Dodge Pickup R2500 (1996-2010) blk/tan Wiring diagrams

1 2 CAN IHS BUS (-) CAN IHS BUS (+) 1 4 6 5 BATT FD BRK SIG 2 BRK SIG 1 GND 10 29 34 35 BATT FD BATT FD CAN BUS (+) CAN BUS (-) 14 23 BRAKE SIGNAL 2 BRAKE SIGNAL 1 3.7L 3.7L/ 4.7L 32 33 34 OUTPUT SPEED SIG INPUT SPEED SIG SPEED SENS RTN 5 VOL FD 5 VOLT SUPPLY 5.7L 5.7L/4.7L A/T ACCELERATOR PEDAL POSITION SENSOR (LEFT SIDE OF DASH) APP SENS RTN APP SENS RTN 2 APP SIG (1) APP SIG (2) BLK WIRE BLK/TAN WIRE BRN/DK BLU WIRE BRN/DK GRN WIRE BRN/LT GRN WIRE BRN/ORG WIRE BRN/VIO WIRE BRN/YEL WIRE CLUSTER COMPUTER DATA LINES SYSTEM DK BLU WIRE DK BLU/ YEL WIRE DK GRN/BRN WIRE DK GRN/ORG WIRE DK GRN/RED WIRE DK GRN/VIO WIRE EXCEPT 3.7L FUSE FUSE POWER MODULE (LEFT FRONT OF ENGINE COMPT) GROUND HOT AT ALL TIMES LT BLU/DK GRN WIRE LT GRN/RED WIRE NEUT SIG OUTPUT SPEED SENSOR (3.7L: LEFT REAR OF TRANSMISSION) PARK PARK/NEUT SIG PNK/YEL WIRE POWERTRAIN CONTROL MODULE (3.7L, 4.7L: REAR OF ENGINE) RED WIRE S/C SIG 1 S/C SIG 2 S/C SW GND SPEED CONTROL SWITCH STEERING CONTROL MODULE (LEFT SIDE OF DASH) STOP LAMP SWITCH (ON BRAKE PEDAL SUPPORT) TAN/ORG WIRE TAN/YEL WIRE THROTTLE BODY (3.7L, 4.7L) (TOP OF ENGINE) TOP OF ENGINE) TOTALLY INTEGRATED TRANSMISSION RANGE SENSOR (3.7L: LEFT SIDE OF TRANSMISSION) TRANSMISSION SOLENIOD/TRS ASSEMBLY (LEFT SIDE OF TRANSMISSION) VIO WIRE VIO/BRN WIRE VIO/ORG WIRE WHT/BRN WIRE WHT/GRY WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE WHT/ORG WIRE YEL WIRE YEL/DK BLU WIRE YEL/PNK WIRE

4.7L EXCEPT 4.7L ACCEL BLK WIRE BLK/LT BLU WIRE BLK/TAN WIRE BLK/VIO WIRE BRAKE SW CLOCKSPRING CONTROLLER ANTILOCK BRAKE (ON LEFT REAR OF ENGINE COMPT) BRAKE SWITCH SENSE DATA LINK CONNECTOR (BELOW LEFT SIDE OF DASH) DECEL DK BLU/RED WIRE DUMP INSTRUMENT CLUSTER PCI BUS LT BLU WIRE LT BLU/VIO WIRE LT GRN WIRE LT GRN/RED WIRE OFF PCI BUS PNK WIRE POWERTRAIN CONTROL MODULE (ON RIGHT SIDE OF FIREWALL) PWR SUPPLY RED WIRE RED/LT GRN WIRE RESUME RIGHT INSTRUMENT PANEL SENSOR GND SPEED CONTROL SERVO (ON LEFT FRONT OF ENGINE COMPT) (LEFT FRONT OF ENGINE COMPT) SPEED CONTROL SWITCH-LEFT SPEED CONTROL SWITCH-RIGHT SPEED SW SIG STEERING COLUMN) TAN/RED WIRE VACUUM VACUUM SOL VENT VENT SOL VIO/BRN WIRE VIO/DK GRN WIRE VIO/YEL WIRE WHT WIRE WHT/PNK WIRE YEL/RED WIRE

ADJUST PEDALS MOTOR DRIVER ADJUST PEDALS MOTOR FORWARD ADJUST PEDALS MOTOR REARWARD ADJUSTABLE PEDALS MOTOR (LEFT SIDE OF STEERING COLUMN) ADJUSTABLE PEDALS MOTOR DRIVER ADJUSTABLE PEDALS SWITCH B(+) BLK/TAN WIRE GROUND HOT AT ALL TIMES LT BLU WIRE LT GRN WIRE LT GRN/LT BLU WIRE LT GRN/WHT WIRE ORG RED/ WIRE RED/ORG WIRE TOTALLY CIRCUIT BOARD INTEGRATED POWER MODULE (LEFT FRONT OF ENGINE COMPT) WHT WIRE

2 1 11 CAN IHS BUS(-) CAN IHS BUS(+) LIN BUS COMPUTER DATA LINES SYSTEM 29 9 10 9 14 23 65 66 BRK SIG 2 BRK SIG 1 35 34 18 35 COMPUTER DATA LINES SYSTEM CAN BUS (-) CAN BUS (+) 5.7L 5.7L 6.7L ANTI-LOCK BRAKES MODULE (LEFT REAR OF ENGINE COMPT) B (+) CAN BUS (-) BUS (+) BATT FD BLK WIRE BLK/DK GRN WIRE BLK/TAN WIRE BRAKE FLUID LEVEL SENSOR (LEFT REAR OF ENGINE COMPT) BRK FLUID LEVEL SW SENSE CAN BUS (+) 2 CLUSTER COMPUTER DATA LINES SYSTEM DK DK DK GRN WIRE DK GRN/LT GRN WIRE DK GRN/ORG WIRE DK GRN/RED WIRE DK GRN/TAN WIRE DK GRN/VIO WIRE DK GRN/WHT WIRE DK GRN/YEL WIRE FUSE FUSED B (+) IGN RS PNK WIRE FUSED B(+) CAN BUS 2 (+) GND (LEFT SIDE OF DASH) GRN WIRE GROUND HOT AT ALL TIMES IGN RS LEFT FRONT ABS WHEEL SPEED SENSOR (LEFT FRONT WHEEL HUB ASSEMBLY) LF WHEEL SPD SENSOR (+) LF WHEEL SPD SENSOR (-) LT BLU WIRE LT BLU/DK GRN WIRE LT GRN WIRE LT GRN/RED WIRE ORG/ WIRE PARKING BRAKE SWITCH (TOP OF PARKING BRAKE PEDAL) PNK PNK IGN RUN/START BRK SIG 1 BRK SIG 2 11 12 WIRE PNK WIRE POWERTRAIN CONTROL MODULE PRK BRK SW SIG REAR ABS WHEEL SPEED SENSOR REAR WHEEL SPD SENS (-) REAR WHEEL SPD SENS (+) RED WIRE RF WHEEL SPD SENSOR (+) RF WHEEL SPD SENSOR (-) RIGHT FRONT ABS WHEEL SPEED SENSOR (RIGHT FRONT WHEEL HUB ASSEMBLY) STOP LAMP SWITCH (ON BRAKE PEDAL SUPPORT) STP LMP SIG TAN WIRE TAN/RED WIRE TOTALLY INTEGRATED POWER MODULE (LEFT FRONT OF ENGINE COMPT) CIRCUIT BOARD VIO WIRE WHT WIRE WHT/DK GRN WIRE WHT/GRY WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE WHT/ORG WIRE WIRELESS IGNITION NODE YEL WIRE

A/C HEATER CONTROL AUTO HDLP SIG AUTO- STICK SWITCH B(+) BEAM DRV LH HIGH BEAM DRV RH LOW BLK WIRE BLK/LT BLU WIRE BLK/LT GRN WIRE BLK/TAN WIRE CAN IHS BUS (-) CIRCUIT BOARD CLUSTER COMPUTER DATA LINES SYSTEM DK GRN/WHT WIRE FOG LP SW SIG FUSE FUSED B (+) GROUND HDLP SW MUX RTN HEADLAMP SWITCH HOT AT ALL TIMES LEFT FRONT FOG LAMP LEFT HEADLAMP LF FOG LP CTRL LH HDLP RTN SIG LH LOW BEAM DRV LP CTRL RF FOG MLFCT SW RTN ORG/BRN WIRE PANEL LP DIM SIG PARKING BRAKE SWITCH (TOP OF PARKING BRAKE PEDAL) PRK BRK SW SENS RED WIRE RH HIGH BEAM DRV RIGHT FRONT FOG LAMP RIGHT HEADLAMP RTN SIG RH HDLP SUN SENSOR TOTALLY INTEGRATED POWER MODULE (LEFT FRONT OF ENGINE COMPT) WHT WIRE WHT/DK BLU WIRE WHT/GRY WIRE WHT/LT GRN WIRE WHT/ORG WIRE WHT/TAN WIRE WHT/VIO WIRE WHT/YEL WIRE

18 35 35 34 CAN C BUS (-) CAN C BUS (+) 5.7L 6.7L 5.7L ASTK UP BATT FD BATT FD (5.7L) RUN/START (6.7L) BLK/LT GRN WIRE BLK/TAN WIRE BRAKE TRANSMISSION SHIFT INTERLOCK BRK SIG BRK SIG 2 BRN/YEL WIRE BTSI CTRL CAN-BUS CLUSTER COMPUTER DATA LINES SYSTEM DK GRN/DK BLU WIRE DK GRN/LT BLU WIRE DK GRN/RED WIRE DK GRN/YEL WIRE ERS AUTOSTICK SWITCH FUSE GROUND HEAD- LAMP SWITCH HOT AT ALL TIMES HOT AT ALL TIMES CIRCUIT BOARD IGN FD LT BLU/DK GRN WIRE LT GRN/RED WIRE PNK/TAN WIRE PNK/WHT WIRE POWERTRAIN CONTROL MODULE (RIGHT REAR OF ENGINE COMPT) PRK/NEUT SIG RED WIRE RUN/START IGN RUN/START SOLENOID STOP LAMP SWITCH (ON BRAKE PEDAL SUPPORT) SW RTN TOTALLY INTEGRATED POWER MODULE (LEFT FRONT OF ENGINE COMPT) TRANSMISSION SOLENOID/TRS ASSEMBLY TRS PARK SIG WHT/GRY WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE WHT/ORG WIRE WHT/YEL WIRE WIN WIRELESS IGNITION NODE YEL/DK BLU WIRE

A/C PRESSURE TRANSDUCER (NEAR A/C COMPRESSOR) A/C SIG AMBIENT TEMPERATURE SENSOR (LEFT UNDERSIDE OF HOOD) ANTI-LOCK BRAKES SYSTEM BLK/LT BLU WIRE BLK/TAN WIRE BRN WIRE BRN/DK BLU WIRE BRN/DK GRN WIRE BRN/PNK WIRE BRN/WHT WIRE COIL DRIVER 2 COIL DRIVER 1 COIL DRIVER 7 INJ 8 DRIVER INJ 7 DRIVER DATA LINK CONNECTOR (BELOW LEFT SIDE OF DASH) DK BLU WIRE DK GRN WIRE DK GRN/RED WIRE DK GRN/WHT WIRE DK GRN/YEL WIRE ENGINE COOLANT TEMPERATURE SENSOR ENGINE OIL PRESSURE SWITCH FUSE 19 FUSED B(+) IGN (START) GEN FIELD ECT SENS IN TP SENS SIG GROUND GRY WIRE GRY/LT BLU WIRE GRY/YEL WIRE HOT AT ALL TIMES HOT IN RUN OR START IGN (RUN-STRT) IGN (RUN-STRT) VSS IGNITION SWITCH INJ 4 DRIVER INJ 3 DRIVER INJ 2 DRIVER INJ 1 DRIVER TP SENS RET INTEGRATED POWER MODULE (ON LEFT FRONT OF ENGINE COMPT) LEFT KNOCK SENSOR LOCK OFF LT BLU/BRN WIRE LT BLU/RED WIRE LT BLU/VIO WIRE LT GRN WIRE LT GRN/BLK WIRE MAP SENS SIG KNOCK 1 RET KNOCK 1 SIG OIL PRES SIG A/C PRES SIG IDLE AIR 1 ORG/ WIRE ORG/DK BLU WIRE PCI BUS PNK SCI TRANSMIT WIRE PNK WIRE PNK/LT BLU WIRE POWERTRAIN CONTROL MODULE (ON RIGHT SIDE OF FIREWALL) PTC 1 RED/WHT WIRE RUN WIRE SCI RECEIVE SCI TRANSMIT SENS GND SENSOR GND STARTING/CHARGING SYSTEM SWITCH TAN WIRE TAN/BLK WIRE TAN/DK GRN WIRE TAN/LT BLU WIRE TAN/LT GRN WIRE TAN/ORG WIRE TAN/PNK WIRE TAN/RED WIRE TAN/WHT WIRE TRANSMISSIONS SYSTEM VIO/BRN WIRE VIO/LT GRN WIRE VIO/TAN WIRE VIO/WHT WIRE VSS SIG 2 GROUND WHT WIRE WHT/DK BLU WIRE YEL WIRE YEL/BLK WIRE YEL/WHT WIRE

ASD CTRL B(+) BATT FD BLK WIRE BLK/GRY WIRE BLK/TAN WIRE BRK ACTV BRN WIRE BRN/BLK WIRE BRN/DK BLU WIRE BRN/DK GRN WIRE BRN/GRY WIRE BRN/LT BLU WIRE BRN/LT GRN WIRE BRN/ORG WIRE BRN/TAN WIRE BRN/VIO WIRE BRN/WHT WIRE BRN/YEL WIRE CLSTR/CHMSL CTRL SIG DK BLU/DK GRN WIRE DK BLU/GRY WIRE DK BLU/LT BLU WIRE DK BLU/LT GRN WIRE DK BLU/ORG WIRE DK BLU/PNK WIRE DK BLU/RED WIRE DK BLU/TAN WIRE DK BLU/WHT WIRE DK BLU/YEL WIRE DK GRN/RED WIRE ENGINE COOLANT TEMPERATURE SENSOR FD 3 FUEL LVL SNSR RTN FUEL PUMP MODULE FUEL PUMP RELAY FUEL SNDR LVL SIG PRI FUSE HOT AT ALL TIMES HOT AT ALL TIMES CIRCUIT BOARD IGN SW OUT (RUN-START) INTAKE AIR TEMPERATURE SENSOR LT BLU/DK GRN WIRE LT GRN/RED WIRE LT GRN/TAN WIRE LVL SNSR RTN MANIFOLD ABSOLUTE PRESSURE (MAP) SENSOR OF ENGINE COMPT) OXYGEN SENSOR 1/1 (IN EXHAUST, LEFT OF TRANSMISSION) OXYGEN SENSOR 1/2 (IN EXHAUST, LEFT OF TRANSMISSION) OXYGEN SENSOR 2/1 (IN EXHAUST, LEFT OF TRANSMISSION) OXYGEN SENSOR 2/2 (IN EXHAUST, LEFT OF TRANSMISSION) PMP MTR FD PMP RLY FD PNK/GRY WIRE PNK/YEL WIRE PRIMARY SHORT RUNNER VALVE SOLENOID (REAR OF ENGINE) SNDR LVL SIG SNSE SIG SNSE SIG 2 SRV ACTR SRV SEN OUT STOP LAMP SWITCH (ON BRAKE PEDAL SUPPORT) TOP OF ENGINE) TOTALLY INTEGRATED POWER MODULE (LEFT FRONT VIO/BRN WIRE VIO/GRY WIRE VIO/ORG WIRE YEL/DK BLU WIRE YEL/PNK WIRE

A/C PRESS SIG AUTO SHUT DOWN RELAY BLK/DK GRN WIRE BLK/GRY WIRE BLK/LT BLU WIRE BLK/RED WIRE BLK/TAN WIRE BRN WIRE BRN/DK BLU WIRE BRN/WHT WIRE BRN/YEL WIRE CALIF CAM POS SNS IDLE AIR 4 IDLE AIR 1 CAPACITOR CONTROLLER ANTI-LOCK BRAKE (LEFT REAR OF ENG COMPT) DK BLU WIRE DK BLU/BLK WIRE DK BLU/TAN WIRE DK BLU/YEL WIRE DK GRN WIRE DK GRN/GRY WIRE DK GRN/ORG WIRE DK GRN/RED WIRE DK GRN/WHT WIRE FUEL INJECTORS FUEL PUMP RELAY FUSE 19 FUSE 17 FUSE 2 FUSED B(+) TPS SENS IN GROUND GROUND GRY WIRE GRY/BLK WIRE GRY/LT BLU WIRE GRY/RED WIRE GRY/YEL WIRE HOT AT ALL TIMES IAT SENS IN ECT SENS IN IGNITION COIL (LEFT) IGNITION COIL (RIGHT) INTEGRATED POWER MODULE (LEFT FRONT OF ENG COMPT) LEFT FRONT FENDER) LT BLU/BRN WIRE LT GRN/BLK WIRE LT GRN/RED WIRE LT GRN/WHT WIRE MAP SENS IN NO 1 DRVR NO 2 DRVR NO 3 DRVR NO 4 DRVR NO 5 DRVR OIL PRESS SIG ORG/ WIRE ORG/BLK WIRE ORG/DK BLU WIRE OUTPUT SENS OUTPUT SPEED SENSOR (ON LEFT REAR OF TRANSMISSION) OVERDRV SOL PNK WIRE POWERTRAIN CONTROL MODULE (ON RIGHT SIDE OF FIREWALL) PTO SW SENS RED/WHT WIRE RED/YEL WIRE RLY OUT STARTING/CHARGING SYSTEM SWITCH TAN WIRE TAN/BLK WIRE TAN/WHT WIRE TAN/YEL WIRE TO FUSE 49 (DIAGRAM 3 OF 3) TRANSMISSION RANGE SENSOR (ON LEFT SIDE OF TRANSMISSION) VAR FRCE SOL VIO WIRE VIO/BLK WIRE VIO/TAN WIRE VIO/WHT WIRE VSS IN OUTPUT SENS GOV PRESS SIG TRANS RELAY WHT/DK BLU WIRE WHT/ORG WIRE YEL/BLK WIRE YEL/GRY WIRE YEL/WHT WIRE

1 2 3 4 5 6 7 8 TRANS RLY OUT 5-VOLT A/C PRESSURE TRANSDUCER (ON LEFT SIDE OF A/C COMPRESSOR) AIR CONDITIONING SYSTEM AUTO SHT RLY CRUISE VAC SOL CRUISE VNT SOL BLK/LT BLU WIRE BLK/RED WIRE BLK/TAN WIRE BLK/VIO WIRE BRAKE SW IN GEN FIELD OUT FUEL LVL SENS SIG SCI TRANSMIT BRN WIRE BRN/VIO WIRE BRN/WHT WIRE CRUISE CONTROL SYSTEM CRUISE SW IN DATA LINK CONNECTOR (LEFT SIDE OF DASH) DK BLU WIRE DK BLU/ORG WIRE DK BLU/YEL WIRE DK GRN WIRE DK GRN/ORG WIRE DK GRN/WHT WIRE DOWNSTREAM OXYGEN SENSOR RELAY (CALIFORNIA) FROM AUTO SHUT DOWN RELAY (DIAGRAM 1 OF 3) FUEL PMP RLY EVAP SOL CTRL FUSE 49 FUSE 5 GENERATOR HOT AT ALL TIMES INTAKE AIR TEMPERATURE SENSOR (IN LEFT FRONT SIDE OF INTAKE MANIFOLD) INTEGRATED POWER MODULE (LEFT FRONT OF ENGINE COMPT) LEAK DETECTION PUMP (ON RIGHT FRONT OF INNER FENDER) LT BLU/BLK WIRE LT BLU/VIO WIRE LT GRN WIRE LT GRN/RED WIRE ORG/ WIRE ORG/BLK WIRE ORG/DK BLU WIRE ORG/WHT WIRE OVERDRIVE SWITCH PNK WIRE PNK/BLK WIRE PNK/YEL WIRE POWERTRAIN CONTROL MODULE (RIGHT SIDE OF FIREWALL) PRESS SIG RED WIRE RED/LT GRN WIRE SCI RECEIVE PCI BUS SENS GRD SENSOR GRD GOV PRESS SIG PRESS SOL CTRL 3-4 SOL CTRL TCC SOL CTRL TRANS TEMP SNS STOP LAMP SWITCH (ON BRAKE PEDAL BRACKET) TAN/RED WIRE THROTTLE POSITION SENSOR (ON THROTTLE BODY) TRANSMISSION RELAY TRANSMISSION SOLENOID ASSEMBLY (INSIDE TRANSMISSION) VIO WIRE VIO/BRN WIRE VIO/WHT WIRE WHT/DK BLU WIRE WHT/DK GRN WIRE WHT/PNK WIRE YEL/RED WIRE