Chevrolet Suburban X (2000-2006) instrument panel cluster Wiring diagrams

ABS IND. ANTI-THEFT SYSTEM BATTERY BLK WIRE BLK/WHT WIRE BODY CONTROL MODULE (ON LOWER LEFT SIDE OF DASH, BELOW STEERING COLUMN) BRAKE FLUID LEVEL SWITCH (ON LEFT SIDE OF BRAKE FLUID RESERVOIR) BRAKE IND BRAKE PRESSURE DIFFERENTIAL SWITCH (BELOW MASTER CYLINDER) BRN WIRE CRUISE FUSE DATA LINK CONNECTOR (DLC) (BELOW STEERING COLUMN) DK BLU WIRE DK GRN WIRE GROUND GRY WIRE HOT IN RUN HOT IN RUN OR START IGN E FUSE INSTRUMENT PANEL CLUSTER LEFT I/P FUSE BLOCK (ON LOWER LEFT SIDE OF DASH) LO REF LOGIC LT BLU WIRE LT GRN WIRE PNK WIRE PPL SEO IGN FUSE STEERING WHEEL POS MARKER PULSE SIG STEERING WHEEL POSITION SENS SIG STEERING WHEEL POSITION SIG A STEERING WHEEL POSITION SIG B STEERING WHEEL SPEED/ POSITION SENSOR (NEAR BASE OF STEERING COLUMN) THEFT DETERRENT CONTROL MODULE TRACTION CONTROL SWITCH TRANSFER CASE SHIFT CONTROL MODULE UNDERHOOD FUSE BLOCK (AT LEFT SIDE OF ENG COMPT, NEAR BATTERY) WHT WIRE YAW RATE FREQUENCY YAW, LATERAL ACCELERATION SENSOR (UNDER RIGHT FRONT SEAT) YEL WIRE

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 TP SENSOR 1 SIG 15 14 SERIAL DATA SERIAL DATA ACCELERATION PEDAL POSITION SENSOR (BEHIND ACCELERATOR PEDAL) APP SENSOR 1 SIG BLK WIRE BLK/WHT WIRE BRN WIRE CLASS 2 DATA CLASS 2 DATA COMPUTER DATA LINES SYSTEM CRUISE FUSE CRUISE IND DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE ETC/ECM FUSE GRY WIRE GRY/BLK WIRE GRY/WHT WIRE HOT AT ALL TIMES HOT IN RUN HOT IN RUN, START IGN INSTRUMENT PANEL CLUSTER LEFT I/P FUSE BLOCK (ON LOWER LEFT SIDE OF DASH) LOW REF (NOT USED) LOW REF LOW REF APP SENSOR 2 SIG PPL LT BLU WIRE LT BLU/BLK WIRE LT GRN/BLK WIRE NCA WIRE OFF ON OFF ORG/ WIRE ORG/BLK WIRE PNK WIRE POWERTRAIN CONTROL MODULE (LEFT FRONT OF ENGINE COMPT) PPL PPL/WHT WIRE RESUME/ ACCEL CRUISE CONTROL ON/OFF SWITCH RESUME/ACCEL SERIAL DATA SET/ COAST STOP LPS FUSE STOPLAMP SWITCH (TOP OF BRAKE PEDAL) TAN WIRE THROTTLE ACTUATOR CONTROL MODULE (RIGHT REAR OF ENGINE COMPT) TURN SIGNAL/ MULTIFUNCTION SWITCH UNDER- HOOD FUSE BLOCK UNDERHOOD FUSE BLOCK (NEAR BATTERY) VEH STOP FUSE VEHICLE SPEED SENSOR (VSS) (ON REAR OF TRANSMISSION) VSS HIGH VSS LOW W/ ELECTRONIC ADJUSTABLE PEDAL W/O ELECTRONIC ADJUSTABLE PEDAL WHT WIRE WHT/BLK WIRE YEL WIRE YEL/BLK WIRE

ABS IND. AIR BAG IND ANALOG CLOCK BATTERY GROUND BATTERY IND BLK WIRE BLK/WHT WIRE BODY CONTROL MODULE (BCM) (ON LOWER LEFT SIDE OF DASH, BELOW STEERING COLUMN) BRAKE IND BRN WIRE BRN/WHT WIRE CARGO LAMP IND CLASS 2 DATA COMPUTER DATA LINES COOLANT TEMP GAUGE CRUISE IND DIC MODE SW DIC TOGGLE SW DIC SW SIG DIC FUEL SIG DK BLU WIRE DK GRN/WHT WIRE EXCEPT SEO EXCEPT SEO SEO FUEL GAUGE FUSE GRY WIRE HIGH BEAM IND HOT AT ALL TIMES HOT IN RUN OR START I/P DIM I/P RELAY BLOCK IGN E FUSE IGNITION IGNITION CLASS 2 DATA ILLUMINATION INSTRUMENT PANEL CLUSTER IPC SERIAL DATA IPC/DIC FUSE LAMP LEFT TURN LEFT TURN IND LO WASH FLUID VSS ENG SPEED SIG LOW FUEL IND LT BLU WIRE MESSAGE DISPLAY VARIABLE DIMMING MIL CNTRL OIL GAUGE ORG/ WIRE ORN/ OVERDRIVE OFF IND PNK WIRE RADIO FUSE RED WIRE RIGHT TURN IND RIGHT TURN SUPPL. BRAKE SEAT BELT IND SECURITY IND SEO SEO IGN FUSE SOON IND (MIL) SERVICE ENGINE SPEEDOMETER TACHOMETER TIRE PRESSURE IND TOW/HAUL IND TRACTION CONTROL IND TRANSMISSION TEMP GAUGE TRIP ODOMETER HOUR METER TRIP RESET UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT, NEAR BATTERY) VOLTS GAUGE WASHER FLUID LEVEL SENSOR (IN WASHER FLUID RESERVOIR) WHT WIRE YEL WIRE

58 59 SERIAL DATA SERIAL DATA BLK WIRE BLK/WHT WIRE BODY CONTROL MODULE (LOWER LEFT SIDE OF DASH, BELOW STEERING COLUMN) BODY RELAY BLOCK (UNDER LEFT SIDE OF DASH) DATA DATA LINK CONNECTOR (BELOW LEFT SIDE OF DASH) PPL DK GRN WIRE GRY WIRE HOT AT ALL TIMES HOT IN RUN, START INSTRUMENT PANEL CLUSTER KEY LT GRN WIRE MAGNET LOCK CYLINDER ORG/ WIRE PASSLOCK SENSOR (INTERNAL TO STEERING COLUMN) PNK IGN PWR WIRE PNK WIRE POWERTRAIN CONTROL MODULE (ON LEFT FRONT OF ENGINE COMPT) PPL RED/WHT WIRE SECURITY SENSOR SENSOR PWR BATTERY GROUND SENSOR REF SERIAL DATA SENSOR SIG SERIAL DATA GROUND SPLICE TAMPER SENSOR TBC BATT FUSE TBC IGN 1 FUSE UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENG COMPT) YEL WIRE

AUX PWR FUSE RR HVAC FUSE AUXILIARY POWER OUTLET (BIN) AUXILIARY POWER OUTLET (FRONT) AUXILIARY POWER OUTLET (CONSOLE) BLK WIRE BLOWER FUSE BLOWER MOTOR RESISTOR ASSEMBLY DEFOG RELAY EXC SEO EXCEPT LUXURY F/PMP RELAY FROM SUNROOF FUSE (DIAGRAM 1 OF 6) FUSE GARAGE DOOR OPENER HEADLAMP BALLAST (LEFT) HEADLAMP BALLAST (RIGHT) HVAC CONTROL ASSEMBLY (REAR AUXILIARY) HVAC CONTROL MODULE HVAC/ECAS FUSE I/P RELAY BLOCK (UNDER LEFT SIDE OF DASH, NEAR KICK PANEL) INFO FUSE INSTRUMENT PANEL CLUSTER IPC/DIC FUSE LH HID FUSE LUXURY ORG/ WIRE OVERHEAD CONSOLE PCM B FUSE POWERTRAIN CONTROL MODULE REAR SEAT ENTERTAINMENT ASSEMBLY RED WIRE RH HID FUSE RIGHT I/P FUSE BLOCK (LOWER RIGHT SIDE OF DASH) ROOF BEACON RELAY (UPFITTER OPTION) ROOF BEACON SWITCH (UPFITTER OPTION) RR DEFOG FUSE SEO STOP LP FUSE STOPLAMP SWITCH TO LBEC 1 FUSE (DIAGRAM 3 OF 6) TRANSFER CASE ENCODER MOTOR TRANSFER CASE SHIFT CONTROL MODULE TREC FUSE UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT, NEAR BATTERY) VEHICLE COMMUNICATION INTERFACE MODULE VEHICLE COMMUNICATION INTERFACE MODULE REMOTE PLAYBACK DEVICE (CD PLAYER) W/ADJUSTABLE PEDALS W/O ADJUSTABLE PEDALS

BLK WIRE BODY RELAY BLOCK (UNDER LEFT SIDE OF DASH) BRN WIRE CARGO DOOR KEY SWITCH DK BLU WIRE DOOR CONTACT PLATE DRIVER MINI-WEDGE DOOR JAMB SWITCH ECC FUSE FRONT PASSENGER MINI-WEDGE DOOR JAMB SWITCH GRY WIRE HOT AT ALL TIMES INSTRUMENT PANEL CLUSTER KEY SW LEFT I/P FUSE BLOCK (BEHIND LOWER LEFT SIDE OF DASH) LIFTGATE ACTUATOR LIFTGATE KEY SWITCH LIFTGATE LOCK RELAY LOCK LT BLU WIRE LT GRN WIRE ORG/ WIRE RIGHT I/P FUSE BLOCK RIGHT I/P FUSE BLOCK (LOWER RIGHT SIDE OF DASH) RT DOOR CIRCUIT BREAKER SPLICE PACK TAN WIRE TBC BATT FUSE UNDERHOOD FUSE BLOCK (AT LEFT SIDE OF ENGINE COMPT) W/ CARGO DOORS W/O CARGO DOORS WHT WIRE

33 34 35 PNK WIRE A/C SYSTEM A/C SYSTEM STARTING/CHARGING SYSTEM TRANSMISSIONS SYSTEM AIR CONDITIONING SYSTEM ANTI-LOCK BRAKES SYSTEM BLK WIRE BLK/WHT WIRE BRN WIRE BRN/WHT WIRE CRANK FUSE CSS SIG AXLE SW SIG VSS LOW SIG VSS HIGH SIG AT ISS HIGH SIG AT ISS LOW SIG CTRL CYCLE SIG DELIVERED TORQ PC SOL HI CTRL DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE DK GRN/WHT WIRE EVAP CANP CTRL EVAP VENT CTRL MIL CTRL 2-3 SS CTRL 1-2 SS CTRL VSS OUT VSS OUT TFT SENS SIG EXC SEO FUEL LEV SENS FUSE GRY WIRE GRY/BLK WIRE HOT AT ALL TIMES HOT IN RUN, START HOT IN START IAT SIG IGN CTRL IGN CTRL IGN CTRL IGN CTRL PPL IGN IGN CTRL IGN CTRL IGN CTRL IGN CTRL IGN FEED GND IGNITION COILS INSTRUMENT CLUSTER SYSTEM INSTRUMENT PANEL CLUSTER IPC/DIC FUSE LOGIC LT BLU WIRE LT BLU/WHT WIRE LT GRN WIRE LT GRN/BLK WIRE MAF SIG MAP SIG MALFUNCTION INDICATOR LAMP NCA WIRE ORG/ WIRE PC SOL LO CTRL PMP RLY CTRL RPM OUT PNK 11 12 13 14 15 16 17 WIRE PNK PNK WIRE PNK WIRE POWERTRAIN CONTROL MODULE (LEFT FRONT OF ENGINE COMPT) PPL PPL FUEL LEV SIG PPL PNK PNK WIRE PPL/WHT WIRE PRESS SENS SIG IND CTRL RED WIRE RED/BLK WIRE RED/WHT WIRE REF LO REF LOW RPM OUT SEO SPARK PLUG SPARK SPARK PLUG PLUG STARTING/CHARGING SYSTEM STARTING/CHARGING SYSTEM TRANSMISSIONS SYSTEM TAN WIRE TAN/BLK WIRE TAN/WHT WIRE TCC SOL CTRL CLU RLY CTRL UNDERHOOD FUSE BLOCK WHT WIRE YEL WIRE YEL/BLK WIRE

33 34 35 PNK WIRE A/C SYSTEM A/C SYSTEM STARTING/CHARGING SYSTEM TRANSMISSIONS SYSTEM AIR CONDITIONING SYSTEM ANTI-LOCK BRAKES SYSTEM BLK WIRE BLK/WHT WIRE BRN WIRE BRN/WHT WIRE CRANK FUSE CSS SIG AXLE SW SIG VSS LOW SIG VSS HIGH SIG AT ISS HIGH SIG AT ISS LOW SIG CTRL CYCLE SIG DELIVERED TORQ PC SOL HI CTRL DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE DK GRN/WHT WIRE EVAP CANP CTRL EVAP VENT CTRL MIL CTRL 2-3 SS CTRL 1-2 SS CTRL VSS OUT VSS OUT TFT SENS SIG EXC SEO FUEL LEV SENS FUSE GRY WIRE GRY/BLK WIRE HOT AT ALL TIMES HOT IN RUN, START HOT IN START IAT SIG IGN CTRL IGN CTRL IGN CTRL IGN CTRL PPL IGN IGN CTRL IGN CTRL IGN CTRL IGN CTRL IGN FEED GND IGNITION COILS INSTRUMENT CLUSTER SYSTEM INSTRUMENT PANEL CLUSTER IPC/DIC FUSE LOGIC LT BLU WIRE LT BLU/WHT WIRE LT GRN WIRE LT GRN/BLK WIRE MAF SIG MAP SIG MALFUNCTION INDICATOR LAMP NCA WIRE ORG/ WIRE PC SOL LO CTRL PMP RLY CTRL RPM OUT PNK 11 12 13 14 15 16 17 WIRE PNK PNK WIRE PNK WIRE POWERTRAIN CONTROL MODULE (LEFT FRONT OF ENGINE COMPT) PPL PPL FUEL LEV SIG PPL PNK PNK WIRE PPL/WHT WIRE PRESS SENS SIG IND CTRL RED WIRE RED/BLK WIRE RED/WHT WIRE REF LO REF LOW RPM OUT SEO SPARK PLUG SPARK SPARK PLUG PLUG STARTING/CHARGING SYSTEM STARTING/CHARGING SYSTEM TRANSMISSIONS SYSTEM TAN WIRE TAN/BLK WIRE TAN/WHT WIRE TCC SOL CTRL CLU RLY CTRL UNDERHOOD FUSE BLOCK WHT WIRE YEL WIRE YEL/BLK WIRE

33 34 35 PNK WIRE A/C SYSTEM A/C SYSTEM STARTING/CHARGING SYSTEM TRANSMISSIONS SYSTEM AIR CONDITIONING SYSTEM ANTI-LOCK BRAKES SYSTEM BLK WIRE BLK/WHT WIRE BRN WIRE BRN/WHT WIRE CRANK FUSE CSS SIG AXLE SW SIG VSS LOW SIG VSS HIGH SIG AT ISS HIGH SIG AT ISS LOW SIG CTRL CYCLE SIG DELIVERED TORQ PC SOL HI CTRL DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE DK GRN/WHT WIRE EVAP CANP CTRL EVAP VENT CTRL MIL CTRL 2-3 SS CTRL 1-2 SS CTRL VSS OUT VSS OUT TFT SENS SIG EXC SEO FUEL LEV SENS FUSE GRY WIRE GRY/BLK WIRE HOT AT ALL TIMES HOT IN RUN, START HOT IN START IAT SIG IGN CTRL IGN CTRL IGN CTRL IGN CTRL PPL IGN IGN CTRL IGN CTRL IGN CTRL IGN CTRL IGN FEED GND IGNITION COILS INSTRUMENT CLUSTER SYSTEM INSTRUMENT PANEL CLUSTER IPC/DIC FUSE LOGIC LT BLU WIRE LT BLU/WHT WIRE LT GRN WIRE LT GRN/BLK WIRE MAF SIG MAP SIG MALFUNCTION INDICATOR LAMP NCA WIRE ORG/ WIRE PC SOL LO CTRL PMP RLY CTRL RPM OUT PNK 11 12 13 14 15 16 17 WIRE PNK PNK WIRE PNK WIRE POWERTRAIN CONTROL MODULE (LEFT FRONT OF ENGINE COMPT) PPL PPL FUEL LEV SIG PPL PNK PNK WIRE PPL/WHT WIRE PRESS SENS SIG IND CTRL RED WIRE RED/BLK WIRE RED/WHT WIRE REF LO REF LOW RPM OUT SEO SPARK PLUG SPARK SPARK PLUG PLUG STARTING/CHARGING SYSTEM STARTING/CHARGING SYSTEM TRANSMISSIONS SYSTEM TAN WIRE TAN/BLK WIRE TAN/WHT WIRE TCC SOL CTRL CLU RLY CTRL UNDERHOOD FUSE BLOCK WHT WIRE YEL WIRE YEL/BLK WIRE

29 30 31 PNK WIRE A/C SYSTEM A/C SYSTEM CHARGING SYSTEM ANTI-LOCK BRAKES SYSTEM BLK WIRE BLK/WHT WIRE BRN WIRE BRN/WHT WIRE CLU RLY CTRL CRANK FUSE CTRL DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE DK GRN/WHT WIRE EVAP CANP CTRL EVAP VENT CTRL MIL CTRL 2-3 SS CTRL 1-2 SS CTRL VSS OUT VSS OUT TFT SENS SIG EXC SEO FUEL LEV SENS FUSE GEN GRY WIRE GRY/BLK WIRE HOT AT ALL TIMES HOT IN RUN, START HOT IN START IAT SIG IGN CTRL IGN CTRL IGN CTRL IGN CTRL PPL IGN IGN CTRL IGN CTRL IGN CTRL IGN CTRL IGN FEED GND IGNITION COILS INPUT SHAFT SPEED SENSOR (IN AUTOMATIC TRANSMISSION) INSTRUMENT CLUSTER SYSTEM INSTRUMENT PANEL CLUSTER IPC/DIC FUSE LOGIC LT BLU WIRE LT BLU/WHT WIRE LT GRN WIRE LT GRN/BLK WIRE MAF SIG MAP SIG MALFUNCTION INDICATOR LAMP NCA WIRE ORG/ WIRE PC SOL HI CTRL PC SOL LO CTRL PMP RLY CTRL RPM OUT PNK PNK WIRE PNK WIRE POWERTRAIN CONTROL MODULE (PCM) (LEFT FRONT OF ENGINE COMPT) PPL PPL FUEL LEV SIG PPL PNK PNK WIRE PPL/WHT WIRE PRESS SENS SIG IND CTRL RED WIRE RED/BLK WIRE RED/WHT WIRE REF LO REF LOW RPM OUT SEO SPARK PLUG SPARK PLUG SPARK PLUG STARTING SYSTEM TAN WIRE TAN/WHT WIRE UNDER- HOOD FUSE BLOCK VSS LOW SIG VSS HIGH SIG AT ISS HIGH SIG AT ISS LOW SIG WHT WIRE YEL WIRE YEL/BLK WIRE