Chevrolet Suburban X (2000-2006) engine controls system Wiring diagrams

1 2 6 8 16 19 20 21 40 42 46 47 48 51 62 63 GND TCC PWM PC SOL HI PC SOL LO 1-2 SHIFT SOLENOID 2-3 SHIFT SOLENOID 3-2 SHIFT SOLENOID A/T FLUID PRESSURE MANUAL MANUAL VALVE POSITION SWITCH AUTOMATIC TRANSMISSION BLK WIRE BLK/WHT WIRE BODY CONTROL MODULE (BELOW STEERING COLUMN) BRAKE FUSE BRN WIRE BRN/WHT WIRE DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE ENGINE CONTROLS SYSTEM ENGINE COOLANT TEMPERATURE SENSOR (FRONT OF LEFT CYLINDER HEAD) EXCEPT SEO FLUID TEMP SENSOR FUSE GRY WIRE GRY/BLK WIRE HOT AT ALL TIMES HOT IN HOT IN RUN, ACC, START HOT IN RUN, START I/P RELAY BLOCK (BELOW LEFT SIDE OF DASH) INSTRUMENT CLUSTER INSTRUMENT PANEL CLUSTER (IPC) IPC/DIC FUSE LEFT I/P FUSE BLOCK (LOWER LEFT SIDE OF DASH) LT BLU WIRE LT BLU/WHT WIRE LT GRN WIRE LT GRN/BLK WIRE MALFUNCTION INDICATOR LAMP OF TRANSMISSION) ORG/ WIRE ORG/BLK WIRE PARK/NEUTRAL POSITION SWITCH (LEFT SIDE OF TRANSMISSION) PCM B FUSE PNK PNK WIRE PNK WIRE POWERTRAIN CONTROL MODULE (LEFT FRONT OF ENGINE COMPT) PPL PPL DATA LINK CONNECTOR (BELOW STEERING COLUMN) PPL/WHT WIRE PRESS CTRL SOLENOID RED WIRE RED/BLK WIRE REV RUN WIRE SEO SPLICE PACK STOPLIGHT SWITCH (TOP OF BRAKE PEDAL BRACKET) TAN WIRE TAN/BLK WIRE TCC PWM SOLENOID TCC SOLENOID TOW/HAUL SWITCH TRANSFER CASE) UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT, NEAR BATTERY) PCM 1 FUSE UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT, NEAR THE BATTERY) VEHICLE SPEED SENSOR WHT WIRE YEL WIRE YEL/BLK WIRE

1 2 6 8 16 19 20 21 40 42 46 47 48 51 62 63 GND TCC PWM PC SOL HI PC SOL LO 1-2 SHIFT SOLENOID 2-3 SHIFT SOLENOID 3-2 SHIFT SOLENOID A/T FLUID PRESSURE MANUAL MANUAL VALVE POSITION SWITCH AUTOMATIC TRANSMISSION BLK WIRE BLK/WHT WIRE BODY CONTROL MODULE (BELOW STEERING COLUMN) BRAKE FUSE BRN WIRE BRN/WHT WIRE DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE ENGINE CONTROLS SYSTEM ENGINE COOLANT TEMPERATURE SENSOR (FRONT OF LEFT CYLINDER HEAD) EXCEPT SEO FLUID TEMP SENSOR FUSE GRY WIRE GRY/BLK WIRE HOT AT ALL TIMES HOT IN HOT IN RUN, ACC, START HOT IN RUN, START I/P RELAY BLOCK (BELOW LEFT SIDE OF DASH) INSTRUMENT CLUSTER INSTRUMENT PANEL CLUSTER (IPC) IPC/DIC FUSE LEFT I/P FUSE BLOCK (LOWER LEFT SIDE OF DASH) LT BLU WIRE LT BLU/WHT WIRE LT GRN WIRE LT GRN/BLK WIRE MALFUNCTION INDICATOR LAMP OF TRANSMISSION) ORG/ WIRE ORG/BLK WIRE PARK/NEUTRAL POSITION SWITCH (LEFT SIDE OF TRANSMISSION) PCM B FUSE PNK PNK WIRE PNK WIRE POWERTRAIN CONTROL MODULE (LEFT FRONT OF ENGINE COMPT) PPL PPL DATA LINK CONNECTOR (BELOW STEERING COLUMN) PPL/WHT WIRE PRESS CTRL SOLENOID RED WIRE RED/BLK WIRE REV RUN WIRE SEO SPLICE PACK STOPLIGHT SWITCH (TOP OF BRAKE PEDAL BRACKET) TAN WIRE TAN/BLK WIRE TCC PWM SOLENOID TCC SOLENOID TOW/HAUL SWITCH TRANSFER CASE) UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT, NEAR BATTERY) PCM 1 FUSE UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT, NEAR THE BATTERY) VEHICLE SPEED SENSOR WHT WIRE YEL WIRE YEL/BLK WIRE

5 VOLT REF LOW REF COOLNT LEV SIG OIL LEV SW BLK WIRE BLU WIRE BRN WIRE BRN/WHT WIRE COMPUTER DATA LINES COOLANT LEVEL SWITCH (IN COOLANT RESERVOIR) DK BLU WIRE DK DK DK GRN WIRE DK GRN/WHT WIRE ENGINE CONTROLS SYSTEM ENGINE OIL LEVEL SWITCH (LOWER RIGHT SIDE OF OIL PAN) ENGINE OIL PRESSURE SENSOR (ON TOP REAR OF ENGINE) FUEL LEVEL SENSOR (PRIMARY) (INSIDE FUEL TANK) FUEL LEVEL SENSOR (SECONDARY) (INSIDE FUEL TANK) GRN WIRE GRY WIRE I/P RELAY BLOCK INFLATABLE RESTRAINT STEERING WHEEL MODULE COIL LT GRN WIRE NCA WIRE ORG/ WIRE PERSON- ALIZATION POWERTRAIN CONTROL MODULE (PCM) (ON LEFT FRONT OF ENGINE COMPT) PPL ROW SEAT) (CADILLAC) REAR OBJECT SENSOR CONTROL MODULE SBA SIG STEERING WHEEL DIC CONTROLS TAN/WHT WIRE TRIP FUEL SELECT VSS W/ DUAL TANK W/O DUAL TANK WHT WIRE YEL WIRE

AM ANTENNA ANT ENABLE SIG ANTENNA ANTENNA ANTENNA ANTENNA EXCEPT EXCALADE EXT COAX BARE BARE DRAIN WIRE BCM CLASS 2 SERIAL DATA BLK/WHT WIRE BODY CONTROL MODULE BRN WIRE BRN/WHT WIRE COAX COAX ESCALADE EXT COMPUTER COMPUTER DATA LINES SYSTEM PNK WIRE DK BLU WIRE DK GRN WIRE DK GRN/WHT WIRE DRAIN WIRE ENABLE SIG ENGINE CONTROLS SYSTEM FM ANTENNA FM COMP SIG FM IMPEDANCE MATCHING MODULE (IN RIGHT REAR QUARTER GLASS) GROUND HOT AT ALL TIMES I/P FUSE BLOCK (BELOW LOWER LEFT SIDE OF DASH) INFLATABLE RESTRAINT STEERING WHEEL MODULE COIL LF SPK OUT+ LF SPK OUT- RR SPK OUT+ RR SPK OUT- GROUND LR AUD SIG+ LR SPK OUT + LR SPK OUT - RF SPK OUT + RF SPK OUT - LT BLU WIRE LT GRN WIRE NCA WIRE ORG/ WIRE ORG/BLK WIRE OUT TO RADIO PNK/BLK WIRE PROG RADIO RADIO ANTENNA MODULE (ABOVE RIGHT REAR QUARTER GLASS, IN HEADLINER) RADIO FUSE REAR SEAT AUDIO CONTROLLER (ON REAR OF CENTER CONSOLE) RED WIRE REMOTE RADIO CONTROL SIGNAL REMOTE RADIO CONTROL SUPPLY VOLTAGE RIGHT AUD SIG LEFT AUD SIG COMMON AUD SIG CELL VOICE SIG VOICE LOW REF RR AUD SIG+ SEEK DN SEEK UP SERIAL DATA SOURCE DN SOURCE UP STEERING WHEEL AUDIO CONTROLS SYSTEM DATA LINES TAN WIRE UNDERHOOD FUSE BLOCK (AT LEFT SIDE OF ENGINE COMPARTMENT) VEH SPEED SEN VEHICLE COMMUNICATION INTERFACE MODULE (RIGHT SIDE OF DASH) VOICE VOICE LO REF VOICE SIGNAL VOL DN VOL UP

AM ANTENNA ANT ENABLE SIG ANTENNA ANTENNA ANTENNA ANTENNA EXCEPT EXCALADE EXT COAX BARE BARE DRAIN WIRE BLK/WHT WIRE BODY CONTROL MODULE BCM CLASS 2 SERIAL DATA BRN WIRE BRN/WHT WIRE CELL VOICE SIG VOICE LOW REF VOICE LOW REF COAX COAX ESCALADE EXT COMPUTER DATA LINES SYSTEM COMPUTER DATA LINES SYSTEM PNK WIRE DK BLU WIRE DK GRN WIRE DK GRN/WHT WIRE DRAIN WIRE ENABLE SIG ENGINE CONTROLS SYSTEM FM ANTENNA FM COMP SIG FM IMPEDANCE MATCHING MODULE (IN RIGHT REAR QUARTER GLASS) GROUND HOT AT ALL TIMES I/P FUSE BLOCK (BELOW LOWER LEFT SIDE OF DASH) INFLATABLE RESTRAINT STEERING WHEEL MODULE COIL LF SPK OUT+ LF SPK OUT- RR SPK OUT+ RR SPK OUT- GROUND LR AUD SIG+ LR SPK OUT + LR SPK OUT - RF SPK OUT + RF SPK OUT - LT BLU WIRE LT GRN WIRE NCA WIRE ORG/ WIRE ORG/BLK WIRE OUT TO RADIO PNK/BLK WIRE PROG RADIO RADIO ANTENNA MODULE (ABOVE RIGHT REAR QUARTER GLASS, IN HEADLINER) RADIO FUSE REAR SEAT AUDIO CONTROLLER (ON REAR OF CENTER CONSOLE) RED WIRE REMOTE RADIO CONTROL SIGNAL REMOTE RADIO CONTROL SUPPLY VOLTAGE RIGHT AUD SIG LEFT AUD SIG COMMON AUD SIG RR AUD SIG+ SEEK DN SEEK UP SERIAL DATA SOURCE DN SOURCE UP STEERING WHEEL AUDIO CONTROLS TAN WIRE UNDERHOOD FUSE BLOCK (AT LEFT SIDE OF ENGINE COMPARTMENT) VEH SPEED SEN VEHICLE COMMUNICATION INTERFACE MODULE (RIGHT SIDE OF DASH) VOICE VOICE LO REF VOICE SIGNAL VOL DN VOL UP

AM ANTENNA ANT ENABLE SIG ANTENNA ANTENNA ANTENNA ANTENNA EXCEPT EXCALADE EXT COAX BARE BARE DRAIN WIRE BCM CLASS 2 SERIAL DATA BLK WIRE BLK/WHT WIRE BODY CONTROL MODULE BRN WIRE BRN/WHT WIRE CELL VOICE SIG VOICE LOW REF COAX COAX ESCALADE EXT COMPUTER DATA LINES SYSTEM COMPUTER DATA LINES SYSTEM PNK WIRE DK BLU WIRE DK GRN WIRE DK GRN/WHT WIRE DRAIN WIRE ENABLE SIG ENGINE CONTROLS SYSTEM FM ANTENNA FM COMP SIG FM IMPEDANCE MATCHING MODULE (IN RIGHT REAR QUARTER GLASS) GROUND HOT AT ALL TIMES I/P FUSE BLOCK (BELOW LOWER LEFT SIDE OF DASH) INFLATABLE RESTRAINT STEERING WHEEL MODULE COIL LF SPK OUT+ LF SPK OUT- RR SPK OUT+ RR SPK OUT- GROUND LR AUD SIG+ LR SPK OUT + LR SPK OUT - RF SPK OUT + RF SPK OUT - LT BLU WIRE LT GRN WIRE NCA WIRE ORG/ WIRE ORG/BLK WIRE OUT TO RADIO PNK/BLK WIRE PROG RADIO RADIO ANTENNA MODULE (ABOVE RIGHT REAR QUARTER GLASS, IN HEADLINER) RADIO FUSE REAR SEAT AUDIO CONTROLLER (ON REAR OF CENTER CONSOLE) RED WIRE REMOTE RADIO CONTROL SIGNAL REMOTE RADIO CONTROL SUPPLY VOLTAGE RIGHT AUD SIG LEFT AUD SIG COMMON AUD SIG RR AUD SIG+ SEEK DN SEEK UP SERIAL DATA SOURCE DN SOURCE UP STEERING WHEEL AUDIO CONTROLS TAN WIRE UNDERHOOD FUSE BLOCK (AT LEFT SIDE OF ENGINE COMPARTMENT) VEH SPEED SEN VEHICLE COMMUNICATION INTERFACE MODULE (RIGHT SIDE OF DASH) VOICE VOICE LO REF VOICE SIGNAL VOL DN VOL UP

AM ANTENNA ANT ENABLE SIG ANTENNA ANTENNA ANTENNA ANTENNA EXCEPT EXCALADE EXT COAX BARE BARE DRAIN WIRE BCM CLASS 2 SERIAL DATA BLK/WHT WIRE BODY CONTROL MODULE BRN WIRE BRN/WHT WIRE CELL VOICE SIG VOICE LOW REF COAX COAX ESCALADE EXT COMPUTER DATA LINES SYSTEM COMPUTER DATA LINES SYSTEM PNK WIRE DK BLU WIRE DK GRN WIRE DK GRN/WHT WIRE DRAIN WIRE ENABLE SIG ENGINE CONTROLS SYSTEM FM ANTENNA FM COMP SIG FM IMPEDANCE MATCHING MODULE (IN RIGHT REAR QUARTER GLASS) GROUND HOT AT ALL TIMES I/P FUSE BLOCK (BELOW LOWER LEFT SIDE OF DASH) INFLATABLE RESTRAINT STEERING WHEEL MODULE COIL LF SPK OUT+ LF SPK OUT- RR SPK OUT+ RR SPK OUT- GROUND LR AUD SIG+ LR SPK OUT + LR SPK OUT - RF SPK OUT + RF SPK OUT - LT BLK WIRE LT BLU WIRE LT GRN WIRE NCA WIRE ORG/ WIRE ORG/BLK WIRE OUT TO RADIO PNK/BLK WIRE PROG RADIO RADIO ANTENNA MODULE (ABOVE RIGHT REAR QUARTER GLASS, IN HEADLINER) RADIO FUSE REAR SEAT AUDIO CONTROLLER (ON REAR OF CENTER CONSOLE) RED WIRE REMOTE RADIO CONTROL SIGNAL REMOTE RADIO CONTROL SUPPLY VOLTAGE RIGHT AUD SIG LEFT AUD SIG COMMON AUD SIG RR AUD SIG+ SEEK DN SEEK UP SERIAL DATA SOURCE DN SOURCE UP STEERING WHEEL AUDIO CONTROLS TAN WIRE UNDERHOOD FUSE BLOCK (AT LEFT SIDE OF ENGINE COMPARTMENT) VEH SPEED SEN VEHICLE COMMUNICATION INTERFACE MODULE (RIGHT SIDE OF DASH) VOICE VOICE LO REF VOICE SIGNAL VOL DN VOL UP