Dodge Cab & Chassis R2500 (1996-2006) blk/dk blu Wiring diagrams

2 4 6 8 FUSED IGN (ST/RUN) SENSOR GND PNP SW SENSE ENG SPEED SENS SIG 22 23 31 32 FUSED B(+) TP SENS SIG GND GND 40 41 CCD (-) CCD (+) 6 13 24 25 OD LAMP DRIVER TRANS OD SW SENSE BRAKE SW SENSE GENERATOR OUTPUT 9 10 11 PNK WIRE BLK WIRE BLK/DK BLU WIRE BLK/LT BLU WIRE BLK/LT GRN WIRE BLK/TAN WIRE BLK/WHT WIRE BRN WIRE CCD (+) CCD (-) CSI RECEIVE DATA LINK CONNECTOR (PARTIAL) (LEFT BOTTOM OF DASH) DK BLU WIRE DK BLU/BLK WIRE ENGINE CONTROL MODULE ENGINE CONTROL MODULE (LEFT SIDE OF ENG, BEHIND FUEL FILTER) FUSE 14 FUSE 9 GRY WIRE GRY/BLK WIRE HOT AT ALL TIMES HOT IN RUN OR START IND INSTRUMENT CLUSTER JOINT CONNECTOR 1 JOINT CONNECTOR 3 JOINT CONNECTOR 6 JOINT CONNECTOR 7 JUNCTION BLOCK LT GRN WIRE LT GRN/BLK WIRE LT GRN/ORG WIRE LT GRN/WHT WIRE MIL IND ORG/ WIRE ORG/BLK WIRE ORG/DK BLU WIRE ORG/WHT WIRE OVER- DRIVE OFF IND OVERDRIVE SWITCH PNK SCI TRANSIT WIRE PNK WIRE POWERTRAIN CONTROL MODULE (IN ENG COMPT, ON RIGHT SIDE OF FIREWALL) RED/WHT WIRE SENSOR GND SENSOR GROUND ECT SIG CKP SIG TPS SIG ENG SPEED SENS SIG STOP LAMP SWITCH (TOP OF BRAKE PEDAL BRACKET) SWITCH (ON FRONT AXLE TUBE) TAN/BLK WIRE TRANSMISSION OUTPUT SHAFT SPEED SENSOR (ON LEFT SIDE OF TRANSMISSION) VIO WIRE VIO/BRN WIRE VIO/WHT WIRE WHT WIRE WHT/BLK WIRE WHT/ORG WIRE WHT/PNK WIRE YEL WIRE

5 VOLT SUPPLY 9 10 11 PNK WIRE BLK WIRE BLK/DK BLU WIRE BLK/LT BLU WIRE BLK/WHT WIRE BRN WIRE CONTROLLER ANTI-LOCK BRAKE DK BLU WIRE ENGINE CONTROLS SYSTEM ENGINE COOLANT TEMPERATURE SENSOR (ON LEFT SIDE OF CYLINDER HEAD, AT REAR END) ENGINE SPEED SENSOR (ON FRONT OF ENG, IN TIMING CHAIN CASE/COVER) ENGINE STARTER MOTOR RELAY FUSE FUSE 3 GENERATOR GOVERNOR PRESSURE SIGNAL SENSOR GROUND VARIABLE FORCE SOLENOID CONTROL GRN WIRE GRY WIRE HOT AT ALL TIMES INNER FENDER) JOINT CONNECTOR 2 LT BLU WIRE LT GRN/WHT WIRE OF HYDRAULIC CONTROL UNIT) ORG/ WIRE ORG/BLK WIRE OVERDRIVE SOLENOID CONTROL TORQUE CONVERTER CLUTCH SOLENOID CONTROL PARK/ NEUTRAL POSITION SWITCH (ON LEFT SIDE OF TRANSMISSION) PNK WIRE POWER DISTRIBUTION CENTER RED WIRE RED/WHT WIRE TAN WIRE TAN/BLK WIRE TRANS CTRL RLY OUTPUT TRANSMISSION CONTROL RELAY TRANSMISSION SOLENOID ASSEMBLY (TRANSMISSION) TRANSMISSION TEMPERATURE SENSOR SIGNAL VIO WIRE VIO/WHT WIRE WHT WIRE WHT/ORG WIRE YEL WIRE

1 2 SENSOR GROUND SENSOR SIGNAL A/C COMPRESSOR CLUTCH RELAY A/C HEATER CONTROL A/C INDICATOR A/C SELECT BLEND DOOR DRIVER BLK/DK BLU WIRE BLK/TAN WIRE BLOWER MOTOR (BENEATH LOWER RIGHT SIDE OF DASH, ON HVAC ASSEMBLY) BLOWER MOTOR RESISTOR BLOCK (BENEATH LOWER RIGHT SIDE OF DASH, ON HVAC ASSEMBLY) BLU WIRE COMMON DOOR DRIVER CONDENSER FAN RELAY DATA LINK CONNECTOR (BELOW LEFT SIDE OF DASH) DIESEL DK BLU WIRE DK BLU/BLK WIRE DK BLU/GRY WIRE DK BLU/ORG WIRE DK BLU/PNK WIRE DK BLU/RED WIRE DK BLU/WHT WIRE DK BLU/YEL WIRE DK DK DK DK DK DK DK DK DK LT PNK W/DUAL ZONE A/C WIRE DK GRN WIRE DK GRN/YEL WIRE EVAPORATOR TEMPERATURE SENSOR (BEHIND RIGHT SIDE OF DASH, INSIDE HVAC ASSEMBLY) FUSE 16 FUSE 12 PTC 1 FUSE 36 GRN WIRE GRY WIRE GRY/DK BLU WIRE HEATED MIRROR RELAY HEATER MIRROR INDICATOR HOT AT ALL TIMES HOT IN HOT IN RUN OR START HVAC MICRO CONTROLLER IGNITION SWITCH INSTRUMENT CLUSTER INTEGRATED POWER MODULE (ON LEFT FRONT OF ENGINE COMPARTMENT) LOCK OFF LT BLU WIRE LT BLU/VIO WIRE LT BLU/YEL WIRE LT GRN WIRE LT GRN/BLK WIRE OFF OFF HEATED MIRROR ORG/YEL WIRE PANEL LAMPS DRIVER PASS BLEND DOOR DRIVER RECIRC RECIRCULATION DOOR ACTUATOR (BEHIND RIGHT SIDE OF DASH, ON HVAC ASSEMBLY) RECIRCULATION DOOR DRIVER RECIRCULATION INDICATOR RED WIRE RED/BLK WIRE RUN WIRE TAN WIRE VIO/LT GRN WIRE WHT WIRE WHT/BLK WIRE YEL WIRE YEL/LT GRN WIRE

A/C COM- PRESSOR CLUTCH A/C FUEL COM- SHUT PRESSOR DOWN FUEL CLUTCH SOLENOID HEATER AIRBAG CONTROL MODULE RADIO BLK WIRE BLK/DK BLU WIRE BLK/LT GRN WIRE BLK/PNK WIRE BLK/TAN WIRE BLK/VIO WIRE BLK/WHT WIRE BLOWER MOTOR RELAY BRAKE UNDER- HOOD WIPER PRESSURE LAMP MOTOR SWITCH CONTROLLER GENERATOR ANTI-LOCK BRAKE DATA LINK CONNECTOR DAYTIME RUNNING LAMP MODULE DIESEL DIESEL ONLY ENGINE STARTER MOTOR RELAY FOG LAMP RELAY FUEL HEATER RELAY FUEL PUMP MODULE FUEL PUMP RELAY FUEL SHUT DOWN RELAY GAS HIGH NOTE HORN J/C 1 (IN PDC) J/C 3 J/C 4 LEFT BACK-UP LAMP LEFT FOG LAMP LEFT HEADLAMP LEFT PARK/TURN SIGNAL LAMP LEFT RIGHT FRONT FRONT DOOR DOOR SPEAKER SPEAKER LEFT UPSTREAM HEATED OXYGEN POWERTRAIN SENSOR CONTROL MODULE LOW NOTE HORN LOW WASHER FLUID SWITCH POWER DISTRIBUTION CENTER POWERTRAIN CONTROL MODULE PREMIUM RADIO CHOKE RELAY RIGHT HEADLAMP RIGHT PARK/TURN SIGNAL LAMP RIGHT RIGHT BACK-UP LICENSE TRAILER LAMP LAMP TOW CON- NECTOR RIGHT TAIL/ STOP/TURN SIGNAL LAMP SWITCH TOP OF TRANSMISSION) TRAILER TOW RELAY VEHICLE SPEED CONTROL SERVO RIGHT FOG LAMP WINDSHIELD WASHER PUMP MOTOR

B(+) BLK/DK BLU WIRE BLK/ORG WIRE CLOCKSPRING (ON STEERING COLUMN) DK GRN WIRE DK GRN/VIO WIRE FUSE 11 GRY WIRE GRY/LT BLU WIRE GRY/RED WIRE GRY/YEL WIRE HORN 1 (LEFT FRONT FENDER) HORN 2 (LEFT FRONT FENDER) HORN CONTROL OUTPUT HORN SWITCH HOT AT ALL TIMES INSTRUMENT CLUSTER LT BLU WIRE RED WIRE VIO WIRE YEL WIRE

AMPLIFIER AUDIO (BEHIND UPPER RIGHT SIDE OF DASH) ANTENNA BLK WIRE BLK/DK BLU WIRE BLK/DK GRN WIRE BLK/LT BLU WIRE BRN/LT BLU WIRE BRN/RED WIRE BRN/YEL WIRE CENTER INSTRUMENT PANEL SPEAKER CLOCKSPRING DATA LINK CONNECTOR (BELOW LEFT SIDE OF DASH) DK BLU/BLK WIRE DK BLU/ORG WIRE DK BLU/RED WIRE DK BLU/WHT WIRE DK GRN WIRE DK GRN/RED WIRE FUSE 21 FUSE 51 FUSED B (+) GROUND GRY/WHT WIRE HOT AT ALL TIMES HOT IN RUN OR ACC INSTRUMENT CLUSTER RADIO CTRL MUX INTEGRATED POWER MODULE (ON LEFT FRONT OF ENGINE COMPT) L I/P SPKR - LEFT FRONT DOOR SPEAKER LEFT INSTRUMENT PANEL SPEAKER LEFT REAR SPEAKER LF DR SPKR+ LF SPKR LR SPKR LR SPKR (+) LR SPKR (-) RR SPKR (-) RR SPKR (+) GROUND LT BLU WIRE LT BLU/BLK WIRE LT BLU/RED WIRE LT BLU/VIO WIRE LT GRN/DK GRN WIRE LT GRN/RED WIRE NCA WIRE ORG/BLK WIRE ORG/DK BLU WIRE ORG/RED WIRE PCI BUS PCI BUS FUSED B(+) IGN SWITCH PNK WIRE PRESET PTC 2 + R I/P SPKR (-) RADIO REMOTE RADIO SWITCH LEFT RF DR SPKR+ RF SPKR RF SPKR (+) RF SPKR (-) LF SPKR (-) LF SPKR (+) GROUND FUSED B(+) RIGHT FRONT DOOR SPEAKER RIGHT INSTRUMENT PANEL SPEAKER RIGHT REAR SPEAKER RR SPKR SEEK DN SEEK UP TAN/BLK WIRE TAN/VIO WIRE VIO WIRE VIO/GRY WIRE VIO/LT BLU WIRE VOL DN REMOTE RADIO SWITCH RIGHT VOL UP WHT/BLK WIRE WHT/RED WIRE YEL WIRE YEL/BLK WIRE YEL/RED WIRE

1 2 CCD BUS (+) CCD BUS (-) 14 16 17 MUX CTRL CCD (+) CCD (-) ANTENNA BLK WIRE BLK/DK BLU WIRE BLK/LT GRN WIRE BLK/VIO WIRE BLK/YEL WIRE BRN/LT BLU WIRE BRN/RED WIRE BRN/YEL WIRE CENTRAL TIMER MODULE (LEFT SIDE OF DASH, RIGHT OF STEERING COLUMN) CLOCK SPRING 1 DAY BRIGHTNESS SENSE DIMMER DK BLU/ORG WIRE DK BLU/RED WIRE DK BLU/WHT WIRE DK GRN WIRE FUSE 1 FUSE 12 FUSE 5 FUSE 8 GROUND HEAD OFF HEADLAMP SWITCH HOT AT ALL TIMES HOT IN RUN OR ACC INSTRUMENT CLUSTER JOINT CONNECTOR 5 (LEFT SIDE OF DASH) JOINT CONNECTOR 6 (LEFT SIDE OF DASH) JOINT CONNECTOR 7 (BEHIND LEFT SIDE OF DASH) JOINT CONNECTOR 8 (LEFT END OF DASH, NEAR JUNCTION BLOCK) JUNCTION BLOCK (LEFT END OF DASH) LEFT FRONT DOOR SPEAKER LEFT REAR SPEAKER LEFT REMOTE RADIO SWITCH LF SPKR (-) RF SPKR (-) DAY SENSE DIMMER SIG FUSED IGN FUSED B(+) LR SPKR (+) RR SPKR (+) LF SPKR (+) RF SPKR (+) LR SPKR (-) RR SPKR (-) NCA WIRE ORG/ WIRE PNK WIRE PRESET RADIO RED WIRE RED/BLK WIRE RED/WHT WIRE RIGHT FRONT DOOR SPEAKER RIGHT REAR SPEAKER SEEK DN SEEK UP TAN WIRE VIO WIRE VIO/BRN WIRE VOL DN RIGHT REMOTE RADIO SWITCH VOL UP WHT WIRE WHT/BLK WIRE YEL WIRE

BLK WIRE BLK/DK BLU WIRE BLK/LT BLU WIRE BLK/WHT WIRE BLK/YEL WIRE BRN/ORG WIRE CAMSHAFT POSITION SENSOR CCD(-) CUMMINS BUS (-) DATA LINK CONNECTOR (LEFT BOTTOM OF DASH) DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE FUEL HEATER (IN TOP OF FUEL FILTER HOUSING) FUEL TRANSFER PUMP (ON LOWER LEFT SIDE OF ENG, BELOW REARWARD OF FUEL FILTER) FUSE 17 FUSE 11 FUSE 9 GRY WIRE GRY/BLK WIRE HOT IN RUN OR START IND INSTRUMENT CLUSTER JOINT CONNECTOR JOINT CONNECTOR 7 (LEFT SIDE OF INSTRUMENT PANEL) JUNCTION BLOCK (LEFT END OF DASH) LT BLU/BLK WIRE LT GRN/BLK WIRE LT GRN/DK BLU WIRE NCA WIRE ORG/ WIRE ORG/BLK WIRE ORG/DK BLU WIRE PNK/DK BLU WIRE PTO SWITCH RED/BLK WIRE RED/TAN WIRE RED/WHT WIRE VIO/BRN WIRE VIO/WHT WIRE WAIT TO WHT/BLK WIRE WHT/ORG WIRE WHT/PNK WIRE WHT/VIO WIRE YEL/DK BLU WIRE YEL/LT GRN WIRE YEL/WHT WIRE

ACC PEDAL POS SENS BATTERY BLK WIRE BLK/DK BLU WIRE BLK/LT BLU WIRE BLK/RED WIRE BLK/TAN WIRE BLK/YEL WIRE BRN/ORG WIRE BRN/WHT WIRE CMPSENS SIG FAULT SIG CRUISE CONTROL SYSTEM DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE DK GRN/RED WIRE ENGINE CONTROL MODULE (ON LEFT SIDE OF ENG, BEHIND FUEL FILTER) ENGINE OIL PRESSURE SENSOR (ON LEFT SIDE OF ENG, NEAR NEAR ECM) FUEL INJECTION PUMP (ON LEFT SIDE OF ENG, ON REAR OF TIMING GEAR HOUSING) FUEL PUMP RELAY (IN PDC) FUSE B(+) GND FUSED B(+) FUSIBLE LINKS GRY WIRE GRY/BLK WIRE GRY/RED WIRE INTAKE AIR HEATER INTAKE AIR HEATER RELAY 1 (ON LEFT INNER FENDER, BELOW LEFT BATTERY) INTAKE AIR HEATER RELAY 2 (ON LEFT INNER FENDER, BELOW LEFT BATTERY) INTAKE AIR TEMPERATURE SENSOR (IN LEFT REAR SIDE OF INTAKE MANIFOLD) JOINT CONNECTOR 1 (IN PDC) JOINT CONNECTOR 2 (IN PDC) LT BLU/BLK WIRE LT BLU/RED WIRE LT GRN/BLK WIRE LT GRN/DK BLU WIRE MANIFOLD AIR PRESSURE SENSOR (LEFT REAR SIDE OF INTAKE MANIFOLD) NCA WIRE ORG/ WIRE ORG/BLK WIRE ORG/BRN WIRE ORG/DK BLU WIRE PNK/DK BLU WIRE RED/LT GRN WIRE RED/WHT WIRE SENSOR GND CUMMIN BUS (-) DL (+) FUEL INJ PMP ECT SENS SIG TRANS PMP PWR TAN/BLK WIRE VIO/BRN WIRE VIO/ORG WIRE VIO/WHT WIRE WHT WIRE WHT/BLK WIRE WHT/ORG WIRE WHT/PNK WIRE YEL/BLK WIRE YEL/DK BLU WIRE YEL/LT GRN WIRE YEL/RED WIRE YEL/WHT WIRE