Dodge Pickup R2500 (1996-2010) brn/pnk Wiring diagrams

1 2 3 4 5 6 DSL HIGH SIDE DRVR RTN ENG CTRL COM SNSR RTN RAD FAN MTR SPD SIG 1 2 3 4 AUTO HEADLAMPS SIG SUN SENSOR SIG 1 SUN SENSOR SIG 2 SENSOR GROUND 1 4 3 IGN RUN CTRL OUT IR SENSOR RETURN IR SENSOR SIGNAL 30 53 17 52 ENG CTRL COM SNSR RTN ENG CTRL COM SNSR RTN 4 RAD FAN MTR SPD SIG 4 2 3 1 BLWR MTR HI DRV FT BLW FD BLWR CTRL GND 70 16 33 6 IGN ULK/RUN/STRT A/C CLUTCH A/C CLUTCH COIL A/C COMPRESSOR, CLUTCH (LEFT SIDE OF ENGINE) A/C HEATER CONTROL A/C PRESS SIG A/C PRESS SNSE RTN A/C PRESS SNSE RTN A/C PRESS SNSR FD A/C PRESS SIG 1 2 3 A/C PRESS SNSR FD A/C PRESSURE TRANSDUCER B(+) BLK WIRE BLK/LT BLU WIRE BLK/LT GRN WIRE BLK/TAN WIRE BLOWER MODULE BLOWER MOTOR (RIGHT SIDE OF DASH) BLW MTR SPLY BRN WIRE BRN/LT BLU WIRE BRN/ORG WIRE BRN/PNK WIRE BRN/WHT WIRE BUS (-) CAN CAN IHS BUS (-) CAN IHS BUS (+) IOD FD FUSED IGN RUN CTRL OUT COIL COMPUTER DATA LINES SYSTEM CTRL OUT DK BLU WIRE DK BLU/DK GRN WIRE DK BLU/GRY WIRE DK BLU/LT BLU WIRE DK BLU/LT GRN WIRE DK BLU/ORG WIRE DK BLU/PNK WIRE DK BLU/RED WIRE DK BLU/TAN WIRE DK BLU/WHT WIRE DK BLU/YEL WIRE DK GRN WIRE DRIVER BLEND DOOR ACTUATOR (ON HVAC UNIT) ENGINE CONTROLS SYSTEM ENGINE COOLANT TEMPERATURE SENSOR EVAP SIG EVAP SNSE RTN EVAPORATOR TEMPERATURE SENSOR (CENTER OF DASH) FAN RADIATOR HIGH RELAY FAN RADIATOR LOW RELAY FUSE HALLEFCT ELECN ENG SPD OUT HALLEFCT ELECN ENG SPD OUT ENG CTRL COM SNSR RTN 2 COOL TEMP SNSR SIG 65 20 40 HOT AT ALL TIMES HOT AT ALL TIMES FUSE HOT W/ RUN RELAY ENERGIZED INFRARED SENSOR LT BLU WIRE LT BLU/BRN WIRE LT BLU/ORG WIRE LT BLU/RED WIRE LT GRN WIRE MODE DOOR ACTUATOR 1 (ON HVAC UNIT) MODE DOOR ACTUATOR 2 (ON HVAC UNIT) NAVIGATION SYSTEM ORG/ WIRE PASSENGER BLEND DOOR ACTUATOR (ON HVAC UNIT) PNK/WHT WIRE PNK/YEL WIRE POWERTRAIN CONTROL MODULE RAD FAN RAD FAN LOW SPD SIG RADIATOR FAN RADIATOR FAN DRIVE RECIRCULATION DOOR ACTUATOR RED/WHT WIRE RUN/START SIG HI SPD SUN SENSOR TAN WIRE TOTALLY INTEGRATED POWER MODULE (LEFT FRONT OF ENGINE COMPT) CIRCUIT BOARD VIO/LT BLU WIRE VIO/ORG WIRE WHT/DK BLU WIRE WHT/GRY WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE WHT/ORG WIRE WHT/VIO WIRE

1 2 3 4 5 6 DSL HIGH SIDE DRVR RTN ENG CTRL COM SNSR RTN RAD FAN MTR SPD SIG 30 53 17 ENG CTRL COM SNSR RTN ENG CTRL COM SNSR RTN 4 RAD FAN MTR SPD SIG A/C PRESS PRESS SNS SNS SIG RTN FD A/C PRESS SIG A/C PRESS SNSE RTN A/C PRESS SNSR FD A/C PRESSURE TRANSDUCER BLK WIRE BLK/LT BLU WIRE BRN/LT BLU WIRE BRN/ORG WIRE BRN/PNK WIRE BRN/WHT WIRE BUS (-) CAN COMPUTER DATA LINES SYSTEM DK BLU/DK GRN WIRE DK BLU/GRY WIRE DK GRN/DK BLU WIRE ENGINE CONTROLS SYSTEM ENGINE COOLANT TEMPERATURE SENSOR FAN RADIATOR FUSE HALLEFCT ELECN ENG SPD OUT HALLEFCT ELECN ENG SPD OUT ENG CTRL COM SNSR RTN 2 COOL TEMP SNSR SIG HOT AT ALL TIMES IGN ULK/RUN/STRT 16 33 6 LT BLU/BRN WIRE LT BLU/ORG WIRE PNK/WHT WIRE PNK/YEL WIRE POWER MODULE (LEFT FRONT OF ENGINE COMPT) CIRCUIT BOARD POWERTRAIN CONTROL MODULE PRESS. RAD FAN HI SPD SIG RAD FAN LOW SPD SIG RADIATOR FAN DRIVE RADIATOR FAN HIGH RELAY RADIATOR FAN LOW RELAY RUN/START TOTALLY INTEGRATED VIO/ORG WIRE WHT/DK BLU WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE

A/C PRESSURE TRANSDUCER (NEAR A/C COMPRESSOR) A/C SIG AMBIENT TEMPERATURE SENSOR (LEFT UNDERSIDE OF HOOD) ANTI-LOCK BRAKES SYSTEM BLK/LT BLU WIRE BLK/TAN WIRE BRN WIRE BRN/DK BLU WIRE BRN/DK GRN WIRE BRN/PNK WIRE BRN/WHT WIRE COIL DRIVER 2 COIL DRIVER 1 COIL DRIVER 7 INJ 8 DRIVER INJ 7 DRIVER DATA LINK CONNECTOR (BELOW LEFT SIDE OF DASH) DK BLU WIRE DK GRN WIRE DK GRN/RED WIRE DK GRN/WHT WIRE DK GRN/YEL WIRE ENGINE COOLANT TEMPERATURE SENSOR ENGINE OIL PRESSURE SWITCH FUSE 19 FUSED B(+) IGN (START) GEN FIELD ECT SENS IN TP SENS SIG GROUND GRY WIRE GRY/LT BLU WIRE GRY/YEL WIRE HOT AT ALL TIMES HOT IN RUN OR START IGN (RUN-STRT) IGN (RUN-STRT) VSS IGNITION SWITCH INJ 4 DRIVER INJ 3 DRIVER INJ 2 DRIVER INJ 1 DRIVER TP SENS RET INTEGRATED POWER MODULE (ON LEFT FRONT OF ENGINE COMPT) LEFT KNOCK SENSOR LOCK OFF LT BLU/BRN WIRE LT BLU/RED WIRE LT BLU/VIO WIRE LT GRN WIRE LT GRN/BLK WIRE MAP SENS SIG KNOCK 1 RET KNOCK 1 SIG OIL PRES SIG A/C PRES SIG IDLE AIR 1 ORG/ WIRE ORG/DK BLU WIRE PCI BUS PNK SCI TRANSMIT WIRE PNK WIRE PNK/LT BLU WIRE POWERTRAIN CONTROL MODULE (ON RIGHT SIDE OF FIREWALL) PTC 1 RED/WHT WIRE RUN WIRE SCI RECEIVE SCI TRANSMIT SENS GND SENSOR GND STARTING/CHARGING SYSTEM SWITCH TAN WIRE TAN/BLK WIRE TAN/DK GRN WIRE TAN/LT BLU WIRE TAN/LT GRN WIRE TAN/ORG WIRE TAN/PNK WIRE TAN/RED WIRE TAN/WHT WIRE TRANSMISSIONS SYSTEM VIO/BRN WIRE VIO/LT GRN WIRE VIO/TAN WIRE VIO/WHT WIRE VSS SIG 2 GROUND WHT WIRE WHT/DK BLU WIRE YEL WIRE YEL/BLK WIRE YEL/WHT WIRE

AUTO SHUTDOWN RELAY BLK/LT BLU WIRE BRN WIRE BRN/DK BLU WIRE BRN/DK GRN WIRE BRN/PNK WIRE COIL ON PLUG DK BLU/YEL WIRE DK GRN WIRE DK GRN/ORG WIRE DK GRN/RED WIRE DK GRN/WHT WIRE FUEL INJECTOR FUEL PUMP RELAY FUSE 17 FUSE 2 GRY WIRE GRY/LT BLU WIRE HOT AT ALL TIMES HOT IN RUN OR START INTEGRATED POWER MODULE (ON LEFT FRONT OF ENGINE COMPT) LT BLU/BRN WIRE LT BLU/RED WIRE ORG/ WIRE ORG/DK BLU WIRE PNK/LT BLU WIRE PTC 1 TAN WIRE TAN/DK GRN WIRE TAN/LT BLU WIRE TAN/LT GRN WIRE TAN/ORG WIRE TAN/PNK WIRE TAN/RED WIRE TAN/WHT WIRE VIO/TAN WIRE VIO/WHT WIRE WHT WIRE WHT/DK BLU WIRE YEL/WHT WIRE

BLK/LT BLU WIRE BLK/RED WIRE BLK/WHT WIRE BRN WIRE BRN/DK GRN WIRE BRN/ORG WIRE BRN/PNK WIRE BRN/VIO WIRE CAMSHAFT POSITION SENSOR (LOWER FRONT OF RIGHT CYL HEAD) CRANKSHAFT POSITION SENSOR (LOWER RIGHT SIDE OF ENG BLOCK) DK BLU/YEL WIRE DK GRN/ORG WIRE DK GRN/RED WIRE DK GRN/WHT WIRE GRY/BLK WIRE INTAKE AIR TEMPERATURE SENSOR (ON INTAKE MANIFOLD, NEAR THROTTLE BODY) MANIFOLD ABSOLUTE PRESSURE SENSOR (ON FRONT OF INTAKE MANIFOLD) NCA WIRE ORG/ WIRE ORG/DK BLU WIRE OXYGEN SENSOR 1/1 (UPSTREAM) (NEAR LEFT FRONT SIDE OF TRANSMISSION) OXYGEN SENSOR 1/2 (DOWNSTREAM) (NEAR LEFT REAR SIDE OF TRANSMISSION) PNK/LT BLU WIRE TAN/WHT WIRE TAN/YEL WIRE VIO/WHT WIRE WHT WIRE

28 29 30 31 32 33 34 35 36 37 38 TP 2 SIG 5 VOLT SUPPLY IAT SIG 3 5 7 9 11 TPS 1 OUT APP 1 OUT REQ SENS SENS GRD RPM SIG 5-VOLT AC COMP CLTCH ACCELERATOR PEDAL POSITION SENSOR AIR CONDITIONING SYSTEM APPS 1 RET APPS 1 RET APPS 2 RET S/C SW 2 SIG ASD RELAY OUT SOL CTRL APPS 1 SIG APPS 2 RET APPS 2 SIG ASD RELAY OUT SOL CTRL PRS SW SIG AUTO SHT RLY BATTERY TEMPERATURE SENSOR (UNDER BATTERY TRAY) BLK WIRE BLK/DK GRN WIRE BLK/LT BLU WIRE BLK/PNK WIRE BLK/RED WIRE BLK/VIO WIRE BRAKE LAMP SWITCH (ABOVE BRAKE PEDAL) BRK SW 2 SIG BRN WIRE BRN/DK GRN WIRE BRN/ORG WIRE BRN/PNK WIRE BRN/VIO WIRE CLOCKSPRING CMP SIG CKP SENS SIG KNOCK 2 SIG KNOCK 2 RET ETC MTR CTRL COOLING FANS SYSTEM CRUISE CONTROL SYSTEM DK BLU/DK GRN WIRE DK BLU/GRY WIRE DK BLU/ORG WIRE DK BLU/VIO WIRE DK BLU/YEL WIRE DK GRN/ORG WIRE DK GRN/WHT WIRE ELECTRONIC THROTTLE CONTROL MODULE EVAP/PURGE SOLENOID (LEFT FRONT OF ENGINE COMPT) FAN RLY CTRL FUEL PUMP MODULE (INSIDE FUEL TANK) GRY/BLK WIRE LEAK DETECTION PUMP (FORWARD OF FUEL TANK) LEFT FRONT FENDER) LT BLU/BLK WIRE ORG/ WIRE ORG/DK BLU WIRE ORG/PNK WIRE PMP SOL CTRL 1/2 HTR CTRL PNK/BLK WIRE PNK/DK BLU WIRE PNK/YEL WIRE POWER STEERING PRESSURE SWITCH (BELOW POWER STEERING RESERVOIR) POWERTRAIN CONTROL MODULE (ON RIGHT SIDE OF FIREWALL) PTO SW SENS BRAKE SW SENS PTO SWITCH CONTROLLER ANTI-LOCK BRAKE (ON LEFT REAR OF ENG COMPT) RED/LT GRN WIRE RED/WHT WIRE RIGHT KNOCK SENSOR SENSE STARTING/ CHARGING SYSTEM TAN/BLK WIRE TAN/YEL WIRE TRANS- MISSIONS SYSTEM VIO/ORG WIRE VIO/WHT WIRE WHT WIRE WHT/DK GRN WIRE WHT/PNK WIRE WHT/TAN WIRE YEL/BLK WIRE YEL/DK GRN WIRE YEL/RED WIRE

5 VOLT SUPPLY ACTUATOR GND BRN WIRE BRN/DK BLU WIRE BRN/DK GRN WIRE BRN/LT BLU WIRE BRN/ORG WIRE BRN/PNK WIRE BRN/VIO WIRE BRN/YEL WIRE BYPASS STATUS CAMSHAFT POSITION SENSOR (LOWER LEFT FRONT OF ENGINE) CRANKCASE SENSOR (TOP LEFT SIDE OF ENGINE) DK BLU/BRN WIRE DK BLU/GRY WIRE DK BLU/LT GRN WIRE DK BLU/TAN WIRE EGR AIRFLOW CONTROL VALVE (LEFT SIDE OF ENGINE) EGR COOLER BY-PASS VALVE ELECTRONIC TURBO ACTUATOR (LOWER RIGHT FRONT OF ENGINE EXHAUST PRESSURE SENSOR 1/1 (TOP RIGHT FRONT OF ENGINE) FUEL CONTROL ACTUATOR (LEFT FRONT OF ENGINE) FUEL RAIL PRESSURE SENSOR (TOP LEFT REAR OF ENGINE) FUSED B (+) HIGH DATA LINK INLET TEMPERATURE/ PRESSURE SENSOR (TOP RIGHT OF ENGINE) LOW DATA LINK MAP TEMPERATURE/ PRESSURE SENSOR (TOP LEFT SIDE OF ENGINE) MASS AIR FLOW SENSOR (TOP RIGHT FRONT OF ENGINE) OF ENGINE COMPT) PNK/ORG WIRE PNK/YEL WIRE PRES SENS SIG PWR RLY RTN RADIATOR FAN DRIVE (FRONT OF ENGINE COMPT) RED/ORG WIRE RLY FEED SENS GND SENS SIG SENSOR GND SIGNAL SMART POWER RELAY (LEFT FRONT TEMP SENS SIG TTVA MTR (+) VALVE (+) SIG VIO/WHT WIRE WHT/LT GRN WIRE

BLK WIRE BRN WIRE BRN/DK BLU WIRE BRN/DK GRN WIRE BRN/GRY WIRE BRN/LT BLU WIRE BRN/ORG WIRE BRN/PNK WIRE BRN/TAN WIRE BRN/VIO WIRE BRN/WHT WIRE BRN/YEL WIRE CRANKSHAFT POSITION SENSOR (LOWER LEFT FRONT OF ENGINE) DK BLU WIRE DK BLU/BRN WIRE DK BLU/GRY WIRE DK BLU/LT BLU WIRE DK BLU/LT GRN WIRE DK BLU/TAN WIRE DK BLU/WHT WIRE DK BLU/YEL WIRE EGR BYPASS VLV SIG FUEL CTRL RTN EGR TEMPERATURE SENSOR (TOP LEFT FRONT OF ENGINE) EGR VALVE ASSEMBLY ENGINE CONTROL MODULE (LOWER LEFT FRONT OF ENGINE BLOCK) ENGINE COOLANT TEMPERATURE SENSOR (TOP FRONT OF ENGINE) FAN SPD SENS GND FUEL INJECTOR 1 (TOP OF ENGINE, OVER CYLINDER 1) FUEL INJECTOR 2 (TOP OF ENGINE, OVER CYLINDER 2) FUEL INJECTOR 3 (TOP OF ENGINE, OVER CYLINDER 3) FUEL INJECTOR 4 (TOP OF ENGINE, OVER CYLINDER 4) FUEL INJECTOR 5 (TOP OF ENGINE, OVER CYLINDER 5) FUEL INJECTOR 6 (TOP OF ENGINE, OVER CYLINDER 6) GRY WIRE GRY/BRN WIRE GRY/DK BLU WIRE INTAKE TEMPERATURE /PRESSURE SENSOR (RAM 2500) (RIGHT SIDE OF ENGINE) LT BLU/BRN WIRE LT GRN/BRN WIRE OIL PRESSURE SWITCH (LEFT SIDE OF ENGINE) ORG/BRN WIRE PNK/YEL WIRE RED WIRE SENS GND SENS SIG SIG STARTING/ CHARGING SYSTEM TAN WIRE TTVA MTR (+) CRANKCASE SENS SIG ECT SIG TURBO SPEED SENSOR (LOWER RIGHT FRONT OF ENGINE) VIO/GRY WIRE VIO/LT GRN WIRE VIO/ORG WIRE VIO/WHT WIRE WATER IN FUEL SENSOR (MIDDLE LEFT SIDE OF ENGINE BLOCK) WHT/BRN WIRE WHT/LT GRN WIRE YEL/BRN WIRE

4 RTN 4 SIG 5 RTN 5 SIG 6 RTN 6 SIG AIR INTKE THRTL MTR (+) AIR INTKE THRTL MTR (-) ALTR FLD FD ASD CTRL BLK WIRE BOOST PRESSURE SENSOR BRN/DK BLU WIRE BRN/DK GRN WIRE BRN/GRY WIRE BRN/LT BLU WIRE BRN/LT GRN WIRE BRN/ORG WIRE BRN/PNK WIRE BRN/TAN WIRE BRN/VIO WIRE BRN/WHT WIRE BRN/YEL WIRE BST PRESS SIG CAM POSTN CAMSHAFT POSITION SENSOR CHRGE AIR TEMP SNSR COM SNSR COM SNSR RTN 4 COMPUTER DATA LINES SYSTEM CTRL COM SNSR RTN 4 DIFF PRESS SNSE DK BLU WIRE DK BLU/BRN WIRE DK BLU/GRY WIRE DK BLU/LT GRN WIRE DK BLU/WHT WIRE DK BLU/YEL WIRE DSL HIGH SIDE DRVR RTN EGR BYPSS VLV SIG EGR MTR OUT EGR MTR POS SIG 2 TURBO SPD SNSR SIG CAM POSTN SNSR SIG ELECTRONIC TURBO ACTUATOR ENG CTRL COM SNSR RTN 4 AIR THRTL STAT FDBK SIG 2 ENG FAN SPD OUT EXHAUST DIFFERENTIAL PRESSURE SENSOR FD 3 FUEL INJ + FUEL INJ 3 RTN FUEL INJ 2 RTN FUEL INJ 1 RTN FUEL INJECTOR 4 (TOP OF ENGINE, OVER CYLINDER 4) FUEL PUMP MOTOR GRY/BRN WIRE HI SIDE DRVR RTN INLET AIR PRESSURE SENSOR INTKE THRTL MTR (+) LT BLU/BRN WIRE LT GRN/BRN WIRE MAF AFLW SIG OIL PRESSURE SWITCH (LEFT SIDE OF ENGINE) ORG/BRN WIRE PMP PNK/YEL WIRE POWERTRAIN CONTROL MODULE RAD FAN MTR SPD RAD FAN MTR SPD SIG OIL PRESS SNSE/SW SIG RADIATOR FAN DRIVE RED/VIO WIRE RTN 4 SNSR SIG SSR IGN FD STARTING/ CHARGING SYSTEM THRTL STAT FDBK SIG 2 VIO/GRY WIRE VIO/ORG WIRE VLTG FD WHT/BRN WIRE WHT/DK GRN WIRE WHT/LT GRN WIRE YEL/BRN WIRE