Dodge Pickup R2500 (1996-2010) blk/lt grn Wiring diagrams

1 2 3 4 AUTO HEADLAMPS SIG SUN SENSOR SIG 1 SUN SENSOR SIG 2 SENSOR GROUND 1 4 3 IGN RUN CTRL OUT IR SENSOR RETURN IR SENSOR SIGNAL 10 9 34 35 FUSED B(+) GND CAN BUS (+) CAN BUS (-) 27 20 SENS GND ECT SIG 4 2 3 1 BLWR MTR HI DRV FT BLW FD BLWR CTRL GND A/C CLUTCH COIL A/C CLUTCH CTRL OUT A/C COMPRESSOR CLUTCH (3.7L, 4.7L: FRONT OF ENGINE) A/C HEATER CONTROL A/C PRESS A/C PRESS SNSE RTN A/C PRESS SNSR FD A/C PRESS SIG A/C PRESS SNSR FD B(+) BLK WIRE BLK/LT BLU WIRE BLK/LT GRN WIRE BLK/TAN WIRE BLOWER MODULE BLOWER MOTOR (RIGHT SIDE BRN WIRE CAN 2 BUS (-) CAN IHS BUS (-) CAN IHS BUS (+) IOD FD FUSED IGN RUN CTRL OUT CIRCUIT BOARD CLUTCH A/C COIL COMPUTER DATA LINES SYSTEM DK BLU WIRE DK BLU/DK GRN WIRE DK BLU/GRY WIRE DK BLU/LT BLU WIRE DK BLU/LT GRN WIRE DK BLU/ORG WIRE DK BLU/PNK WIRE DK BLU/RED WIRE DK BLU/TAN WIRE DK BLU/WHT WIRE DK BLU/YEL WIRE DK GRN/DK BLU WIRE DRIVER BLEND MODE DOOR DOOR ACTUATOR ACTUATOR 1 (ON HVAC UNIT) (ON HVAC UNIT) ENGINE CONTROLS SYSTEM EVAP SIG EVAP SNSE RTN EVAPORATOR TEMPERATURE SENSOR (CENTER OF DASH) FAN RADIATOR HIGH RELAY FAN RADIATOR LOW RELAY FUSE FUSE FUSE HI SPD RAD FAN HOT AT ALL TIMES HOT W/ RUN RELAY ENERGIZED INFRARED SENSOR LOW SPD SIG LT BLU WIRE LT BLU/BRN WIRE LT BLU/ORG WIRE LT BLU/RED WIRE LT GRN WIRE MODE DOOR ACTUATOR 2 (ON HVAC UNIT) NAVIGATION SYSTEM OF DASH) ORG/ WIRE PASSENGER BLEND DOOR ACTUATOR (ON HVAC UNIT) PNK/YEL WIRE POWERTRAIN CONTROL MODULE (3.7L, 4.7L: REAR OF ENGINE) RAD FAN RADIATOR FAN RECIRCULATION DOOR ACTUATOR RED WIRE RED/WHT WIRE SIG SNSE RTN A/C PRESS SPLY BLW MTR SUN SENSOR TAN WIRE TOP OF ENGINE) TOTALLY INTEGRATED POWER MODULE (LEFT FRONT OF ENGINE COMPT) TRANSDUCER) VIO/LT BLU WIRE VIO/ORG WIRE WHT/GRY WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE WHT/ORG WIRE WHT/VIO WIRE

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 GND 1 2 SENS GND SENS SIG 10 34 35 9 BATT FD C BUS (+) C BUS (-) GND 27 20 ECT SIG SENS GND A/C A/C CLUTCH A/C A/C PRESS CTRL PRESS CLUTCH OUTPUT COIL A/C CLUTCH COIL A/C COMPRESSOR CLUTCH (3.7L, 4.7L: FRONT OF ENGINE) A/C HEATER CONTROL A/C PRESS SIG A/C PRESS SNS RTN A/C PRESS SNS SNS SIGNAL RTN FD A/C PRESS SNSR FD A/C PRESSURE TRANSDUCER (3.7L, 4.7L: TOP FRONT OF ENGINE) AUTO HDLP SIG B(+) BLK WIRE BLK/LT BLU WIRE BLK/LT GRN WIRE BLK/TAN WIRE BLOWER MOTOR (RIGHT SIDE OF DASH) BLOWER MOTOR RESISTOR (RIGHT SIDE OF DASH) BLWR CAN 2 CAN 2 MTR BUS (+) BUS (-) SPLY CIRCUIT BOARD COMMON DOOR DRIVER 2 MODE DOOR 2 DRIVER COMPUTER DATA LINES SYSTEM DK BLU WIRE DK BLU/BRN WIRE DK BLU/DK GRN WIRE DK BLU/GRY WIRE DK BLU/LT BLU WIRE DK BLU/LT GRN WIRE DK BLU/ORG WIRE DK BLU/PNK WIRE DK BLU/RED WIRE DK BLU/TAN WIRE DK BLU/VIO WIRE DK BLU/YEL WIRE DK GRN/DK BLU WIRE DRIVER BLEND DOOR ACTUATOR (ON HVAC UNIT) ENGINE CONTROLS SYSTEM EVAP SNSE RTN EVAP SNSE RTN AUTO HDLP SIG EVAP TEMP SENS SIG EVAP SNSE RTN EVAPORATOR TEMPERATURE SENSOR (CENTER OF DASH) FAN RADIATOR HIGH RELAY FAN RADIATOR LOW RELAY FRONT MODE DOOR ACTUATOR FUSE FUSE FUSE HOT AT ALL TIMES HOT W/ RUN RELAY ENERGIZED IOD FD IGN R LT BLU/BRN WIRE LT BLU/ORG WIRE LT BLU/RED WIRE MODE DOOR ACTUATOR 2 (ON HVAC UNIT) PNK/YEL WIRE POWER MODULE (LEFT FRONT OF ENGINE COMPT) POWERTRAIN CONTROL MODULE (3.7L, 4.7L: REAR OF ENGINE) RAD FAN HI SPD SIG RAD FAN LOW SPD SIG RADIATOR FAN RED WIRE RED/WHT WIRE SUN SENSOR TOP OF ENGINE) TOTALLY INTEGRATED VIO/ORG WIRE WHT/GRY WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE WHT/ORG WIRE WHT/VIO WIRE

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 INPUT SPEED SENS SIG 1 2 3 4 5 6 7 8 9 10 11 12 PRESS SW 1 PRESS SW 6 1 2 3 4 5 6 7 8 9 10 NEUTRAL SW ALL TIMES B(+) TRANS SNS CTRL OUT BLK WIRE BLK/LT GRN WIRE CAN C BUS (+) CAN C BUS (-) COMPT) COMPUTER DATA LINES SYSTEM DK GRN WIRE DK GRN/BRN WIRE DK GRN/DK BLU WIRE DK GRN/GRY WIRE DK GRN/LT BLU WIRE DK GRN/LT GRN WIRE DK GRN/ORG WIRE DK GRN/PNK WIRE DK GRN/RED WIRE DK GRN/TAN WIRE DK GRN/VIO WIRE DK GRN/WHT WIRE DK GRN/YEL WIRE FUSE 10 FUSE 4 FUSE 24 FUSED B (+) GROUND FUSED IGN SW OUT (OFF-RUN-START) INPUT SPEED SENSOR (LEFT SIDE OF TRANSMISSION) LINEAR SOL 4 (+) LINEAR SOL 2 (+) LINEAR SOL 4 (-) LINEAR SOL 2 (-) PRESS SW 2 PRESS SW 3 LT BLU/BLK WIRE ORG/LT GRN WIRE OUTPUT SPEED SENS SIG TRANS CTRL OUTPUT TRANS CTRL OUTPUT OUTPUT SPEED SENSOR (LEFT REAR OF TRANSMISSION) PNK/WHT WIRE POWER TAKE OFF RELAY (INFO NOT AVAILABLE) POWER TAKEOFF RLY ENABLE RANGE SW 1 (OFF-RUN-START) TRS PARK SW GROUND RANGE SW DRV RANGE SW REVERSE RED WIRE TOTALLY INTEGRATED POWER MODULE (LEFT FRONT FENDER) ELECTRONICS TOW/HAUL OVERDR OFF SW TRANS TEMP SENS SIG TORQUE OIL TEMP SIG GROUND TOW/HAUL OVERDRIVE OFF SWITCH TRANSMISSION CONTROL MODULE (LEFT END OF DASH) TRANSMISSION RANGE SENSOR (LEFT SIDE OF TRANSMISSION) TRANSMISSION RELAY TRANSMISSION SOLENOID ASSEMBLY (LEFT SIDE OF TRANSMISSION) TRANSMISSION TEMPERATURE SENSOR (RIGHT SIDE OF TRANSMISSION) TRS RANGE SW DRV TRS RANGE SW PARK TRS RANGE SW REVERSE TRX-LINEAR SOL 3 (+) TRS RANGE SW 1 TRX-PRESS SW 4 TRX-PRESS SW 1 TRX-PRESS SW 5 TRX-PRESS SW 3 TRX-PRESS SW 6 TRX-PRESS SW 2 TRX-PRESS SW 8 WHT/LT BLU WIRE WHT/LT GRN WIRE YEL WIRE YEL/BRN WIRE YEL/DK BLU WIRE YEL/GRY WIRE YEL/ORG WIRE YEL/PNK WIRE YEL/RED WIRE YEL/VIO WIRE YEL/WHT WIRE

1 2 3 4 5 6 DSL HIGH SIDE DRVR RTN ENG CTRL COM SNSR RTN RAD FAN MTR SPD SIG 1 2 3 4 AUTO HEADLAMPS SIG SUN SENSOR SIG 1 SUN SENSOR SIG 2 SENSOR GROUND 1 4 3 IGN RUN CTRL OUT IR SENSOR RETURN IR SENSOR SIGNAL 30 53 17 52 ENG CTRL COM SNSR RTN ENG CTRL COM SNSR RTN 4 RAD FAN MTR SPD SIG 4 2 3 1 BLWR MTR HI DRV FT BLW FD BLWR CTRL GND 70 16 33 6 IGN ULK/RUN/STRT A/C CLUTCH A/C CLUTCH COIL A/C COMPRESSOR, CLUTCH (LEFT SIDE OF ENGINE) A/C HEATER CONTROL A/C PRESS SIG A/C PRESS SNSE RTN A/C PRESS SNSE RTN A/C PRESS SNSR FD A/C PRESS SIG 1 2 3 A/C PRESS SNSR FD A/C PRESSURE TRANSDUCER B(+) BLK WIRE BLK/LT BLU WIRE BLK/LT GRN WIRE BLK/TAN WIRE BLOWER MODULE BLOWER MOTOR (RIGHT SIDE OF DASH) BLW MTR SPLY BRN WIRE BRN/LT BLU WIRE BRN/ORG WIRE BRN/PNK WIRE BRN/WHT WIRE BUS (-) CAN CAN IHS BUS (-) CAN IHS BUS (+) IOD FD FUSED IGN RUN CTRL OUT COIL COMPUTER DATA LINES SYSTEM CTRL OUT DK BLU WIRE DK BLU/DK GRN WIRE DK BLU/GRY WIRE DK BLU/LT BLU WIRE DK BLU/LT GRN WIRE DK BLU/ORG WIRE DK BLU/PNK WIRE DK BLU/RED WIRE DK BLU/TAN WIRE DK BLU/WHT WIRE DK BLU/YEL WIRE DK GRN WIRE DRIVER BLEND DOOR ACTUATOR (ON HVAC UNIT) ENGINE CONTROLS SYSTEM ENGINE COOLANT TEMPERATURE SENSOR EVAP SIG EVAP SNSE RTN EVAPORATOR TEMPERATURE SENSOR (CENTER OF DASH) FAN RADIATOR HIGH RELAY FAN RADIATOR LOW RELAY FUSE HALLEFCT ELECN ENG SPD OUT HALLEFCT ELECN ENG SPD OUT ENG CTRL COM SNSR RTN 2 COOL TEMP SNSR SIG 65 20 40 HOT AT ALL TIMES HOT AT ALL TIMES FUSE HOT W/ RUN RELAY ENERGIZED INFRARED SENSOR LT BLU WIRE LT BLU/BRN WIRE LT BLU/ORG WIRE LT BLU/RED WIRE LT GRN WIRE MODE DOOR ACTUATOR 1 (ON HVAC UNIT) MODE DOOR ACTUATOR 2 (ON HVAC UNIT) NAVIGATION SYSTEM ORG/ WIRE PASSENGER BLEND DOOR ACTUATOR (ON HVAC UNIT) PNK/WHT WIRE PNK/YEL WIRE POWERTRAIN CONTROL MODULE RAD FAN RAD FAN LOW SPD SIG RADIATOR FAN RADIATOR FAN DRIVE RECIRCULATION DOOR ACTUATOR RED/WHT WIRE RUN/START SIG HI SPD SUN SENSOR TAN WIRE TOTALLY INTEGRATED POWER MODULE (LEFT FRONT OF ENGINE COMPT) CIRCUIT BOARD VIO/LT BLU WIRE VIO/ORG WIRE WHT/DK BLU WIRE WHT/GRY WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE WHT/ORG WIRE WHT/VIO WIRE

ABMT TEMP/ CAN FCM BUS (-) ABMT TEMP/FCM B(+) BATTERY BLK WIRE BLK/LT GRN WIRE BRN WIRE CAN CAN BUS (-) BUS (+) CAN-BUS CHARGING CIRCUIT CIRCUIT BOARD COMPUTER DATA LINES SYSTEM DK BLU WIRE DK GRN WIRE FUSE GRY WIRE HOLD-IN HOOD AJAR SWITCH (LEFT FRONT OF ENGINE COMPT) HOT AT ALL TIMES IGN RUN ST IGN SW FD LT BLU WIRE LT BLU/RED WIRE LT GRN WIRE ORG/ WIRE PNK WIRE PNK/TAN WIRE POWER MODULE (LEFT FRONT OF ENGINE COMPT) POWERTRAIN CONTROL MODULE (LEFT REAR OF ENGINE) PRK NEUT SIG PRK/NEUT SIG PULL- IN RED WIRE STARTER STARTER RELAY STARTER RLY COIL STARTER RLY RTN TOTALLY INTEGRATED TRANSMISSION SOLENOID/TRS ASSEMBLY (LEFT SIDE OF TRANSMISSION) UHOOD SW SIG VIO WIRE VIO/BRN WIRE VIO/LT BLU WIRE WHT WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE WIRELESS IGNITION NODE YEL WIRE YEL/DK BLU WIRE

ACCY DLY RLY CTRL B(+) BATT PRE 2 BLK/LT GRN WIRE BRN/YEL WIRE BTSI SOL ULK CAN-BUS CIRCUIT BOARD CIRCUIT BREAKER 2 COMPUTER DATA LINES SYSTEM DK GRN/RED WIRE DRIVER DOOR MODULE DRIVER WINDOW/ DOOR LOCK SWITCH FT PASS DR LK SW SIG FT PASS SW ILLM/SNS RTN FT PASS UP SW SNSE FUSE HDLP RT RTN HEADLIGHTS SYSTEM HOT AT ALL TIMES IGN (RUN-START) IGN RUN ACC IGN SW IGN SW FD IGNITION WIRELESS NODE LIN BUS LIN SLVE RTN LT BLU/RED WIRE ORG/GRY WIRE ORG/LT GRN WIRE ORG/TAN WIRE PASSENGER DOOR MODULE PASSENGER WINDOW/ DOOR LOCK SWITCH PNK/WHT WIRE PNK/YEL WIRE REGULAR CAB EXCEPT RT LO BEAM FD RUN/ ACCESSORY DELAY RELAY STOP LAMP SWITCH (ON BRAKE PEDAL SUPPORT) STP LMP SIG SW ILLM FT PASS TOTALLY INTEGRATED POWER MODULE (LEFT FRONT OF ENGINE COMPT) TRANS RNG PARK VIO/LT GRN WIRE W/ SUNROOF WDW RUN/ACCY IGN WHT WIRE WHT/GRY WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE WHT/ORG WIRE WHT/TAN WIRE YEL/DK BLU WIRE

2 1 CAN IHS BUS(-) CAN IHS BUS(+) B(+) BLK WIRE BLK/BRN WIRE BLK/LT GRN WIRE BLK/TAN WIRE BLK/WHT WIRE BRAKE FLUID LEVEL SENSOR (LEFT REAR OF ENGINE COMPT) CAN IHS CAN IHS SW SIG BUS (-) BUS (+) CAN-BUS CLUSTER COMPUTER DATA LINES SYSTEM DK GRN/ORG WIRE DK GRN/WHT WIRE DRIVER DOOR LATCH DRIVER SEAT BELT BUCKLE SWITCH DRV SEAT BELT BUCKLE SW GND DRV SEAT BELT BUCKLE SW SEN ERS AUTOSTIC SWITCH (W/ COLUMN SHIFT) EXCEPT 6.7L FUSE FUSED B(+) FUSED IGN RUN/START CONT OUT GROUND HDLP FOG LAMP SW HEADLAMP SWITCH HOT AT ALL TIMES LEFT REAR DOOR LATCH (EXCEPT REGULAR CAB) LT GRN WIRE LT GRN/ BLK WIRE LT GRN/GRY WIRE LT GRN/TAN WIRE MLFNCT SW RTN OCCUPANT RESTRAINT CONTROLLER MODULE (CENTER FRONT OF BODY) PARK BRK SW PARKING BRAKE SWITCH (TOP OF PARKING BRAKE PEDAL) PASS AJAR SW JN PASSENGER DOOR LATCH PNK/LT GRN WIRE RED/GRY WIRE RIGHT REAR DOOR LATCH (EXCEPT REGULAR CAB) RR LR BRAKE AJAR AJAR FLUID SW SW SIG SW RTN VIO WIRE VIO/GRY WIRE VIO/WHT WIRE VIO/YEL WIRE WHT WIRE WHT/GRY WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE WHT/ORG WIRE WHT/YEL WIRE

1 2 CAN IHS BUS (-) CAN IHS BUS (+) 1 7 3 9 CAN IHS BUS (-) CAN IHS BUS (+) CAN IHS BUS (-) CAN IHS BUS (+) 2 1 CAN IHS BUS(-) CAN IHS BUS(+) B(+) BLK/LT GRN WIRE BLK/TAN WIRE BUS - CAN C (-) DIAGNOSTIC CAN IHS (-) CAN IHS BUS (+) CAN IHS BUS (-) CAN IHS BUS (-) CAN-BUS CIRCUIT BOARD DRIVER DOOR MODULE EXCEPT 6.7L FUSE HEATED SEATS MODULE HOT AT ALL TIMES LT BLU WIRE MEMORY SEAT MODULE OCCUPANT RESTRAINT CONTROLLER MODULE (CENTER FRONT OF BODY) PASSENGER DOOR MODULE RADIO AMPLIFIER (IF EQUIPPED) RED/PNK WIRE STEERING ANGLE SENSOR (IF EQUIPPED) TOTALLY INTEGRATED POWER MODULE (LEFT FRONT OF ENGINE COMPT) TRAILER TOW MODULE W/ MEMORY W/O HEATED SEATS, MEMORY W/ HEATED SEATS, MEMORY WHT WIRE WHT/DK BLU WIRE WHT/DK GRN WIRE WHT/GRY WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE WHT/ORG WIRE WIRELESS IGNITION NODE

BLK WIRE BLK/LT GRN WIRE BLK/PNK WIRE CAN C BUS (+) CAN C CAN C BUS (+) BUS (-) COMPUTER DATA LINES SYSTEM DYN SENS HIGH LNK DYN SENS LOW LNK DYNAMICS SENSOR (W/ ESP) (UNDER FRONT OF CENTER CONSOLE) ELECTRONICS B(+) FUSE 28 FUSE 30 FUSED IGN SW OUT (RUN-START) GRY WIRE GRY/ PNK WIRE HIGH LNK DYN SENS HOT AT ALL TIMES HOT IN ON OR START IGN SW OUT (RUN-START) LOW LNK DYN SENS LT BLU/ WHT WIRE LT GRN PNK/ WIRE LT GRN WHT/ WIRE ORG/ WIRE PNK/ LT GRN WIRE PNK/GRY WIRE PNK/LT GRN WIRE STEERING ANGLE SENSOR (W/ ESP) (ON STEERING COLUMN) TOTALLY INTEGRATED POWER MODULE (AT LEFT FRONT FENDER) WHT LT GRN/ WIRE WHT WIRE WHT/GRY WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE WHT/ORG WIRE

AIR HTR RLY 1 CTRL SIG AUXILIARY BATTERY BATT FEED BLK WIRE BLK/LT GRN WIRE BRN/DK GRN WIRE BRN/GRY WIRE BRN/YEL WIRE COMPUTER DATA LINES SYSTEM DK BLU/DK GRN WIRE DK GRN WIRE DK GRN/BRN WIRE DK GRN/DK BLU WIRE DK GRN/LT BLU WIRE DK GRN/ORG WIRE DK GRN/TAN WIRE DK GRN/WHT WIRE DK GRN/YEL WIRE ENG CTRL COM FEED FLNK 10 FLNK 10 GAGE FUEL HEATER RELAY GAGE GRY WIRE IGN RS IGNITION WIRELESS NODE INTAKE AIR HEATER INTAKE AIR HEATER RELAY INTKE AIR HTR RLY 1 BATT LR/CC SOL CTRL LT GRN/RED WIRE OD SOL CTRL OVRDRV PRESS SW SIG PNK WIRE PNK/GRY WIRE PNK/LT GRN WIRE PNK/WHT WIRE PRESS SOL SW SIG PRESS SW UD FD RED WIRE RED/WHT WIRE RED/YEL WIRE RLY 1 BATT INTKE AIR HTR RLY 2 BATT INTKE AIR HTR RTN 4 HI SIDE DRVR SNSR RTN SNSR SIG SOL TRANS MS FS LR STP LMP SIG SWD BATT FD TRANS RNG TEMP TRANSMISSION SOLENOID/TRS ASSEMBLY TRS RNG PRK/NEUT SIG UD SOL CTRL VAR FRCE SOL FD/SGNL VIO/ORG WIRE WHT WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE YEL/BRN WIRE YEL/DK BLU WIRE YEL/DK GRN WIRE YEL/GRY WIRE YEL/LT BLU WIRE YEL/LT GRN WIRE YEL/ORG WIRE YEL/TAN WIRE YEL/WHT WIRE