Dodge Cab & Chassis R3500 HD (2008-2009) org/ Wiring diagrams

17 18 CAN B BUS(+) CAN B BUS(-) 32 34 33 SPEED SENS SIG SENS GND SPEED SENS SIG 34 35 CAN C BUS (+) CAN C BUS (-) ACCEL APPS 1 SIG APPS 1 RTN APPS 2 RTN APPS 2 SIG BLK WIRE BRN WIRE BRN/DK BLU WIRE BRN/DK GRN WIRE BRN/ORG WIRE BRN/VIO WIRE BRN/WHT WIRE BRN/YEL WIRE CLUSTER COLUMN) COMPUTER DATA LINES SYSTEM COMPUTER DATA LINES SYSTEM (RIGHT REAR OF ENGINE COMPT) DECEL DK BLU WIRE DK BLU/DK GRN WIRE DK GRN WIRE DK GRN/BRN WIRE DK GRN/ORG WIRE DK GRN/VIO WIRE DK GRN/WHT WIRE FUSE 26 GRN WIRE GRY WIRE HOT AT ALL TIMES TOTALLY INTEGRATED POWER MODULE (LEFT FRONT FENDER) FUSE 28 INPUT SPEED SENSOR (LEFT SIDE OF TRANSMISSION) LEFT SPEED CONTROL SWITCH OFF ORG/ WIRE PNK WIRE PNK/YEL WIRE POWERTRAIN CONTROL MODULE (RIGHT REAR OF ENGINE COMPT) RED WIRE RESUME RIGHT SPEED CONTROL SWITCH STEERING CONTROL MODULE (ON STEERING STOP LAMP SWITCH (ON TAN WIRE TAN/ORG WIRE TAN/YEL WIRE THROTTLE BODY (ON TOP OF ENGINE) TP 1 SIG TP SENSOR TP 2 SIG ETC MOTOR(+) ETC MOTOR(-) VIO WIRE VIO/BRN WIRE VIO/ORG WIRE VIO/YEL WIRE WHT WIRE WHT/BRN WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE WHT/ORG WIRE YEL WIRE YEL/PNK WIRE

17 18 CAN B BUS(+) CAN B BUS(-) 33 42 28 27 APPS 1 RTN 36 37 6 25 SPEED CTRL BRAKE SW 4 5 1 21 CAN C BUS (+) CAN C BUS (-) 44 45 33 35 48 3 SPD SENS SIG SENS GND 6.7L 5.9L ACCEL ACCELERATOR PEDAL POSITION SENSOR (LEFT SIDE OF DASH) APPS 1 SIG APPS 1 RTN APPS 2 RTN APPS 2 SIG APPS 2 SIG APPS 2 RTN APPS 1 SIG BLK WIRE BLU WIRE BRN WIRE BRN/VIO WIRE BRN/WHT WIRE BRN/YEL WIRE CAN C BUS (+) CLUSTER COMPUTER DATA LINES SYSTEM DECEL DK BLU WIRE DK BLU/DK GRN WIRE DK GRN WIRE DK GRN/BRN WIRE DK GRN/ORG WIRE DK GRN/VIO WIRE DK GRN/WHT WIRE ENGINE CONTROL MODULE (LOWER LEFT FRONT OF ENGINE BLOCK) FUSE 28 GRN WIRE GRY WIRE HOT AT ALL TIMES HOT AT ALL TIMES TOTALLY INTEGRATED POWER MODULE (LEFT FRONT FENDER) FUSE 26 INPUT SPEED SENSOR (LEFT SIDE OF TRANSMISSION) LEFT SPEED CONTROL SWITCH OFF ORG/ WIRE OUTPUT SPEED SENSOR (5.9L) (BOTTOM OF TRANSMISSION) OUTPUT SPEED SENSOR (LEFT REAR OF TRANSMISSION) PNK EXTERIOR LIGHTS SYSTEM WIRE PNK WIRE REAR OF ENGINE COMPT) RED WIRE RESUME RIGHT SPEED CONTROL SWITCH SENS GND SENS GND S/C SW RTN S/C SW 1 SIG S/C SW 2 SIG 33 40 56 46 56 SENS SIG STEERING CONTROL MODULE (ON STEERING COLUMN) STOP LAMP SWITCH (ON BRAKE PEDAL SUPPORT) TAN WIRE TRANSMISSION CONTROL MODULE VIO WIRE VIO/BRN WIRE VIO/ORG WIRE VIO/YEL WIRE WHT WIRE WHT/BRN WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE WHT/ORG WIRE YEL WIRE YEL/DK BLU WIRE

17 18 CAN B BUS(+) CAN B BUS(-) 33 42 28 27 APPS 1 RTN 36 37 6 25 SPEED CTRL BRAKE SW 4 5 1 21 CAN C BUS (+) CAN C BUS (-) 44 45 33 35 48 3 SPD SENS SIG SENS GND 6.7L 5.9L ACCEL ACCELERATOR PEDAL POSITION SENSOR (LEFT SIDE OF DASH) APPS 1 SIG APPS 1 RTN APPS 2 RTN APPS 2 SIG APPS 2 SIG APPS 2 RTN APPS 1 SIG BLK WIRE BLU WIRE BRN WIRE BRN/VIO WIRE BRN/WHT WIRE BRN/YEL WIRE CAN C BUS (+) CLUSTER COMPUTER DATA LINES SYSTEM DECEL DK BLU WIRE DK BLU/DK GRN WIRE DK GRN WIRE DK GRN/BRN WIRE DK GRN/ORG WIRE DK GRN/VIO WIRE DK GRN/WHT WIRE ENGINE CONTROL MODULE (LOWER LEFT FRONT OF ENGINE BLOCK) FUSE 28 GRN WIRE GRY WIRE HOT AT ALL TIMES HOT AT ALL TIMES TOTALLY INTEGRATED POWER MODULE (LEFT FRONT FENDER) FUSE 26 INPUT SPEED SENSOR (LEFT SIDE OF TRANSMISSION) LEFT SPEED CONTROL SWITCH OFF ORG/ WIRE OUTPUT SPEED SENSOR (5.9L) (BOTTOM OF TRANSMISSION) OUTPUT SPEED SENSOR (LEFT REAR OF TRANSMISSION) PNK EXTERIOR LIGHTS SYSTEM WIRE PNK WIRE REAR OF ENGINE COMPT) RED WIRE RESUME RIGHT SPEED CONTROL SWITCH SENS GND SENS GND S/C SW RTN S/C SW 1 SIG S/C SW 2 SIG 33 40 56 46 56 SENS SIG STEERING CONTROL MODULE (ON STEERING COLUMN) STOP LAMP SWITCH (ON BRAKE PEDAL SUPPORT) TAN WIRE TRANSMISSION CONTROL MODULE VIO WIRE VIO/BRN WIRE VIO/ORG WIRE VIO/YEL WIRE WHT WIRE WHT/BRN WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE WHT/ORG WIRE YEL WIRE YEL/DK BLU WIRE

1 2 3 4 GROUND PANEL LAMPS DRIVER ESP ON/OFF SENSE SENSOR GROUND 1 2 3 6 IGN SW OUT (RUN-START) DYNAMICS HIGH DATA DYNAMICS LOW DATA GROUND 17 18 10 CAN B BUS (+) CAN B BUS (-) SENSOR GROUND 35 34 CAN C BUS (-) CAN C BUS (+) 43 44 45 46 RH RR WHEEL SPD SENS (+) RH RR WHEEL SPD SENS (-) GROUND 5.9L 6.7L ANTI-LOCK BRAKES MODULE (LEFT REAR OF ENGINE COMPT) B(+) BLK WIRE BLK/DK GRN WIRE BLK/LT GRN WIRE BLK/ORG WIRE BLK/PNK WIRE BRAKE FLUID LEVEL SENSOR (LEFT REAR OF ENGINE COMPT) BRAKE SWITCH 1 SIGNAL BRAKE SWITCH 1 SIGNAL CAN C BUS (+) BRK FLUID LEVEL SW SENSE CAN B CAN B BUS (+) BUS (-) CAN C BUS (+) CAN C CAN C BUS (+) BUS (-) CLUSTER COMPUTER DATA LINES SYSTEM DIESEL DK DK DK GRN WIRE DK GRN/BRN WIRE DK GRN/LT BLU WIRE DK GRN/LT GRN WIRE DK GRN/ORG WIRE DK GRN/RED WIRE DK GRN/TAN WIRE DK GRN/VIO WIRE DK GRN/WHT WIRE DK GRN/YEL WIRE DYNAMICS SENS HIGH DATA DYNAMICS SENS LOW DATA DYNAMICS SENSOR (W/ ESP) (UNDER FRONT OF CENTER CONSOLE) ELECTRONICS ENGINE CONTROL MODULE (LOWER LEFT FRONT OF ENGINE BLOCK) ESP ON/OFF SENSE ESP SWITCH (IF EQUIPPED) FUSE 13 FUSE 18 FUSE 28 FUSE 30 FUSED B (+) CAN C BUS + FUSED B (+) IGN SW OUT (RUN-START) FUSED IGN SW OUT (RUN-START) GAS GRN WIRE GRN/GRY WIRE GROUND GRY WIRE HOT AT ALL TIMES HOT IN RUN OR START IGN SW OUT (RUN-START) CAN C BUS (+) CAN C BUS (-) GROUND LEFT FRONT ABS WHEEL SPEED SENSOR (LEFT REAR OF ENGINE COMPT) LEFT REAR ABS WHEEL SPEED SENSOR LF WHEEL SPD SENSOR (+) LF WHEEL SPD SENSOR (-) LT BLU WIRE LT GRN WIRE ORG/ WIRE ORG/DK BLU WIRE PANEL LAMPS DRIVER PNK WIRE PNK/ (EXCEPT ESP/5.7L POWER WAGON, 6.7L EXCEPT SHIFT ON THE FLY) WIRE PNK/GRY WIRE PNK/LT GRN WIRE POWERTRAIN CONTROL MODULE (RIGHT REAR OF ENGINE COMPT) REAR ABS WHEEL SPEED SENSOR (W/O ESP) (NEAR RIGHT REAR FRAME RAIL) RED WIRE RF WHEEL SPD SENSOR (+) RF WHEEL SPD SENSOR (-) RIGHT FRONT ABS WHEEL SPEED SENSOR (ON KNUCKLE SPINDLE ASSEMBLY) RIGHT REAR ABS WHEEL SPEED SENSOR (W/ ESP) (AT RIGHT REAR WHEEL ASSEMBLY) STEERING ANGLE SENSOR (W/ ESP) STOP LAMP SWITCH (ON BRAKE PEDAL SUPPORT) TAN WIRE TAN/RED WIRE TOTALLY INTEGRATED POWER MODULE (AT LEFT FRONT FENDER) TRAILER TOW DAMPING RLY CTRL VIO WIRE VIO/DK BLU WIRE W/ ESP W/O ESP WHT WIRE WHT/GRY WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE WHT/ORG WIRE YEL WIRE

BLK WIRE BLK/LT GRN WIRE BLK/PNK WIRE CAN C BUS (+) CAN C CAN C BUS (+) BUS (-) COMPUTER DATA LINES SYSTEM DYN SENS HIGH LNK DYN SENS LOW LNK DYNAMICS SENSOR (W/ ESP) (UNDER FRONT OF CENTER CONSOLE) ELECTRONICS B(+) FUSE 28 FUSE 30 FUSED IGN SW OUT (RUN-START) GRY WIRE GRY/ PNK WIRE HIGH LNK DYN SENS HOT AT ALL TIMES HOT IN ON OR START IGN SW OUT (RUN-START) LOW LNK DYN SENS LT BLU/ WHT WIRE LT GRN PNK/ WIRE LT GRN WHT/ WIRE ORG/ WIRE PNK/ LT GRN WIRE PNK/GRY WIRE PNK/LT GRN WIRE STEERING ANGLE SENSOR (W/ ESP) (ON STEERING COLUMN) TOTALLY INTEGRATED POWER MODULE (AT LEFT FRONT FENDER) WHT LT GRN/ WIRE WHT WIRE WHT/GRY WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE WHT/ORG WIRE

15 16 CAN B BUS (-) CAN B BUS (+) A/C HEATER CONTROL B(+) BLK WIRE CAN B CAN B BUS (+) BUS (-) COMPUTER DATA LINES SYSTEM DK BLU/GRY WIRE DRIVER OUTSIDE REARVIEW MIRROR (DRIVER'S DOOR) ELECTRONICS EXCEPT BASE FUSE 8 HOT AT ALL TIMES ORG/ WIRE PASSENGER (LEFT KICK OUTSIDE PANEL) REARVIEW MIRROR (FRONT PASSENGER'S DOOR) REAR WINDOW DEFOG SWITCH REAR WINDOW DEFOGGER CTRL OUT TOTALLY INTEGRATED POWER MODULE (LEFT FRONT FENDER) WHT WIRE WHT/ORG WIRE

1 2 SENS GND SENS SIG A/C CLUTCH CTRL A/C CLUTCH CTRL OUTPUT A/C HEATER CONTROL A/C INDICATOR A/C PRES 5 VOLT SPLY A/C PRES GND A/C PRES SIG A/C SELECT B(+) BLEND DOOR DRIVER BLK WIRE BLK/LT BLU WIRE BLK/LT GRN WIRE BLK/ORG WIRE BLOWER MOTOR RESISTOR (RIGHT SIDE OF DASH) BLU WIRE BRN WIRE CLUSTER COMMON DOOR DRIVER COMPUTER DATA LINES SYSTEM CONDENSER FAN CTRL OUTPUT DK BLU WIRE DK BLU/BRN WIRE DK BLU/DK GRN WIRE DK BLU/LT BLU WIRE DK BLU/LT GRN WIRE DK BLU/ORG WIRE DK BLU/TAN WIRE DK BLU/VIO WIRE DK BLU/YEL WIRE DK DK DRIVER BLEND DOOR ACTUATOR (ON HVAC UNIT) ELECTRONICS EVAPORATOR TEMPERATURE SENSOR (RIGHT SIDE OF HVAC) EXCEPT BASE FENDER) FUSE 23 FUSE 33 FUSED IGN SW OUT (RUN) FUSED IGN SW OUT (RUN-START) HEATER MIRROR INDICATOR HOT AT ALL TIMES HVAC MICRO CONTROLLER LT BLU WIRE LT BLU/BRN WIRE LT BLU/ORG WIRE LT BLU/WHT WIRE LT GRN WIRE MODE DOOR ACTUATOR 1 (PANEL TO FLOOR) (ON HVAC UNIT) MODE DOOR ACTUATOR 2 (DEFROST TO FLOOR) (ON HVAC UNIT) OFF OFF HEATED MIRROR ORG/ WIRE ORG/GRY WIRE PANEL LAMPS DRIVER PASS BLEND DOOR DRIVER PASSENGER BLEND DOOR ACTUATOR (EXCEPT BASE) (ON HVAC UNIT) PNK WIRE PNK/LT BLU WIRE PNK/LT GRN WIRE RECIRC RECIRCULATION DOOR ACTUATOR (ON HVAC UNIT) RECIRCULATION DOOR DRIVER RECIRCULATION INDICATOR RED WIRE TAN WIRE TOTALLY INTEGRATED POWER MODULE (LEFT FRONT WHT WIRE WHT/ORG WIRE YEL WIRE

34 35 CAN C BUS (+) CAN C BUS (-) 5 4 CAN C BUS (-) CAN C BUS (+) 6.7L 5.9L A/C CLUTCH CTRL A/C COMPRESSOR CLUTCH (FRONT OF A/C COMPRESSOR) A/C PRES 5 VOLT SPLY A/C PRES GND BLK WIRE BLK/GRY WIRE BLK/LT BLU WIRE BLK/WHT WIRE BLU WIRE BRN WIRE BRN/WHT WIRE BRN/YEL WIRE COMPUTER DATA LINES SYSTEM CONDENSER FAN MOTOR (GAS) (LEFT FRONT OF ENGINE COMPT) DIESEL DK BLU WIRE DK BLU/DK GRN WIRE DK BLU/YEL WIRE DK GRN WIRE ECT SIG ENGINE BLOCK) ENGINE CONTROL MODULE (LOWER LEFT FRONT OF ENGINE CONTROLS SYSTEM ENGINE COOLANT TEMPERATURE GAS LT BLU WIRE LT BLU/BRN WIRE LT BLU/ORG WIRE LT BLU/WHT WIRE ORG/ WIRE POWERTRAIN CONTROL MODULE (RIGHT REAR OF ENGINE COMPT) SENS GND SENSOR (5.7L: FRONT OF ENGINE) (6.7L: TOP FRONT OF ENGINE) VIO WIRE VIO/ORG WIRE WHT WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE YEL WIRE

A/C HEATER CONTROL B(+) BLK WIRE CAN B BUS (+) CAN B BUS (-) CAN B BUS (+) COMPUTER DATA LINES SYSTEM DK BLU WIRE DK BLU/WHT WIRE ELECTRIC HEATED BACKLITE ELECTRONICS REAR WINDOW DEFOGGER CTRL OUT EXCEPT BASE HOT AT ALL TIMES NCA WIRE ORG/ WIRE REAR WINDOW DEFOG SWITCH TOTALLY INTEGRATED POWER MODULE (LEFT FRONT FENDER) WHT WIRE WHT/ORG WIRE

5.9L 6.7L B(+) CAN C BUS (+) BLK WIRE BLK/DK GRN WIRE BLK/ORG WIRE BRAKE SWITCH 1 SIGNAL BRAKE SWITCH 1 SIGNAL 34 35 C BUS (+) C BUS (-) BRK FLUID LEVEL SW SENSE CAN C BUS (+) COMPUTER DATA LINES SYSTEM DIESEL DK DK DK GRN WIRE DK GRN/LT GRN WIRE DK GRN/ORG WIRE DK GRN/RED WIRE DK GRN/TAN WIRE DK GRN/WHT WIRE DK GRN/YEL WIRE ELECTRONICS FUSED IGN SW OUT (RUN-START) ENGINE CONTROL MODULE FUSE 13 FUSE 30 GAS GRN WIRE HOT AT ALL TIMES LF WHEEL SPD SENSOR (-) LT BLU WIRE LT GRN WIRE ORG/ WIRE PNK WIRE PNK/LT GRN WIRE RED WIRE TAN WIRE TOTALLY INTEGRATED POWER MODULE (AT LEFT FRONT FENDER) WHT WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE YEL WIRE