Chevrolet Volt I (2010-2015) vio/blk Wiring diagrams

1 2 3 INTERIOR LAMP CTRL INADVERTENT POWER CTRL BACKUP LAMP SPLY VOLT ACCESSORY VOLTAGE IGNITION 1 VOLTAGE ANTI-THEFT SYSTEM ANTI-THEFT SYSTEM ANTI-THEFT SYSTEM CRUISE CONTROL SYSTEM APO/EXT LIGHTS BCM/EXT LIGHTS BCM/EXT LIGHTS FUSE BLK WIRE BLK/BRN WIRE BLK/GRY WIRE BLK/YEL WIRE BODY CONTROL MODULE BRN WIRE BRN/LT GRN WIRE BRN/WHT WIRE BRN/YEL WIRE COMPUTER DATA LINES SYSTEM COMPUTER DATA LINES SYSTEM DOOR LOCKS SYSTEM DOOR LOCKS SYSTEM SHIFT INTERLOCK SYSTEM DOOR LOCKS, ANTI-THEFT SYSTEMS DRIVER DR LK SW LOCK SIG EXTERIOR LIGHTS SYSTEM INTERIOR LIGHTS SYSTEM COMPUTER DATA LINES SYSTEM EXTERIOR LIGHTS SYSTEM WIPER/WASHER SYSTEM EXTERIOR LIGHTS SYSTEMS FUSE GRY WIRE GRY/BLK WIRE GRY/LT GRN WIRE GRY/WHT WIRE HDLP SW FLASH TO PASS SIG HORN SWITCH SIGNAL HEADLAMP SW ON SIG HEADLAMPS OFF SIG CTRL HEADLIGHTS SYSTEM HEADLIGHTS SYSTEM HORNS SYSTEM HI SPD GMLAN SERIAL DATA + HI SPD GMLAN SERIAL DATA - HOT AT ALL TIMES INSTRUMENT CLUSTER SYSTEM INTERIOR LIGHTS SYSTEM INTERCONNECT NETWORK BUS 4 LOW SPD GMLAN SERIAL DATA INTERIOR LAMP DEFEAT SW SIG INTERIOR LIGHTS SYSTEM DOOR LOCKS, ANTI-THEFT SYSTEMS LEFT INSTRUMENT PANEL FUSE BLOCK (BEHIND LEFT END OF DASH) LO SPD GMLAN SERIAL DATA LOW REF LR CHILD SECURITY MTR LOCK STATUS SIG SHIFT POSITION SIG LT BLU WIRE LT BLU/BLK WIRE LT BLU/BRN WIRE LT BLU/LT GRN WIRE LT BLU/VIO WIRE LT BLU/WHT WIRE LT BLU/YEL WIRE LT GRN WIRE LT GRN/BRN WIRE LT GRN/GRY WIRE LT GRN/RED WIRE LT GRN/VIO WIRE LT GRN/WHT WIRE LT HDLP FUSE POWER DISTRIBUTION SYSTEM RED WIRE RED/BRN WIRE RED/LT BLU WIRE RED/LT GRN WIRE RED/VIO WIRE RED/YEL WIRE REMOTE FUNCTION SPLY VOLT HAZARD SWITCH SIGNAL REMOTE FUNCTION ACTUATOR RF TURN SIGNAL SW SIG WINDSHIELD WASHER SW SIG RR CHILD SECURITY MTR LOCK STATUS SIG COURTESY LAMP SW SIG RR TURN LP FEEDBACK SIG IP LP DIMMING CTRL RT HDLP FUSE SHIFT INTERLOCK SYSTEM INTERIOR LIGHTS SYSTEM VIO WIRE VIO/BLK WIRE VIO/YEL WIRE WHT WIRE WHT/BLK WIRE WHT/BRN WIRE WHT/LT BLU WIRE WHT/RED WIRE WHT/VIO WIRE WINDSHIELD WIPER SW HI SIG WIPER/WASHER SYSTEM YEL WIRE YEL/BRN WIRE YEL/GRY WIRE YEL/LT BLU WIRE YEL/LT GRN WIRE

ANTI-THEFT SYSTEM BATTERY BLK WIRE BLK/BRN WIRE BLK/VIO WIRE BODY CONTROL MODULE (UNDER RIGHT SIDE OF DASH) BRN/GRY WIRE BRN/LT GRN WIRE BRN/VIO WIRE BRN/WHT WIRE BRN/YEL WIRE CHILD SECURITY LOCK RLY CTRL COMPUTER DATA LINES SYSTEM CURRENT SENSOR SIGNAL DOOR LOCKS, ANTI-THEFT SYSTEMS END GATE LATCH RLY SPLY VOL CRUISE/ETC/TCC BRAKE SIGNAL ENGINE CONTROLS SYSTEM ENGINE CONTROLS SYSTEM COMPUTER DATA LINES SYSTEM GROUND GRY WIRE GRY/LT BLU WIRE GRY/LT GRN WIRE HEADLAMP HIGH BEAM RLY CTRL HORN RLY CTRL HEADLIGHTS SYSTEM HEADLIGHTS SYSTEM ENGINE CONTROLS SYSTEM EXTERIOR LIGHTS SYSTEM HEADLIGHTS SYSTEM HORNS SYSTEM HI SPEED GMLAN SERIAL DATA(+) HI SPEED GMLAN SERIAL DATA(-) HOT AT ALL TIMES INT LAMPS FUSE INTERCONNECT NETWORK BUS 3 LR TURN SIG LAMP SPLY VOLT LT BLU WIRE LT BLU/VIO WIRE LT BLU/WHT WIRE LT GRN WIRE LT GRN/BRN WIRE LT GRN/VIO WIRE LT GRN/YEL WIRE REAR CLOSURE HANDLE SW OPEN SIG INTERCONNECT NETWORK BUS 1 REAR TURN LAMP FEEDBACK SIG RED WIRE RED/GRY WIRE RED/LT GRN WIRE RIGHT INSTRUMENT PANEL FUSE BLOCK (BEHIND RIGHT SIDE OF INSTRUMENT PANEL) RUN IGNITION 3 VOLTAGE TRN SIG LCKS FUSE TRUNK, TAILGATE, FUEL DOORS SYSTEM TRUNK, TAILGATE, FUEL DOORS SYSTEM COMPUTER DATA LINES SYSTEM VIO WIRE VIO/BLK WIRE VIO/BRN WIRE VIO/GRY WIRE VIO/YEL WIRE WHT WIRE WHT/LT BLU WIRE WHT/VIO WIRE WHT/YEL WIRE YEL WIRE YEL/BRN WIRE YEL/LT BLU WIRE

13 7 1 SENS SPLY VOLT SENS SIG B+ VOLT 24 12 RIGHT TURN SW SIG LEFT TURN SW SIG BCM/EXT LIGHTS FUSE BLK WIRE BLK/BRN WIRE BODY CONTROL MODULE (UNDER RIGHT SIDE OF DASH) BRAKE PEDAL POSITION SENSOR (TOP OF BRAKE PEDAL ASSEMBLY) BRAKE SIG BRN/YEL WIRE COMPUTER DATA LINES SYSTEM ENGINE COMPT) ENGINE CONTROL MODULE (ECM) (LEFT FRONT CORNER OF ENGINE COMPT) FEEDBACK SIG HAZARD SW SIG HAZARD SWITCH HEAD HOT AT ALL TIMES LEFT LEFT INSTRUMENT PANEL FUSE BLOCK (BEHIND LEFT END OF DASH) LEFT REAR TURN SIGNAL LAMP LEFT STOP LAMP LEFT TAIL LAMP LEFT TAIL LAMP ASSEMBLY LF TURN SIG SPLY VOLT TAIL LP SPLY VOLT LR TURN SIG SPLY VOLT 7 1 LOGIC LOW REF LT BLU/WHT WIRE LT BLU/YEL WIRE LT GRN WIRE LT GRN/GRY WIRE LT GRN/VIO WIRE LT GRN/WHT WIRE LT GRN/YEL WIRE NETWORK BUS 4 PARK AUTO OFF PARK LAMP SIG RADIO/HVAC CONTROLS RED/BRN WIRE RIGHT RIGHT REAR TURN SIGNAL LAMP RIGHT STOP LAMP RIGHT TAIL LAMP RIGHT TAIL LAMP ASSEMBLY SERIAL DATA TURN SIGNAL/ MULTI-FUNCTION SWITCH UNDERHOOD FUSE BLOCK (LEFT SIDE OF VIO WIRE VIO/BLK WIRE WHT WIRE WHT/BLK WIRE WHT/LT BLU WIRE WHT/VIO WIRE WHT/YEL WIRE YEL/BRN WIRE

1 2 RH HDLP LO SPLY VOLT LH HDLP LO SPLY VOLT 18 12 LOCK MTR STATUS SIG RR LOCK MTR STATUS SIG LR 2 4 DR LCK CTRL (2) ACTR UNLCK CTRL 24 25 GMLAN SER DATA (-) GMLAN SER DATA (+) 27 16 15 19 2 TRANS SIG ACTR RTN UNLCK SIG LCK SIG GND 6 5 IGN VOLT ACC VOLT ACTR RTN B+ GND B+ GND ACC VOLT 2 3 4 5 6 BATT POS VOLT BLK LT GRN/ WIRE BLK WIRE BLK/BRN WIRE BLK/GRY WIRE BODY CONTROL MODULE (UNDER RIGHT SIDE OF DASH) BRN/LT GRN WIRE BRN/WHT WIRE BRN/YEL WIRE COMPUTER DATA LINES COMPUTER DATA LINES SYSTEM DOOR LOCK RELAY DR LOCK CTRL LOCK CTRL 2 GMLAN SERIAL DATA GRY WIRE GRY/BLK WIRE GRY/LT GRN WIRE GRY/WHT WIRE HEADLIGHTS SYSTEM HOOD AJAR SW SIG HORN RLY CTRL HORNS SYSTEM LT BLU WIRE LT BLU/ WHT WIRE LT BLU/BRN WIRE LT BLU/WHT WIRE LT GRN WIRE LT GRN YEL/ WIRE LT GRN/BLK WIRE ORG/ WIRE ORG/LT BLU WIRE RADIO/HVAC CONTROLS RCV SIG RED/BRN WIRE RED/WHT WIRE RLY CTRL SPLY VOLT SW SIG 2 LOW REF SYSTEM TRANS SIG VEHICLE ON/OFF SWITCH VIO/BLK WIRE VIO/YEL WIRE WHT WIRE WHT/LT BLU WIRE YEL WIRE YEL/LT GRN WIRE

1 2 RH HDLP LO SPLY VOLT LH HDLP LO SPLY VOLT 18 12 LOCK MTR STATUS SIG RR LOCK MTR STATUS SIG LR 2 4 DR LCK CTRL (2) ACTR UNLCK CTRL 24 25 GMLAN SER DATA (-) GMLAN SER DATA (+) 27 16 15 19 2 TRANS SIG ACTR RTN UNLCK SIG LCK SIG GND 6 5 IGN VOLT ACC VOLT ACTR RTN B+ GND B+ GND ACC VOLT 2 3 4 5 6 BATT POS VOLT BLK LT GRN/ WIRE BLK WIRE BLK/BRN WIRE BLK/GRY WIRE BODY CONTROL MODULE (UNDER RIGHT SIDE OF DASH) BRN/LT GRN WIRE BRN/WHT WIRE BRN/YEL WIRE COMPUTER DATA LINES COMPUTER DATA LINES SYSTEM DOOR LOCK RELAY DR LOCK CTRL LOCK CTRL 2 GMLAN SERIAL DATA GRY WIRE GRY/BLK WIRE GRY/LT GRN WIRE GRY/WHT WIRE HEADLIGHTS SYSTEM HOOD AJAR SW SIG HORN RLY CTRL HORNS SYSTEM LT BLU WIRE LT BLU/ WHT WIRE LT BLU/BRN WIRE LT BLU/WHT WIRE LT GRN WIRE LT GRN YEL/ WIRE LT GRN/BLK WIRE ORG/ WIRE ORG/LT BLU WIRE RADIO/HVAC CONTROLS RCV SIG RED/BRN WIRE RED/WHT WIRE RLY CTRL SPLY VOLT SW SIG 2 LOW REF SYSTEM TRANS SIG VEHICLE ON/OFF SWITCH VIO/BLK WIRE VIO/YEL WIRE WHT WIRE WHT/LT BLU WIRE YEL WIRE YEL/LT GRN WIRE

AUTOMATIC TRANSMISSION ASSEMBLY BLK WIRE BLK/BRN WIRE BODY CONTROL MODULE (UNDER RIGHT SIDE OF DASH) BRAKE APPLY SENS SUPPLY VOLTAGE BRAKE APPLY SENSOR SIGNAL BRAKE PEDAL POSITION SENSOR (TOP OF BRAKE PEDAL ASSEMBLY) BRN WIRE COLUMN LCK POS SIG COMPUTER DATA LINES COMPUTER DATA LINES SYSTEM CONTROL SOLENOID VALVE ASSEMBLY FUSE HI SPEED GMLAN SERIAL DATA BUS - LOGIC LOW REF LT BLU WIRE LT BLU/YEL WIRE LT GRN WIRE NCA WIRE PARK LOCK SOLENOID CONTROL PARK POSITION SWITCH RED WIRE RED/LT BLU WIRE SERIAL DATA SYSTEM TRANS- MISSION CONTROL MODULE TRANSMISSION INTERNAL MODE SWITCH TRANSMISSION SHIFT LEVER TRANSMISSION SHIFT LOCK CONTROL SOLENOID ACTUATOR VIO/BLK WIRE WHT WIRE WHT/VIO WIRE YEL WIRE

A/C REFRIGERANT PRESSURE SENSOR (RIGHT FRONT OF ENGINE COMPT) BLK/BRN WIRE BLK/GRN WIRE BLK/GRY WIRE BLK/VIO WIRE BLK/YEL WIRE BRN/RED WIRE BRN/VIO WIRE BRN/YEL WIRE CRANKSHAFT POSITION (CKP) SENSOR EXHAUST CAMSHAFT POSITION SENSOR FUEL PRESSURE SENSOR (FUEL LINE AT RIGHT FRONT OF FUEL TANK) GRY/LT BLU WIRE GRY/WHT WIRE GRY/YEL WIRE INTAKE CAMSHAFT POSITION SENSOR (RIGHT FRONT OF CYLINDER HEAD) KNOCK SENSOR (RIGHT SIDE OF ENGINE) LT BLU/VIO WIRE LT BLU/WHT WIRE LT GRN WIRE LT GRN/LT BLU WIRE LT GRN/YEL WIRE VIO/BLK WIRE VIO/BRN WIRE VIO/GRY WIRE VIO/LT BLU WIRE WHT/BLK WIRE YEL/LT BLU WIRE YEL/VIO WIRE YEL/WHT WIRE

5 VOLT REF LOW REF BLK WIRE BLK/BRN WIRE BLK/GRN WIRE BLK/GRY WIRE BLK/VIO WIRE BLK/YEL WIRE BRN/LT BLU WIRE BRN/LT GRN WIRE BRN/RED WIRE BRN/VIO WIRE BRN/WHT WIRE BRN/YEL WIRE CAMSHAFT CAM X SUP VOLT 1 CAMSHAFT POS EXHAUST SENS 1 CAMSHAFT POS IN SENS SPY VOLT 1 CAMSHAFT POS INTAKE SENS 1 CMP PHASER EXHAUST SOL 1 CMP PHASER INTAKE SOL 1 ENGINE CONTROL MODULE (ECM) (LEFT FRONT CORNER OF ENGINE COMPT) ENGINE COOLANT THERMOSTAT HEATER (LEFT FRONT OF ENGINE) GROUND GRY/LT BLU WIRE GRY/WHT WIRE GRY/YEL WIRE IGN CTRL (2) IGN CTRL (4) INSTRUMENT CLUSTER SYSTEM KNOCK SENSOR SIG 1 LOW REF LOW REF LOW REF LT BLU WIRE LT BLU/VIO WIRE LT BLU/WHT WIRE LT GRN WIRE LT GRN/LT BLU WIRE LT GRN/YEL WIRE POWERTRAIN MAIN RLY FUSE SPLY 1 LOW REF LOW REF OIL PRESSURE SW SIG THROTTLE BODY ASSEMBLY (ON INTAKE MANIFOLD ASSEMBLY) THROTTLE POSITION SENSOR SIG 1 THROTTLE POSITION SENSOR SIG 2 VIO/BLK WIRE VIO/BRN WIRE VIO/GRY WIRE VIO/LT BLU WIRE WHT/BLK WIRE YEL WIRE YEL/LT BLU WIRE YEL/VIO WIRE YEL/WHT WIRE

1 2 3 12 13 14 33 34 COS + SIN + EXCITATION - COS - SIN - EXCITATION + SIG RTN AIR CONDITIONING SYSTEM AUTOMATIC TRANSMISSION ASSEMBLY BATT POS VOLT SERIAL DATA + BLK WIRE BLK/WHT WIRE BLU WIRE BRN WIRE BRN/WHT WIRE BRN/YEL WIRE COMPUTER DATA LINES SYSTEM DRIVE MOTOR 1 TEMPERATURE SENSOR DRIVE MOTOR 2 DRIVE MOTOR 2 TEMPERATURE SENSOR DRIVE MOTOR CONTROL MODULE 1 DRIVE MOTOR CONTROL MODULE 2 GRN WIRE GROUND SHIELD GRY WIRE HOT AT ALL TIMES HOT W/ IGNITION MAIN RELAY ENERGIZED HYBRID POWERTRAIN CONTROL MODULE 1 LT BLU WIRE LT BLU/BLK WIRE LT BLU/YEL WIRE LT GRN WIRE NCA WIRE ORG/ WIRE RED WIRE RED/LT BLU WIRE RED/VIO WIRE RED/YEL WIRE SERIAL DATA + SERIAL DATA - SERIAL DATA + SERIAL DATA - SERIAL DATA + TPIM FUSE TPIM/TCM FUSE UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT) VICM FUSE VIO/BLK WIRE VIO/LT GRN WIRE WHT WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE YEL WIRE

AUTOMATIC TRANSMISSION ASSEMBLY AUXILIARY TRANSMISSION FLUID PUMP AUXILIARY TRANSMISSION FLUID PUMP CONTROL MODULE BATT POS VOLT BLK WIRE BLK/WHT WIRE BLK/YEL WIRE BLU WIRE BLU/GRY WIRE BRN WIRE BRN/YEL WIRE COMPUTER DATA LINES SYSTEM DK GRN WIRE DRIVE MOTOR 1 ENGINE CONTROLS CIRCUIT GRN WIRE GRN/BRN WIRE GRY WIRE GRY/ORG WIRE HYBRID POWERTRAIN CONTROL MODULE 1 IMS MODE SW S SIG LOGIC LT BLU WIRE LT BLU/WHT WIRE LT BLU/YEL WIRE LT GRN WIRE LT GRN/RED WIRE LT GRN/YEL WIRE NCA WIRE ORG/ WIRE POWER INVERTER MODULE (LEFT SIDE OF ENGINE COMPT) RED WIRE RED/LT BLU WIRE RED/YEL WIRE RUN/CRNK IGN 1 VOLT SERIAL DATA 2 SIG GND SNSR SIG TRANSMISSION INTERNAL MODE SWITCH VIO WIRE VIO/BLK WIRE VIO/GRN WIRE WHT WIRE WHT/LT GRN WIRE WHT/YEL WIRE YEL WIRE YEL/BLK WIRE YEL/LT GRN WIRE YEL/RED WIRE