Dodge Cab & Chassis R3500 HD (2008-2009) wht/brn Wiring diagrams

17 18 CAN B BUS(+) CAN B BUS(-) 32 34 33 SPEED SENS SIG SENS GND SPEED SENS SIG 34 35 CAN C BUS (+) CAN C BUS (-) ACCEL APPS 1 SIG APPS 1 RTN APPS 2 RTN APPS 2 SIG BLK WIRE BRN WIRE BRN/DK BLU WIRE BRN/DK GRN WIRE BRN/ORG WIRE BRN/VIO WIRE BRN/WHT WIRE BRN/YEL WIRE CLUSTER COLUMN) COMPUTER DATA LINES SYSTEM COMPUTER DATA LINES SYSTEM (RIGHT REAR OF ENGINE COMPT) DECEL DK BLU WIRE DK BLU/DK GRN WIRE DK GRN WIRE DK GRN/BRN WIRE DK GRN/ORG WIRE DK GRN/VIO WIRE DK GRN/WHT WIRE FUSE 26 GRN WIRE GRY WIRE HOT AT ALL TIMES TOTALLY INTEGRATED POWER MODULE (LEFT FRONT FENDER) FUSE 28 INPUT SPEED SENSOR (LEFT SIDE OF TRANSMISSION) LEFT SPEED CONTROL SWITCH OFF ORG/ WIRE PNK WIRE PNK/YEL WIRE POWERTRAIN CONTROL MODULE (RIGHT REAR OF ENGINE COMPT) RED WIRE RESUME RIGHT SPEED CONTROL SWITCH STEERING CONTROL MODULE (ON STEERING STOP LAMP SWITCH (ON TAN WIRE TAN/ORG WIRE TAN/YEL WIRE THROTTLE BODY (ON TOP OF ENGINE) TP 1 SIG TP SENSOR TP 2 SIG ETC MOTOR(+) ETC MOTOR(-) VIO WIRE VIO/BRN WIRE VIO/ORG WIRE VIO/YEL WIRE WHT WIRE WHT/BRN WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE WHT/ORG WIRE YEL WIRE YEL/PNK WIRE

17 18 CAN B BUS(+) CAN B BUS(-) 33 42 28 27 APPS 1 RTN 36 37 6 25 SPEED CTRL BRAKE SW 4 5 1 21 CAN C BUS (+) CAN C BUS (-) 44 45 33 35 48 3 SPD SENS SIG SENS GND 6.7L 5.9L ACCEL ACCELERATOR PEDAL POSITION SENSOR (LEFT SIDE OF DASH) APPS 1 SIG APPS 1 RTN APPS 2 RTN APPS 2 SIG APPS 2 SIG APPS 2 RTN APPS 1 SIG BLK WIRE BLU WIRE BRN WIRE BRN/VIO WIRE BRN/WHT WIRE BRN/YEL WIRE CAN C BUS (+) CLUSTER COMPUTER DATA LINES SYSTEM DECEL DK BLU WIRE DK BLU/DK GRN WIRE DK GRN WIRE DK GRN/BRN WIRE DK GRN/ORG WIRE DK GRN/VIO WIRE DK GRN/WHT WIRE ENGINE CONTROL MODULE (LOWER LEFT FRONT OF ENGINE BLOCK) FUSE 28 GRN WIRE GRY WIRE HOT AT ALL TIMES HOT AT ALL TIMES TOTALLY INTEGRATED POWER MODULE (LEFT FRONT FENDER) FUSE 26 INPUT SPEED SENSOR (LEFT SIDE OF TRANSMISSION) LEFT SPEED CONTROL SWITCH OFF ORG/ WIRE OUTPUT SPEED SENSOR (5.9L) (BOTTOM OF TRANSMISSION) OUTPUT SPEED SENSOR (LEFT REAR OF TRANSMISSION) PNK EXTERIOR LIGHTS SYSTEM WIRE PNK WIRE REAR OF ENGINE COMPT) RED WIRE RESUME RIGHT SPEED CONTROL SWITCH SENS GND SENS GND S/C SW RTN S/C SW 1 SIG S/C SW 2 SIG 33 40 56 46 56 SENS SIG STEERING CONTROL MODULE (ON STEERING COLUMN) STOP LAMP SWITCH (ON BRAKE PEDAL SUPPORT) TAN WIRE TRANSMISSION CONTROL MODULE VIO WIRE VIO/BRN WIRE VIO/ORG WIRE VIO/YEL WIRE WHT WIRE WHT/BRN WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE WHT/ORG WIRE YEL WIRE YEL/DK BLU WIRE

17 18 CAN B BUS(+) CAN B BUS(-) 33 42 28 27 APPS 1 RTN 36 37 6 25 SPEED CTRL BRAKE SW 4 5 1 21 CAN C BUS (+) CAN C BUS (-) 44 45 33 35 48 3 SPD SENS SIG SENS GND 6.7L 5.9L ACCEL ACCELERATOR PEDAL POSITION SENSOR (LEFT SIDE OF DASH) APPS 1 SIG APPS 1 RTN APPS 2 RTN APPS 2 SIG APPS 2 SIG APPS 2 RTN APPS 1 SIG BLK WIRE BLU WIRE BRN WIRE BRN/VIO WIRE BRN/WHT WIRE BRN/YEL WIRE CAN C BUS (+) CLUSTER COMPUTER DATA LINES SYSTEM DECEL DK BLU WIRE DK BLU/DK GRN WIRE DK GRN WIRE DK GRN/BRN WIRE DK GRN/ORG WIRE DK GRN/VIO WIRE DK GRN/WHT WIRE ENGINE CONTROL MODULE (LOWER LEFT FRONT OF ENGINE BLOCK) FUSE 28 GRN WIRE GRY WIRE HOT AT ALL TIMES HOT AT ALL TIMES TOTALLY INTEGRATED POWER MODULE (LEFT FRONT FENDER) FUSE 26 INPUT SPEED SENSOR (LEFT SIDE OF TRANSMISSION) LEFT SPEED CONTROL SWITCH OFF ORG/ WIRE OUTPUT SPEED SENSOR (5.9L) (BOTTOM OF TRANSMISSION) OUTPUT SPEED SENSOR (LEFT REAR OF TRANSMISSION) PNK EXTERIOR LIGHTS SYSTEM WIRE PNK WIRE REAR OF ENGINE COMPT) RED WIRE RESUME RIGHT SPEED CONTROL SWITCH SENS GND SENS GND S/C SW RTN S/C SW 1 SIG S/C SW 2 SIG 33 40 56 46 56 SENS SIG STEERING CONTROL MODULE (ON STEERING COLUMN) STOP LAMP SWITCH (ON BRAKE PEDAL SUPPORT) TAN WIRE TRANSMISSION CONTROL MODULE VIO WIRE VIO/BRN WIRE VIO/ORG WIRE VIO/YEL WIRE WHT WIRE WHT/BRN WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE WHT/ORG WIRE YEL WIRE YEL/DK BLU WIRE

12 13 A/C PRESSURE SIGNAL A/C PRESSURE GROUND IGN SW OUT (START) AAT SIGNAL AAT RETURN AIR CONDITIONING SYSTEM AIR CONDITIONING SYSTEM EXTERIOR LIGHTS SYSTEM AMBIENT AIR TEMPERATURE SENSOR (LEFT FRONT OF ENGINE COMPT) BATTERY BLK/LT BLU WIRE CAN C BUS(+) DIAGNOSTIC CAN C (+) CAN B BUS(+) LEFT REAR TURN LAMP DRV 2 3 CAN C BUS(-) DIAGNOSTIC CAN C (-) CAN B BUS(-) COMPUTER DATA LINES SYSTEM DIESEL ENGINE CONTROLS SYSTEM EXCEPT REMOTE FUSED IGN SW OUTPUT (RUN) GAS GRY/RED WIRE HEADLIGHTS SYSTEM HOOD AJAR SWITCH LT BLU/BRN WIRE LT BLU/ORG WIRE LT BLU/RED WIRE LT BLU/WHT WIRE ORG/RED WIRE PNK/ORG WIRE PNK/VIO WIRE RED WIRE RED/VIO WIRE REMOTE + RIGHT LOW BEAM DRV LEFT HIGH BEAM DRV RIGHT REAR TURN LAMP DRV BRAKE LAMP SW OUTPUT SUPPLEMENTAL RESTRAINTS SYSTEM TAN WIRE TOTALLY INTEGRATED POWER MODULE (LEFT FRONT FENDER) TRANSMISSIONS SYSTEM TRANSMISSIONS SYSTEM AIR CONDITIONING SYSTEM POWER DISTRIBUTION SYSTEM VIO WIRE VIO/LT GRN WIRE VIO/TAN WIRE WHT WIRE WHT/BRN WIRE WHT/DK BLU WIRE WHT/DK GRN WIRE WHT/GRY WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE WHT/ORG WIRE WHT/TAN WIRE WHT/YEL WIRE YEL WIRE

10 11 CAN B BUS (+) CAN B BUS (-) 11 12 CAN B BUS (-) CAN B BUS (+) 14 4 CAN B BUS (+) CAN B BUS (-) 16 15 CAN B BUS (+) CAN B BUS (-) 17 18 CAN B BUS(+) CAN B BUS(-) 2 3 3 18 CAN C BUS (+) CAN C BUS (-) 20 21 CAN C BUS (+) CAN C BUS (-) 3 4 CAN B BUS (+) CAN B BUS (-) 34 35 CAN C BUS (+) CAN C BUS (-) 4 3 CAN B BUS (-) CAN B BUS (+) 4 5 1 21 CAN C BUS (+) CAN C BUS (-) 5 4 CAN B BUS (-) CAN B BUS (+) 5 6 CAN B BUS (+) CAN B BUS (-) 6 17 CAN B BUS (+) CAN B BUS (-) 6 7 2 CAN B BUS (+) CAN B BUS (-) COM-LIN TIRE 6.7L DIESEL 5.9L DIESEL A/C HEATER CONTROL ANTI-LOCK BRAKES MODULE (LEFT REAR OF AWAL RWAL B(+) BLK/LT GRN WIRE BLK/WHT WIRE CAN B BUS (+) CAN C (-) DIAGNOSTIC CAN C BUS (+) CAN C BUS (+) CAN C BUS (-) CLUSTER COM-LIN TIRE PRESS MONI LAN DIESEL ELECTRONIC OVERHEAD MODULE (EXCEPT BASE) ELECTRONICS ENGINE COMPT) ENGINE CONTROL MODULE (LOWER LEFT FRONT OF ENGINE BLOCK) FINAL DRIVE CONTROL MODULE (POWER WAGON) (RIGHT FRONT OF ENGINE COMPT) FUSE 11 GAS GRY/RED WIRE HANDS FREE MODULE (RIGHT SIDE OF DASH) HOT AT ALL TIMES LEFT FRONT TIRE PRESSURE TRANSPONDER MONITOR/DVD MEDIA SYSTEM OCCUPANT RESTRAINT CONTROLLER MODULE (CENTER FRONT OF BODY) POWER MODULE (LEFT FRONT FENDER) POWERTRAIN CONTROL MODULE (RIGHT REAR OF RADIO RADIO AMPLIFIER (PREMIUM) (RIGHT SIDE OF DASH) RIGHT FRONT TIRE PRESSURE TRANSPONDER (RIGHT SIDE OF ENGINE COMPT) SATELLITE RECEIVER (PREMIUM) SUNROOF MOTOR/MODULE (DVD) (SUNROOF MOTOR: CENTER OF HEADLINER) TOTALLY INTEGRATED TRANSMISSION CONTROL MODULE (RC) WHT WIRE WHT/BRN WIRE WHT/GRY WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE WHT/ORG WIRE WIRELESS CONTROL MODULE

5 VOLT SPLY MDS SOL CTRL 4 FUSED B(+) IGN START B(+) BLK WIRE BLK/BRN WIRE BLK/DK GRN WIRE BLK/YEL WIRE BRN WIRE BRN/DK BLU WIRE BRN/DK GRN WIRE BRN/GRY WIRE BRN/LT BLU WIRE BRN/LT GRN WIRE BRN/ORG WIRE BRN/TAN WIRE BRN/VIO WIRE BRN/WHT WIRE BRN/YEL WIRE CAN C BUS (+) CAN C BUS (-) CMP SIG CKP SIG KNOCK SENS 2 SIG KNOCK SENS 2 RETURN ETC MOTOR (-) COIL CTRL 7 INJECTOR CTRL 8 INJECTOR CTRL 7 COMPUTER DATA LINES SYSTEM CTRL SIG DK BLU WIRE DK BLU/DK GRN WIRE DK BLU/GRY WIRE DK BLU/LT BLU WIRE DK BLU/LT GRN WIRE DK BLU/ORG WIRE DK BLU/TAN WIRE DK BLU/YEL WIRE DK GRN WIRE ELECTRONICS FUSE 31 FUSED ASD GEN FIELD CTRL ECT SIG TP 1 SIG GEN SNS GROUND FUSED B(+) IGN SW OUT (RUN-START) IGN SW OUT (OFF-RUN-START) GROUND GROUND OIL PRESSURE SIG SRV SEN OUT HOT AT ALL TIMES IGN (START) KNOCK SENS 1 (-) KNOCK SENS 1 RETURN KNOCK SENS 2 (-) KNOCK SENS 2 RETURN KNOCK SENSOR 1 KNOCK SENSOR 2 (LOWER RIGHT SIDE OF ENGINE BLOCK) MAP SIG KNOCK SENS 1 RETURN KNOCK SENS 1 SIG PNK/GRY WIRE PNK/WHT WIRE PNK/YEL WIRE POWERTRAIN CONTROL MODULE (RIGHT REAR OF ENGINE COMPT) RED WIRE RED/GRY WIRE RLY OUT RUN-START) IGN (OFF- SCI TRANSMIT (TCM) ASD CTRL OUT SENS GROUND TP 2 SIG 5 VOLT SPLY IAT SIG SHORT RUNNER VALVE SOLENOID SIG SRV ACTR SRV ACTR CTRL SIG SRV SEN OUT STARTING/ CHARGING SYSTEM TAN/ORG WIRE TAN/YEL WIRE THROTTLE BODY (ON TOP OF ENGINE) TOTALLY INTEGRATED POWER MODULE (AT LEFT FRONT FENDER) VIO/BRN WIRE VIO/GRY WIRE VIO/ORG WIRE WHT/BRN WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE YEL WIRE YEL/PNK WIRE

5 VOLT SPLY ACCELERATOR PEDAL POSITION SENSOR (LEFT SIDE OF DASH) APP 1 RTN APP 1 SIG APP 2 RTN APP 2 SIG BRN WIRE BRN/DK BLU WIRE BRN/GRY WIRE BRN/LT BLU WIRE BRN/ORG WIRE BRN/TAN WIRE BRN/VIO WIRE BRN/WHT WIRE BRN/YEL WIRE CAMSHAFT POSITION SENSOR (RIGHT FRONT OF ENGINE) CRANKSHAFT POSITION SENSOR (RIGHT SIDE OF ENGINE) DK BLU/DK GRN WIRE DK BLU/GRY WIRE DK BLU/ORG WIRE DK BLU/TAN WIRE DK BLU/YEL WIRE LINE PRESSURE SENSOR (RIGHT SIDE OF TRANSMISSION) LINE SENS PNK/YEL WIRE SENS GND VIO/BRN WIRE VIO/GRY WIRE VIO/YEL WIRE WHT/BRN WIRE YEL/BRN WIRE YEL/PNK WIRE

BLK WIRE BRN/GRY WIRE BRN/ORG WIRE BRN/VIO WIRE BRN/WHT WIRE BRN/YEL WIRE DK BLU/BRN WIRE DK BLU/DK GRN WIRE DK BLU/WHT WIRE DK GRN WIRE DK GRN/BRN WIRE DK GRN/DK BLU WIRE DK GRN/LT BLU WIRE DK GRN/ORG WIRE DK GRN/PNK WIRE DK GRN/TAN WIRE DK GRN/VIO WIRE DK GRN/WHT WIRE DK GRN/YEL WIRE EXCEPT UPFITTER FS-LR SOL SOL L/R PRESS LP LR/LU SOL VFS SOL SOL SOL MULTI DISPLACEMENT SYSTEM CYLINDER 1 SOLENOID MULTI DISPLACEMENT SYSTEM CYLINDER 7 SOLENOID OD PRESS TRS ODC PNK/YEL WIRE PRESS PRESS PTO SW SNS PTO SWITCH TEMP TRS SENS TRANSMISSION SOLENOID/TRS ASSEMBLY (LEFT SIDE OF TRANSMISSION) TRS TRS TRS UD PRESS UDC UPFITTER UPFITTER ACCESSORIES JUMPER KIT VIO WIRE VIO/BRN WIRE VIO/WHT WIRE VIO/YEL WIRE WHT/BRN WIRE YEL/BRN WIRE YEL/DK BLU WIRE YEL/DK GRN WIRE YEL/GRY WIRE YEL/LT BLU WIRE YEL/LT GRN WIRE YEL/ORG WIRE YEL/WHT WIRE

A/C A/C CLUTCH CTRL ANTI-LOCK BRAKES SYSTEM APP 1 SIG ASD CTRL ASD CTRL OUT EVAP PURGE SOL SIG P/S SW SIG BLK WIRE BLK/LT GRN WIRE BRN WIRE BRN/GRY WIRE BRN/ORG WIRE BRN/VIO WIRE BRN/WHT WIRE BRN/YEL WIRE BUS - CAN C (+) CAN C BUS (+) CLUTCH COMPUTER DATA LINES SYSTEM CRUISE CONTROL SYSTEM CTRL DK BLU WIRE DK BLU/BRN WIRE DK BLU/WHT WIRE DK GRN WIRE DK GRN/BRN WIRE DK GRN/DK BLU WIRE DK GRN/LT BLU WIRE DK GRN/ORG WIRE DK GRN/PNK WIRE DK GRN/TAN WIRE DK GRN/VIO WIRE DK GRN/WHT WIRE DK GRN/YEL WIRE ELECTRONICS EXCEPT RAM 2500 FUEL L/R CTRL PRESSURE CTRL SOLENOID GROUND GROUND GROUND LT BLU/ORG WIRE MDS SOL CTRL 7 MDS SOL CTRL 1 MS SOLENOID CTRL PNK/YEL WIRE POWERTRAIN CONTROL MODULE (RIGHT REAR OF ENGINE COMPT) PTO SNS BRAKE SW 1 SIG PUMP CTRL RAM 2500 SENS STARTING/ CHARGING SYSTEM TOTALLY INTEGRATED POWER MODULE (LEFT FRONT FENDER) TRANS CTRL TRANS.) TRANSMISSION CTRL OUT TRANSMISSION CTRL OUT L/R PRESSURE SW SNS TRANSMISSION CTRL TRANSMISSION CTRL OUT UD PRESSURE SW SNS OD PRESSURE SW SNS UD SOLENOID CTRL VARIABLE CAMSHAFT TIMING SOLENOID VCT CTRL VIO WIRE VIO/BRN WIRE VIO/ORG WIRE VIO/WHT WIRE VIO/YEL WIRE WHT/BRN WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE YEL/BRN WIRE YEL/DK BLU WIRE YEL/DK GRN WIRE YEL/GRY WIRE YEL/LT BLU WIRE YEL/LT GRN WIRE YEL/ORG WIRE YEL/WHT WIRE

5-VOLT APPS 1 RET APPS 1 SIG APPS 2 RET APPS 2 SIG BLK WIRE BLK/GRY WIRE BOOST SENS SIG BRN WIRE BRN/DK BLU WIRE BRN/GRY WIRE BRN/LT BLU WIRE BRN/LT GRN WIRE BRN/ORG WIRE BRN/TAN WIRE BRN/VIO WIRE BRN/WHT WIRE BRN/YEL WIRE CAMSHAFT POSITION SENSOR CAN C BUS (+) CAN C BUS (-) F/P RET GEN FIELD CTRL TTVA MOTOR (+) CKP SENS GND SENS RET CKP SIG COMPUTER DATA LINES SYSTEM CRANKSHAFT POSITION SENSOR DK BLU WIRE DK BLU/BRN WIRE DK BLU/DK GRN WIRE DK BLU/GRY WIRE DK BLU/LT GRN WIRE DK BLU/TAN WIRE DK GRN WIRE DRIVER BANK 1 ENGINE CONTROL MODULE (LOWER LEFT FRONT OF ENGINE BLOCK) ENGINE COOLANT TEMPERATURE SENSOR FUEL CTRL TTVA MOTOR (-) SENS GND CKP SIG SENS GND CMP SIG FUEL INJECTORS FUEL RAIL PRESSURE SENSOR (LEFT SIDE OF ENGINE) FUEL SENS FUEL RAIL SIG INLET SNS GRY WIRE IAT SENS SIG PRESSURE SNS ECT SIG INJ 2 CTRL INJ 3 CTRL SENS GND INJ 4 CTRL INJ 5 CTRL DRIVER BANK 2 INJ 6 CTRL LT BLU WIRE MAP TEMPERATURE/ PRESSURE SENSOR PNK/YEL WIRE RET SENS GND SENS GND INJ 1 CTRL SENS SIG CMP SENS GND APPS 1 SIG SENS SIG SIG STARTING/CHARGING SYSTEM TAN WIRE TAN/ORG WIRE TAN/PNK WIRE TAN/YEL WIRE VIO/BRN WIRE VIO/GRY WIRE VIO/LT GRN WIRE VIO/ORG WIRE VIO/WHT WIRE WHT/BRN WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE