Dodge Pickup R2500 (1996-2010) blk/lt grn Wiring diagrams

1 2 3 4 GROUND PANEL LAMPS DRIVER ESP ON/OFF SENSE SENSOR GROUND 1 2 3 6 IGN SW OUT (RUN-START) DYNAMICS HIGH DATA DYNAMICS LOW DATA GROUND 17 18 10 CAN B BUS (+) CAN B BUS (-) SENSOR GROUND 35 34 CAN C BUS (-) CAN C BUS (+) 43 44 45 46 RH RR WHEEL SPD SENS (+) RH RR WHEEL SPD SENS (-) GROUND 5.9L 6.7L ANTI-LOCK BRAKES MODULE (LEFT REAR OF ENGINE COMPT) B(+) BLK WIRE BLK/DK GRN WIRE BLK/LT GRN WIRE BLK/ORG WIRE BLK/PNK WIRE BRAKE FLUID LEVEL SENSOR (LEFT REAR OF ENGINE COMPT) BRAKE SWITCH 1 SIGNAL BRAKE SWITCH 1 SIGNAL CAN C BUS (+) BRK FLUID LEVEL SW SENSE CAN B CAN B BUS (+) BUS (-) CAN C BUS (+) CAN C CAN C BUS (+) BUS (-) CLUSTER COMPUTER DATA LINES SYSTEM DIESEL DK DK DK GRN WIRE DK GRN/BRN WIRE DK GRN/LT BLU WIRE DK GRN/LT GRN WIRE DK GRN/ORG WIRE DK GRN/RED WIRE DK GRN/TAN WIRE DK GRN/VIO WIRE DK GRN/WHT WIRE DK GRN/YEL WIRE DYNAMICS SENS HIGH DATA DYNAMICS SENS LOW DATA DYNAMICS SENSOR (W/ ESP) (UNDER FRONT OF CENTER CONSOLE) ELECTRONICS ENGINE CONTROL MODULE (LOWER LEFT FRONT OF ENGINE BLOCK) ESP ON/OFF SENSE ESP SWITCH (IF EQUIPPED) FUSE 13 FUSE 18 FUSE 28 FUSE 30 FUSED B (+) CAN C BUS + FUSED B (+) IGN SW OUT (RUN-START) FUSED IGN SW OUT (RUN-START) GAS GRN WIRE GRN/GRY WIRE GROUND GRY WIRE HOT AT ALL TIMES HOT IN RUN OR START IGN SW OUT (RUN-START) CAN C BUS (+) CAN C BUS (-) GROUND LEFT FRONT ABS WHEEL SPEED SENSOR (LEFT REAR OF ENGINE COMPT) LEFT REAR ABS WHEEL SPEED SENSOR LF WHEEL SPD SENSOR (+) LF WHEEL SPD SENSOR (-) LT BLU WIRE LT GRN WIRE ORG/ WIRE ORG/DK BLU WIRE PANEL LAMPS DRIVER PNK WIRE PNK/ (EXCEPT ESP/5.7L POWER WAGON, 6.7L EXCEPT SHIFT ON THE FLY) WIRE PNK/GRY WIRE PNK/LT GRN WIRE POWERTRAIN CONTROL MODULE (RIGHT REAR OF ENGINE COMPT) REAR ABS WHEEL SPEED SENSOR (W/O ESP) (NEAR RIGHT REAR FRAME RAIL) RED WIRE RF WHEEL SPD SENSOR (+) RF WHEEL SPD SENSOR (-) RIGHT FRONT ABS WHEEL SPEED SENSOR (ON KNUCKLE SPINDLE ASSEMBLY) RIGHT REAR ABS WHEEL SPEED SENSOR (W/ ESP) (AT RIGHT REAR WHEEL ASSEMBLY) STEERING ANGLE SENSOR (W/ ESP) STOP LAMP SWITCH (ON BRAKE PEDAL SUPPORT) TAN WIRE TAN/RED WIRE TOTALLY INTEGRATED POWER MODULE (AT LEFT FRONT FENDER) TRAILER TOW DAMPING RLY CTRL VIO WIRE VIO/DK BLU WIRE W/ ESP W/O ESP WHT WIRE WHT/GRY WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE WHT/ORG WIRE YEL WIRE

1 IN (+) 1 IN (+) MICROPHONE 16 15 14 13 12 11 10 9 8 7 6 5 4 3 EC MRR RTN MICROPHONE FEED EC MRR SIG 2 IN (+) BLK/LT GRN WIRE CONVERGENCE TELEMATICS MODULE DK BLU WIRE DK GRN LT BLU/ WIRE DK GRN WIRE DK GRN/LT BLU WIRE DK GRN/YEL WIRE DRIVER DOOR MODULE EC MRR RTN EC MRR SIG FEED FEED MICROPHONE FUSE HANDS FREE MODULE (RIGHT SIDE OF DASH) HF MIC REF HF MIC REF BKUP LMPS FD GND HOT AT ALL TIMES CIRCUIT BOARD BATT FD BACKUP LAMP FEED HOT W/ RUN/ START RELAY ENERGIZED IGN RS IN (-) IN (-) MICROPHONE INSIDE REARVIEW MIRROR LT BLU WIRE LT BLU/ DK GRN WIRE LT BLU/DK GRN WIRE LT GRN WIRE MICROPHONE MICROPHONE 1 IN (+) MICROPHONE 2 IN (+) MICROPHONE 2 IN (+) MICROPHONE IN (-) MICROPHONE 1 IN (+) MICROPHONE IN (-) ORG/GRY WIRE PASSENGER DOOR MODULE PNK WIRE PNK/LT GRN WIRE RADIO RED/ WHT WIRE TAN WIRE TAN/ ORG WIRE TAN/ORG WIRE TAN/WHT WIRE TOTALLY INTEGRATED POWER MODULE (LEFT FRONT OF ENGINE COMPT) W/ HANDS FREE, TELEMATICS W/ TELEMATICS W/O HANDS FREE, TELEMATICS WHT RED/ WIRE WHT WIRE WHT/LT GRN WIRE WHT/RED WIRE YEL WIRE

AIR BAG CONTROL MODULE (BEHIND LOWER CENTER OF DASH) BLK WIRE BLK/LT GRN WIRE BLK/TAN WIRE BLK/WHT WIRE CCD BUS (-) CENTRAL TIMER MODULE (ON LEFT SIDE OF DASH) CONTROLLER ANTI-LOCK BRAKE (RWAL: LEFT FRONT INNER FENDER) CUMMINS BUS (-) CUMMINS BUS (DIESEL) (LEFT FRONT OF ENGINE) CUMMINS BUS SHIELD DASH) DATA LINK CONNECTOR (DLC) (ON LEFT BOTTOM OF DASH) DIESEL DK BLU WIRE DK GRN WIRE DRAIN WIRE ENGINE CONTROL MODULE (ON LEFT SIDE OF ENGINE, BEHIND FUEL FILTER) FUSE 12 GAS GAS DIESEL GROUND HOT AT ALL TIMES HYDRAULIC CONTROL UNIT INSTRUMENT CLUSTER J/C 5 (BEHIND LEFT SIDE OF DASH) JUNCTION BLOCK (ON LEFT END OF NCA WIRE OVERHEAD CONSOLE (HIGHLINE) PNK WIRE PNK/DK BLU WIRE POWERTRAIN CONTROL MODULE (ON RIGHT SIDE OF FIREWALL) RADIO SCI RECEIVE SCI TRANSMIT VIO/BRN WIRE WHT/BLK WIRE WHT/VIO WIRE YEL/DK BLU WIRE YEL/DK GRN WIRE

ASH RECEIVER LAMP BLK WIRE BLK/LT BLU WIRE BLK/LT GRN WIRE BLK/ORG WIRE BLK/WHT WIRE BRN/LT GRN WIRE CARGO LAMP 1 CARGO LAMP 2 CENTRAL TIMER MODULE (LEFT SIDE OF DASH) CUP HOLDER LAMP DOME LAMP DOME ON CARGO ON FUSE 12 FUSE 7 GLOVE BOX LAMP) HEADLAMP SWITCH HOT AT ALL TIMES HOT IN RUN IGNITION SWITCH JOINT CONNECTOR 5 (BEHIND LEFT SIDE OF DASH) JOINT CONNECTOR 6 (NEAR BRAKE PEDAL ASSY) JUNCTION BLOCK (RIGHT END OF DASH) LEFT DOOR JAMB SWITCH LEFT VISOR LAMP LOW LINE LT BLU WIRE OVERHEAD CONSOLE OVERHEAD MAP/ COURTESY LAMPS PNK WIRE PNK/ 3 1 WIRE PNK/BLK WIRE PNK/DK BLU WIRE RIGHT DOOR JAMB SWITCH RIGHT VISOR LAMP TAN WIRE UNDERHOOD LAMP/ MERCURY SWITCH YEL (OR WIRE YEL WIRE YEL/RED WIRE

4 7 5 HAZ SW SENSE BATT FD 5 LIN CCN COMPUTER DATA LINES SYSTEM 7 WAY TRAILER TOW WIRING (AT TRAILER HITCH) B(+) BLK WIRE BLK/GRY WIRE BLK/LT GRN WIRE BLK/YEL WIRE CAN CAN IHS IHS BUS(+) BUS(-) CIRCUIT BOARD COMPUTER DATA LINES SYSTEM FUSE FUSE OF ENGINE COMPT) FUSE STP LMP LMP RUN/ST FEED SIG SIG GND (RIGHT SIDE OF DASH) HOT AT ALL TIMES HOT AT ALL TIMES TOTALLY INTEGRATED POWER MODULE (LEFT FRONT HOT W/ RUN/ START/RELAY ENERGIZED INSIDE REARVIEW MIRROR LEFT BACKUP LAMP LEFT FRONT PARK/ TURN LAMP (EXCEPT LEFT FRONT SIDE MARKER LAMP LEFT REAR SIDE MARKER LAMP LEFT TAIL LAMP TAIL/ ASSEMBLY STOP/ TURN LAMP LF LF PARK TURN TURN LAMP SIG SIG FEED IND FD LR HAZ BACKUP TURN SW LAMP SIG SIG FEED FD LT GRN WIRE LT GRN/RED WIRE PNK WIRE PNK/LT GRN WIRE RED WIRE RED/GRY WIRE RF RF TURN TURN SIG SIG FD IND RIGHT BACKUP LAMP RIGHT FRONT PARK/ TURN LAMP RIGHT REAR SIDE MARKER LAMP RIGHT TAIL LAMP ASSEMBLY RR PARK TURN IGNITION LAMP SIG FD TAIL/ STOP/ TURN LAMP UPPER BANK SWITCH WHT WIRE WHT/BRN WIRE WHT/DK GRN WIRE WHT/GRY WIRE WHT/LT GRN WIRE WHT/ORG WIRE WHT/RED WIRE WHT/TAN WIRE WHT/VIO WIRE WHT/YEL WIRE

1 2 3 4 IOD FD GND LIN CCN AUTO STICK UP SW FUSED IGN RUN/START IOD FD B(+) BLK WIRE BLK/BRN WIRE BLK/DK GRN WIRE BLK/LT GRN WIRE BLK/WHT WIRE BRAKE FLUID LEVEL SENSOR (LEFT REAR OF ENGINE COMPT) BRN WIRE BRN/WHT WIRE CAN-BUS CARGO LP SW SIG CIRCUIT BOARD CLUSTER COMPASS MODULE COMPT) COMPUTER DATA LINES SYSTEM DK BLU/WHT WIRE DK GRN/ORG (OR DK GRN/RED) WIRE DK GRN/RED WIRE DK GRN/VIO WIRE DK GRN/WHT WIRE DK GRN/YEL WIRE DRIVER COURTESY LAMPS GROUND DRIVER DOOR LATCH DRV DR AJAR SW SENS ERS AUTO STICK SWITCH EXCEPT 6.7L EXCEPT 6.7L 6.7L FUEL LVL SENS SIG FUEL PUMP MODULE FUSE FUSE FUSE GROUND GROUND LIN CCN HDLP POS FOG LMP SW MODE SELECT HDLP SW MUX RTN HEADLIGHTS SYSTEM HEADLIGHTS SYSTEM TRANSMISSIONS SYSTEM HORN SW SNS HORNS SYSTEM HOT AT ALL TIMES HOT W/ RUN/START RELAY ENERGIZED IGN RUN/ START CTRL IND DRV INVERTER MODULE LEFT REAR DOOR LATCH (QUAD, CREW CAB) LR DR AJAR SW SENS LT GRN WIRE LT GRN/DK BLU WIRE LT GRN/GRY WIRE LT GRN/LT BLU WIRE LT GRN/ORG WIRE LT GRN/TAN WIRE LT GRN/WHT WIRE LT GRN/YEL WIRE LVL SW SENS BRK FLUID OIL PRESS SW OIL PRESSURE SENSOR OIL PRESSURE SWITCH ORG/BRN WIRE ORG/GRY WIRE PANEL LP DIMMER SIG PARK BRAKE SW SNS LR HEATED SEAT SW SENS RR HEATED SEAT SW SENS PARKING BRAKE SWITCH (TOP OF PARKING BRAKE PEDAL) PASS DR AJAR SW SENS PASSENGER DOOR LATCH PNK/LT GRN WIRE POWERTRAIN CONTROL MODULE (3.7L, 4.7L: REAR OF ENGINE) RAIL LAMP FDS DRIVER CARGO LAMPS RED WIRE RED/GRY WIRE RIGHT REAR DOOR LATCH (QUAD, CREW CAB) RR DR AJAR SW SENS RR HEATED SEAT LO IND RR HEATED SEAT HI IND SEATS SYSTEM SEATS SYSTEM SEATS SYSTEM SENS RTN FUEL LVL TOTALLY INTEGRATED POWER MODULE (LEFT FRONT OF ENGINE COMPT) TRANSFER CASE POS SENS TRANSMISSIONS SYSTEM VIO WIRE VIO/BRN WIRE VIO/GRY WIRE VIO/WHT WIRE VIO/YEL WIRE WHT WIRE WHT/DK GRN WIRE WHT/GRY WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE WHT/ORG WIRE WHT/TAN WIRE WHT/YEL WIRE YEL/LT BLU WIRE YEL/WHT WIRE

3 4 CARGO LP DRV PANEL LPS DRV AUTO STICK SWITCH (ERS) AUTOSTICK SWITCH (ERS) (COLUMN SHIFT) B(+) BLK WIRE BLK/DK GRN WIRE BLK/LT GRN WIRE BLK/TAN WIRE BRAKE TRANSMISSION SHIFT INTER LOCK SOLENOID CAN CAN IHS IHS BUS BUS FUSE (+) (-) CARGO LP CENTER HIGH MOUNTED CARGO/STOP LAMP CLUSTER COMPUTER DATA LINES SYSTEM CUP HOLDER LAMP DIM SIG ELECTRONICS EXCEPT REGULAR CAB FUSE FUSE MODULE (LEFT FRONT OF ENGINE COMPT) FUSED B (+) FUSED IGN RUN/ST CTRL OUT GRY WIRE HDLP SW HDLP/FOG HEADLAMP SWITCH HOT AT ALL TIMES HOT IN ON OR START LEFT REAR HEATED SEAT SWITCH (IF EQUIPPED) LP SW SIG LPS CTRL LT GRN WIRE MLFT SW RTN MUX RTN ORG/ WIRE ORG/BRN WIRE ORG/GRY WIRE PANEL LPS PANEL LPS CTRL PANEL LPS DRV PNK WIRE PNK/LT GRN WIRE POWER SLIDING BACKLITE SWITCH RED WIRE RIGHT REAR HEATED SEAT SWITCH SHIFT LEVER ASSEMBLY (FLOOR SHIFT) SW SIG TOTALLY INTEGRATED POWER TRANSFER CASE SELECTOR SWITCH WHT WIRE WHT/GRY WIRE WHT/LT GRN WIRE WHT/ORG WIRE WHT/TAN WIRE WHT/YEL WIRE

1 2 3 4 5 6 7 8 9 10 11 12 FUSED B(+) A/C HEATER CONTROL AUTOMATIC A/C BATT TTOW PRE 3 PRK BLK/LT GRN WIRE BRN/YEL WIRE BTSI CTRL BUS BAR CIRCUIT BOARD COMPUTER DATA LINES SYSTEM EXCEPT PARK ASSIST EXCEPT REGULAR CAB FUSE IGNITION RUN/START CONTROL OUTPUT IGNITION WIRELESS NODE INFRARED PARK ASSIST SENSOR MODULE LT BLU/RED WIRE MANUAL A/C OCCUPANT RESTRAINT CONTROLLER MODULE PARK ASSIST PNK/ YEL WIRE PNK/ORG WIRE PNK/TAN WIRE PNK/VIO WIRE PNK/WHT WIRE PNK/YEL WIRE REAR VIDEO CAMERA (IF EQUIPPED) RELAY RUN WIRE RUN/START GND CAN C BUS + CAN C BUS - BTSI CONTROL STP LMP SIG STOP LAMP SWITCH STP LMP SIG TOTALLY INTEGRATED POWER MODULE TRANSMISSION SHIFT INTERLOCK BRAKE SOLENOID TRS PRK SIG WHT WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE YEL PNK/ WIRE YEL/DK BLU WIRE

1 2 3 4 5 6 7 8 TRANS RLY OUT AIR CONDI- TIONING SYSTEM AUTO SHT RLY CRUISE VAC SOL CRUISE VNT SOL BLK/LT BLU WIRE BLK/LT GRN WIRE BLK/RED WIRE BRN WIRE BRN/WHT WIRE CCD(-) CRUISE CONTROL SYSTEM CRUISE SW IN DATA LINK CONNECTOR (LEFT BOTTOM OF DASH) DK BLU WIRE DK BLU/ORG WIRE DK BLU/WHT WIRE DK BLU/YEL WIRE DK GRN WIRE DK GRN/ORG WIRE FUEL PMP RLY EVAP SOL DRVR FUSE 11 FUSE I GENERATOR HOT AT ALL TIMES HOT IN RUN OR START INSTRUMENT CLUSTER INTAKE AIR TEMPERATURE SENSOR (IN RIGHT FRONT SIDE OF INTAKE MANIFOLD) JOINT CONNECTOR 1 (IN PDC) JOINT CONNECTOR 11 9 2 14 6 5 JUNCTION BLOCK (RIGHT END OF DASH) LEAK DETECTION PUMP (RIGHT FRONT OF INNER FENDER) LT GRN/RED WIRE LT GRN/WHT WIRE NCA WIRE ORG/ WIRE ORG/BLK WIRE ORG/DK BLU WIRE ORG/WHT WIRE OVERDRIVE SWITCH PNK 1 2 WIRE PNK WIRE PNK/DK BLU WIRE PNK/WHT WIRE PNK/YEL WIRE POWER DISTRIBUTION CENTER (IN ENG COMPT, ON LEFT INNER FENDER PANEL) POWERTRAIN CONTROL MODULE (IN ENG COMPT, ON RIGHT SIDE OF FIREWALL) RED WIRE RED/LT GRN WIRE SENSOR GRD GOV PRESS SIG VAR FORCE SOL OVERDRV SOL TCC SOL CTRL TRANS TEMP SNS STOP LAMP SWITCH (ON BRAKE PEDAL BRACKET) TAN/RED WIRE THROTTLE POSITION SENSOR (ON THROTTLE BODY) TRANS- MISSION RELAY TRANSMISSION SOLENOID ASSEMBLY (ON LEFT SIDE OF TRANSMISSION) VIO WIRE VIO/BRN WIRE VIO/WHT WIRE WHT/BLK WIRE WHT/DK GRN WIRE WHT/PNK WIRE YEL/RED WIRE

1 2 3 4 5 6 7 8 TRANS RLY OUT AIR CONDI- TIONING SYSTEM AIR CONDITIONING SYSTEM AUTO SHT RLY CRUISE VAC SOL CRUISE VNT SOL BLK/LT BLU WIRE BLK/LT GRN WIRE BLK/RED WIRE BRN WIRE BRN/VIO WIRE BRN/WHT WIRE CCD(-) CRUISE CONTROL SYSTEM CRUISE SW IN DATA LINK CONNECTOR (LEFT BOTTOM OF DASH) DK BLU WIRE DK BLU/ORG WIRE DK BLU/WHT WIRE DK BLU/YEL WIRE DK GRN WIRE DK GRN/ORG WIRE DK GRN/PNK WIRE DK GRN/WHT WIRE DK GRN/YEL WIRE DOWNSTREAM OXYGEN SENSOR RELAY FUEL PMP RLY EVAP SOL DRVR FUSE GENERATOR HOT AT ALL TIMES INSTRUMENT CLUSTER INTAKE AIR TEMPERATURE SENSOR (IN LEFT FRONT SIDE OF INTAKE MANIFOLD) JOINT CONNECTOR 1 (IN PDC) JOINT CONNECTOR 11 9 2 14 6 5 LEAK DETECTION PUMP (ON RIGHT FRONT OF INNER FENDER) LT GRN/RED WIRE LT GRN/WHT WIRE M/T ONLY ORG/ WIRE ORG/BLK WIRE ORG/DK BLU WIRE ORG/WHT WIRE OVERDRIVE SWITCH PNK WIRE PNK/DK BLU WIRE PNK/WHT WIRE PNK/YEL WIRE POWERTRAIN CONTROL MODULE (IN ENG COMPT, ON RIGHT SIDE OF FIREWALL) RED WIRE RED/LT GRN WIRE SENSOR GRD GOV PRESS SIG VAR FORCE SOL OVERDRV SOL TCC SOL CTRL TRANS TEMP SNS STOP LAMP SWITCH (ON BRAKE PEDAL BRACKET) TAN/RED WIRE THROTTLE POSITION SENSOR (ON THROTTLE BODY) TRANSMISSION RELAY FUSE I TRANSMISSION SOLENOID ASSEMBLY (ON LEFT SIDE OF TRANSMISSION) VIO WIRE VIO/BRN WIRE VIO/WHT WIRE WHT/BLK WIRE WHT/DK GRN WIRE WHT/PNK WIRE YEL WIRE YEL/RED WIRE