Dodge Pickup R2500 (1996-2010) controller anti-lock brake Wiring diagrams

5 VOLT SUPPLY 9 10 11 12 PNK WIRE BLK WIRE BLK/LT BLU WIRE BLK/WHT WIRE BRN WIRE CONTROLLER ANTI-LOCK BRAKE DK BLU WIRE ENGINE CONTROLS SYSTEM ENGINE COOLANT TEMPERATURE SENSOR (ON LEFT SIDE OF CYLINDER HEAD, AT REAR END) ENGINE SPEED SENSOR (ON FRONT OF ENG, IN TIMING CHAIN CASE/COVER) ENGINE STARTER MOTOR RELAY FUSE FUSE 3 GENERATOR GRN WIRE GRY/BLK WIRE HOT AT ALL TIMES INNER FENDER) JOINT CONNECTOR 2 LT BLU WIRE LT GRN/WHT WIRE OF HYDRAULIC CONTROL UNIT) ORG/ WIRE ORG/BLK WIRE ORG/DK BLU WIRE OVERDRIVE SOLENOID CONTROL VARIABLE FORCE SOLENOID CONTROL PARK/ NEUTRAL POSITION SWITCH (ON LEFT SIDE OF TRANSMISSION) PNK WIRE POWER DISTRIBUTION CENTER RED WIRE RED/WHT WIRE SENSOR GROUND GOVERNOR PRESSURE SIGNAL TAN WIRE TAN/BLK WIRE THROTTLE POSITION SENSOR (ON TOP OF INJECTION PUMP) TORQUE CONVERTER CLUTCH SOLENOID CONTROL TRANS CTRL RLY OUTPUT TRANSMISSION CONTROL RELAY TRANSMISSION SOLENOID ASSEMBLY (TRANSMISSION) TRANSMISSION TEMPERATURE SENSOR SIGNAL VIO WIRE VIO/WHT WIRE WHT WIRE WHT/DK BLU WIRE WHT/ORG WIRE YEL WIRE

5 VOLT SUPPLY 9 10 11 PNK WIRE BLK WIRE BLK/DK BLU WIRE BLK/LT BLU WIRE BLK/WHT WIRE BRN WIRE CONTROLLER ANTI-LOCK BRAKE DK BLU WIRE ENGINE CONTROLS SYSTEM ENGINE COOLANT TEMPERATURE SENSOR (ON LEFT SIDE OF CYLINDER HEAD, AT REAR END) ENGINE SPEED SENSOR (ON FRONT OF ENG, IN TIMING CHAIN CASE/COVER) ENGINE STARTER MOTOR RELAY FUSE FUSE 3 GENERATOR GOVERNOR PRESSURE SIGNAL SENSOR GROUND VARIABLE FORCE SOLENOID CONTROL GRN WIRE GRY WIRE HOT AT ALL TIMES INNER FENDER) JOINT CONNECTOR 2 LT BLU WIRE LT GRN/WHT WIRE OF HYDRAULIC CONTROL UNIT) ORG/ WIRE ORG/BLK WIRE OVERDRIVE SOLENOID CONTROL TORQUE CONVERTER CLUTCH SOLENOID CONTROL PARK/ NEUTRAL POSITION SWITCH (ON LEFT SIDE OF TRANSMISSION) PNK WIRE POWER DISTRIBUTION CENTER RED WIRE RED/WHT WIRE TAN WIRE TAN/BLK WIRE TRANS CTRL RLY OUTPUT TRANSMISSION CONTROL RELAY TRANSMISSION SOLENOID ASSEMBLY (TRANSMISSION) TRANSMISSION TEMPERATURE SENSOR SIGNAL VIO WIRE VIO/WHT WIRE WHT WIRE WHT/ORG WIRE YEL WIRE

3-4 SHIFT SOLENOID 5 VOLT SUPPLY 9 10 11 PNK WIRE BLK WIRE BLK/LT BLU WIRE BLK/WHT WIRE BRN WIRE CONTROLLER ANTI-LOCK BRAKE DK BLU WIRE ENGINE CONTROLS SYSTEM ENGINE COOLANT TEMPERATURE SENSOR (INWATER JACKET, AT FRONT OF INTAKE MANIFOLD) ENGINE STARTER MOTOR RELAY FUSE FUSE 3 GENERATOR GOVERNOR PRESSURE SOLENOID GRN WIRE HOT AT ALL TIMES INNER FENDER) JOINT CONNECTOR 2 LT BLU WIRE LT GRN/WHT WIRE OF HYDRAULIC CONTROL UNIT) ORG/ WIRE ORG/BLK WIRE PARK/ NEUTRAL POSITION SWITCH (ON LEFT SIDE OF TRANSMISSION) PNK WIRE POWER DISTRIBUTION CENTER RED WIRE RED/WHT WIRE SENSOR GROUND GOVERNOR PRESSURE SIGNAL TAN/BLK WIRE TORQUE CONVERTER CLUTCH SOLENOID CONTROL TRANS CTRL RLY OUTPUT TRANSMISSION CONTROL RELAY TRANSMISSION SOLENOID ASSEMBLY (TRANSMISSION) TRANSMISSION TEMPERATURE SENSOR SIGNAL VIO WIRE VIO/WHT WIRE WHT WIRE WHT/ORG WIRE YEL WIRE

5 VOLT SUPPLY 8 9 10 11 PNK WIRE BLK WIRE BLK/LT BLU WIRE BLK/WHT WIRE BRN WIRE CONTROLLER ANTI-LOCK BRAKE DK BLU WIRE ENG HARN, NEAR FUEL INJ 5 BREAKOUT) ENGINE CONTROLS SYSTEM ENGINE COOLANT TEMPERATURE SENSOR (ON THERMOSTAT HOUSING) ENGINE STARTER MOTOR RELAY FUSE FUSE 3 GENERATOR GOVERNOR PRESSURE SIGNAL GRN WIRE HOT AT ALL TIMES INNER FENDER) JOINT CONNECTOR 2 LT BLU WIRE LT GRN/WHT WIRE OF HYDRAULIC CONTROL UNIT) ORG/ WIRE ORG/BLK WIRE ORG/DK BLU WIRE OVERDRIVE SOLENOID CONTROL VARIABLE FORCE SOLENOID CONTROL PARK/ NEUTRAL POSITION SWITCH (ON LEFT SIDE OF TRANSMISSION) PNK WIRE POWER DISTRIBUTION CENTER RED WIRE RED/WHT WIRE SENSOR GROUND TAN WIRE TAN/BLK WIRE THROTTLE POSITION SENSOR (ON THROTTLE BODY) TORQUE CONVERTER CLUTCH SOLENOID CONTROL TRANS CTRL RLY OUTPUT TRANSMISSION CONTROL RELAY TRANSMISSION SOLENOID ASSEMBLY (TRANSMISSION) TRANSMISSION TEMPERATURE SENSOR SIGNAL VIO WIRE VIO/WHT WIRE WHT WIRE WHT/DK BLU WIRE WHT/ORG WIRE YEL WIRE

5 VOLT SUPPLY 8 9 10 11 PNK WIRE BLK WIRE BLK/LT BLU WIRE BLK/WHT WIRE BRN WIRE CONTROLLER ANTI-LOCK BRAKE DK BLU WIRE ENG HARN, NEAR FUEL INJ 5 BREAKOUT) ENGINE CONTROLS SYSTEM ENGINE COOLANT TEMPERATURE SENSOR (ON THERMOSTAT HOUSING) ENGINE STARTER MOTOR RELAY FUSE FUSE 3 GENERATOR GOVERNOR PRESSURE SIGNAL GRN WIRE HOT AT ALL TIMES INNER FENDER) JOINT CONNECTOR 2 LT BLU WIRE LT GRN/WHT WIRE OF HYDRAULIC CONTROL UNIT) ORG/ WIRE ORG/BLK WIRE ORG/DK BLU WIRE OVERDRIVE SOLENOID CONTROL VARIABLE FORCE SOLENOID CONTROL PARK/ NEUTRAL POSITION SWITCH (ON LEFT SIDE OF TRANSMISSION) PNK WIRE POWER DISTRIBUTION CENTER RED WIRE RED/WHT WIRE SENSOR GROUND TAN WIRE TAN/BLK WIRE THROTTLE POSITION SENSOR (ON THROTTLE BODY) TORQUE CONVERTER CLUTCH SOLENOID CONTROL TRANS CTRL RLY OUTPUT TRANSMISSION CONTROL RELAY TRANSMISSION SOLENOID ASSEMBLY (TRANSMISSION) TRANSMISSION TEMPERATURE SENSOR SIGNAL VIO WIRE VIO/WHT WIRE WHT WIRE WHT/DK BLU WIRE WHT/ORG WIRE YEL WIRE

18 19 20 PNK WIRE AUTOMATIC SHUTDOWN RELAY BATTERY BLK WIRE BLK/LT BLU WIRE BLK/RED WIRE BLK/TAN WIRE BLK/WHT WIRE BRN WIRE CONTROLLER ANTI-LOCK BRAKE DK BLU/BLK WIRE DK BLU/YEL WIRE DK GRN WIRE DK GRN/ORG WIRE DK GRN/RED WIRE EGR EGR SOLENOID (ON TOP FRONT OF CYLINDER HEAD) FUEL SHUT-DOWN SOLENOID (ON SIDE OF INJECTOR PUMP, ON BRACKET) FUSE 3 FUSE 6 FUSED B(+) TPS SENS IN GEN FIELD DRV TCC DRVR GROUND GROUND GRY/BLK WIRE GRY/ORG WIRE GRY/YEL WIRE HOT AT ALL TIMES IAT SENS IN ECT SENS IN IGN (POWER) INTAKE AIR HEATER INTAKE AIR HEATER RELAY 1 (ON LEFT INNER FENDER, BELOW LEFT BATTERY) INTAKE AIR HEATER RELAY 2 (ON LEFT INNER FENDER, BELOW LEFT BATTERY) LT GRN/BLK WIRE LT GRN/WHT WIRE OIL PRESS SIG ORG/ WIRE ORG/BLK WIRE ORG/DK BLU WIRE OUTPUT SENS PARK/NEUTRAL POSITION SWITCH (ON LEFT SIDE OF TRANSMISSION) PNK WIRE POWERTRAIN CONTROL MODULE (IN ENG COMPT, ON RIGHT SIDE OF FIREWALL) RED/LT BLU WIRE RED/VIO WIRE RED/WHT WIRE SENSOR GRD STARTING/ CHARGING SYSTEM TAN/BLK WIRE TRANSMISSION OUPUT SHAFT SPEED SENSOR (ON LEFT SIDE OF TRANSMISSION) VAR FRCE SOL VIO WIRE VIO/WHT WIRE VSS IN OUTPUT SENS GOV PRESS SIG TRANS RELAY WAIT TO START OVERDRV SOL WATER IN FUEL WHT/ORG WIRE YEL/BLK WIRE

1 2 3 4 5 6 7 8 TRANS RLY OUT 1 2 3 4 5 6 A/C CLUTCH RLY 31 32 GROUND GROUND A/T A/T (TRANS HARN, IN BREAKOUT TO PDC) AIR CONDI- TIONING SYSTEM AUTO SHT RLY CRUISE VAC SOL CRUISE VNT SOL AUTOMATIC SHUTDOWN RELAY BATTERY TEMPER- ATURE SENSOR (BELOW BATTERY TRAY) BLK WIRE BLK/LT BLU WIRE BLK/LT GRN WIRE BLK/TAN WIRE BLK/WHT WIRE BRAKE LAMP SWITCH (ON BRAKE PEDAL BRACKET) BRN WIRE CKP ENG SIG (PINS 9-21 NOT USED) 22 23 FUSED B(+) ACC PEDAL POS CONTROLLER ANTI-LOCK BRAKE CRUISE CONTROL SYSTEM CRUISE FEED ASD RELAY SENS TRANS OVERDRV 12 13 14 15 CRUISE SW IN DK BLU WIRE DK BLU/BLK WIRE DK BLU/ORG WIRE DK BLU/WHT WIRE DK BLU/YEL WIRE DK GRN WIRE DK GRN/ORG WIRE FUEL TANK MODULE (TOP OF FUEL TANK) FUSE 6 FUSE I GEN FIELD DRV TCC DRVR GENERATOR GRY/BLK WIRE HOT AT ALL TIMES IGN (POWER) JOINT CONNECTOR 1 (IN PDC) JOINT CONNECTOR 2 (IN PCD) LT BLU WIRE LT GRN/BLK WIRE LT GRN/RED WIRE LT GRN/WHT WIRE M/T ORG/ WIRE ORG/BLK WIRE ORG/DK BLU WIRE ORG/WHT WIRE OUTPUT SENS OUTPUT SPEED SENSOR (ON LEFT SIDE OF TRANSMISSION) OVERDRV SOL PARK/NEUTRAL POSITION SWITCH (ON LEFT SIDE OF TRANSMISSION) PNK WIRE PNK/DK BLU WIRE PNK/YEL WIRE POWERTRAIN CONTROL MODULE (IN ENG COMPT, ON RIGHT SIDE OF FIREWALL) PRK/NEUTRAL RED WIRE RED/LT BLU WIRE RED/LT GRN WIRE RED/WHT WIRE SENSOR GRD SENSOR GRD GOV PRESS SIG VAR FORCE SOL OVERDRV SOL TCC SOL CTRL TRANS TEMP SNS STARTING/ CHARGING SYSTEM TAN/RED WIRE TRANS- MISSION RELAY TRANSMISSION SOLENOID ASSEMBLY (ON LEFT SIDE OF TRANSMISSION) VAR FRCE SOL VIO WIRE VIO/BRN WIRE VIO/WHT WIRE VSS IN OUTPUT SENS GOV PRESS SIG TRANS RELAY WHT/BLK WIRE WHT/ORG WIRE WHT/PNK WIRE WHT/VIO WIRE YEL WIRE YEL/RED WIRE

29 30 31 PNK WIRE 5.2L, 5.9L ONLY AUTOMATIC SHUTDOWN RELAY BLK WIRE BLK/GRY WIRE BLK/LT BLU WIRE BLK/RED WIRE BLK/TAN WIRE BLK/WHT WIRE BRN WIRE BRN/DK BLU WIRE BRN/WHT WIRE CAM POS SNS IDLE AIR 1 IDLE AIR 4 CONTROLLER ANTI-LOCK BRAKE DISTRIBUTOR DK BLU WIRE DK BLU/BLK WIRE DK BLU/YEL WIRE DK GRN WIRE DK GRN/BLK WIRE DK GRN/ORG WIRE DK GRN/RED WIRE DK GRN/WHT WIRE FUEL INJECTORS FUEL PUMP RELAY FUSE FUSE 3 FUSE 6 FUSED B(+) TPS SENS IN GEN FIELD DRV TCC DRVR INJ 6 DRIVER INJ 8 DRIVER GROUND GROUND GRY WIRE GRY/BLK WIRE GRY/LT BLU WIRE GRY/ORG WIRE GRY/RED WIRE HOT AT ALL TIMES HOT IN RUN OR START IAT SENS IN ECT SENS IN IDLE AIR 2 IDLE AIR 3 IGN (POWER) INJ 1 DRIVER INJ 3 DRIVER INJ 5 DRIVER INJ 2 DRIVER INJ 4 DRIVER JUNCTION BLOCK (RIGHT END OF DASH) FUSE 9 LT BLU WIRE LT BLU/BRN WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/RED WIRE LT GRN/WHT WIRE MAP SENS IN NCA WIRE OIL PRESS SIG ORG/ WIRE ORG/BLK WIRE ORG/DK BLU WIRE OUTPUT SENS OVERDRV SOL PARK/NEUTRAL POSITION SWITCH (ON LEFT SIDE OF TRANSMISSION) PNK WIRE POWERTRAIN CONTROL MODULE (IN ENG COMPT, ON RIGHT SIDE OF FIREWALL) PRK/NEUTRAL COIL DRIVER CRNK POS SNS RED WIRE RED/WHT WIRE SENSOR GRD STARTING/ CHARGING SYSTEM TAN WIRE TAN/BLK WIRE TAN/WHT (OR ORG/BLK) WIRE TAN/YEL WIRE TRANSMISSION OUPUT SHAFT SPEED SENSOR (ON LEFT SIDE OF TRANSMISSION) VAR FRCE SOL VIO WIRE VIO/BLK WIRE VIO/TAN WIRE VIO/WHT WIRE VSS IN OUTPUT SENS GOV PRESS SIG TRANS RELAY WHT/DK BLU WIRE WHT/ORG WIRE YEL WIRE YEL/BLK WIRE YEL/WHT WIRE

32 33 34 PNK WIRE 5.2L, 5.9L ONLY AUTOMATIC SHUTDOWN RELAY BLK/GRY WIRE BLK/LT BLU WIRE BLK/RED WIRE BLK/TAN WIRE BLK/WHT WIRE BRN WIRE BRN/DK BLU WIRE BRN/WHT WIRE CALIF CAM POS SNS IDLE AIR 1 IDLE AIR 4 CONTROLLER ANTI-LOCK BRAKE DISTRIBUTOR DK BLU/BLK WIRE DK BLU/YEL WIRE DK GRN WIRE DK GRN/BLK WIRE DK GRN/ORG WIRE DK GRN/RED WIRE FUEL INJECTORS FUEL PUMP RELAY FUSED B(+) TPS SENS IN GEN FIELD DRV TCC DRVR INJ 6 DRIVER INJ 8 DRIVER GROUND GROUND GRY WIRE GRY/BLK WIRE GRY/LT BLU WIRE GRY/ORG WIRE GRY/RED WIRE HOT IN RUN OR START IAT SENS IN ECT SENS IN IDLE AIR 2 IDLE AIR 3 IGN (POWER) INJ 1 DRIVER INJ 3 DRIVER INJ 5 DRIVER INJ 2 DRIVER INJ 4 DRIVER JUNCTION BLOCK (ON LEFT ENG OF DASH) FUSE 9 LT BLU/BRN WIRE LT GRN/BLK WIRE LT GRN/RED WIRE LT GRN/WHT WIRE MAP SENS IN NCA WIRE OIL PRESS SIG ORG/ WIRE ORG/BLK WIRE ORG/DK BLU WIRE ORG/TAN WIRE OUTPUT SENS OUTPUT SPEED SENSOR (ON LEFT SIDE OF TRANSMISSION) OVERDRV SOL PARK/NEUTRAL POSITION SWITCH (ON LEFT SIDE OF TRANSMISSION) PNK WIRE POWER TAKE OFF SWITCH (5.2L/5.9L) POWERTRAIN CONTROL MODULE (IN ENG COMPT, ON RIGHT SIDE OF FIREWALL) PRK/NEUTRAL COIL DRIVER CRNK POS SNS PTO SW SENS RED/LT BLU WIRE RED/WHT WIRE SENSOR GRD STARTING/ CHARGING SYSTEM TAN WIRE TAN/BLK WIRE TAN/WHT (OR BLK/DK GRN) WIRE TAN/WHT WIRE TAN/YEL WIRE VAR FRCE SOL VIO WIRE VIO/BLK WIRE VIO/TAN WIRE VIO/WHT WIRE VSS IN OUTPUT SENS GOV PRESS SIG TRANS RELAY WHT/DK BLU WIRE WHT/ORG WIRE YEL/BLK WIRE YEL/WHT WIRE

28 29 30 PNK WIRE AUTOMATIC SHUTDOWN RELAY BLK/DK GRN WIRE BLK/GRY WIRE BLK/LT BLU WIRE BLK/RED WIRE BLK/TAN WIRE BLK/WHT WIRE BRN WIRE BRN/DK BLU WIRE BRN/WHT WIRE CALIF CAM POS SNS IDLE AIR 1 IDLE AIR 4 CAPACITOR CONTROLLER ANTI-LOCK BRAKE DK BLU WIRE DK BLU/BLK WIRE DK BLU/WHT WIRE DK BLU/YEL WIRE DK GRN BLK/ WIRE DK GRN WIRE DK GRN/BLK WIRE DK GRN/GRY WIRE DK GRN/ORG WIRE DK GRN/RED WIRE FUEL INJECTORS FUEL PUMP RELAY FUSE 6 FUSE 3 FUSED B(+) TPS SENS IN GRN WIRE GROUND GROUND GRY WIRE GRY/BLK WIRE GRY/LT BLU WIRE GRY/ORG WIRE GRY/RED WIRE HOT AT ALL TIMES IAT SENS IN ECT SENS IN IGNITION COIL 4-PACK IGNITION COIL 6-PACK LT BLU WIRE LT BLU/BRN WIRE LT GRN/ BLK WIRE LT GRN/BLK WIRE LT GRN/RED WIRE LT GRN/WHT WIRE MAP SENS IN NCA WIRE OIL PRESS SIG ORG/ WIRE ORG/BLK WIRE ORG/DK BLU WIRE OUTPUT SENS OUTPUT SPEED SENSOR (ON LEFT SIDE OF TRANSMISSION) OVERDRV SOL PARK/NEUTRAL POSITION SWITCH (ON LEFT SIDE OF TRANSMISSION) PNK WIRE POWERTRAIN CONTROL MODULE (IN ENG COMPT, ON RIGHT SIDE OF FIREWALL) RED WIRE RED/BLK WIRE RED/LT BLU WIRE RED/WHT WIRE STARTING/ CHARGING SYSTEM TAN WIRE TAN/BLK WIRE TAN/WHT WIRE TAN/YEL WIRE TO SPARK PLUGS TO SPARK PLUGS TO SPARK PLUGS TO SPARK PLUGS TO SPARK PLUGS VAR FRCE SOL VIO WIRE VIO/BLK WIRE VIO/TAN WIRE VIO/WHT WIRE VSS IN OUTPUT SENS GOV PRESS SIG TRANS RELAY WHT WIRE WHT/DK BLU WIRE WHT/ORG WIRE YEL WIRE YEL/BLK WIRE YEL/GRY WIRE YEL/WHT WIRE