Dodge Cab & Chassis R3500 HD (2008-2009) yel/org Wiring diagrams

B(+) TRANS TRANS CTRL OUT CTRL BLK WIRE BLK/LT GRN (OR BLK) WIRE BLK/LT GRN WIRE BRN/YEL WIRE DK BLU/DK GRN WIRE DK GRN WIRE DK GRN/BRN WIRE DK GRN/DK BLU WIRE DK GRN/LT BLU WIRE DK GRN/ORG WIRE DK GRN/PNK WIRE DK GRN/TAN WIRE DK GRN/VIO WIRE DK GRN/WHT WIRE DK GRN/YEL WIRE ELECTRONICS EXCEPT RAM 2500 FS- SOL HOT AT ALL TIMES IGN SW (START) INPUT SPEED SENSOR (LEFT SIDE OF TRANSMISSION) L/R PRESS PRESS PRESS LINE PRESSURE SENSOR (RIGHT SIDE OF TRANSMISSION) VOLT SIG GND LINE PRS SENS OUTPT SPD SENS INPT SPD SENS SPD SENS GND TRNS TMP SNS MS SOL CTRL OD SOL CTRL ODC SOL UD LR SOL SOL UD PRESS OD PRESS OUTPUT SPEED SENSOR (LEFT REAR OF TRANSMISSION) POWERTRAIN CONTROL MODULE (RIGHT REAR OF ENGINE COMPT) PRESS. RAM 2500 SNSR GND TEMPERATURE SENSOR TOTALLY INTEGRATED POWER MODULE (LEFT FRONT FENDER) TRANSMISSION SOLENOID/TRS ASSEMBLY (LEFT SIDE OF TRANSMISSION) TRNS CTRL OUT TRNS CTRL OUT L/R PRESS SW TRNS CTRL TRNS CTRL OUT TRS TRS IGN SW (START) SENSE TRS TRS TRS TRS UD PRESS SW OD PRESS SW UD SOL CTRL L/R SOL CTRL PRESS CTRL SOL UDC LR/LU LP SOL VFS SOL YEL WIRE YEL/BRN WIRE YEL/DK BLU WIRE YEL/DK GRN WIRE YEL/GRY WIRE YEL/LT BLU WIRE YEL/LT GRN WIRE YEL/ORG WIRE YEL/PNK WIRE YEL/WHT WIRE

27 23 5 9 29 24 17 14 25 15 45 44 SENS SIG 5 VOLT SPLY TRANS CTRL 6 2 1 5 3 SENS GND 8 20 TTVA MTR (+) TTVA MTR (-) B(+) TRANS CTRL CAN B CAN B BUS (+) BUS (-) CLUSTER COMPUTER DATA LINES SYSTEM DK BLU WIRE DK BLU/DK GRN WIRE DK GRN WIRE DK GRN/BRN WIRE DK GRN/ORG WIRE DK GRN/TAN WIRE DK GRN/VIO WIRE DK GRN/YEL WIRE ELECTRONICS ENGINE CONTROL MODULE (LOWER LEFT FRONT OF ENGINE BLOCK) ENGINE CONTROL SYSTEM EXCEPT RAM 3500 FUSE 10 HOT AT ALL TIMES LEFT REAR OF ENGINE COMPT) ORG/ WIRE OUTPUT SPEED SENSOR (BOTTOM OF TRANSMISSION) SENS SIG TTVA (-) TTVA (+) SNS TAN/ORG WIRE TAN/YEL WIRE TOTALLY INTEGRATED POWER MODULE (AT LEFT FRONT FENDER) TRANS CTRL OUT TRANSMISSION RANGE SENSOR (RE) (LEFT SIDE OF TRANSMISSION) TRANSMISSION SOLENOID ASSEMBLY (RE) (LEFT SIDE OF TRANSMISSION) TRANSMISSION THROTTLE VALVE ASSEMBLY (RE) TRS CAN B CAN B RETURN BUS + BUS - TRS SIG WHT WIRE WHT/ORG WIRE YEL/BRN WIRE YEL/DK BLU WIRE YEL/LT BLU WIRE YEL/ORG WIRE YEL/PNK WIRE YEL/TAN WIRE

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 INPUT SPEED SENS SIG 1 2 3 4 5 6 7 8 9 10 11 12 PRESS SW 1 PRESS SW 6 1 2 3 4 5 6 7 8 9 10 NEUTRAL SW ALL TIMES B(+) TRANS SNS CTRL OUT BLK WIRE BLK/LT GRN WIRE CAN C BUS (+) CAN C BUS (-) COMPT) COMPUTER DATA LINES SYSTEM DK GRN WIRE DK GRN/BRN WIRE DK GRN/DK BLU WIRE DK GRN/GRY WIRE DK GRN/LT BLU WIRE DK GRN/LT GRN WIRE DK GRN/ORG WIRE DK GRN/PNK WIRE DK GRN/RED WIRE DK GRN/TAN WIRE DK GRN/VIO WIRE DK GRN/WHT WIRE DK GRN/YEL WIRE FUSE 10 FUSE 4 FUSE 24 FUSED B (+) GROUND FUSED IGN SW OUT (OFF-RUN-START) INPUT SPEED SENSOR (LEFT SIDE OF TRANSMISSION) LINEAR SOL 4 (+) LINEAR SOL 2 (+) LINEAR SOL 4 (-) LINEAR SOL 2 (-) PRESS SW 2 PRESS SW 3 LT BLU/BLK WIRE ORG/LT GRN WIRE OUTPUT SPEED SENS SIG TRANS CTRL OUTPUT TRANS CTRL OUTPUT OUTPUT SPEED SENSOR (LEFT REAR OF TRANSMISSION) PNK/WHT WIRE POWER TAKE OFF RELAY (INFO NOT AVAILABLE) POWER TAKEOFF RLY ENABLE RANGE SW 1 (OFF-RUN-START) TRS PARK SW GROUND RANGE SW DRV RANGE SW REVERSE RED WIRE TOTALLY INTEGRATED POWER MODULE (LEFT FRONT FENDER) ELECTRONICS TOW/HAUL OVERDR OFF SW TRANS TEMP SENS SIG TORQUE OIL TEMP SIG GROUND TOW/HAUL OVERDRIVE OFF SWITCH TRANSMISSION CONTROL MODULE (LEFT END OF DASH) TRANSMISSION RANGE SENSOR (LEFT SIDE OF TRANSMISSION) TRANSMISSION RELAY TRANSMISSION SOLENOID ASSEMBLY (LEFT SIDE OF TRANSMISSION) TRANSMISSION TEMPERATURE SENSOR (RIGHT SIDE OF TRANSMISSION) TRS RANGE SW DRV TRS RANGE SW PARK TRS RANGE SW REVERSE TRX-LINEAR SOL 3 (+) TRS RANGE SW 1 TRX-PRESS SW 4 TRX-PRESS SW 1 TRX-PRESS SW 5 TRX-PRESS SW 3 TRX-PRESS SW 6 TRX-PRESS SW 2 TRX-PRESS SW 8 WHT/LT BLU WIRE WHT/LT GRN WIRE YEL WIRE YEL/BRN WIRE YEL/DK BLU WIRE YEL/GRY WIRE YEL/ORG WIRE YEL/PNK WIRE YEL/RED WIRE YEL/VIO WIRE YEL/WHT WIRE

1 2 3 4 5 6 7 8 9 10 11 12 13 14 FUSED B(+) 1 2 3 4 5 6 7 8 9 10 11 12 13 GROUND SHIFT MOTOR CTRL A SHIFT MOTOR CTRL B 5 VOLT SUPPLY MODE SENSOR A SENSOR RETURN 6 7 8 9 10 11 12 FUSED IGN SW OUT A/C CLUTCH CTRL ASD CTRL BRAKE FLUID LEVEL SW SNS GROUND AIR CONDITIONING SYSTEM ENGINE CONTROLS SYSTEM ANTI-LOCK BRAKES SYSTEM ANTI-LOCK BRAKES SYSTEM ANTI-LOCK BRAKES SYSTEM DOOR LOCKS, TRANSMISSIONS, MIRRORS SYSTEMS BLK WIRE BLK/WHT WIRE BLK/YEL WIRE BRN WIRE BRN/GRY WIRE BRN/ORG WIRE BRN/TAN WIRE BRN/WHT WIRE DK BLU/GRY WIRE DK BLU/WHT WIRE DK BLU/YEL WIRE DK GRN WIRE DK GRN/ORG WIRE DK GRN/RED WIRE ENGINE CONTROLS SYSTEM ENGINE CONTROLS SYSTEM AIR CONDITIONING SYSTEM SEATS, ENGINE CONTROLS SYSTEM POWER DISTRIBUTION SYSTEM INSTRUMENT CLUSTER SYSTEM ENGINE CONTROLS SYSTEM WIPER/WASHER SYSTEM FUEL PUMP CTRL WIPER PARK SW SENSE FUSED B (+) FUSED B(+) FUEL PUMP CTRL OUT HORN CTRL OUT GROUND FUSED B(+) FUSED B(+) FUSED IGN SW (RUN-START) FUSED B(+) FUSED IGN SW OUT (RUN) FUSED IGN SW OUT (RUN) FUSED IGN SW (RUN-ACC) FUSED IGN SW (RUN-ACC) FUSED B(+) FUSED IGN SW (RUN-START) FUSED IGN SW OUT (OFF-RUN-START) 1 2 FUSED PARK LAMP FEED FUSED PARK LAMP FEED FUSED PARK LAMP FEED GRY/LT BLU WIRE GRY/PNK WIRE GRY/RED WIRE GRY/YEL WIRE HORN CTRL OUT WIPER LOW SPEED CTRL GROUND HEATED MIRROR CTRL OUT FUSED B(+) HORNS SYSTEM WIPER/WASHER SYSTEM INSTRUMENT CLUSTER SYSTEM SOUND SYSTEMS ENGINE CONTROLS SYSTEM INTERIOR LIGHTS, SOUNDS, COMPUTER DATA LINES SYSTEMS LT BLU/ORG WIRE LT GRN WIRE ORG/RED WIRE PASSIVE RESTRAINT SYSTEM POWER DISTRIBUTION SYSTEM PNK/DK GRN WIRE PNK/GRY WIRE PNK/LT BLU WIRE PNK/LT GRN WIRE PNK/RED WIRE PNK/WHT WIRE PNK/YEL WIRE POWER DISTRIBUTION SYSTEM POWER WINDOWS SYSTEM RED WIRE RED/DK BLU WIRE RED/LT BLU WIRE RED/ORG WIRE RED/YEL WIRE SEATS SYSTEM AIR CONDITIONING SYSTEM STARTER SOLENOID CTRL 3 4 5 6 7 8 9 10 11 12 13 14 TAN/RED WIRE TOTALLY INTEGRATED POWER MODULE (LEFT FRONT FENDER) TRANSMISSIONS SYSTEM TRANSMISSIONS SYSTEM ANTI-THEFT SYSTEM TRANSMISSIONS SYSTEM EXTERIOR LIGHTS SYSTEM TRANSMISSIONS SYSTEM POWER TOPS SYSTEM DEFOGGER SYSTEM TRANSMISSIONS, ENGINE CONTROLS SYSTEMS VIO/LT BLU WIRE VIO/TAN WIRE VIO/YEL WIRE WARNING SYSTEMS WASHER PUMP MOTOR CTRL IGN SW OUT (RUN-START) ADJUSTABLE PEDALS OUT WHT/DK GRN WIRE WHT/GRY WIRE WHT/YEL WIRE WIPER/WASHER SYSTEM WIPER/WASHER SYSTEM POWER DISTRIBUTION SYSTEM SEATS SYSTEM YEL WIRE YEL/DK BLU WIRE YEL/GRY WIRE YEL/ORG WIRE YEL/RED WIRE

1 4 2 3 SOURCE RETURN SENS SPLY SENS SNS BLK WIRE CAN C BUS(+) CAN C BUS(-) R LCKR SRC F LCKR SRC LCKR SW SNS COMPUTER DATA LINES SYSTEM DISCONNECTING STABILIZER BAR SWITCH FINAL DRIVE CONTROL MODULE (MOUNTED ON FRONT STABILIZER BAR) FRONT LOCKER SOLENOID (LEFT REAR OF ENGINE) FRONT/ REAR LOCK FUSE 30 FUSE 9 HOT AT ALL TIMES HOT IN ON OR START ORG/DK BLU WIRE PNK/LT GRN WIRE REAR LOCK REAR LOCKER SOLENOID (AT REAR DIFFERENTIAL) RED/YEL WIRE STBLR SW SNS ILLUM SNS ILLUM SNS ILLUM SNS ILLUM SNS ILLUM SNS TOTALLY INTEGRATED POWER MODULE (LEFT FRONT FENDER) UNLOCK WHT/LT BLU WIRE WHT/LT GRN WIRE YEL WIRE YEL/BLK WIRE YEL/BRN WIRE YEL/DK GRN WIRE YEL/GRY WIRE YEL/LT BLU WIRE YEL/LT GRN WIRE YEL/ORG WIRE YEL/TAN WIRE YEL/WHT WIRE

1 2 3 4 5 5 V SPLY MODE SENSOR A SENSOR RETURN SHIFT CTRL B SHIFT CTRL A 17 18 CAN B BUS(+) CAN B BUS(-) B(+) SHIFT SHIFT MTR MTR MODE SENS 5 V CTRL CTRL BUS BUS SENS RTN SPLY BLK WIRE BRN/WHT WIRE CAN (-) CAN (+) CLUSTER COMPUTER DATA LINES SYSTEM DK GRN WIRE ELECTRONICS EXCEPT BASE FUSE 29 HOT AT ALL TIMES HOT IN ON OR START TOTALLY INTEGRATED POWER MODULE (LEFT FRONT FENDER) MODE SELECT NEUTRAL IND ORG/DK BLU WIRE PNK/DK GRN WIRE SENS IN TRANSFER CASE SELECTOR SWITCH (5.9L DIESEL: LEFT SIDE OF TRANSFER CASE) VIO/BRN WIRE VIO/YEL WIRE WHT WIRE WHT/DK GRN WIRE WHT/ORG WIRE YEL WIRE YEL/ORG WIRE

BLK WIRE BRN/GRY WIRE BRN/ORG WIRE BRN/VIO WIRE BRN/WHT WIRE BRN/YEL WIRE DK BLU/BRN WIRE DK BLU/DK GRN WIRE DK BLU/WHT WIRE DK GRN WIRE DK GRN/BRN WIRE DK GRN/DK BLU WIRE DK GRN/LT BLU WIRE DK GRN/ORG WIRE DK GRN/PNK WIRE DK GRN/TAN WIRE DK GRN/VIO WIRE DK GRN/WHT WIRE DK GRN/YEL WIRE EXCEPT UPFITTER FS-LR SOL SOL L/R PRESS LP LR/LU SOL VFS SOL SOL SOL MULTI DISPLACEMENT SYSTEM CYLINDER 1 SOLENOID MULTI DISPLACEMENT SYSTEM CYLINDER 7 SOLENOID OD PRESS TRS ODC PNK/YEL WIRE PRESS PRESS PTO SW SNS PTO SWITCH TEMP TRS SENS TRANSMISSION SOLENOID/TRS ASSEMBLY (LEFT SIDE OF TRANSMISSION) TRS TRS TRS UD PRESS UDC UPFITTER UPFITTER ACCESSORIES JUMPER KIT VIO WIRE VIO/BRN WIRE VIO/WHT WIRE VIO/YEL WIRE WHT/BRN WIRE YEL/BRN WIRE YEL/DK BLU WIRE YEL/DK GRN WIRE YEL/GRY WIRE YEL/LT BLU WIRE YEL/LT GRN WIRE YEL/ORG WIRE YEL/WHT WIRE

A/C A/C CLUTCH CTRL ANTI-LOCK BRAKES SYSTEM APP 1 SIG ASD CTRL ASD CTRL OUT EVAP PURGE SOL SIG P/S SW SIG BLK WIRE BLK/LT GRN WIRE BRN WIRE BRN/GRY WIRE BRN/ORG WIRE BRN/VIO WIRE BRN/WHT WIRE BRN/YEL WIRE BUS - CAN C (+) CAN C BUS (+) CLUTCH COMPUTER DATA LINES SYSTEM CRUISE CONTROL SYSTEM CTRL DK BLU WIRE DK BLU/BRN WIRE DK BLU/WHT WIRE DK GRN WIRE DK GRN/BRN WIRE DK GRN/DK BLU WIRE DK GRN/LT BLU WIRE DK GRN/ORG WIRE DK GRN/PNK WIRE DK GRN/TAN WIRE DK GRN/VIO WIRE DK GRN/WHT WIRE DK GRN/YEL WIRE ELECTRONICS EXCEPT RAM 2500 FUEL L/R CTRL PRESSURE CTRL SOLENOID GROUND GROUND GROUND LT BLU/ORG WIRE MDS SOL CTRL 7 MDS SOL CTRL 1 MS SOLENOID CTRL PNK/YEL WIRE POWERTRAIN CONTROL MODULE (RIGHT REAR OF ENGINE COMPT) PTO SNS BRAKE SW 1 SIG PUMP CTRL RAM 2500 SENS STARTING/ CHARGING SYSTEM TOTALLY INTEGRATED POWER MODULE (LEFT FRONT FENDER) TRANS CTRL TRANS.) TRANSMISSION CTRL OUT TRANSMISSION CTRL OUT L/R PRESSURE SW SNS TRANSMISSION CTRL TRANSMISSION CTRL OUT UD PRESSURE SW SNS OD PRESSURE SW SNS UD SOLENOID CTRL VARIABLE CAMSHAFT TIMING SOLENOID VCT CTRL VIO WIRE VIO/BRN WIRE VIO/ORG WIRE VIO/WHT WIRE VIO/YEL WIRE WHT/BRN WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE YEL/BRN WIRE YEL/DK BLU WIRE YEL/DK GRN WIRE YEL/GRY WIRE YEL/LT BLU WIRE YEL/LT GRN WIRE YEL/ORG WIRE YEL/WHT WIRE

5 VOLT SPLY SENS GND SOL CTRL APPS 1 SIG APPS 2 SIG BRAKE SIG 2 BRAKE SIG 1 B(+) BATTERY TEMPERATURE SENSOR (UNDER BATTERY TRAY) BLK WIRE BRN WIRE BRN/LT BLU WIRE BRN/ORG WIRE BRN/VIO WIRE BRN/WHT WIRE BRN/YEL WIRE CAN B BUS (+) COIL SIG COMPUTER DATA LINES SYSTEM CRUISE CONTROL SYSTEM CTRL A/C CLUTCH DK BLU/DK GRN WIRE DK BLU/VIO WIRE DK GRN WIRE DK GRN/BRN WIRE DK GRN/ORG WIRE DK GRN/TAN WIRE DK GRN/VIO WIRE DK GRN/WHT WIRE ELECTRONICS ENGINE CONTROL MODULE (LOWER LEFT FRONT OF ENGINE BLOCK) FP CTRL FUEL HTR CTRL OUT FUEL PMP CTRL OUT FUSE 28 FUSE 42 FUSE 6 FUSED B (+) FUSED B (+) GND FUSED B(+) A/C CLUTCH CTRL HOT AT ALL TIMES HOT IN RUN OR START TOTALLY INTEGRATED POWER MODULE (LEFT FRONT FENDER) LT BLU/ORG WIRE ORG/ WIRE ORG/RED WIRE PNK/GRY WIRE PNK/YEL WIRE PWM FAN SIG OSS SIG SENS GND S/C SW 1 SIG BATT TEMP SIG APPS 2 RET GND GND RADIATOR FAN DRIVE (FRONT OF ENGINE COMPT) RED WIRE RED/ORG WIRE RUN/START SENS GND SENS SIG SNS SOL CTRL 3-4 SOL CTRL STARTING/ CHARGING SYSTEM TEMP SENS SIG FUSED B(+) TRANS CTRL TRANS CTRL INTAKE RLY CTRL F/P CTRL TRANS CTRL OUT TRANSMISSION RANGE SENSOR (LEFT SIDE OF TRANSMISSION) TTVA POS SENS VIO WIRE VIO/BRN WIRE VIO/YEL WIRE WHT WIRE WHT/BRN WIRE WHT/ORG WIRE YEL/BRN WIRE YEL/DK BLU WIRE YEL/LT BLU WIRE YEL/ORG WIRE YEL/PNK WIRE

DK BLU/DK GRN WIRE DK GRN WIRE DK GRN/BRN WIRE DK GRN/ORG WIRE DK GRN/TAN WIRE DK GRN/VIO WIRE OUTPUT SPEED SENSOR (BOTTOM OF TRANSMISSION) TRANSMISSION SOLENOID ASSEMBLY (LEFT SIDE OF TRANSMISSION) YEL/BRN WIRE YEL/LT BLU WIRE YEL/ORG WIRE YEL/PNK WIRE