Wiring diagram engine performance 5.9l 24-valve diesels for Dodge Cab & Chassis R2500 (1996-2006)

1 2 3 4 5 6 7 8 TRANS RLY OUT 1 2 3 4 5 6 A/C CLUTCH RLY 31 32 GROUND GROUND A/T A/T (TRANS HARN, IN BREAKOUT TO PDC) AIR CONDI- TIONING SYSTEM AUTO SHT RLY CRUISE VAC SOL CRUISE VNT SOL AUTOMATIC SHUTDOWN RELAY BATTERY TEMPER- ATURE SENSOR (BELOW BATTERY TRAY) BLK WIRE BLK/LT BLU WIRE BLK/LT GRN WIRE BLK/TAN WIRE BLK/WHT WIRE BRAKE LAMP SWITCH (ON BRAKE PEDAL BRACKET) BRN WIRE CKP ENG SIG (PINS 9-21 NOT USED) 22 23 FUSED B(+) ACC PEDAL POS CONTROLLER ANTI-LOCK BRAKE CRUISE CONTROL SYSTEM CRUISE FEED ASD RELAY SENS TRANS OVERDRV 12 13 14 15 CRUISE SW IN DK BLU WIRE DK BLU/BLK WIRE DK BLU/ORG WIRE DK BLU/WHT WIRE DK BLU/YEL WIRE DK GRN WIRE DK GRN/ORG WIRE FUEL TANK MODULE (TOP OF FUEL TANK) FUSE 6 FUSE I GEN FIELD DRV TCC DRVR GENERATOR GRY/BLK WIRE HOT AT ALL TIMES IGN (POWER) JOINT CONNECTOR 1 (IN PDC) JOINT CONNECTOR 2 (IN PCD) LT BLU WIRE LT GRN/BLK WIRE LT GRN/RED WIRE LT GRN/WHT WIRE M/T ORG/ WIRE ORG/BLK WIRE ORG/DK BLU WIRE ORG/WHT WIRE OUTPUT SENS OUTPUT SPEED SENSOR (ON LEFT SIDE OF TRANSMISSION) OVERDRV SOL PARK/NEUTRAL POSITION SWITCH (ON LEFT SIDE OF TRANSMISSION) PNK WIRE PNK/DK BLU WIRE PNK/YEL WIRE POWERTRAIN CONTROL MODULE (IN ENG COMPT, ON RIGHT SIDE OF FIREWALL) PRK/NEUTRAL RED WIRE RED/LT BLU WIRE RED/LT GRN WIRE RED/WHT WIRE SENSOR GRD SENSOR GRD GOV PRESS SIG VAR FORCE SOL OVERDRV SOL TCC SOL CTRL TRANS TEMP SNS STARTING/ CHARGING SYSTEM TAN/RED WIRE TRANS- MISSION RELAY TRANSMISSION SOLENOID ASSEMBLY (ON LEFT SIDE OF TRANSMISSION) VAR FRCE SOL VIO WIRE VIO/BRN WIRE VIO/WHT WIRE VSS IN OUTPUT SENS GOV PRESS SIG TRANS RELAY WHT/BLK WIRE WHT/ORG WIRE WHT/PNK WIRE WHT/VIO WIRE YEL WIRE YEL/RED WIRE

BLK WIRE BLK/DK BLU WIRE BLK/LT BLU WIRE BLK/WHT WIRE BLK/YEL WIRE BRN/ORG WIRE CAMSHAFT POSITION SENSOR CCD(-) CUMMINS BUS (-) DATA LINK CONNECTOR (LEFT BOTTOM OF DASH) DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE FUEL HEATER (IN TOP OF FUEL FILTER HOUSING) FUEL TRANSFER PUMP (ON LOWER LEFT SIDE OF ENG, BELOW REARWARD OF FUEL FILTER) FUSE 17 FUSE 11 FUSE 9 GRY WIRE GRY/BLK WIRE HOT IN RUN OR START IND INSTRUMENT CLUSTER JOINT CONNECTOR JOINT CONNECTOR 7 (LEFT SIDE OF INSTRUMENT PANEL) JUNCTION BLOCK (LEFT END OF DASH) LT BLU/BLK WIRE LT GRN/BLK WIRE LT GRN/DK BLU WIRE NCA WIRE ORG/ WIRE ORG/BLK WIRE ORG/DK BLU WIRE PNK/DK BLU WIRE PTO SWITCH RED/BLK WIRE RED/TAN WIRE RED/WHT WIRE VIO/BRN WIRE VIO/WHT WIRE WAIT TO WHT/BLK WIRE WHT/ORG WIRE WHT/PNK WIRE WHT/VIO WIRE YEL/DK BLU WIRE YEL/LT GRN WIRE YEL/WHT WIRE

ACC PEDAL POS SENS BATTERY BLK WIRE BLK/DK BLU WIRE BLK/LT BLU WIRE BLK/RED WIRE BLK/TAN WIRE BLK/YEL WIRE BRN/ORG WIRE BRN/WHT WIRE CMPSENS SIG FAULT SIG CRUISE CONTROL SYSTEM DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE DK GRN/RED WIRE ENGINE CONTROL MODULE (ON LEFT SIDE OF ENG, BEHIND FUEL FILTER) ENGINE OIL PRESSURE SENSOR (ON LEFT SIDE OF ENG, NEAR NEAR ECM) FUEL INJECTION PUMP (ON LEFT SIDE OF ENG, ON REAR OF TIMING GEAR HOUSING) FUEL PUMP RELAY (IN PDC) FUSE B(+) GND FUSED B(+) FUSIBLE LINKS GRY WIRE GRY/BLK WIRE GRY/RED WIRE INTAKE AIR HEATER INTAKE AIR HEATER RELAY 1 (ON LEFT INNER FENDER, BELOW LEFT BATTERY) INTAKE AIR HEATER RELAY 2 (ON LEFT INNER FENDER, BELOW LEFT BATTERY) INTAKE AIR TEMPERATURE SENSOR (IN LEFT REAR SIDE OF INTAKE MANIFOLD) JOINT CONNECTOR 1 (IN PDC) JOINT CONNECTOR 2 (IN PDC) LT BLU/BLK WIRE LT BLU/RED WIRE LT GRN/BLK WIRE LT GRN/DK BLU WIRE MANIFOLD AIR PRESSURE SENSOR (LEFT REAR SIDE OF INTAKE MANIFOLD) NCA WIRE ORG/ WIRE ORG/BLK WIRE ORG/BRN WIRE ORG/DK BLU WIRE PNK/DK BLU WIRE RED/LT GRN WIRE RED/WHT WIRE SENSOR GND CUMMIN BUS (-) DL (+) FUEL INJ PMP ECT SENS SIG TRANS PMP PWR TAN/BLK WIRE VIO/BRN WIRE VIO/ORG WIRE VIO/WHT WIRE WHT WIRE WHT/BLK WIRE WHT/ORG WIRE WHT/PNK WIRE YEL/BLK WIRE YEL/DK BLU WIRE YEL/LT GRN WIRE YEL/RED WIRE YEL/WHT WIRE