Dodge Cab & Chassis R2500 (1996-2006) org/ Wiring diagrams

5.7L ANTI-LOCK BRAKES MODULE (LEFT REAR OF ENGINE COMPT) B(+) CAN C BUS (+) BLK WIRE BLK/DK GRN WIRE BLK/ORG WIRE BRAKE FLUID LEVEL SENSOR (LEFT REAR OF ENGINE COMPT) BRAKE SWITCH 1 SIGNAL POWERTRAIN CONTROL MODULE (RIGHT REAR OF ENGINE COMPT) BRK FLUID LEVEL SW SENSE CAN C BUS (+) COMPUTER DATA LINES SYSTEM DK GRN WIRE DK GRN/GRY WIRE DK GRN/LT GRN WIRE DK GRN/ORG WIRE DK GRN/RED WIRE DK GRN/TAN WIRE DK GRN/WHT WIRE DK GRN/YEL WIRE ELECTRONICS FUSED IGN SW OUT (RUN-START) FUSE 13 FUSE 28 GRY WIRE HOT AT ALL TIMES LT BLU WIRE LT GRN WIRE ORG/ WIRE PNK WIRE PNK/GRY WIRE RED WIRE STOP LAMP SWITCH (ON BRAKE PEDAL SUPPORT) TAN WIRE TOTALLY INTEGRATED POWER MODULE (AT LEFT FRONT FENDER) WHT WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE YEL WIRE

5 VOLT SPLY 6 2 1 5 3 SNS GND 5 VOLT SNS SIG TTVA (-) TTVA (+) 8 20 TTVA (+) TTVA (-) B(+) TRANS CTRL CLUSTER CLUSTER MUX DK BLU WIRE DK BLU/DK GRN WIRE DK GRN WIRE DK GRN/BRN WIRE DK GRN/ORG WIRE DK GRN/TAN WIRE DK GRN/VIO WIRE DK GRN/YEL WIRE ELECTRONICS ENGINE CONTROL MODULE (LOWER LEFT FRONT OF ENGINE BLOCK) ENGINE CONTROL SYSTEM FUSE 10 HOT AT ALL TIMES LEFT REAR LT BLU/BLK WIRE OF ENGINE COMPT) ORG/ WIRE OUTPUT SPEED SENSOR (BOTTOM OF TRANSMISSION) TAN/ORG WIRE TAN/YEL WIRE TOTALLY INTEGRATED POWER MODULE (AT LEFT FRONT FENDER) TOW/HAUL OVERDRIVE SWITCH TRANS CTRL OUT TRANSMISSION RANGE SENSOR (LEFT SIDE OF TRANSMISSION) TRANSMISSION SOLENOID ASSEMBLY (LEFT SIDE OF TRANSMISSION) TRANSMISSION THROTTLE VALVE ASSEMBLY YEL/BRN WIRE YEL/DK BLU WIRE YEL/LT BLU WIRE YEL/ORG WIRE YEL/PNK WIRE YEL/TAN WIRE

1 2 SENSOR GROUND SENSOR SIGNAL A/C CLUTCH CONTROL A/C HEATER CONTROL A/C INDICATOR A/C SELECT B(+) BLEND DOOR DRIVER BLK/LT GRN WIRE BLK/ORG WIRE BLOWER MOTOR RESISTOR (BEHIND RIGHT SIDE OF DASH) BLU WIRE BRN WIRE COMMON DOOR DRIVER COMPUTER DATA LINES SYSTEM DK BLU WIRE DK BLU/BRN WIRE DK BLU/DK GRN WIRE DK BLU/LT BLU WIRE DK BLU/LT GRN WIRE DK BLU/ORG WIRE DK BLU/TAN WIRE DK BLU/VIO WIRE DK BLU/YEL WIRE ELECTRONICS A/C CLUTCH CONTROL OUTPUT EVAPORATOR TEMPERATURE SENSOR (RIGHT SIDE OF HVAC) EXCEPT BASE FUSE 23 FUSE 32 FUSED IGNITION SWITCH OUTPUT (RUN) FUSED IGNITION SWITCH OUTPUT (RUN-START) GRY WIRE GRY/PNK WIRE HEATER MIRROR INDICATOR HOT AT ALL TIMES HVAC MICRO CONTROLLER INSTRUMENT CLUSTER LOW HIGH OFF LT BLU WIRE LT BLU/BRN WIRE LT BLU/ORG WIRE LT GRN WIRE MODE DOOR ACTUATOR 1 (PANEL TO FLOOR) (ON HVAC UNIT) MODE DOOR ACTUATOR 2 (DEFROST TO FLOOR) (ON HVAC UNIT) OFF OFF HEATED MIRROR ORG/ WIRE ORG/GRY WIRE PANEL LAMPS DRIVER PASS BLEND DOOR DRIVER PASSENGER BLEND DOOR ACTUATOR (ON HVAC UNIT) PNK WIRE PNK/LT GRN WIRE RECIRC RECIRCULATION DOOR ACTUATOR RECIRCULATION DOOR DRIVER RECIRCULATION INDICATOR RED WIRE TAN WIRE TOTALLY INTEGRATED POWER MODULE (AT LEFT FRONT FENDER) WHT WIRE WHT/ORG WIRE YEL WIRE

5 VOLT SUPPLY A/C CLUTCH CTRL A/C COMPRESSOR CLUTCH (FRONT OF A/C COMPRESSOR) A/C PRESS SIG A/C PRESSURE SIGNAL A/C PRESSURE TRANSDUCER B(+) A/C PRESSURE GROUND BLK WIRE BLK/GRY WIRE BLK/LT BLU WIRE BRN WIRE BRN/YEL WIRE CONDENSER FAN MOTOR (GAS) (LEFT FRONT OF ENGINE COMPT) CONDENSOR FAN CONTROL OUTPUT DIESEL DIESEL/ NGC DK BLU/DK GRN WIRE DK BLU/YEL WIRE DK GRN WIRE ECT SIG ELECTRONICS ENGINE CONTROL MODULE (DIESEL) (LOWER LEFT FRONT OF ENGINE BLOCK) ENGINE COOLANT TEMPERATURE SENSOR (DIESEL) EXCEPT SRT-10 EXCEPT SRT-10 SRT-10 GAS HOT AT ALL TIMES LT BLU WIRE LT BLU/BRN WIRE LT BLU/ORG WIRE OF ENGINE) ORG/ WIRE POWERTRAIN CONTROL MODULE (RIGHT REAR OF ENGINE COMPARTMENT) RELAY CONTROL SENS GND SENSOR GND SIGNAL SRT-10 TOTALLY INTEGRATED POWER MODULE (AT LEFT FRONT FENDER) VIO/ORG WIRE WHT WIRE YEL/PNK WIRE

B(+) CAN B BUS (+) BLK WIRE CAN B BUS (+) ELECTRONICS FUSE 5 FUSED B (+) GROUND HOT AT ALL TIMES LT BLU WIRE ORG/ WIRE ORG/LT BLU WIRE ORG/LT GRN WIRE ORG/TAN WIRE ORG/YEL WIRE RED WIRE RED/LT BLU WIRE SUNROOF CLOSE SW SENSE SUNROOF MOTOR/ MODULE SUNROOF SW SUPPLY SUNROOF SWITCH SUNROOF VENT SW SENSE SUNROOF OPEN SW SENSE TOTALLY INTEGRATED POWER MODULE (AT LEFT FRONT FENDER) WHT WIRE WHT/ORG WIRE

B(+) BLK WIRE CAN B BUS (+) COMPUTER DATA LINES SYSTEM DK BLU WIRE DK BLU/WHT WIRE ELECTRONICS FUSED IGN HEATED BACKLITE HOT AT ALL TIMES MIDDLE NCA WIRE ORG/ WIRE TOTALLY INTEGRATED POWER MODULE (AT LEFT FRONT FENDER) WHT WIRE