Dodge Cab & Chassis R3500 (1996-2006) Wiring diagram engine performance 8.0l

A/C PRESS SIG AUTO SHUT DOWN RELAY BLK/DK GRN WIRE BLK/GRY WIRE BLK/LT BLU WIRE BLK/RED WIRE BLK/TAN WIRE BRN WIRE BRN/DK BLU WIRE BRN/WHT WIRE BRN/YEL WIRE CALIF CAM POS SNS IDLE AIR 4 IDLE AIR 1 CAPACITOR CONTROLLER ANTI-LOCK BRAKE (LEFT REAR OF ENG COMPT) DK BLU WIRE DK BLU/BLK WIRE DK BLU/TAN WIRE DK BLU/YEL WIRE DK GRN WIRE DK GRN/GRY WIRE DK GRN/ORG WIRE DK GRN/RED WIRE DK GRN/WHT WIRE FUEL INJECTORS FUEL PUMP RELAY FUSE 19 FUSE 17 FUSE 2 FUSED B(+) TPS SENS IN GROUND GROUND GRY WIRE GRY/BLK WIRE GRY/LT BLU WIRE GRY/RED WIRE GRY/YEL WIRE HOT AT ALL TIMES IAT SENS IN ECT SENS IN IGNITION COIL (LEFT) IGNITION COIL (RIGHT) INTEGRATED POWER MODULE (LEFT FRONT OF ENG COMPT) LEFT FRONT FENDER) LT BLU/BRN WIRE LT GRN/BLK WIRE LT GRN/RED WIRE LT GRN/WHT WIRE MAP SENS IN NO 1 DRVR NO 2 DRVR NO 3 DRVR NO 4 DRVR NO 5 DRVR OIL PRESS SIG ORG/ WIRE ORG/BLK WIRE ORG/DK BLU WIRE OUTPUT SENS OUTPUT SPEED SENSOR (ON LEFT REAR OF TRANSMISSION) OVERDRV SOL PNK WIRE POWERTRAIN CONTROL MODULE (ON RIGHT SIDE OF FIREWALL) PTO SW SENS RED/WHT WIRE RED/YEL WIRE RLY OUT STARTING/CHARGING SYSTEM SWITCH TAN WIRE TAN/BLK WIRE TAN/WHT WIRE TAN/YEL WIRE TO FUSE 49 (DIAGRAM 3 OF 3) TRANSMISSION RANGE SENSOR (ON LEFT SIDE OF TRANSMISSION) VAR FRCE SOL VIO WIRE VIO/BLK WIRE VIO/TAN WIRE VIO/WHT WIRE VSS IN OUTPUT SENS GOV PRESS SIG TRANS RELAY WHT/DK BLU WIRE WHT/ORG WIRE YEL/BLK WIRE YEL/GRY WIRE YEL/WHT WIRE

2/2 (DOWN- STREAM) (RIGHT EXHAUST DOWNPIPE, DOWNSTREAM OF CONVERTER) (CALIF) BATTERY TEMPER- ATURE SENSOR (BELOW BATTERY TRAY) BLK WIRE BLK/DK GRN WIRE BLK/LT BLU WIRE BLK/RED WIRE BLK/WHT WIRE BRN WIRE BRN/VIO WIRE BRN/WHT WIRE CAMSHAFT POSITION SENSOR (RIGHT FRONT SIDE OF ENGINE) CLOCKSPRING CRANKSHAFT POSITION SENSOR DK BLU WIRE DK BLU/YEL WIRE DK GRN WIRE DK GRN/BLK WIRE DK GRN/ORG WIRE DK GRN/RED WIRE DK GRN/WHT WIRE DRVR 1 DRVR 2 DRVR 3 DRVR 4 ENGINE COOLANT TEMPERATURE SENSOR (ON THERMOSTAT HOUSING) ENGINE OIL PRESSURE SWITCH (LOWER LEFT SIDE OF ENG) EVAP/ PURGE SOLENOID (LEFT FRONT OF ENGINE COMPT) FRONT SIDE OF TRANS) FRONT SIDE OF TRANSMISSION) FUEL PUMP MODULE (INSIDE FUEL TANK) FUSE 50 GRY/BLK WIRE GRY/RED WIRE GRY/YEL WIRE HEATED OXYGEN SENSOR HEATED OXYGEN SENSOR 11 HEATED OXYGEN SENSOR 12 HEATED OXYGEN SENSOR 21 HOT IN RUN OR START INTEGRATED POWER MODULE (LEFT FRONT OF ENGINE COMPT) LT BLU/BLK WIRE LT GRN/BLK WIRE LT GRN/RED WIRE MANIFOLD ABSOLUTE PRESSURE SENSOR (ON RIGHT UPPER SIDE OF INTAKE MANIFOLD) NCA WIRE ORG/ WIRE ORG/BLK WIRE ORG/DK BLU WIRE PNK WIRE PNK/BLK WIRE PNK/YEL WIRE PTC 1 PTO SWITCH RED WIRE TAN/BLK WIRE TAN/WHT WIRE TAN/YEL WIRE VIO WIRE VIO/BLK WIRE VIO/WHT WIRE WHT WIRE YEL/BLK WIRE

1 2 3 4 5 6 7 8 TRANS RLY OUT 5-VOLT A/C PRESSURE TRANSDUCER (ON LEFT SIDE OF A/C COMPRESSOR) AIR CONDITIONING SYSTEM AUTO SHT RLY CRUISE VAC SOL CRUISE VNT SOL BLK/LT BLU WIRE BLK/RED WIRE BLK/TAN WIRE BLK/VIO WIRE BRAKE SW IN GEN FIELD OUT FUEL LVL SENS SIG SCI TRANSMIT BRN WIRE BRN/VIO WIRE BRN/WHT WIRE CRUISE CONTROL SYSTEM CRUISE SW IN DATA LINK CONNECTOR (LEFT SIDE OF DASH) DK BLU WIRE DK BLU/ORG WIRE DK BLU/YEL WIRE DK GRN WIRE DK GRN/ORG WIRE DK GRN/WHT WIRE DOWNSTREAM OXYGEN SENSOR RELAY (CALIFORNIA) FROM AUTO SHUT DOWN RELAY (DIAGRAM 1 OF 3) FUEL PMP RLY EVAP SOL CTRL FUSE 49 FUSE 5 GENERATOR HOT AT ALL TIMES INTAKE AIR TEMPERATURE SENSOR (IN LEFT FRONT SIDE OF INTAKE MANIFOLD) INTEGRATED POWER MODULE (LEFT FRONT OF ENGINE COMPT) LEAK DETECTION PUMP (ON RIGHT FRONT OF INNER FENDER) LT BLU/BLK WIRE LT BLU/VIO WIRE LT GRN WIRE LT GRN/RED WIRE ORG/ WIRE ORG/BLK WIRE ORG/DK BLU WIRE ORG/WHT WIRE OVERDRIVE SWITCH PNK WIRE PNK/BLK WIRE PNK/YEL WIRE POWERTRAIN CONTROL MODULE (RIGHT SIDE OF FIREWALL) PRESS SIG RED WIRE RED/LT GRN WIRE SCI RECEIVE PCI BUS SENS GRD SENSOR GRD GOV PRESS SIG PRESS SOL CTRL 3-4 SOL CTRL TCC SOL CTRL TRANS TEMP SNS STOP LAMP SWITCH (ON BRAKE PEDAL BRACKET) TAN/RED WIRE THROTTLE POSITION SENSOR (ON THROTTLE BODY) TRANSMISSION RELAY TRANSMISSION SOLENOID ASSEMBLY (INSIDE TRANSMISSION) VIO WIRE VIO/BRN WIRE VIO/WHT WIRE WHT/DK BLU WIRE WHT/DK GRN WIRE WHT/PNK WIRE YEL/RED WIRE