Chevrolet Suburban X (2000-2006) hot in run, start Wiring diagrams

ACCESSORY VOLT BATTERY + COURTESY LAMP SUPPLY VOLTAGE BACKUP LAMP SUPPLY VOLT BLK WIRE BODY CONTROL MODULE (ON LOWER LEFT SIDE OF DASH, BELOW STEERING COLUMN) CARGO LAMP LOW CTRL PARK BRAKE SW SIG BACKUP LAMP SIG COURTESY LAMPS ON SIG DK BLU/WHT WIRE DK GRN WIRE FUSE GRY WIRE GRY/BLK WIRE HEADLAMP SW HEADLAMP ON SIG HEADLIGHTS SYSTEM HOT AT ALL TIMES HOT IN RUN, ACC HOT IN RUN, START HOT IN RUN, START, ACC I/P LAMPS DIMMER SW LOW REF LOW REF INTERIOR LIGHTS SYSTEM EXTERIOR LIGHTS SYSTEM INTERIOR LIGHTS SYSTEM INTERIOR LIGHTS SYSTEM INTERIOR LIGHTS SYSTEM LEFT I/P FUSE BLOCK LIFT GATE AJAR SW SIG RIGHT REAR DOOR AJAR SW SIG LEFT REAR DOOR AJAR SW SIG LT BLU WIRE LT BLU/BLK WIRE LT GRN WIRE LT GRN/BLK WIRE ORG/ WIRE PARK BRAKE SWITCH (PART OF PARK BRAKE ASSEMBLY) PNK WIRE PNK/BLK WIRE POWER WINDOW SW LR DOWN SIG POWER WINDOW SW LR UP SIG POWER WINDOWS SYSTEM POWER WINDOWS SYSTEM TBC ACCY FUSE TBC IGN 0 FUSE TBC IGN 1 FUSE UNDERHOOD FUSE BLOCK WARNINGS SYSTEM HEADLIGHTS SYSTEM WHT WIRE YEL WIRE

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 TP SENSOR 1 SIG 15 14 SERIAL DATA SERIAL DATA ACCELERATION PEDAL POSITION SENSOR (BEHIND ACCELERATOR PEDAL) APP SENSOR 1 SIG BLK WIRE BLK/WHT WIRE BRN WIRE CLASS 2 DATA CLASS 2 DATA COMPUTER DATA LINES SYSTEM CRUISE FUSE CRUISE IND DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE ETC/ECM FUSE GRY WIRE GRY/BLK WIRE GRY/WHT WIRE HOT AT ALL TIMES HOT IN RUN HOT IN RUN, START IGN INSTRUMENT PANEL CLUSTER LEFT I/P FUSE BLOCK (ON LOWER LEFT SIDE OF DASH) LOW REF (NOT USED) LOW REF LOW REF APP SENSOR 2 SIG PPL LT BLU WIRE LT BLU/BLK WIRE LT GRN/BLK WIRE NCA WIRE OFF ON OFF ORG/ WIRE ORG/BLK WIRE PNK WIRE POWERTRAIN CONTROL MODULE (LEFT FRONT OF ENGINE COMPT) PPL PPL/WHT WIRE RESUME/ ACCEL CRUISE CONTROL ON/OFF SWITCH RESUME/ACCEL SERIAL DATA SET/ COAST STOP LPS FUSE STOPLAMP SWITCH (TOP OF BRAKE PEDAL) TAN WIRE THROTTLE ACTUATOR CONTROL MODULE (RIGHT REAR OF ENGINE COMPT) TURN SIGNAL/ MULTIFUNCTION SWITCH UNDER- HOOD FUSE BLOCK UNDERHOOD FUSE BLOCK (NEAR BATTERY) VEH STOP FUSE VEHICLE SPEED SENSOR (VSS) (ON REAR OF TRANSMISSION) VSS HIGH VSS LOW W/ ELECTRONIC ADJUSTABLE PEDAL W/O ELECTRONIC ADJUSTABLE PEDAL WHT WIRE WHT/BLK WIRE YEL WIRE YEL/BLK WIRE

58 59 SERIAL DATA SERIAL DATA BLK WIRE BLK/WHT WIRE BODY CONTROL MODULE (LOWER LEFT SIDE OF DASH, BELOW STEERING COLUMN) BODY RELAY BLOCK (UNDER LEFT SIDE OF DASH) DATA DATA LINK CONNECTOR (BELOW LEFT SIDE OF DASH) PPL DK GRN WIRE GRY WIRE HOT AT ALL TIMES HOT IN RUN, START INSTRUMENT PANEL CLUSTER KEY LT GRN WIRE MAGNET LOCK CYLINDER ORG/ WIRE PASSLOCK SENSOR (INTERNAL TO STEERING COLUMN) PNK IGN PWR WIRE PNK WIRE POWERTRAIN CONTROL MODULE (ON LEFT FRONT OF ENGINE COMPT) PPL RED/WHT WIRE SECURITY SENSOR SENSOR PWR BATTERY GROUND SENSOR REF SERIAL DATA SENSOR SIG SERIAL DATA GROUND SPLICE TAMPER SENSOR TBC BATT FUSE TBC IGN 1 FUSE UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENG COMPT) YEL WIRE

AVALANCHE/ ESCALADE EXT BLK WIRE BODY CONTROL MODULE (LOWER LEFT SIDE OF DASH) COMPUTER DATA LINES SYSTEM HOT AT ALL TIMES HOT IN RUN, START HTR HVAC CONTROL MODULE (BEHIND CENTER OF DASH) I/P RELAY BLOCK (LOWER LEFT SIDE OF DASH) IGN LEFT CARGO DOOR CONTACT PLATE (BODY) LEFT CARGO DOOR CONTACT PLATE (DOOR) LEFT CARGO REAR WINDOW DEFOGGER GRID LIFTGATE DEFOGGER GRID LOGIC LT GRN WIRE PPL REAR DEFOG SWITCH REAR DEFOGGER RELAY REAR WINDOW DEFOGGER GRID RELAY CNTRL RIGHT CARGO DOOR CONTACT PLATE (BODY) RIGHT CARGO DOOR CONTACT PLATE (DOOR) RIGHT CARGO REAR WINDOW DEFOGGER GRID SERIAL DATA SPLICE PACK W/CARGO DOORS W/LIFTGATE WHT WIRE WINDOW CONTACTOR

3-2 SS CTRL REF LOW A/C SYSTEM ANTI-LOCK BRAKES SYS 470 451 1671 1667 451 1669 1664 1478 ANTI-LOCK BRAKES SYS 771 420 776 48 1744 846 1101 625 451 BLK WIRE BLK/ WHT WIRE BLK/WHT WIRE BODY CONTROL MODULE (BELOW STEERING COLUMN) BRN WIRE BRN/WHT WIRE DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE ELECTRONIC SUSPENSION SYSTEM FUEL COMP SIG B+ CLS 2 DATA CLS 2 DATA FUSE FUSE FUSE GRY WIRE HOT AT ALL TIMES HOT IN ACCY, RUN, START LEFT I/P FUSE BLOCK IGN 0 FUSE HOT IN RUN, START INJ 7 CTRL INJ 4 CTRL INJECTORS KS SIGNAL KS SIGNAL CKP SIG REQ TORQ SIG SERIAL DATA SERIAL DATA LEV SW SIG LT BLU WIRE LT BLU/BLK WIRE LT GRN WIRE LT GRN/BLK WIRE OIL LEV SW SIG ORG/ WIRE ORG/BLK WIRE PCMB FUSE PNK PNK WIRE PNK WIRE PNK/BLK WIRE PNK/WHT WIRE POWERTRAIN CONTROL MODULE (LEFT FRONT OF ENGINE COMPT) PPL PPL PPL PPL/WHT WIRE PRND B SIG CMP SIG ECT SIG IGN INJ 5 CTRL INJ 8 CTRL RANGE B RANGE C IGN B+ REF LOW RED WIRE RED/BLK WIRE REF LOW REF LOW (A/T) REF LOW REF LOW GND STARTING/ CHARGING SYSTEM TAN WIRE TAN/WHT WIRE UNDER- HOOD FUSE BLOCK WHT WIRE YEL WIRE YEL/BLK WIRE

BLK WIRE BLK/WHT WIRE BRN WIRE BRN/WHT WIRE COOLANT LEVEL SWITCH (IN COOLANT RESERVOIR) DK BLU WIRE DK BLU/WHT WIRE DK GRN/WHT WIRE ENGINE COOLANT TEMPERATURE SENSOR (FRONT OF LEFT CYLINDER HEAD) ENGINE OIL LEVEL SWITCH (RIGHT SIDE OF OIL PAN) FUEL PUMP RELAY FUEL PUMP RELAY (SECONDARY) (DUAL TANKS) (ON UNDERHOOD FUSE BLOCK BRACKET) FUEL PUMP, SENDER ASSEMBLY (PRIMARY) (IN FUEL TANK) FUSE GRY WIRE HEATED OXYGEN SENSOR (BANK 1 SENSOR 1) (LEFT EXH PIPE, BEFORE CONVERTER) HEATED OXYGEN SENSOR (BANK 1 SENSOR 2) (LEFT EXH PIPE, AFTER CONVERTER) HEATED OXYGEN SENSOR (BANK 2 SENSOR 1) (RIGHT EXH PIPE, BEFORE CONVERTER) HEATED OXYGEN SENSOR (BANK 2 SENSOR 2) (RIGHT EXH PIPE, AFTER CONVERTER) HOT AT ALL TIMES HOT IN RUN, START KNOCK SENSOR (UNDER INTAKE MANIFOLD) LT BLU WIRE LT GRN WIRE NCA WIRE ORG/BLK WIRE PARK/NEUTRAL POSITION SWITCH (LEFT SIDE OF TRANSMISSION) PCM B FUSE PNK PNK WIRE PNK WIRE PNK/BLK WIRE PPL PPL PNK PNK 18 19 WIRE PPL PPL PPL/WHT WIRE RED WIRE RED/WHT WIRE TAN WIRE TAN/WHT WIRE UNDER- HOOD FUSE BLOCK UNDERHOOD FUSE BLOCK WHT WIRE WHT/ BLK WIRE YEL WIRE

33 34 35 PNK WIRE 9 10 PNK WIRE ACT CNTRL APP SENS 1 APP SENS 2 AUTOMATIC TRANSMISSION INPUT SHAFT SPEED SENSOR BLK WIRE BLK/WHT WIRE BRN WIRE CRUISE CONTROL SYSTEM CRUISE REQ DATA DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE DK GRN/WHT WIRE ECT/ECM FUSE FUEL COMPOSITION SENSOR (FLEX FUEL) FUSE GROUND GRY WIRE GRY/BLK WIRE HOT AT ALL TIMES HOT IN RUN OR START HOT IN RUN, START IGN LEFT I/P FUSE BLOCK LT BLU WIRE LT BLU/BLK WIRE LT BLU/WHT WIRE LT GRN WIRE LT GRN/BLK WIRE NOT USED ORG/ WIRE ORG/BLK WIRE PNK 11 12 13 14 15 16 17 WIRE PNK PNK PNK WIRE PNK PNK WIRE PNK WIRE PPL PPL PNK PNK 28 29 WIRE PPL PNK PNK WIRE PPL/WHT WIRE R/A INPUT RED WIRE RED/BLK WIRE RED/WHT WIRE REF LOW S/C INPUT SIGNAL STP LP IN TAC CTRL TAN WIRE TAN/BLK WIRE TAN/WHT WIRE THROTTLE ACTUATOR CONTROL MODULE (REAR OF ENGINE COMPT) TP SENS 1 TP SENS 2 UNDERHOOD FUSE BLOCK VEH STOP FUSE WHT WIRE WHT/BLK WIRE YEL WIRE YEL/BLK WIRE

33 34 35 PNK WIRE A/C SYSTEM A/C SYSTEM STARTING/CHARGING SYSTEM TRANSMISSIONS SYSTEM AIR CONDITIONING SYSTEM ANTI-LOCK BRAKES SYSTEM BLK WIRE BLK/WHT WIRE BRN WIRE BRN/WHT WIRE CRANK FUSE CSS SIG AXLE SW SIG VSS LOW SIG VSS HIGH SIG AT ISS HIGH SIG AT ISS LOW SIG CTRL CYCLE SIG DELIVERED TORQ PC SOL HI CTRL DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE DK GRN/WHT WIRE EVAP CANP CTRL EVAP VENT CTRL MIL CTRL 2-3 SS CTRL 1-2 SS CTRL VSS OUT VSS OUT TFT SENS SIG EXC SEO FUEL LEV SENS FUSE GRY WIRE GRY/BLK WIRE HOT AT ALL TIMES HOT IN RUN, START HOT IN START IAT SIG IGN CTRL IGN CTRL IGN CTRL IGN CTRL PPL IGN IGN CTRL IGN CTRL IGN CTRL IGN CTRL IGN FEED GND IGNITION COILS INSTRUMENT CLUSTER SYSTEM INSTRUMENT PANEL CLUSTER IPC/DIC FUSE LOGIC LT BLU WIRE LT BLU/WHT WIRE LT GRN WIRE LT GRN/BLK WIRE MAF SIG MAP SIG MALFUNCTION INDICATOR LAMP NCA WIRE ORG/ WIRE PC SOL LO CTRL PMP RLY CTRL RPM OUT PNK 11 12 13 14 15 16 17 WIRE PNK PNK WIRE PNK WIRE POWERTRAIN CONTROL MODULE (LEFT FRONT OF ENGINE COMPT) PPL PPL FUEL LEV SIG PPL PNK PNK WIRE PPL/WHT WIRE PRESS SENS SIG IND CTRL RED WIRE RED/BLK WIRE RED/WHT WIRE REF LO REF LOW RPM OUT SEO SPARK PLUG SPARK SPARK PLUG PLUG STARTING/CHARGING SYSTEM STARTING/CHARGING SYSTEM TRANSMISSIONS SYSTEM TAN WIRE TAN/BLK WIRE TAN/WHT WIRE TCC SOL CTRL CLU RLY CTRL UNDERHOOD FUSE BLOCK WHT WIRE YEL WIRE YEL/BLK WIRE

3-2 SS CTRL REF LOW A/C SYSTEM ANTI-LOCK BRAKES SYS 470 451 1671 1667 451 1669 1664 1478 ANTI-LOCK BRAKES SYS 771 420 776 48 1744 846 1101 625 451 BLK WIRE BLK/ WHT WIRE BLK/WHT WIRE BODY CONTROL MODULE (BELOW STEERING COLUMN) BRN WIRE BRN/WHT WIRE DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE ELECTRONIC SUSPENSION SYSTEM FUEL COMP SIG B+ CLS 2 DATA CLS 2 DATA FUSE FUSE FUSE GRY WIRE HOT AT ALL TIMES HOT IN ACCY, RUN, START LEFT I/P FUSE BLOCK IGN 0 FUSE HOT IN RUN, START INJ 7 CTRL INJ 4 CTRL INJECTORS KS SIGNAL KS SIGNAL CKP SIG REQ TORQ SIG SERIAL DATA SERIAL DATA LEV SW SIG LT BLU WIRE LT BLU/BLK WIRE LT GRN WIRE LT GRN/BLK WIRE OIL LEV SW SIG ORG/ WIRE ORG/BLK WIRE PCMB FUSE PNK PNK WIRE PNK WIRE PNK/BLK WIRE PNK/WHT WIRE POWERTRAIN CONTROL MODULE (LEFT FRONT OF ENGINE COMPT) PPL PPL PPL PPL/WHT WIRE PRND B SIG CMP SIG ECT SIG IGN INJ 5 CTRL INJ 8 CTRL RANGE B RANGE C IGN B+ REF LOW RED WIRE RED/BLK WIRE REF LOW REF LOW (A/T) REF LOW REF LOW GND STARTING/ CHARGING SYSTEM TAN WIRE TAN/WHT WIRE UNDER- HOOD FUSE BLOCK WHT WIRE YEL WIRE YEL/BLK WIRE

BLK WIRE BLK/WHT WIRE BRN WIRE BRN/WHT WIRE COOLANT LEVEL SWITCH (IN COOLANT RESERVOIR) DK BLU WIRE DK BLU/WHT WIRE DK GRN/WHT WIRE ENGINE COOLANT TEMPERATURE SENSOR (FRONT OF LEFT CYLINDER HEAD) ENGINE OIL LEVEL SWITCH (RIGHT SIDE OF OIL PAN) FUEL PUMP RELAY FUEL PUMP RELAY (SECONDARY) (DUAL TANKS) (ON UNDERHOOD FUSE BLOCK BRACKET) FUEL PUMP, SENDER ASSEMBLY (PRIMARY) (IN FUEL TANK) FUSE GRY WIRE HEATED OXYGEN SENSOR (BANK 1 SENSOR 1) (LEFT EXH PIPE, BEFORE CONVERTER) HEATED OXYGEN SENSOR (BANK 1 SENSOR 2) (LEFT EXH PIPE, AFTER CONVERTER) HEATED OXYGEN SENSOR (BANK 2 SENSOR 1) (RIGHT EXH PIPE, BEFORE CONVERTER) HEATED OXYGEN SENSOR (BANK 2 SENSOR 2) (RIGHT EXH PIPE, AFTER CONVERTER) HOT AT ALL TIMES HOT IN RUN, START KNOCK SENSOR (UNDER INTAKE MANIFOLD) LT BLU WIRE LT GRN WIRE NCA WIRE ORG/BLK WIRE PARK/NEUTRAL POSITION SWITCH (LEFT SIDE OF TRANSMISSION) PCM B FUSE PNK PNK WIRE PNK WIRE PNK/BLK WIRE PPL PPL PNK PNK 18 19 WIRE PPL PPL PPL/WHT WIRE RED WIRE RED/WHT WIRE TAN WIRE TAN/WHT WIRE UNDER- HOOD FUSE BLOCK UNDERHOOD FUSE BLOCK WHT WIRE WHT/ BLK WIRE YEL WIRE