Dodge Intrepid II (1997-2004) manual temperature control head Wiring diagrams

1 2 3 4 5 BLEND AIR DR DRVR SENSOR GND FBCK SIGNAL 1 2 3 4 5 DRIVER 1 2 3 4 5 MODE DOOR DRIVER SENSOR GROUND MODE FBCK SIGNAL 1 2 3 SENSOR GROUND 2 1 GROUND SIGNAL 20 9 1 15 13 22 12 14 EVAP TEMP SIG MODE FDBK SIG BLND DR FDBK 27 29 SENS GND 5 VOLT SUPPLY 32 4 6 11 AMBIENT TEMP RELAY CTRL RELAY CTRL RELAY CTRL 38 21 PCI BUS A/C PRESS SIG A/C COMPRESSOR CLUTCH A/C COMPRESSOR CLUTCH RELAY (IN POWER DISTRIBUTION CENTER) A/C PRESS SIG A/C PRESSURE TRANSDUCER (ON A/C DISCHARGE LINE) BLEND DOOR ACTUATOR (ON LOWER LEFT SIDE OF HVAC ASSEMBLY) BLK WIRE BLK/LT BLU WIRE BLK/TAN WIRE BLOWER MOTOR BLOWER MOTOR RESISTOR BLOCK (ON LOWER RIGHT SIDE OF HVAC HOUSING) BLU WIRE BODY CONTROL MODULE (AT LEFT END OF DASH, ATTACHED TO JUNCTION BLOCK) BRN WIRE BRN/WHT WIRE CLOCKSPRING (BEHIND STEERING WHEEL, IN STEERING COLUMN) COMMON COMMON DR DRVR DEFOGGER SYSTEM DK BLU WIRE DK BLU/BLK WIRE DK BLU/GRY WIRE DK BLU/ORG WIRE DK BLU/PNK WIRE DK BLU/RED WIRE DK BLU/WHT WIRE DK GRN WIRE DK GRN/YEL WIRE FUSE FUSE 17 FUSE 21 FUSE 23 GRN WIRE GROUND GRY WIRE GRY/DK BLU WIRE HIGH BLOWER MTR HIGH SPEED RADIATOR FAN RELAY HOT AT ALL TIMES HOT IN RUN JUNCTION BLOCK (AT LEFT END OF DASH) HOT IN RUN OR START LOW BLOWER MTR LOW SPEED RADIATOR FAN RELAY LT BLU WIRE LT GRN WIRE LT GRN/BLK WIRE MANUAL TEMPERATURE CONTROL HEAD MODE DOOR ACTUATOR (ON LOWER LEFT SIDE OF HVAC UNIT HOUSING) NCA WIRE ORG/ WIRE PANEL LAMPS DRVR PCI BUS PK LP RLY OUT A/C MODE MUX TEMP SELECT A/C LED IND SIG PNK WIRE PNK/DK BLU WIRE POWER DISTRIBUTION CENTER (ON LEFT SIDE OF ENGINE COMPARTMENT) POWERTRAIN CONTROL MODULE (PCM) (IN LEFT REAR OF ENGINE COMPARTMENT) RADIATOR FAN REAR WDO DEFOG RECIRCULATION DOOR ACTUATOR (ON RIGHT SIDE OF HVAC ASSEMBLY) RED WIRE RED/BRN WIRE RED/TAN WIRE RED/WHT WIRE SOUND SYSTEMS TAN WIRE TEMP SELECT A/C MODE SW MUX VIO/LT GRN WIRE VIO/PNK WIRE VIO/WHT WIRE VIO/YEL WIRE WHT WIRE YEL WIRE YEL/BLK WIRE YEL/ORG WIRE YEL/WHT WIRE

1 2 3 SENSOR GROUND 2 1 GROUND SIGNAL 21 38 A/C PRESS SIG PCI BUS 27 29 SENSOR GND 5 VOLT SUPPLY 4 6 11 32 RELAY CTRL RELAY CTRL RELAY CTRL AMBIENT TEMP A/C COMPRESSOR CLUTCH A/C COMPRESSOR CLUTCH RELAY A/C PRESS SIG BLK WIRE BLK/LT BLU WIRE BLK/TAN WIRE BLOWER MOTOR RESISTOR BLOCK (ON LOWER RIGHT SIDE OF HVAC ASSEMBLY) BLU WIRE BODY CONTROL MODULE (AT LEFT END OF DASH, ATTACHED TO JUNCTION BLOCK) BRN/WHT WIRE CLOCKSPRING (BEHIND STEERING WHEEL, IN STEERING COLUMN) DEFOGGER SYSTEM DK BLU WIRE DK BLU/BLK WIRE DK BLU/GRY WIRE DK BLU/ORG WIRE DK BLU/PNK WIRE DK BLU/RED WIRE DK BLU/WHT WIRE DK GRN/YEL WIRE EVAP TEMP SIG A/C MODE MUX EVAPORATOR TEMPERATURE SENSOR (IN HVAC ASSEMBLY, ON FACE OF EVAPORATOR) FUSE 17 FUSE 21 FUSE 23 GRN WIRE GROUND GRY/DK BLU WIRE HIGH BLOWER MTR HOT IN RUN HOT IN RUN OR START JUNCTION BLOCK (AT LEFT END OF DASH) LOW BLOWER MTR LT BLU WIRE LT GRN WIRE LT GRN/BLK WIRE MANUAL TEMPERATURE CONTROL HEAD NCA WIRE ORG/ WIRE PANEL LAMPS DRVR PCI BUS PNK/DK BLU WIRE POWER DISTRIBUTION CENTER (ON LEFT SIDE OF ENGINE COMPARTMENT) POWERTRAIN CONTROL MODULE (PCM) (IN LEFT REAR OF ENGINE COMPARTMENT) REAR WDO DEFOG RED/BRN WIRE RED/TAN WIRE RED/WHT WIRE SOUND SYSTEMS TAN WIRE TEMP SELECT A/C MODE SW MUX VIO/LT GRN WIRE VIO/PNK WIRE VIO/WHT WIRE VIO/YEL WIRE WHT WIRE YEL/BLK WIRE YEL/ORG WIRE YEL/WHT WIRE

AUTOMATIC TEMPERATURE CONTROL HEAD BLK WIRE BODY CONTROL MODULE CIGAR LIGHTER COMBINATION FLASHER CONCORDE DODGE DATA LINK CONNECTOR (DLC) DODGE DODGE) RIGHT TAIL/STOP LAMP 2 FROM FROM SEAT BELT SWITCH (DIAGRAM 1 OF 3) GLOVE BOX LAMP) HEADLAMP SWITCH INSTRUMENT CLUSTER JUNCTION BLOCK LEFT BACK-UP LAMP LEFT REAR TURN SIGNAL LAMP LEFT TAIL LAMP LEFT TAIL/STOP LAMP 1 LEFT TAIL/STOP LAMP LICENSE LAMP MANUAL TEMPERATURE CONTROL HEAD ORG/ WIRE PROVISIONS FOR AUXILIARY LIGHTING (POLICE PACKAGE) RIGHT BACK-UP LAMP RIGHT REAR TURN SIGNAL LAMP RIGHT TAIL/STOP LAMP RIGHT TAIL/STOP LAMP 1 TRANSMISSION RANGE INDICATOR ILLUMINATION (PRNDL) TURN SIGNAL/ HAZARD SWITCH