Dodge Cab & Chassis R3500 HD (2008-2009) blk Wiring diagrams

17 18 CAN B BUS(+) CAN B BUS(-) 32 34 33 SPEED SENS SIG SENS GND SPEED SENS SIG 34 35 CAN C BUS (+) CAN C BUS (-) ACCEL APPS 1 SIG APPS 1 RTN APPS 2 RTN APPS 2 SIG BLK WIRE BRN WIRE BRN/DK BLU WIRE BRN/DK GRN WIRE BRN/ORG WIRE BRN/VIO WIRE BRN/WHT WIRE BRN/YEL WIRE CLUSTER COLUMN) COMPUTER DATA LINES SYSTEM COMPUTER DATA LINES SYSTEM (RIGHT REAR OF ENGINE COMPT) DECEL DK BLU WIRE DK BLU/DK GRN WIRE DK GRN WIRE DK GRN/BRN WIRE DK GRN/ORG WIRE DK GRN/VIO WIRE DK GRN/WHT WIRE FUSE 26 GRN WIRE GRY WIRE HOT AT ALL TIMES TOTALLY INTEGRATED POWER MODULE (LEFT FRONT FENDER) FUSE 28 INPUT SPEED SENSOR (LEFT SIDE OF TRANSMISSION) LEFT SPEED CONTROL SWITCH OFF ORG/ WIRE PNK WIRE PNK/YEL WIRE POWERTRAIN CONTROL MODULE (RIGHT REAR OF ENGINE COMPT) RED WIRE RESUME RIGHT SPEED CONTROL SWITCH STEERING CONTROL MODULE (ON STEERING STOP LAMP SWITCH (ON TAN WIRE TAN/ORG WIRE TAN/YEL WIRE THROTTLE BODY (ON TOP OF ENGINE) TP 1 SIG TP SENSOR TP 2 SIG ETC MOTOR(+) ETC MOTOR(-) VIO WIRE VIO/BRN WIRE VIO/ORG WIRE VIO/YEL WIRE WHT WIRE WHT/BRN WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE WHT/ORG WIRE YEL WIRE YEL/PNK WIRE

17 18 CAN B BUS(+) CAN B BUS(-) 33 42 28 27 APPS 1 RTN 36 37 6 25 SPEED CTRL BRAKE SW 4 5 1 21 CAN C BUS (+) CAN C BUS (-) 44 45 33 35 48 3 SPD SENS SIG SENS GND 6.7L 5.9L ACCEL ACCELERATOR PEDAL POSITION SENSOR (LEFT SIDE OF DASH) APPS 1 SIG APPS 1 RTN APPS 2 RTN APPS 2 SIG APPS 2 SIG APPS 2 RTN APPS 1 SIG BLK WIRE BLU WIRE BRN WIRE BRN/VIO WIRE BRN/WHT WIRE BRN/YEL WIRE CAN C BUS (+) CLUSTER COMPUTER DATA LINES SYSTEM DECEL DK BLU WIRE DK BLU/DK GRN WIRE DK GRN WIRE DK GRN/BRN WIRE DK GRN/ORG WIRE DK GRN/VIO WIRE DK GRN/WHT WIRE ENGINE CONTROL MODULE (LOWER LEFT FRONT OF ENGINE BLOCK) FUSE 28 GRN WIRE GRY WIRE HOT AT ALL TIMES HOT AT ALL TIMES TOTALLY INTEGRATED POWER MODULE (LEFT FRONT FENDER) FUSE 26 INPUT SPEED SENSOR (LEFT SIDE OF TRANSMISSION) LEFT SPEED CONTROL SWITCH OFF ORG/ WIRE OUTPUT SPEED SENSOR (5.9L) (BOTTOM OF TRANSMISSION) OUTPUT SPEED SENSOR (LEFT REAR OF TRANSMISSION) PNK EXTERIOR LIGHTS SYSTEM WIRE PNK WIRE REAR OF ENGINE COMPT) RED WIRE RESUME RIGHT SPEED CONTROL SWITCH SENS GND SENS GND S/C SW RTN S/C SW 1 SIG S/C SW 2 SIG 33 40 56 46 56 SENS SIG STEERING CONTROL MODULE (ON STEERING COLUMN) STOP LAMP SWITCH (ON BRAKE PEDAL SUPPORT) TAN WIRE TRANSMISSION CONTROL MODULE VIO WIRE VIO/BRN WIRE VIO/ORG WIRE VIO/YEL WIRE WHT WIRE WHT/BRN WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE WHT/ORG WIRE YEL WIRE YEL/DK BLU WIRE

17 18 CAN B BUS(+) CAN B BUS(-) 33 42 28 27 APPS 1 RTN 36 37 6 25 SPEED CTRL BRAKE SW 4 5 1 21 CAN C BUS (+) CAN C BUS (-) 44 45 33 35 48 3 SPD SENS SIG SENS GND 6.7L 5.9L ACCEL ACCELERATOR PEDAL POSITION SENSOR (LEFT SIDE OF DASH) APPS 1 SIG APPS 1 RTN APPS 2 RTN APPS 2 SIG APPS 2 SIG APPS 2 RTN APPS 1 SIG BLK WIRE BLU WIRE BRN WIRE BRN/VIO WIRE BRN/WHT WIRE BRN/YEL WIRE CAN C BUS (+) CLUSTER COMPUTER DATA LINES SYSTEM DECEL DK BLU WIRE DK BLU/DK GRN WIRE DK GRN WIRE DK GRN/BRN WIRE DK GRN/ORG WIRE DK GRN/VIO WIRE DK GRN/WHT WIRE ENGINE CONTROL MODULE (LOWER LEFT FRONT OF ENGINE BLOCK) FUSE 28 GRN WIRE GRY WIRE HOT AT ALL TIMES HOT AT ALL TIMES TOTALLY INTEGRATED POWER MODULE (LEFT FRONT FENDER) FUSE 26 INPUT SPEED SENSOR (LEFT SIDE OF TRANSMISSION) LEFT SPEED CONTROL SWITCH OFF ORG/ WIRE OUTPUT SPEED SENSOR (5.9L) (BOTTOM OF TRANSMISSION) OUTPUT SPEED SENSOR (LEFT REAR OF TRANSMISSION) PNK EXTERIOR LIGHTS SYSTEM WIRE PNK WIRE REAR OF ENGINE COMPT) RED WIRE RESUME RIGHT SPEED CONTROL SWITCH SENS GND SENS GND S/C SW RTN S/C SW 1 SIG S/C SW 2 SIG 33 40 56 46 56 SENS SIG STEERING CONTROL MODULE (ON STEERING COLUMN) STOP LAMP SWITCH (ON BRAKE PEDAL SUPPORT) TAN WIRE TRANSMISSION CONTROL MODULE VIO WIRE VIO/BRN WIRE VIO/ORG WIRE VIO/YEL WIRE WHT WIRE WHT/BRN WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE WHT/ORG WIRE YEL WIRE YEL/DK BLU WIRE

1 2 3 4 GROUND PANEL LAMPS DRIVER ESP ON/OFF SENSE SENSOR GROUND 1 2 3 6 IGN SW OUT (RUN-START) DYNAMICS HIGH DATA DYNAMICS LOW DATA GROUND 17 18 10 CAN B BUS (+) CAN B BUS (-) SENSOR GROUND 35 34 CAN C BUS (-) CAN C BUS (+) 43 44 45 46 RH RR WHEEL SPD SENS (+) RH RR WHEEL SPD SENS (-) GROUND 5.9L 6.7L ANTI-LOCK BRAKES MODULE (LEFT REAR OF ENGINE COMPT) B(+) BLK WIRE BLK/DK GRN WIRE BLK/LT GRN WIRE BLK/ORG WIRE BLK/PNK WIRE BRAKE FLUID LEVEL SENSOR (LEFT REAR OF ENGINE COMPT) BRAKE SWITCH 1 SIGNAL BRAKE SWITCH 1 SIGNAL CAN C BUS (+) BRK FLUID LEVEL SW SENSE CAN B CAN B BUS (+) BUS (-) CAN C BUS (+) CAN C CAN C BUS (+) BUS (-) CLUSTER COMPUTER DATA LINES SYSTEM DIESEL DK DK DK GRN WIRE DK GRN/BRN WIRE DK GRN/LT BLU WIRE DK GRN/LT GRN WIRE DK GRN/ORG WIRE DK GRN/RED WIRE DK GRN/TAN WIRE DK GRN/VIO WIRE DK GRN/WHT WIRE DK GRN/YEL WIRE DYNAMICS SENS HIGH DATA DYNAMICS SENS LOW DATA DYNAMICS SENSOR (W/ ESP) (UNDER FRONT OF CENTER CONSOLE) ELECTRONICS ENGINE CONTROL MODULE (LOWER LEFT FRONT OF ENGINE BLOCK) ESP ON/OFF SENSE ESP SWITCH (IF EQUIPPED) FUSE 13 FUSE 18 FUSE 28 FUSE 30 FUSED B (+) CAN C BUS + FUSED B (+) IGN SW OUT (RUN-START) FUSED IGN SW OUT (RUN-START) GAS GRN WIRE GRN/GRY WIRE GROUND GRY WIRE HOT AT ALL TIMES HOT IN RUN OR START IGN SW OUT (RUN-START) CAN C BUS (+) CAN C BUS (-) GROUND LEFT FRONT ABS WHEEL SPEED SENSOR (LEFT REAR OF ENGINE COMPT) LEFT REAR ABS WHEEL SPEED SENSOR LF WHEEL SPD SENSOR (+) LF WHEEL SPD SENSOR (-) LT BLU WIRE LT GRN WIRE ORG/ WIRE ORG/DK BLU WIRE PANEL LAMPS DRIVER PNK WIRE PNK/ (EXCEPT ESP/5.7L POWER WAGON, 6.7L EXCEPT SHIFT ON THE FLY) WIRE PNK/GRY WIRE PNK/LT GRN WIRE POWERTRAIN CONTROL MODULE (RIGHT REAR OF ENGINE COMPT) REAR ABS WHEEL SPEED SENSOR (W/O ESP) (NEAR RIGHT REAR FRAME RAIL) RED WIRE RF WHEEL SPD SENSOR (+) RF WHEEL SPD SENSOR (-) RIGHT FRONT ABS WHEEL SPEED SENSOR (ON KNUCKLE SPINDLE ASSEMBLY) RIGHT REAR ABS WHEEL SPEED SENSOR (W/ ESP) (AT RIGHT REAR WHEEL ASSEMBLY) STEERING ANGLE SENSOR (W/ ESP) STOP LAMP SWITCH (ON BRAKE PEDAL SUPPORT) TAN WIRE TAN/RED WIRE TOTALLY INTEGRATED POWER MODULE (AT LEFT FRONT FENDER) TRAILER TOW DAMPING RLY CTRL VIO WIRE VIO/DK BLU WIRE W/ ESP W/O ESP WHT WIRE WHT/GRY WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE WHT/ORG WIRE YEL WIRE

1 2 3 4 D DR AJAR LR DR AJAR RR DR AJAR P DR AJAR 18 17 CAN B BUS(-) CAN B BUS(+) AAT RTN B(+) BLK WIRE BLK/GRY WIRE CAB CHASSIS) CAN B CLUSTER COM-LIN TIRE PRESS COMPUTER DATA HEADLIGHTS LINES SYSTEM SYSTEM COMPUTER DATA LINES SYSTEM DIESEL GAS DRIVER DOOR LATCH (LEFT FRONT DOOR) ELECTRONICS FUSE 11 FUSE 2 FUSED B (+) FUSED HOOD IGN SW AJAR OUTPUT SWITCH (RUN-START) SENSE FUSED IGN SW OUT GRY/LT BLU WIRE GRY/RED WIRE GRY/YEL WIRE HOOD AJAR SWITCH HORN CONTROL OUTPUT HORNS SYSTEM HOT AT ALL TIMES IGN SW SENS IGNITION SWITCH LEFT FRONT TIRE PRESSURE TRANSPONDER LT GRN/BLK WIRE PASSENGER DOOR LATCH PICK-UP PNK/WHT WIRE POWER LOCKS POWER MODULE (LEFT FRONT FENDER) RED WIRE RIGHT FRONT TIRE PRESSURE TRANSPONDER (RIGHT SIDE OF ENGINE COMPT) TOTALLY INTEGRATED VIO WIRE VIO/BRN WIRE VIO/GRY WIRE VIO/LT BLU WIRE VIO/TAN WIRE VIO/WHT WIRE VIO/YEL WIRE WHT WIRE WHT/GRY WIRE WHT/LT GRN WIRE WHT/ORG WIRE WIRELESS CONTROL MODULE

1 2 3 4 5 6 7 8 9 10 11 12 13 14 FUSED B(+) 1 2 3 4 5 6 7 8 9 10 11 12 13 GROUND SHIFT MOTOR CTRL A SHIFT MOTOR CTRL B 5 VOLT SUPPLY MODE SENSOR A SENSOR RETURN 6 7 8 9 10 11 12 FUSED IGN SW OUT A/C CLUTCH CTRL ASD CTRL BRAKE FLUID LEVEL SW SNS GROUND AIR CONDITIONING SYSTEM ENGINE CONTROLS SYSTEM ANTI-LOCK BRAKES SYSTEM ANTI-LOCK BRAKES SYSTEM ANTI-LOCK BRAKES SYSTEM DOOR LOCKS, TRANSMISSIONS, MIRRORS SYSTEMS BLK WIRE BLK/WHT WIRE BLK/YEL WIRE BRN WIRE BRN/GRY WIRE BRN/ORG WIRE BRN/TAN WIRE BRN/WHT WIRE DK BLU/GRY WIRE DK BLU/WHT WIRE DK BLU/YEL WIRE DK GRN WIRE DK GRN/ORG WIRE DK GRN/RED WIRE ENGINE CONTROLS SYSTEM ENGINE CONTROLS SYSTEM AIR CONDITIONING SYSTEM SEATS, ENGINE CONTROLS SYSTEM POWER DISTRIBUTION SYSTEM INSTRUMENT CLUSTER SYSTEM ENGINE CONTROLS SYSTEM WIPER/WASHER SYSTEM FUEL PUMP CTRL WIPER PARK SW SENSE FUSED B (+) FUSED B(+) FUEL PUMP CTRL OUT HORN CTRL OUT GROUND FUSED B(+) FUSED B(+) FUSED IGN SW (RUN-START) FUSED B(+) FUSED IGN SW OUT (RUN) FUSED IGN SW OUT (RUN) FUSED IGN SW (RUN-ACC) FUSED IGN SW (RUN-ACC) FUSED B(+) FUSED IGN SW (RUN-START) FUSED IGN SW OUT (OFF-RUN-START) 1 2 FUSED PARK LAMP FEED FUSED PARK LAMP FEED FUSED PARK LAMP FEED GRY/LT BLU WIRE GRY/PNK WIRE GRY/RED WIRE GRY/YEL WIRE HORN CTRL OUT WIPER LOW SPEED CTRL GROUND HEATED MIRROR CTRL OUT FUSED B(+) HORNS SYSTEM WIPER/WASHER SYSTEM INSTRUMENT CLUSTER SYSTEM SOUND SYSTEMS ENGINE CONTROLS SYSTEM INTERIOR LIGHTS, SOUNDS, COMPUTER DATA LINES SYSTEMS LT BLU/ORG WIRE LT GRN WIRE ORG/RED WIRE PASSIVE RESTRAINT SYSTEM POWER DISTRIBUTION SYSTEM PNK/DK GRN WIRE PNK/GRY WIRE PNK/LT BLU WIRE PNK/LT GRN WIRE PNK/RED WIRE PNK/WHT WIRE PNK/YEL WIRE POWER DISTRIBUTION SYSTEM POWER WINDOWS SYSTEM RED WIRE RED/DK BLU WIRE RED/LT BLU WIRE RED/ORG WIRE RED/YEL WIRE SEATS SYSTEM AIR CONDITIONING SYSTEM STARTER SOLENOID CTRL 3 4 5 6 7 8 9 10 11 12 13 14 TAN/RED WIRE TOTALLY INTEGRATED POWER MODULE (LEFT FRONT FENDER) TRANSMISSIONS SYSTEM TRANSMISSIONS SYSTEM ANTI-THEFT SYSTEM TRANSMISSIONS SYSTEM EXTERIOR LIGHTS SYSTEM TRANSMISSIONS SYSTEM POWER TOPS SYSTEM DEFOGGER SYSTEM TRANSMISSIONS, ENGINE CONTROLS SYSTEMS VIO/LT BLU WIRE VIO/TAN WIRE VIO/YEL WIRE WARNING SYSTEMS WASHER PUMP MOTOR CTRL IGN SW OUT (RUN-START) ADJUSTABLE PEDALS OUT WHT/DK GRN WIRE WHT/GRY WIRE WHT/YEL WIRE WIPER/WASHER SYSTEM WIPER/WASHER SYSTEM POWER DISTRIBUTION SYSTEM SEATS SYSTEM YEL WIRE YEL/DK BLU WIRE YEL/GRY WIRE YEL/ORG WIRE YEL/RED WIRE

15 16 CAN B BUS (-) CAN B BUS (+) A/C HEATER CONTROL B(+) BLK WIRE CAN B CAN B BUS (+) BUS (-) COMPUTER DATA LINES SYSTEM DK BLU/GRY WIRE DRIVER OUTSIDE REARVIEW MIRROR (DRIVER'S DOOR) ELECTRONICS EXCEPT BASE FUSE 8 HOT AT ALL TIMES ORG/ WIRE PASSENGER (LEFT KICK OUTSIDE PANEL) REARVIEW MIRROR (FRONT PASSENGER'S DOOR) REAR WINDOW DEFOG SWITCH REAR WINDOW DEFOGGER CTRL OUT TOTALLY INTEGRATED POWER MODULE (LEFT FRONT FENDER) WHT WIRE WHT/ORG WIRE

1 2 SENS GND SENS SIG A/C CLUTCH CTRL A/C CLUTCH CTRL OUTPUT A/C HEATER CONTROL A/C INDICATOR A/C PRES 5 VOLT SPLY A/C PRES GND A/C PRES SIG A/C SELECT B(+) BLEND DOOR DRIVER BLK WIRE BLK/LT BLU WIRE BLK/LT GRN WIRE BLK/ORG WIRE BLOWER MOTOR RESISTOR (RIGHT SIDE OF DASH) BLU WIRE BRN WIRE CLUSTER COMMON DOOR DRIVER COMPUTER DATA LINES SYSTEM CONDENSER FAN CTRL OUTPUT DK BLU WIRE DK BLU/BRN WIRE DK BLU/DK GRN WIRE DK BLU/LT BLU WIRE DK BLU/LT GRN WIRE DK BLU/ORG WIRE DK BLU/TAN WIRE DK BLU/VIO WIRE DK BLU/YEL WIRE DK DK DRIVER BLEND DOOR ACTUATOR (ON HVAC UNIT) ELECTRONICS EVAPORATOR TEMPERATURE SENSOR (RIGHT SIDE OF HVAC) EXCEPT BASE FENDER) FUSE 23 FUSE 33 FUSED IGN SW OUT (RUN) FUSED IGN SW OUT (RUN-START) HEATER MIRROR INDICATOR HOT AT ALL TIMES HVAC MICRO CONTROLLER LT BLU WIRE LT BLU/BRN WIRE LT BLU/ORG WIRE LT BLU/WHT WIRE LT GRN WIRE MODE DOOR ACTUATOR 1 (PANEL TO FLOOR) (ON HVAC UNIT) MODE DOOR ACTUATOR 2 (DEFROST TO FLOOR) (ON HVAC UNIT) OFF OFF HEATED MIRROR ORG/ WIRE ORG/GRY WIRE PANEL LAMPS DRIVER PASS BLEND DOOR DRIVER PASSENGER BLEND DOOR ACTUATOR (EXCEPT BASE) (ON HVAC UNIT) PNK WIRE PNK/LT BLU WIRE PNK/LT GRN WIRE RECIRC RECIRCULATION DOOR ACTUATOR (ON HVAC UNIT) RECIRCULATION DOOR DRIVER RECIRCULATION INDICATOR RED WIRE TAN WIRE TOTALLY INTEGRATED POWER MODULE (LEFT FRONT WHT WIRE WHT/ORG WIRE YEL WIRE

34 35 CAN C BUS (+) CAN C BUS (-) 5 4 CAN C BUS (-) CAN C BUS (+) 6.7L 5.9L A/C CLUTCH CTRL A/C COMPRESSOR CLUTCH (FRONT OF A/C COMPRESSOR) A/C PRES 5 VOLT SPLY A/C PRES GND BLK WIRE BLK/GRY WIRE BLK/LT BLU WIRE BLK/WHT WIRE BLU WIRE BRN WIRE BRN/WHT WIRE BRN/YEL WIRE COMPUTER DATA LINES SYSTEM CONDENSER FAN MOTOR (GAS) (LEFT FRONT OF ENGINE COMPT) DIESEL DK BLU WIRE DK BLU/DK GRN WIRE DK BLU/YEL WIRE DK GRN WIRE ECT SIG ENGINE BLOCK) ENGINE CONTROL MODULE (LOWER LEFT FRONT OF ENGINE CONTROLS SYSTEM ENGINE COOLANT TEMPERATURE GAS LT BLU WIRE LT BLU/BRN WIRE LT BLU/ORG WIRE LT BLU/WHT WIRE ORG/ WIRE POWERTRAIN CONTROL MODULE (RIGHT REAR OF ENGINE COMPT) SENS GND SENSOR (5.7L: FRONT OF ENGINE) (6.7L: TOP FRONT OF ENGINE) VIO WIRE VIO/ORG WIRE WHT WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE YEL WIRE

5.9L 6.7L B(+) CAN C BUS (+) BLK WIRE BLK/DK GRN WIRE BLK/ORG WIRE BRAKE SWITCH 1 SIGNAL BRAKE SWITCH 1 SIGNAL 34 35 C BUS (+) C BUS (-) BRK FLUID LEVEL SW SENSE CAN C BUS (+) COMPUTER DATA LINES SYSTEM DIESEL DK DK DK GRN WIRE DK GRN/LT GRN WIRE DK GRN/ORG WIRE DK GRN/RED WIRE DK GRN/TAN WIRE DK GRN/WHT WIRE DK GRN/YEL WIRE ELECTRONICS FUSED IGN SW OUT (RUN-START) ENGINE CONTROL MODULE FUSE 13 FUSE 30 GAS GRN WIRE HOT AT ALL TIMES LF WHEEL SPD SENSOR (-) LT BLU WIRE LT GRN WIRE ORG/ WIRE PNK WIRE PNK/LT GRN WIRE RED WIRE TAN WIRE TOTALLY INTEGRATED POWER MODULE (AT LEFT FRONT FENDER) WHT WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE YEL WIRE