT) FAN RLY CTRL FUEL PUMP MODULE (INSIDE FUEL TANK) GRY/BLK WIRE LEAK DETECTION PUMP (FORWARD OF FUEL TANK) LEFT FRONT FENDER) LT BLU/BLK WIRE ORG/ WIRE ORG/DK BLU WIRE ORG/PNK WIRE PMP SOL CTRL 1/2 HTR CTRL PNK/BLK WIRE PNK/DK BLU WIRE PNK/YEL WIRE POWER STEERING PRESSURE SWITCH (BELOW POWER STEERING RESERVOIR) POWERTRAIN CONTROL MODULE (ON RIGHT SIDE OF FIREWALL) PTO SW SENS BRAKE SW SENS PTO SWITCH CONTROLLER ANTI-LOCK BRAKE (ON LEFT REAR OF ENG COMPT) RED/LT GRN WIRE RED/WHT WIRE RIGHT KNOCK SENSOR SENSE STARTING/ CHARGING SYSTEM TAN/BLK WIRE TAN/YEL WIRE TRANS- MISSIONS SYSTEM VIO/ORG WIRE VIO/WHT WIRE WHT WIRE WHT/DK GRN WIRE WHT/PNK WIRE WHT/TAN WIRE YEL/BLK WIRE YEL/DK GRN WIRE YEL/RED WIRE

5-VOLT APPS 1 RET APPS 1 SIG APPS 2 RET APPS 2 SIG BLK WIRE BLK/GRY WIRE BOOST SENS SIG BRN WIRE BRN/DK BLU WIRE BRN/GRY WIRE BRN/LT BLU WIRE BRN/LT GRN WIRE BRN/ORG WIRE BRN/TAN WIRE BRN/VIO WIRE BRN/WHT WIRE BRN/YEL WIRE CAMSHAFT POSITION SENSOR CAN C BUS (+) CAN C BUS (-) F/P RET GEN FIELD CTRL TTVA MOTOR (+) CKP SENS GND SENS RET CKP SIG COMPUTER DATA LINES SYSTEM CRANKSHAFT POSITION SENSOR DK BLU WIRE DK BLU/BRN WIRE DK BLU/DK GRN WIRE DK BLU/GRY WIRE DK BLU/LT GRN WIRE DK BLU/TAN WIRE DK GRN WIRE DRIVER BANK 1 ENGINE CONTROL MODULE (LOWER LEFT FRONT OF ENGINE BLOCK) ENGINE COOLANT TEMPERATURE SENSOR FUEL CTRL TTVA MOTOR (-) SENS GND CKP SIG SENS GND CMP SIG FUEL INJECTORS FUEL RAIL PRESSURE SENSOR (LEFT SIDE OF ENGINE) FUEL SENS FUEL RAIL SIG INLET SNS GRY WIRE IAT SENS SIG PRESSURE SNS ECT SIG INJ 2 CTRL INJ 3 CTRL SENS GND INJ 4 CTRL INJ 5 CTRL DRIVER BANK 2 INJ 6 CTRL LT BLU WIRE MAP TEMPERATURE/ PRESSURE SENSOR PNK/YEL WIRE RET SENS GND SENS GND INJ 1 CTRL SENS SIG CMP SENS GND APPS 1 SIG SENS SIG SIG STARTING/CHARGING SYSTEM TAN WIRE TAN/ORG WIRE TAN/PNK WIRE TAN/YEL WIRE VIO/BRN WIRE VIO/GRY WIRE VIO/LT GRN WIRE VIO/ORG WIRE VIO/WHT WIRE WHT/BRN WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE

5 VOLT SUPPLY ACTUATOR GND BRN WIRE BRN/DK BLU WIRE BRN/DK GRN WIRE BRN/LT BLU WIRE BRN/ORG WIRE BRN/PNK WIRE BRN/VIO WIRE BRN/YEL WIRE BYPASS STATUS CAMSHAFT POSITION SENSOR (LOWER LEFT FRONT OF ENGINE) CRANKCASE SENSOR (TOP LEFT SIDE OF ENGINE) DK BLU/BRN WIRE DK BLU/GRY WIRE DK BLU/LT GRN WIRE DK BLU/TAN WIRE EGR AIRFLOW CONTROL VALVE (LEFT SIDE OF ENGINE) EGR COOLER BY-PASS VALVE ELECTRONIC TURBO ACTUATOR (LOWER RIGHT FRONT OF ENGINE EXHAUST PRESSURE SENSOR 1/1 (TOP RIGHT FRONT OF ENGINE) FUEL CONTROL ACTUATOR (LEFT FRONT OF ENGINE) FUEL RAIL PRESSURE SENSOR (TOP LEFT REAR OF ENGINE) FUSED B (+) HIGH DATA LINK INLET TEMPERATURE/ PRESSURE SENSOR (TOP RIGHT OF ENGINE) LOW DATA LINK MAP TEMPERATURE/ PRESSURE SENSOR (TOP LEFT SIDE OF ENGINE) MASS AIR FLOW SENSOR (TOP RIGHT FRONT OF ENGINE) OF ENGINE COMPT) PNK/ORG WIRE PNK/YEL WIRE PRES SENS SIG PWR RLY RTN RADIATOR FAN DRIVE (FRONT OF ENGINE COMPT) RED/ORG WIRE RLY FEED SENS GND SENS SIG SENSOR GND SIGNAL SMART POWER RELAY (LEFT FRONT TEMP SENS SIG TTVA MTR (+) VALVE (+) SIG VIO/WHT WIRE WHT/LT GRN WIRE

BLK WIRE BRN WIRE BRN/DK BLU WIRE BRN/DK GRN WIRE BRN/GRY WIRE BRN/LT BLU WIRE BRN/ORG WIRE BRN/PNK WIRE BRN/TAN WIRE BRN/VIO WIRE BRN/WHT WIRE BRN/YEL WIRE CRANKSHAFT POSITION SENSOR (LOWER LEFT FRONT OF ENGINE) DK BLU WIRE DK BLU/BRN WIRE DK BLU/GRY WIRE DK BLU/LT BLU WIRE DK BLU/LT GRN WIRE DK BLU/TAN WIRE DK BLU/WHT WIRE DK BLU/YEL WIRE EGR BYPASS VLV SIG FUEL CTRL RTN EGR TEMPERATURE SENSOR (TOP LEFT FRONT OF ENGINE) EGR VALVE ASSEMBLY ENGINE CONTROL MODULE (LOWER LEFT FRONT OF ENGINE BLOCK) ENGINE COOLANT TEMPERATURE SENSOR (TOP FRONT OF ENGINE) FAN SPD SENS GND FUEL INJECTOR 1 (TOP OF ENGINE, OVER CYLINDER 1) FUEL INJECTOR 2 (TOP OF ENGINE, OVER CYLINDER 2) FUEL INJECTOR 3 (TOP OF ENGINE, OVER CYLINDER 3) FUEL INJECTOR 4 (TOP OF ENGINE, OVER CYLINDER 4) FUEL INJECTOR 5 (TOP OF ENGINE, OVER CYLINDER 5) FUEL INJECTOR 6 (TOP OF ENGINE, OVER CYLINDER 6) GRY WIRE GRY/BRN WIRE GRY/DK BLU WIRE INTAKE TEMPERATURE /PRESSURE SENSOR (RAM 2500) (RIGHT SIDE OF ENGINE) LT BLU/BRN WIRE LT GRN/BRN WIRE OIL PRESSURE SWITCH (LEFT SIDE OF ENGINE) ORG/BRN WIRE PNK/YEL WIRE RED WIRE SENS GND SENS SIG SIG STARTING/ CHARGING SYSTEM TAN WIRE TTVA MTR (+) CRANKCASE SENS SIG ECT SIG TURBO SPEED SENSOR (LOWER RIGHT FRONT OF ENGINE) VIO/GRY WIRE VIO/LT GRN WIRE VIO/ORG WIRE VIO/WHT WIRE WATER IN FUEL SENSOR (MIDDLE LEFT SIDE OF ENGINE BLOCK) WHT/BRN WIRE WHT/LT GRN WIRE YEL/BRN WIRE