Chevrolet Volt I (2010-2015) breakout) Wiring diagrams

BLK WIRE BLK/BRN WIRE BRAKE FLUID LEVEL SWITCH BREAKOUT) CHARGE PORT DOOR OPEN REQUEST SWITCH DRIVER DOOR LATCH ASSEMBLY DRIVER EXTERIOR DOOR HANDLE ASSEMBLY DRIVER LEFT OUTSIDE TURN REARVIEW SIGNAL MIRROR REPEATER GLASS LAMP DRIVER OUTSIDE REARVIEW MIRROR DRIVER WINDOW MOTOR DRIVER WINDOW SWITCH FRONT, REAR PARKING ASSIST CONTROL MODULE HYBRID/EV BATTERY BATTERY ENERGY CONTACTOR CONTROL ASSEMBLY MODULE HYBRID/EV BATTERY PACK HYBRID/EV POWERTRAIN CONTROL MODULE 2 MULTI-AXIS ACCELERATION SENSOR NCA WIRE OUTSIDE REARVIEW MIRROR SWITCH PASSENGER COMPARTMENT HEATER COOLANT COOLANT HEATER CONTROL CONTROL VALVE MODULE PASSENGER DOOR LATCH ASSEMBLY PASSENGER EXTERIOR DOOR HANDLE ASSEMBLY PASSENGER OUTSIDE REARVIEW MIRROR PASSENGER OUTSIDE REARVIEW MIRROR GLASS PASSENGER PRESENCE DETECTION MODULE PASSENGER WINDOW SWITCH RADIO REFUEL REQUEST SWITCH RIGHT REAR DOOR LATCH ASSEMBLY RIGHT REAR EXTERIOR DOOR HANDLE ASSEMBLY RIGHT TURN SIGNAL REPEATER LAMP SEAT HEATING CONTROL MODULE TELEMATICS COMMUNICATION INTERFACE CONTROL MODULE W/ PARKING ASSIST

1 2 NETWORK BUS 4 RR DOOR AJAR SW SIG 2 1 LR DOOR AJAR SW SIG NETWORK BUS 4 2500 2501 COMPUTER DATA LINES SYSTEM 2501 2500 COMPUTER DATA LINES SYSTEM 29 43 SERIAL DATA(+) SERIAL DATA(-) 5 6 NETWORK BUS 3 RF DOOR AJAR SW SIG 6 4 LF DOOR AJAR SW SIG NETWORK BUS 3 64 27 FUEL LVL SENS SIG LO REF BLK WIRE BLK/LT BLU WIRE BLK/LT GRN WIRE BODY CONTROL MODULE (UNDER RIGHT SIDE OF DASH) BREAKOUT) BRN WIRE BRN/WHT WIRE COMPUTER DATA LINES SYSTEM DRIVER DOOR LATCH (CENTER REAR OF DRIVER'S DOOR) DRIVER WINDOW MOTOR (DRIVER'S DOOR) ENGINE CONTROL MODULE (LEFT FRONT CORNER OF ENGINE COMPT) ENGINE CONTROLS SYSTEM ENGINE OIL PRESSURE SWITCH (TOP LEFT SIDE OF ENGINE) FUEL PUMP, SENDER ASSEMBLY (TOP OF FUEL TANK) GMLAN SERIAL DATA - GMLAN SERIAL DATA + GRY WIRE GRY/BLK WIRE HYBRID POWERTRAIN CONTROL MODULE 2 (UNDER FRONT PASSENGER'S SEAT) LEFT REAR DOOR LATCH (CENTER REAR OF LEFT REAR DOOR) LEFT REAR WINDOW SWITCH LIFT GATE AJAR SW SIG 1 LIFTGATE LATCH ASSEMBLY (BOTTOM CENTER OF LIFTGATE) LO REF LT BLU WIRE LT BLU/BLK WIRE LT BLU/GRY WIRE LT BLU/VIO WIRE LT GRN WIRE LT GRN/GRY WIRE LT GRN/YEL WIRE OIL PRESS SW SIG PARK BRAKE CONTROL SWITCH PARK BRK APPLY SW SIG PARK BRK RELEASE SW SIG PARK BRK SW SPLY VOLT PARK BRK APPLY SW VOLT REF PARKING BRAKE CONTROL MODULE (BEHIND LEFT SIDE OF REAR BUMPER) PASSENGER DOOR LATCH (CENTER REAR OF FRONT PASSENGER'S DOOR) PASSENGER WINDOW SWITCH RED/BRN WIRE RIGHT REAR DOOR LATCH (CENTER REAR OF RIGHT REAR DOOR) RIGHT REAR WINDOW SWITCH SERIAL DATA TEMP SENS SIG VIO/GRY WIRE VOL REF PARK BRK SW SIG WHT WIRE YEL WIRE YEL/LT BLU WIRE

1 2 3 SIG GND 4 5 6 7 8 9 10 LANE DEPARTURE WARNING IND CTRL BAT+ BCM/EXT LIGHTS BLK WIRE BODY CONTROL MODULE (UNDER RIGHT SIDE OF DASH) BREAKOUT) COMPUTER DATA LINES LOGIC SYSTEM COMPUTER DATA LINES SYSTEM DK GRN WIRE FORWARD COLLISION IND FORWARD COLLISION SWITCH FRONTVIEW CAMERA MODULE (TOP CENTER OF WINDSHIELD) FUSE GROUND DISTRIBUTION SYSTEM HOT AT ALL TIMES IND DIMMING CTRL INSTRUMENT CLUSTER LANE DEPARTURE WARNING LANE DEPARTURE WARNING IND LEFT INSTRUMENT PANEL FUSE BLOCK (BEHIND LEFT END OF DASH) LEFT STEERING WHEEL CONTROLS SWITCH LO SPD GMLAN SERIAL DATA LT GRN WIRE RED/BRN WIRE RED/YEL WIRE SERIAL DATA STEERING WHEEL AIR BAG COIL (TOP OF STEERING COLUMN) STEERING WHEEL RESISTOR LADDER SIG 2 WHT WIRE

AUDIO SIG 2 AUX AUX AUDIO AUX AUDIO COMMON SIGNAL LEFT AUX AUDIO SIGNAL 2 AUX AUDIO SCREEN 2 RH AUX AUDIO SIGNAL 2 AUX DETECTION SIG AUXILIARY AUDIO BATTERY VOLT BLK WIRE BLK/LT GRN WIRE BLK/WHT WIRE BLK/YEL WIRE BREAKOUT) BRN WIRE BRN/LT BLU WIRE BRN/VIO WIRE BRN/WHT WIRE CELLULAR TEL VIOCE SIG CENTER STACK WAKE UP SIG COMMON SIG COMPUTER DATA LINES SYSTEM CONNECTOR BREAKOUT) DETECTION SIG HOT AT ALL TIMES LEFT INSTRUMENT PANEL FUSE BLOCK (BEHIND LEFT END OF DASH) INPUT INSTRUMENT PANEL LEFT AUX LOGIC LOW REFERENCE LT BLU WIRE LT BLU/BLK WIRE LT BLU/BRN WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/YEL WIRE NCA WIRE RADIO RADIO CONTROLS RADIO/HVAC CONTROLS RDO FUSE RED/YEL WIRE RIGHT AUX STACK SERIAL DATA HIGH STACK SERIAL DATA LOW STACK SERIAL DATA SHIELD USB VIO/LT BLU WIRE YEL WIRE

AUDIO SIG 2 AUX AUX AUDIO AUX AUDIO COMMON SIGNAL LEFT AUX AUDIO SIGNAL 2 AUX AUDIO SCREEN 2 RH AUX AUDIO SIGNAL 2 AUX DETECTION SIG AUXILIARY AUDIO BATTERY VOLT BLK WIRE BLK/LT GRN WIRE BLK/WHT WIRE BLK/YEL WIRE BREAKOUT) BRN WIRE BRN/LT BLU WIRE BRN/VIO WIRE BRN/WHT WIRE CELLULAR TEL VIOCE SIG CENTER STACK WAKE UP SIG COMMON SIG COMPUTER DATA LINES SYSTEM CONNECTOR BREAKOUT) DETECTION SIG HOT AT ALL TIMES LEFT INSTRUMENT PANEL FUSE BLOCK (BEHIND LEFT END OF DASH) INPUT INSTRUMENT PANEL LEFT AUX LOGIC LOW REFERENCE LT BLU WIRE LT BLU/BLK WIRE LT BLU/BRN WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/YEL WIRE NCA WIRE RADIO RADIO CONTROLS RADIO/HVAC CONTROLS RDO FUSE RED/YEL WIRE RIGHT AUX STACK SERIAL DATA HIGH STACK SERIAL DATA LOW STACK SERIAL DATA SHIELD USB VIO/LT BLU WIRE YEL WIRE