Chevrolet Suburban X (2000-2006) class 2 serial data Wiring diagrams

1 7 BATT (+) GND BLK WIRE BLK/RED WIRE BLK/WHT WIRE BLU WIRE BRN WIRE BRN/WHT WIRE CLASS 2 SERIAL DATA CLASS 2 SERIAL DATA ADJUST PDL SENSOR SIG COMPUTER DATA LINES SYSTEM DRIVER BACK HEATED SEAT ELEMENT DRIVER DOOR MODULE DRIVER SEAT RECLINER MOTOR POSITION SENSOR EAP FUSE ELECTRONIC ADJUSTABLE PEDALS ASSEMBLY ELECTRONIC ADJUSTABLE PEDALS RELAY (BEHIND LOWER LEFT OF DASH) ELECTRONIC ADJUSTABLE PEDALS SWITCHES EXIT FRONT PASS- ENGER BACK HEATED SEAT ELEMENT HOT AT ALL TIMES I/P RELAY BLOCK (LEFT OF STEERING COLUMN) LOW REF LT BLU WIRE MEMORY SEAT MODULE (UNDER LEFT FRONT SEAT) MEMORY/ HEATED SEAT SWITCH ORG/ WIRE ORG/BLK WIRE PNK (IN DRIVER SEAT JUMPER HARN) WIRE PNK WIRE PPL RECLINE MTR POS SEN SIG RED WIRE SEAT CIRCUIT BREAKER SET 1 SET 2 TAN WIRE UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT) WHT WIRE YEL WIRE

A/C COMP CL RLY CTRL A/C COMPRESSOR CLUTCH A/C COMPRESSOR CLUTCH RELAY A/C LOW PRESSURE SWITCH (RIGHT SIDE OF ACCUMULATOR) A/C ON A/C RECIRC A/C REF PRE SENS SIG A/C REFRIGERANT PRESSURE SENSOR (IN HIGH SIDE PRESSURE LINE) AMBIENT AIR TEMPERATURE SENSOR (IN RIGHT FRONT BUMPER FILLER ASSEMBLY AUTO BLK WIRE BLK/WHT WIRE BLOWER FUSE BLOWER MOTOR (RIGHT SIDE OF DASH) BLOWER MOTOR CONTROL PROCESSOR (BEHIND RIGHT SIDE OF DASH) BRN WIRE BRN/WHT WIRE CLASS 2 SER DATA CLASS 2 SERIAL DATA DK BLU WIRE DK GRN WIRE DK GRN/WHT WIRE FAN DN FAN UP FRT DEF GROUND GROUND TEMP SEN ASS CTRL BLOWER SPEED CTRL GRY WIRE GRY/BLK WIRE HOT AT ALL TIMES HOT AT ALL TIMES A/C COMP FUSE HOT IN HOT IN RUN OR START IGN E FUSE HVAC 1 FUSE HVAC CONTROL MODULE (BEHIND CENTER OF DASH) HVAC/ ECAS FUSE I/P RELAY BLOCK (LEFT SIDE OF DASH) INSIDE AIR TEMPERATURE SENSOR ASSEMBLY (IN HEADLINER ABOVE DRIVER) INST LAMP DIM CTRL GROUND LEFT I/P FUSE BLOCK (LOWER LEFT SIDE OF DASH) LEFT TEMP CONTROL LO PRESS SENS SIG RT TEMP DOOR CTRL LT TEMP DOOR CTRL LOGIC LOW REF LOWER LEFT AIR TEMPERATURE SENSOR (LEFT END OF HVAC MODULE) LOWER RIGHT AIR TEMPERATURE SENSOR (BOTTOM OF HVAC MODULE) LT BLU WIRE LT BLU/BLK WIRE LT GRN WIRE LT GRN/BLK WIRE MODE MODE DOOR CTRL MODE DOOR CTRL IGN 3 LOW REF B(+) OFF ORG/ WIRE POWERTRAIN CONTROL MODULE OR ENGINE CONTROL MODULE (LEFT FRONT OF ENGINE COMPT) PPL PPL/WHT WIRE RECIR RECIR DOOR CTRL RT TEMP DOOR CTRL LT TEMP DOOR CTRL RED WIRE RED/BLK WIRE RIGHT I/P FUSE BLOCK (LOWER RIGHT SIDE OF DASH) RIGHT TEMP CONTROL RUN WIRE SPEED CTRL B(+) GROUND TAN WIRE UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT, NEAR BATTERY) UPPER LEFT AIR TEMPERATURE SENSOR (BELOW DASH TRIM PANEL) UPPER RIGHT AIR TEMPERATURE SENSOR (BELOW DASH TRIM PANEL) WHT WIRE WHT/BLK WIRE YEL WIRE

11 12 PPL AMBIENT LIGHT SENS LO REF AMBIENT LIGHT SENS SIG RIGHT SUNLOAD SENSOR SIG LEFT SUNLOAD SENSOR SIG AMBIENT LIGHT SENSOR BLK WIRE BODY CONTROL MODULE (LOWER LEFT SIDE OF DASH, BELOW STEERING COLUMN) BRN WIRE CLASS 2 SERIAL DATA DK BLU WIRE DK GRN WIRE GRY WIRE LEFT AIR TEMPERATURE ACTUATOR (BOTTOM OF HVAC MODULE) LEFT SOLAR SENSOR LOGIC LT BLU WIRE LT BLU/BLK WIRE LT BLU/WHT WIRE LT GRN WIRE MODE ACTUATOR (LEFT SIDE OF HVAC MODULE) PPL RECIRCULATION ACTUATOR (UPPER RIGHT OF HVAC MODULE) RIGHT AIR TEMPERATURE ACTUATOR (TOP OF HVAC MODULE) RIGHT I/P FUSE BLOCK (LOWER RIGHT SIDE OF DASH) RIGHT SOLAR SENSOR SUNLOAD SENSOR ASSEMBLY (TOP CENTER OF DASH) TAN WIRE WHT WIRE WHT/BLK WIRE YEL WIRE

1056 1037 INTERIOR LIGHTS SYSTEM COMPUTER DATA LINES SYSTEM 2353 1382 4040 1732 230 2240 INTERIOR LIGHTS SYSTEM INTERIOR LIGHTS SYSTEM 710 308 COMPUTER DATA LINES SYSTEM EXTERIOR LIGHTS SYSTEM 812 1140 1969 1080 1353 ANTI-THEFT SYSTEM AMBIENT LIGHT SENSOR AMBIENT LIGHT SENSOR (TOP CENTER OF DASH) ANTI-LOCK BRAKES SYSTEM INTERIOR LIGHTS SYSTEM HEADLIGHTS SYSTEM ANTI-THEFT SYSTEM HEADLIGHTS SYSTEM HORNS SYSTEM ANTI-THEFT SYSTEM SOUND SYSTEM HEADLIGHTS SYSTEM HEADLIGHTS SYSTEM BLK WIRE BLK/WHT WIRE BODY CONTROL MODULE (ON LOWER LEFT SIDE OF DASH, BELOW STEERING COLUMN) BRN/WHT WIRE CLASS 2 SERIAL DATA CLASS 2 SERIAL DATA PARK LAMP SW ON SIG DEFOGGER SYSTEM DK BLU WIRE DK GRN WIRE DK GRN/WHT WIRE FUSE GRY WIRE GRY/BLK WIRE HOT AT ALL TIMES I/P RELAY BLOCK INTERIOR LIGHTS SYSTEM INTERIOR LIGHTS SYSTEM LEFT I/P FUSE BLOCK LT BLU WIRE LT BLU/BLK WIRE LT GRN WIRE LT GRN/BLK WIRE ORG/ WIRE ORG/BLK WIRE PNK WIRE PNK/WHT WIRE POWER DISTRIBUTION SYSTEM PPL PPL INTERIOR LAMP DEFEAT SW SIG PPL/WHT WIRE REAR DEFOG RLY CTRL RED WIRE RED/WHT WIRE SOLAR SENSOR SOLAR SENSOR SUNLOAD SENSOR (ON CENTER OF DASH, NEAR DEFROST DEFLECTORS) TAN WIRE TAN/BLK WIRE TBC BATT FUSE TOW/HAUL SW SIG TOW/HAUL SWITCH UNDERHOOD FUSE BLOCK W/ AUTOMATIC A/C W/ MANUAL A/C WHT WIRE YEL WIRE

A/C COMP CL RLY CTRL A/C COMPRESSOR CLUTCH A/C COMPRESSOR CLUTCH RELAY A/C LOW PRESSURE SWITCH (RIGHT SIDE OF ACCUMULATOR) A/C ON SWITCH A/C REF PRE SENS SIG A/C REFRIGERANT PRESSURE SENSOR (IN HIGH SIDE PRESSURE LINE) BLK WIRE CLASS 2 SER DATA LO PRESS SENS SIG CLASS 2 SERIAL DATA DK BLU WIRE DK GRN WIRE GRY WIRE HOT AT ALL TIMES A/C COMP FUSE HOT IN RUN OR START IGN E FUSE HVAC CONTROL MODULE (BEHIND CENTER OF DASH) LOGIC LOW REF POWERTRAIN CONTROL MODULE OR ENGINE CONTROL MODULE (LEFT FRONT OF ENGINE COMPT) RED WIRE UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT, NEAR BATTERY) WHT WIRE

BLK WIRE BLK/WHT WIRE BODY CONTROL MODULE (LOWER LEFT SIDE OF DASH, BELOW STEERING COLUMN) BRN WIRE CLASS 2 DATA CLASS 2 SERIAL DATA CTSY LAMP CTRL CTSY LAMP ON SIG CTSY LAMP POWER CTSY LAMP SUPPLY DK BLU WIRE DK BLU/WHT WIRE DOME LAMP SWITCH DOOR AJAR SIG DRIVER DOOR MODULE (BEHIND LEFT FRNT DOOR TRIM PANEL, NEAR HANDLE GRY/BLK WIRE HEADLAMP SWITCH INADVERTANT PWR SUPPLY LEFT FRONT DOOR COURTESY LAMP LEFT LIFTGATE AJAR SWITCH RIGHT LIFTGATE AJAR SWITCH LIFTGATE AJAR SIG RR DOOR AJAR SIG LR DOOR AJAR SIG LIFTGLASS AJAR SWITCH LOW REF LR DOOR COURTESY LAMP (2003) LT BLU/BLK WIRE LT GRN WIRE LT GRN/BLK WIRE MINI WEDGE (DRIVER DOOR JAMB SWITCH) MINI WEDGE (LR DOOR JAMB SWITCH) MINI WEDGE (RR DOOR JAMB SWITCH) ORG/ WIRE PNK/BLK WIRE PPL INT LAMP DEFEAT SIG PPL INT LAMP DEFEAT SW RIGHT CARGO DOOR AJAR SWITCH RIGHT CARGO DOOR CONTACT PLATE RR DOOR COURTESY LAMP (2003) SPLICE PACK TAN WIRE W/O CARGO DOORS W/ CARGO DOORS

A/C COMP CL RLY CTRL A/C COMPRESSOR CLUTCH A/C COMPRESSOR CLUTCH RELAY A/C LOW PRESSURE SWITCH (RIGHT SIDE OF ACCUMULATOR) A/C ON SWITCH A/C RECIRC A/C REF PRE SENS SIG A/C REFRIGERANT PRESSURE SENSOR (IN HIGH SIDE PRESSURE LINE) BLK WIRE BLK/WHT WIRE BLOWER FUSE BLOWER MOTOR (UNDER RIGHT SIDE OF DASH) BLOWER MOTOR CONTROL SWITCH BLOWER MOTOR RELAY BLOWER MOTOR RESISTOR ASSEMBLY (ON HVAC MODULE, NEAR BLOWER MOTOR) BRN WIRE BRN/WHT WIRE CLASS 2 SER DATA CLASS 2 SERIAL DATA DK BLU WIRE DK GRN WIRE DK GRN/WHT WIRE FRT DEF GRY WIRE HOT AT ALL TIMES HOT AT ALL TIMES A/C COMP FUSE HOT IN HOT IN RUN OR START IGN E FUSE HTR A/C FUSE HVAC 1 FUSE HVAC CONTROL MODULE (BEHIND CENTER OF DASH) HVAC/ ECAS FUSE I/P RELAY BLOCK (LEFT SIDE OF DASH) INST LAMP DIM CTRL GROUND LEFT I/P FUSE BLOCK (LOWER LEFT SIDE OF DASH) LEFT TEMP CONTROL LOGIC LOW REF LT BLU WIRE LT BLU/BLK WIRE LT GRN WIRE MODE CONTROL MODE DOOR CTRL MODE DOOR CTRL IGN 3 LOW REF B(+) OFF OFF BLOW MT CTRL LO PRESS SENS SIG RT TEMP DOOR CTRL LT TEMP DOOR CTRL ORG/ WIRE POWERTRAIN CONTROL MODULE OR ENGINE CONTROL MODULE (LEFT FRONT OF ENGINE COMPT) PPL RECIR DOOR CTRL RT TEMP DOOR CTRL LT TEMP DOOR CTRL RECIRC SWITCH RED WIRE RED/BLK WIRE RIGHT I/P FUSE BLOCK (LOWER RIGHT SIDE OF DASH) RIGHT TEMP CONTROL RUN WIRE TAN WIRE UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT, NEAR BATTERY) WHT WIRE WHT/BLK WIRE YEL WIRE

BLK WIRE BODY CONTROL MODULE (LOWER LEFT SIDE OF DASH, BELOW STEERING COLUMN) BRN WIRE CLASS 2 SERIAL DATA DK BLU WIRE DK GRN WIRE LEFT AIR TEMPERATURE ACTUATOR (BOTTOM OF HVAC MODULE) LOGIC LT BLU WIRE LT BLU/BLK WIRE LT GRN WIRE MODE ACTUATOR (LEFT SIDE OF HVAC MODULE) RECIRCULATION ACTUATOR (UPPER RIGHT OF HVAC MODULE) LOGIC RIGHT AIR TEMPERATURE ACTUATOR (TOP OF HVAC MODULE) RIGHT I/P FUSE BLOCK (LOWER RIGHT SIDE OF DASH) TAN WIRE WHT/BLK WIRE YEL WIRE

11 10 5 BATT (+) MEM 1 SW SIG MEM 2 SW SIG 2 3 PNK WIRE 4 5 PPL BLK WIRE BLK/WHT WIRE BRN WIRE BRN/WHT WIRE CLASS 2 SERIAL DATA COMPUTER DATA LINES SYSTEM DK BLU WIRE DK GRN WIRE DRIVER DOOR MODULE (BEHIND LEFT FRONT DOOR TRIM PANEL, NEAR HANDLE) DRIVER SEAT BOLSTER MOTOR DRIVER SEAT BOLSTER MOTOR POSITION SENSOR DRIVER SEAT BOLSTER/ LUMBAR SWITCH DRIVER SEAT FRONT VERTICAL MOTOR DRIVER SEAT FRONT VERTICAL POSITION SENSOR DRIVER SEAT HORIZ- ONTAL POSITION SENSOR DRIVER SEAT LUMBAR MOTOR DRIVER SEAT LUMBAR MOTOR POSITION SENSOR DRIVER SEAT REAR VERTICAL MOTOR DRIVER SEAT REAR VERTICAL POSITION SENSOR DRIVER SEAT RECLINER MOTOR DRIVER SEAT RECLINER MOTOR POSITION SENSOR EXIT GRY/RED WIRE IN OUT LT BLU WIRE LT GRN WIRE MEMORY/ HEATED SEAT SWITCH ORG/ WIRE OUT PNK WIRE PPL RED WIRE SET 1 SET 2 TAN WIRE WHT WIRE WHT/RED WIRE YEL WIRE

2 3 1340 1050 BATTERY GROUND 22 14 1046 4140 CLASS 2 SERIAL DATA BATTERY 22 14 1047 4240 CLASS 2 SERIAL DATA BATTERY 4 2 1050 1240 GROUND BATTERY 8 7 4 3 PNK LOW REF MIR SIGNAL MIR SENS LOW REF MIR HTR LOW REF WIRE BLK WIRE BRN WIRE CLASS 2 SERIAL DATA COMPUTER DATA LINES SYSTEM DDM FUSE DK BLU WIRE DK GRN WIRE DOWN DRIVER DOOR MODULE (IN DRIVER'S DOOR) DRIVER MIRROR DRIVER OUTSIDE REARVIEW MIRROR ELECTRO- CHROMIC FOLDING/ TELESCOPING MOTOR FOLDING/ TELESCOPING MOTOR HORIZONTAL FRONT PASSENGER OUTSIDE REARVIEW MIRROR FRONT PASSENGER DOOR MODULE (IN RIGHT FRONT DOOR) GRY WIRE HEATING ELEMENT HEATING ELEMENT (NEAR RIGHT "A" PILLAR) HOT AT ALL TIMES HOT AT ALL TIMES LEFT I/P FUSE BLOCK (LOWER LEFT SIDE OF DASH) HVAC CONTROL MODULE (IN CENTER OF DASH) I/P RELAY BLOCK (NEAR LEFT KICK PANEL) LEFT LEFT I/P FUSE BLOCK (LOWER LEFT SIDE OF DASH) LEFT UP HORIZONTAL LEFT UP VERTICAL LT BLU WIRE LT DOORS CIRCUIT BREAKER LT GRN WIRE ORG/ WIRE PASS- ENGER MIRROR PDM FUSE PNK WIRE PPL PPL/WHT WIRE RED WIRE RIGHT RIGHT I/P FUSE BLOCK (LOWER RIGHT SIDE OF DASH) RT DOOR CIRCUIT BREAKER SWITCH POWER TAN WIRE VERTICAL WHT WIRE WHT/RED WIRE YEL WIRE