Dodge Cab & Chassis R2500 (1996-2006) wht/vio Wiring diagrams

9 10 11 PNK WIRE ACC PDL POS SENS GND GND BLK WIRE BLK/LT BLU WIRE BLK/TAN WIRE BLK/WHT WIRE BRAKE LAMP SWITCH (ON BRAKE PEDAL BRACKET) BRN WIRE CCD (+) CCD (-) DATA LINK CONNECTOR (PARTIAL) (ON LEFT BOTTOM OF DASH) DK BLU WIRE DK BLU/BLK WIRE DK GRN WIRE ENGINE CONTROL MODULE (ON LEFT SIDE OF ENGINE, BEHIND FUEL FILTER) FUSE 14 FUSE 9 GRY WIRE GRY/BLK WIRE HOT AT ALL TIMES HOT IN RUN OR START INSTRUMENT CLUSTER JOINT CONNECTOR 1 (IN PDC) JOINT CONNECTOR 7 JUNCTION BLOCK (ON LEFT END OF DASH) LT GRN WIRE LT GRN/BLK WIRE LT GRN/WHT WIRE O/D IND ORG/ WIRE ORG/BLK WIRE ORG/DK BLU WIRE ORG/WHT WIRE OUTPUT SPEED SENSOR (ON LEFT SIDE OF TRANSMISSION) OVERDRIVE SWITCH PNK WIRE PNK/DK BLU WIRE POWERTRAIN CONTROL MODULE (IN ENGINE COMPT, ON RIGHT SIDE OF FIREWALL) RED/WHT WIRE SWITCH TAN/BLK WIRE VIO WIRE VIO/BRN WIRE VIO/WHT WIRE WHT WIRE WHT/BLK WIRE WHT/ORG WIRE WHT/PNK WIRE WHT/VIO WIRE YEL WIRE

2 4 6 8 FUSED IGN (ST/RUN) SENSOR GND PNP SW SENSE ENG SPEED SENS SIG 22 23 31 32 FUSED B(+) TP SENS SIG GND GND 9 10 11 PNK WIRE AUTOMATIC SHUTDOWN RELAY BLK WIRE BLK/LT BLU WIRE BLK/TAN WIRE BLK/WHT WIRE BRN WIRE CCD (+) CCD (-) CUMMINS BUS (-) DATA LINK CONNECTOR (PARTIAL) (LEFT BOTTOM OF DASH) DK BLU WIRE DK BLU/BLK WIRE DK GRN WIRE ENGINE CONTROL MODULE (LEFT SIDE OF ENG, BEHIND FUEL FILTER) FUSE 14 FUSE 9 GRY WIRE GRY/BLK WIRE HOT AT ALL TIMES HOT IN RUN OR START IND INSTRUMENT CLUSTER JOINT CONNECTOR 1 JOINT CONNECTOR 3 JOINT CONNECTOR 4 JOINT CONNECTOR 7 JUNCTION BLOCK LT GRN WIRE LT GRN/BLK WIRE LT GRN/WHT WIRE MIL IND ORG/ WIRE ORG/BLK WIRE ORG/DK BLU WIRE ORG/WHT WIRE OVERDRIVE SWITCH PNK WIRE PNK/DK BLU WIRE POWERTRAIN CONTROL MODULE (IN ENG COMPT, ON RIGHT SIDE OF FIREWALL) RED WIRE RED/WHT WIRE STOP LAMP SWITCH (TOP OF BRAKE PEDAL BRACKET) SWITCH (ON FRONT AXLE TUBE) TAN/BLK WIRE TRANSMISSION OUTPUT SHAFT SPEED SENSOR (ON LEFT SIDE OF TRANSMISSION) VIO WIRE VIO/BRN WIRE VIO/WHT WIRE WHT WIRE WHT/BLK WIRE WHT/ORG WIRE WHT/PNK WIRE WHT/VIO WIRE YEL WIRE

1 2 3 4 5 6 7 8 9 10 11 12 13 14 REAR WHL SPD SENSOR (+) BLK WIRE BLK/GRY WIRE BLK/LT GRN WIRE BLK/VIO WIRE BRAKE LAMP SWITCH (ON BRAKE PEDAL BRACKET) BRAKE PRESSURE SWITCH (ON COMBINATION VALVE) CCD BUS (+) FUSE IGN SW (RUN) CONTROLLER ANTI-LOCK BRAKE (LEFT FENDER SIDE SHIELD) DATA LINK CONNECTOR (LEFT BOTTOM OF DASH) DIESEL ENGINE CONTROLS SYSTEM FUSE 11 FUSE 14 FUSE 3 GROUND FUSE B (+) REAR WHL SPD SENSOR (-) BRAKE SW SENSE CCD BUS (-) GRY WIRE GRY/BLK WIRE HOT AT ALL TIMES HOT IN IND INSTRUMENT CLUSTER J/C 1 (IN PDC) JOINT CONNECTOR 7 (LEFT SIDE OF DASH) JUNCTION BLOCK (LEFT END OF DASH) POWERTRAIN CONTROL MODULE (RIGHT REAR OF ENG COMPT) REAR WHEEL SPEED SENSOR (IN DIFFERENTIAL HOUSING) RED BRAKE IND DRIVER WIRE RED WIRE RED/DK BLU WIRE RED/DK GRN WIRE RED/GRY WIRE RED/VIO WIRE RUN WIRE VEHICLE SPEED SEN SIG GROUND FUSE B (+) VIO/BRN WIRE VSS WHT WIRE WHT/BLK WIRE WHT/DK BLU WIRE WHT/ORG WIRE WHT/PNK WIRE WHT/VIO WIRE YEL WIRE

AIR BAG CONTROL MODULE (BEHIND LOWER CENTER OF DASH) BLK WIRE BLK/LT GRN WIRE BLK/TAN WIRE BLK/WHT WIRE CCD BUS (-) CENTRAL TIMER MODULE (ON LEFT SIDE OF DASH) CONTROLLER ANTI-LOCK BRAKE (RWAL: LEFT FRONT INNER FENDER) CUMMINS BUS (-) CUMMINS BUS (DIESEL) (LEFT FRONT OF ENGINE) CUMMINS BUS SHIELD DASH) DATA LINK CONNECTOR (DLC) (ON LEFT BOTTOM OF DASH) DIESEL DK BLU WIRE DK GRN WIRE DRAIN WIRE ENGINE CONTROL MODULE (ON LEFT SIDE OF ENGINE, BEHIND FUEL FILTER) FUSE 12 GAS GAS DIESEL GROUND HOT AT ALL TIMES HYDRAULIC CONTROL UNIT INSTRUMENT CLUSTER J/C 5 (BEHIND LEFT SIDE OF DASH) JUNCTION BLOCK (ON LEFT END OF NCA WIRE OVERHEAD CONSOLE (HIGHLINE) PNK WIRE PNK/DK BLU WIRE POWERTRAIN CONTROL MODULE (ON RIGHT SIDE OF FIREWALL) RADIO SCI RECEIVE SCI TRANSMIT VIO/BRN WIRE WHT/BLK WIRE WHT/VIO WIRE YEL/DK BLU WIRE YEL/DK GRN WIRE

1 2 CCD BUS (+) CCD BUS (-) 14 16 17 MUX CTRL CCD (+) CCD (-) AMP L REAR SPKR (+) AMP R REAR SPKR (-) AMP TWEETER SPKR (+) ANTENNA BLK WIRE BLK/LT GRN WIRE BLK/RED WIRE BLK/VIO WIRE BLK/YEL WIRE BRN/LT BLU WIRE BRN/RED WIRE BRN/YEL WIRE CENTRAL TIMER MODULE (LEFT SIDE OF DASH, INBOARD OF STEERING COLUMN OPENING) CLOCK SPRING 1 DK BLU WIRE DK BLU/ORG WIRE DK BLU/RED WIRE DK BLU/WHT WIRE DK GRN WIRE FUSE 12 FUSE 4 FUSE 8 GRN WIRE GROUND HOT AT ALL TIMES HOT IN RUN OR ACC JOINT CONNECTOR 5 (LEFT SIDE OF DASH) JOINT CONNECTOR 6 (LEFT SIDE OF DASH) JOINT CONNECTOR 7 (BEHIND LEFT SIDE OF DASH) JUNCTION BLOCK (LEFT END OF DASH) L FRONT SPKR - L REAR SPKR - LEFT FRONT DOOR SPEAKER LEFT REAR SPEAKER LEFT REMOTE RADIO SWITCH LEFT TWEETER SPEAKER LF SPKR (-) RF SPKR (-) DAY SENSE ILLUMINATION FUSED IGN FUSED B(+) LT BLU/BLK WIRE LT BLU/RED WIRE LT GRN WIRE NCA WIRE ORG/ WIRE PNK WIRE PRESET R FRONT SPKR - R REAR SPKR - RADIO RADIO CHOKE RADIO CHOKE RELAY (BEHIND CENTER OF DASH) RED WIRE RED/BLK WIRE RED/WHT WIRE RIGHT FRONT DOOR SPEAKER RIGHT REAR SPEAKER RIGHT TWEETER SPEAKER SEEK DN SEEK UP TAN/BLK WIRE TAN/VIO WIRE VIO WIRE VIO/BRN WIRE VOL DN RIGHT REMOTE RADIO SWITCH VOL UP WHT WIRE WHT/BLK WIRE WHT/DK GRN WIRE WHT/VIO WIRE YEL/BLK WIRE YEL/RED WIRE

1 2 CCD BUS (+) CCD BUS (-) 14 16 17 MUX CTRL CCD (+) CCD (-) AMP L REAR SPKR (+) AMP R REAR SPKR (-) AMP TWEETER SPKR (+) ANTENNA BLK WIRE BLK/LT GRN WIRE BLK/RED WIRE BLK/VIO WIRE BLK/YEL WIRE BRN/LT BLU WIRE BRN/RED WIRE BRN/YEL WIRE CENTRAL TIMER MODULE (LEFT SIDE OF DASH, INBOARD OF STEERING COLUMN OPENING) CLOCK SPRING 1 DK BLU WIRE DK BLU/ORG WIRE DK BLU/RED WIRE DK BLU/WHT WIRE DK GRN WIRE FUSE 12 FUSE 4 FUSE 8 GRN WIRE GROUND HOT AT ALL TIMES HOT IN RUN OR ACC JOINT CONNECTOR 5 (LEFT SIDE OF DASH) JOINT CONNECTOR 6 (LEFT SIDE OF DASH) JOINT CONNECTOR 7 (BEHIND LEFT SIDE OF DASH) JUNCTION BLOCK (LEFT END OF DASH) L FRONT SPKR - L REAR SPKR - LEFT FRONT DOOR SPEAKER LEFT REAR SPEAKER LEFT REMOTE RADIO SWITCH LEFT TWEETER SPEAKER LF SPKR (-) RF SPKR (-) DAY SENSE ILLUMINATION FUSED IGN FUSED B(+) LT BLU/BLK WIRE LT BLU/RED WIRE LT GRN WIRE NCA WIRE ORG/ WIRE PNK WIRE PRESET R FRONT SPKR - R REAR SPKR - RADIO RADIO CHOKE RADIO CHOKE RELAY (BEHIND CENTER OF DASH) RED WIRE RED/BLK WIRE RED/WHT WIRE RIGHT FRONT DOOR SPEAKER RIGHT REAR SPEAKER RIGHT TWEETER SPEAKER SEEK DN SEEK UP TAN/BLK WIRE TAN/VIO WIRE VIO WIRE VIO/BRN WIRE VOL DN RIGHT REMOTE RADIO SWITCH VOL UP WHT WIRE WHT/BLK WIRE WHT/DK GRN WIRE WHT/VIO WIRE YEL/BLK WIRE YEL/RED WIRE

ABS WARNING IND CTRL ABS WARNING LAMP BLK WIRE BLK/ WHT WIRE BLK/GRY WIRE BLK/ORG WIRE BLK/PNK WIRE BRAKE SW INPUT BRAKE WARNING BRAKE WARNING LAMP BRAKE WARNING SWITCH (LEFT SIDE FRAME RAIL) DIAGNOSTIC SIGNAL DIESEL DUMP SOL FUSE 14 FUSE 20 FUSE BLOCK FUSED B (+) FUSED IGN RUN GASOLINE GROUND GROUND JOINT (NEAR PDC) GRY/BLK WIRE HOT AT ALL TIMES HOT IN RUN IGNITION SWITCH INSTRUMENT CLUSTER ISOLATE SOL JOINT CONNECTOR B (NEAR REAR OF FUSE BLOCK) JOINT CONNECTOR C (BEHIND KNEE BOLSTER) LT BLU/BLK WIRE LT GRN/RED WIRE LT GRN/WHT WIRE OFF PARK BRAKE INDIC. PARK BRAKE INPUT PARK BRAKE SWITCH (ON BRAKE BRACKET) PNK/DK BLU WIRE REAR WHEEL ANTI-LOCK CONTROL MODULE (CENTER OF I/P) REAR WHEEL SENSOR REAR WHEEL SPEED SENSOR (LEFT FRAME RAIL, NEAR FUEL TANK) RED/DK BLU WIRE RED/VIO WIRE RESET SW RESET+ RUN WIRE RWAL DUMP SOLENOID RWAL HYDRAULIC VALVE (BELOW MASTER CYLINDER) RWAL ISOLATE SOLENOID STOP LAMP SWITCH (BRAKE PEDAL BRACKET) VACUUM SENSOR (DIESEL ONLY) (LEFT FENDER SIDE SHIELD) WHT WIRE WHT/ BLK WIRE WHT/BLK WIRE WHT/PNK WIRE WHT/VIO WIRE

1 2 3 4 5 6 7 8 TRANS RLY OUT A/C REQUEST A/C SELECT IN BRAKE SW IN GEN FIELD OUT A/T AIR CONDI- TIONING SYSTEM AUTO SHT RLY CRUISE VAC SOL CRUISE VNT SOL OVERDRV IND BATT TEMP SENS BLK/LT BLU WIRE BLK/LT GRN WIRE BLK/RED WIRE BRN WIRE CCD(-) CRUISE CONTROL SYSTEM CRUISE FEED ASD RELAY SENS TRANS OVERDRV CRUISE SW IN DATA LINK CONNECTOR (LEFT BOTTOM OF DASH) DK BLU/ORG WIRE DK BLU/WHT WIRE DK BLU/YEL WIRE DK GRN/ORG WIRE FUSE 17 FUSE M GENERATOR HOT AT ALL TIMES HOT AT ALL TIMES JUNCTION BLOCK (RIGHT END OF DASH) FUSE 14 HOT IN RUN OR START IND INSTRUMENT CLUSTER JOINT CONNECTOR 1 (IN PDC) JOINT CONNECTOR NO 6 (TOP OF STEERING COLUMN, BEHIND INSTRUMENT PANEL) 2 3 LT GRN WIRE LT GRN/ORG WIRE LT GRN/RED WIRE LT GRN/WHT WIRE M/T ORG/ WIRE ORG/BLK WIRE ORG/DK BLU WIRE ORG/WHT WIRE OVERDRIVE OFF IND OVERDRIVE SWITCH PNK 4 5 6 WIRE PNK WIRE PNK/DK BLU WIRE PNK/WHT WIRE PNK/YEL WIRE POWER DISTRIBUTION CENTER (IN ENG COMPT, ON LEFT INNER FENDER PANEL) POWERTRAIN CONTROL MODULE (IN ENG COMPT, ON RIGHT SIDE OF FIREWALL) RED WIRE RED/LT GRN WIRE SCI TRANSMIT CCD BUS (-) SCI RECEIVE CCD BUS (+) SENSOR GRD GOV PRESS SIG VAR FORCE SOL OVERDRV SOL TCC SOL CTRL TRANS TEMP SNS STOP LAMP SWITCH (ON BRAKE PEDAL BRACKET) TAN/RED WIRE THROTTLE POSITION SENSOR (ON TOP OF INJECTOR PUMP) TRANS- MISSION RELAY TRANSMISSION SOLENOID ASSEMBLY (ON LEFT SIDE OF TRANSMISSION) VIO WIRE VIO/BRN WIRE VIO/WHT WIRE WAIT TO WHT/BLK WIRE WHT/DK BLU WIRE WHT/PNK WIRE WHT/VIO WIRE YEL WIRE YEL/RED WIRE

1 2 3 4 5 6 7 8 TRANS RLY OUT 1 2 3 4 5 6 A/C CLUTCH RLY 31 32 GROUND GROUND A/T A/T (TRANS HARN, IN BREAKOUT TO PDC) AIR CONDI- TIONING SYSTEM AUTO SHT RLY CRUISE VAC SOL CRUISE VNT SOL AUTOMATIC SHUTDOWN RELAY BATTERY TEMPER- ATURE SENSOR (BELOW BATTERY TRAY) BLK WIRE BLK/LT BLU WIRE BLK/LT GRN WIRE BLK/TAN WIRE BLK/WHT WIRE BRAKE LAMP SWITCH (ON BRAKE PEDAL BRACKET) BRN WIRE CKP ENG SIG (PINS 9-21 NOT USED) 22 23 FUSED B(+) ACC PEDAL POS CONTROLLER ANTI-LOCK BRAKE CRUISE CONTROL SYSTEM CRUISE FEED ASD RELAY SENS TRANS OVERDRV 12 13 14 15 CRUISE SW IN DK BLU WIRE DK BLU/BLK WIRE DK BLU/ORG WIRE DK BLU/WHT WIRE DK BLU/YEL WIRE DK GRN WIRE DK GRN/ORG WIRE FUEL TANK MODULE (TOP OF FUEL TANK) FUSE 6 FUSE I GEN FIELD DRV TCC DRVR GENERATOR GRY/BLK WIRE HOT AT ALL TIMES IGN (POWER) JOINT CONNECTOR 1 (IN PDC) JOINT CONNECTOR 2 (IN PCD) LT BLU WIRE LT GRN/BLK WIRE LT GRN/RED WIRE LT GRN/WHT WIRE M/T ORG/ WIRE ORG/BLK WIRE ORG/DK BLU WIRE ORG/WHT WIRE OUTPUT SENS OUTPUT SPEED SENSOR (ON LEFT SIDE OF TRANSMISSION) OVERDRV SOL PARK/NEUTRAL POSITION SWITCH (ON LEFT SIDE OF TRANSMISSION) PNK WIRE PNK/DK BLU WIRE PNK/YEL WIRE POWERTRAIN CONTROL MODULE (IN ENG COMPT, ON RIGHT SIDE OF FIREWALL) PRK/NEUTRAL RED WIRE RED/LT BLU WIRE RED/LT GRN WIRE RED/WHT WIRE SENSOR GRD SENSOR GRD GOV PRESS SIG VAR FORCE SOL OVERDRV SOL TCC SOL CTRL TRANS TEMP SNS STARTING/ CHARGING SYSTEM TAN/RED WIRE TRANS- MISSION RELAY TRANSMISSION SOLENOID ASSEMBLY (ON LEFT SIDE OF TRANSMISSION) VAR FRCE SOL VIO WIRE VIO/BRN WIRE VIO/WHT WIRE VSS IN OUTPUT SENS GOV PRESS SIG TRANS RELAY WHT/BLK WIRE WHT/ORG WIRE WHT/PNK WIRE WHT/VIO WIRE YEL WIRE YEL/RED WIRE

BLK WIRE BLK/DK BLU WIRE BLK/LT BLU WIRE BLK/WHT WIRE BLK/YEL WIRE BRN/ORG WIRE CAMSHAFT POSITION SENSOR CCD(-) CUMMINS BUS (-) DATA LINK CONNECTOR (LEFT BOTTOM OF DASH) DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE FUEL HEATER (IN TOP OF FUEL FILTER HOUSING) FUEL TRANSFER PUMP (ON LOWER LEFT SIDE OF ENG, BELOW REARWARD OF FUEL FILTER) FUSE 17 FUSE 11 FUSE 9 GRY WIRE GRY/BLK WIRE HOT IN RUN OR START IND INSTRUMENT CLUSTER JOINT CONNECTOR JOINT CONNECTOR 7 (LEFT SIDE OF INSTRUMENT PANEL) JUNCTION BLOCK (LEFT END OF DASH) LT BLU/BLK WIRE LT GRN/BLK WIRE LT GRN/DK BLU WIRE NCA WIRE ORG/ WIRE ORG/BLK WIRE ORG/DK BLU WIRE PNK/DK BLU WIRE PTO SWITCH RED/BLK WIRE RED/TAN WIRE RED/WHT WIRE VIO/BRN WIRE VIO/WHT WIRE WAIT TO WHT/BLK WIRE WHT/ORG WIRE WHT/PNK WIRE WHT/VIO WIRE YEL/DK BLU WIRE YEL/LT GRN WIRE YEL/WHT WIRE