Chevrolet Suburban X (2000-2006) brn Wiring diagrams

3 2 1 PPL BLK WIRE BLK/WHT WIRE BODY CONTROL MODULE (ON LOWER LEFT SIDE OF DASH, BELOW STEERING COLUMN) BRN WIRE BRN/WHT WIRE CIG LTR FUSE DATA LINK CONNECTOR (DLC) (UNDER LEFT SIDE OF DASH, BELOW STEERING COLUMN) DIGITAL RADIO RECEIVER DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE DK GRN/WHT WIRE DRIVE DOOR MODULE (DDM) (IN LEFT FRONT DOOR) ELECTRONIC BRAKE CONTROL MODULE (EBCM) (LEFT REAR FRAME RAIL) ELECTRONIC SUSPENSION CONTROL MODULE (BEHIND RIGHT "C" PILLAR TRIM PANEL) FRONT PASSENGER DOOR MODULE (FPDM) (IN RIGHT FRONT DOOR) GROUND DISTRIBUTION SYSTEM GRY WIRE HOT AT ALL TIMES HVAC CONTROL MODULE (AUXILIARY) (MOUNTED AT TOP OF AUXILIARY HVAC ASSEMBLY) HVAC CONTROL MODULE (BEHIND CENTER OF DASH) I/P RELAY BLOCK I/P RELAY BLOCK (UNDER LEFT SIDE OF DASH, NEAR KICK PANEL) INFLATABLE RESTRAINT SENSING, DIAGNOSTIC MODULE (UNDER LEFT FRONT SEAT) INSTRUMENT PANEL CLUSTER (IPC) LEFT I/P FUSE BLOCK (UNDER LEFT SIDE OF DASH) LT BLU WIRE LT GRN WIRE LT GRN/BLK WIRE MEMORY SEAT MODULE (UNDER SIDE OF DRIVER SEAT) NEAR KICK PANEL) ORG/ WIRE PNK WIRE POWER DISTRIBUTION SYSTEM POWERTRAIN CONTROL MODULE (PCM) (ON LEFT FRONT OF ENGINE COMPT) PPL RADIO (AT CENTER OF DASH) REAR SEAT AUDIO (RSA) CONTROLLER (UNDER REAR OF CENTER CONSOLE) REAR SEAT ENTERTAINMENT (RSE) ASSEMBLY (AT CENTER OF HEADLINER) REMOTE PLAYBACK DEVICE-CD PLAYER (AT CENTER OF DASH, BELOW RADIO) RIGHT I/P FUSE BLOCK (UNDER RIGHT SIDE OF DASH) TAN WIRE THEFT DETERRENT MODULE (AT CENTER OF DASH, BELOW RADIO) TRANSFER CASE SHIFT CONTROL MODULE (BEHIND HEADLAMP SWITCH) UNDERHOOD FUSE BLOCK (AT LEFT SIDE OF ENGINE COMPT, NEAR BATTERY) VEHICLE COMMUNICATION INTERFACE MODULE (VCIM) (BEHIND PASSENGER AIR BAG MODULE) W/O ACTIVE HANDLING W/ ACTIVE HANDLING WHT WIRE YEL WIRE

3 2 1 PPL AUDIO AMPLIFIER (UNDER REAR OF CENTER CONSOLE) BLK WIRE BLK/WHT WIRE BODY CONTROL MODULE (ON LOWER LEFT SIDE OF DASH, BELOW STEERING COLUMN) BRN WIRE BRN/WHT WIRE CIG LTR FUSE DATA LINK CONNECTOR (DLC) (UNDER LEFT SIDE OF DASH, BELOW STEERING COLUMN) DIGITAL RADIO RECEIVER DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE DK GRN/WHT WIRE DRIVE DOOR MODULE (DDM) (IN LEFT FRONT DOOR) ELECTRONIC BRAKE CONTROL MODULE (EBCM) (LEFT REAR FRAME RAIL) ELECTRONIC SUSPENSION CONTROL MODULE (BEHIND RIGHT "C" PILLAR TRIM PANEL) FRONT PASSENGER DOOR MODULE (FPDM) (IN RIGHT FRONT DOOR) GROUND DISTRIBUTION SYSTEM GRY WIRE HOT AT ALL TIMES HVAC CONTROL MODULE (AUXILIARY) (MOUNTED AT TOP OF AUXILIARY HVAC ASSEMBLY) HVAC CONTROL MODULE (BEHIND CENTER OF DASH) I/P RELAY BLOCK INSTRUMENT PANEL CLUSTER (IPC) LEFT I/P FUSE BLOCK (UNDER LEFT SIDE OF DASH) LT BLU WIRE LT GRN WIRE LT GRN/BLK WIRE MEMORY SEAT MODULE (UNDER SIDE OF DRIVER SEAT) NEAR KICK PANEL) ORG/ WIRE PNK WIRE POWER DISTRIBUTION SYSTEM POWERTRAIN CONTROL MODULE (PCM) (ON LEFT FRONT OF ENGINE COMPT) PPL RADIO (AT CENTER OF DASH) REAR SEAT AUDIO (RSA) CONTROLLER (UNDER REAR OF CENTER CONSOLE) REAR SEAT ENTERTAINMENT (RSE) ASSEMBLY (AT CENTER OF HEADLINER) REMOTE PLAYBACK DEVICE-CD PLAYER (AT CENTER OF DASH, BELOW RADIO) RIGHT I/P FUSE BLOCK (UNDER RIGHT SIDE OF DASH) TAN WIRE THEFT DETERRENT MODULE (AT CENTER OF DASH, BELOW RADIO) TRANSFER CASE SHIFT CONTROL MODULE (BEHIND HEADLAMP SWITCH) UNDERHOOD FUSE BLOCK (AT LEFT SIDE OF ENGINE COMPT, NEAR BATTERY) VEHICLE COMMUNICATION INTERFACE MODULE (VCIM) (BEHIND PASSENGER AIR BAG MODULE) W/O ACTIVE HANDLING W/ ACTIVE HANDLING WHT WIRE YEL WIRE

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 TP SENSOR 1 SIG 15 14 SERIAL DATA SERIAL DATA ACCELERATION PEDAL POSITION SENSOR (BEHIND ACCELERATOR PEDAL) APP SENSOR 1 SIG BLK WIRE BLK/WHT WIRE BRN WIRE CLASS 2 DATA CLASS 2 DATA COMPUTER DATA LINES SYSTEM CRUISE FUSE CRUISE IND DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE ETC/ECM FUSE GRY WIRE GRY/BLK WIRE GRY/WHT WIRE HOT AT ALL TIMES HOT IN RUN HOT IN RUN, START IGN INSTRUMENT PANEL CLUSTER LEFT I/P FUSE BLOCK (ON LOWER LEFT SIDE OF DASH) LOW REF (NOT USED) LOW REF LOW REF APP SENSOR 2 SIG PPL LT BLU WIRE LT BLU/BLK WIRE LT GRN/BLK WIRE NCA WIRE OFF ON OFF ORG/ WIRE ORG/BLK WIRE PNK WIRE POWERTRAIN CONTROL MODULE (LEFT FRONT OF ENGINE COMPT) PPL PPL/WHT WIRE RESUME/ ACCEL CRUISE CONTROL ON/OFF SWITCH RESUME/ACCEL SERIAL DATA SET/ COAST STOP LPS FUSE STOPLAMP SWITCH (TOP OF BRAKE PEDAL) TAN WIRE THROTTLE ACTUATOR CONTROL MODULE (RIGHT REAR OF ENGINE COMPT) TURN SIGNAL/ MULTIFUNCTION SWITCH UNDER- HOOD FUSE BLOCK UNDERHOOD FUSE BLOCK (NEAR BATTERY) VEH STOP FUSE VEHICLE SPEED SENSOR (VSS) (ON REAR OF TRANSMISSION) VSS HIGH VSS LOW W/ ELECTRONIC ADJUSTABLE PEDAL W/O ELECTRONIC ADJUSTABLE PEDAL WHT WIRE WHT/BLK WIRE YEL WIRE YEL/BLK WIRE

5 VOLT REF RELAY CONTROL 7 3 BATT+ STEERING POST SIG A AUTOMATIC LEVEL CONTROL (ALC) COMPRESSOR RELAY (NEAR UNDERHOOD FUSE BLOCK) AVALANCHE/ ESCALADE EXT BLK WIRE BLK/WHT WIRE BLU WIRE BRN WIRE COMPRESSOR MOTOR COMPRESSOR/ LEVELING MODULE COMPUTER DATA LINES SYSTEM CRUISE FUSE DATA LINES DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE EXCEPT ALL ESCALADE EXT OTHERS EXCEPT AVALANCHE/ ESCALADE EXT EXHAUST SOL GROUND GRY WIRE HOT AT ALL TIMES HOT IN IGN 3 FUSE LEFT FRONT SUSPENSION DAMPER SOLENOID LEFT I/P FUSE BLOCK (BEHIND LOWER LEFT SIDE OF DASH) LEFT REAR SUSPENSION DAMPER SOLENOID LF DAMP SERVO RR DAMP SERVO STEERING MARKER SIG LT BLU WIRE LT BLU/BLK WIRE LT BLU/WHT WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/WHT WIRE ORG/ WIRE PNK WIRE PNK/WHT WIRE POWERTRAIN CONTROL MODULE (PCM) (AT LEFT FRONT OF ENGINE COMPT) PPL/WHT WIRE PRESSURE SENSOR RED WIRE RED/BLK WIRE RIGHT FRONT SUSPENSION DAMPER SOLENOID RIGHT REAR SUSPENSION DAMPER SOLENOID RIGHT REAR SUSPENSION POSITION SENSOR (RIGHT REAR FRAME RAIL) RTD FUSE RUN WIRE SENSOR SIGNAL SPLICE PACK STEERING MARKER SIG STEERING POST SIG B STEERING POST SIG B SOLENOID CONTROL STEERING POST SIG A STUD 1 FUSE TAN WIRE TAN/WHT WIRE UNDERHOOD FUSE BLOCK (AT LEFT SIDE OF ENGINE COMPT, NEAR BATTERY) WHT WIRE

2 3 15 18 22 KEY SW LO REF DOOR SW LO REF KEY SW SIG DOOR SW SIG SERIAL DATA 5 6 20 22 24 DOOR SW SIG KEY SW LO REF DOOR SW LO REF SERIAL DATA KEY SW SIG AJAR SW B+ EX LIGHTS CTRL GROUND HORN RLY CTRL SERIAL DATA BLK WIRE BLK/WHT WIRE BODY CONTROL MODULE BRN WIRE CARGO/LIFTGATE DOOR AJAR SW DOOR AJAR SW DK BLU WIRE DK GRN WIRE DRIVER DOOR MODULE DRIVER MINI-WEDGE DOOR JAMB SWITCH FRONT PASSENGER DOOR MODULE FRONT PASSENGER MINI-WEDGE DOOR JAMB SWITCH GRN WIRE GROUND GRY/BLK WIRE HEADLIGHTS CTRL HEADLIGHTS SYSTEM HORNS SYSTEM HOT AT ALL TIMES KEY SW LEFT DOOR CONTACT PLATE (BODY) LEFT I/P FUSE BLOCK (LOWER LEFT SIDE OF DASH) LEFT LIFTGATE AJAR SWITCH LEFT REAR MINI-WEDGE DOOR JAMB SWITCH LIFTGATE KEY SWITCH LIFTGLASS AJAR SWITCH LT BLU WIRE LT BLU/BLK WIRE LT GRN WIRE LT GRN/BLK WIRE ORG/ WIRE PNK/BLK WIRE RIGHT CARGO DOOR AJAR SWITCH CARGO DOOR KEY SWITCH RIGHT DOOR CONTACT PLATE (BODY) RIGHT DOOR CONTACT PLATE (DOOR) RIGHT I/P FUSE BLOCK (LOWER RIGHT SIDE OF DASH) RIGHT LIFTGATE AJAR SWITCH RIGHT REAR MINI-WEDGE DOOR JAMB SWITCH SPLICE PACK TAN WIRE TBC BATT FUSE UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENG COMPT) W/ CARGO DOORS W/ LIFTGATE W/CARGO DOORS W/ LIFTGATE WHT WIRE WINDOW WIPER MODULE (LEFT SIDE OF COWL)

22 14 SERIAL DATA BATTERY 7 8 SUPPLY VOLT LOW REF BLK WIRE BRN WIRE COMPUTER DATA LINES SYSTEM DDM FUSE DRIVER DOOR MODULE (DDM) (IN DRIVER'S DOOR) DRIVER OUTSIDE REARVIEW MIRROR FRONT PASSENGER DOOR MODULE (FPDM) (IN RIGHT FRONT DOOR) GROUND HOT AT ALL TIMES HVAC CONTROL MODULE (IN CENTER OF DASH) LEFT I/P FUSE BLOCK (LOWER LEFT SIDE OF DASH) LOW REF ORG/ WIRE PASSENGER OUTSIDE REARVIEW MIRROR PDM FUSE R DEF REAR DEFOG SWITCH RIGHT I/P FUSE BLOCK (LOWER RIGHT SIDE OF DASH) SERIAL DATA SUPPLY VOLT TAN WIRE WHT WIRE

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 HALL A SIG HALL B SIG SENS GND POS 2 SIG 5 VOLT REF B+ VOLT B+ VOLT SERIAL DATA BASE BASE CASE GND GND B+ VOLT BLK WIRE BLK/WHT WIRE BODY CONTROL MODULE (ON LOWER LEFT SIDE OF DASH, BELOW STEERING COLUMN) BRN WIRE CASE GROUND COMPUTER DATA LINES SYSTEM CRUISE FUSE DK BLU WIRE DK GRN WIRE DK GRN/WHT WIRE FUSE GRY WIRE HALL A SIG HALL B SIG SENS GND HALL C SIG HALL C SIG RLY VOLT SENS GND POS 1 SIG 5 VOLT REF HOT AT ALL TIMES HOT IN HOT IN RUN LEFT I/P FUSE BLOCK IGN 3 FUSE I/P RELAY BLOCK (LOWER LEFT SIDE OF DASH) INSTRUMENT CLUSTER SYSTEM LOW REF LT BLU WIRE LT GRN WIRE MEGA FUSE MODE IND CTRL LAT ACCEL SIG ORG/ WIRE PHASE A CTRL PHASE B CTRL PHASE C CTRL PNK PNK WIRE PNK WIRE POS A SIG POS B SIG POWER DISTRIBUTION SYSTEM PPL PULSE SIG REAR WHEEL POSITION SENSOR (LEFT REAR OF VEHICLE) REAR WHEEL STEERING CONTROL MODULE (NEAR SPARE TIRE BRACKET) REAR WHEEL STEERING MODE SELECT SWITCH RED WIRE RLY GND RUN WIRE SENS SIG STEERING GEAR MOTOR ASSEMBLY (NEAR SPARE TIRE BRACKET) STEERING WHEEL SPEED/ POSITION SENSOR (ON STEERING COLUMN) TAN WIRE UNDERHOOD FUSE BLOCK UNDERHOOD FUSE HOLDER VSS IGN 3 VOLT YAW SENS SIG MODE SW SIG WHT WIRE YEL WIRE

3-2 SS CTRL REF LOW A/C SYSTEM ANTI-LOCK BRAKES SYS 470 451 1671 1667 451 1669 1664 1478 ANTI-LOCK BRAKES SYS 771 420 776 48 1744 846 1101 625 451 BLK WIRE BLK/ WHT WIRE BLK/WHT WIRE BODY CONTROL MODULE (BELOW STEERING COLUMN) BRN WIRE BRN/WHT WIRE DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE ELECTRONIC SUSPENSION SYSTEM FUEL COMP SIG B+ CLS 2 DATA CLS 2 DATA FUSE FUSE FUSE GRY WIRE HOT AT ALL TIMES HOT IN ACCY, RUN, START LEFT I/P FUSE BLOCK IGN 0 FUSE HOT IN RUN, START INJ 7 CTRL INJ 4 CTRL INJECTORS KS SIGNAL KS SIGNAL CKP SIG REQ TORQ SIG SERIAL DATA SERIAL DATA LEV SW SIG LT BLU WIRE LT BLU/BLK WIRE LT GRN WIRE LT GRN/BLK WIRE OIL LEV SW SIG ORG/ WIRE ORG/BLK WIRE PCMB FUSE PNK PNK WIRE PNK WIRE PNK/BLK WIRE PNK/WHT WIRE POWERTRAIN CONTROL MODULE (LEFT FRONT OF ENGINE COMPT) PPL PPL PPL PPL/WHT WIRE PRND B SIG CMP SIG ECT SIG IGN INJ 5 CTRL INJ 8 CTRL RANGE B RANGE C IGN B+ REF LOW RED WIRE RED/BLK WIRE REF LOW REF LOW (A/T) REF LOW REF LOW GND STARTING/ CHARGING SYSTEM TAN WIRE TAN/WHT WIRE UNDER- HOOD FUSE BLOCK WHT WIRE YEL WIRE YEL/BLK WIRE

BLK WIRE BLK/WHT WIRE BRN WIRE BRN/WHT WIRE COOLANT LEVEL SWITCH (IN COOLANT RESERVOIR) DK BLU WIRE DK BLU/WHT WIRE DK GRN/WHT WIRE ENGINE COOLANT TEMPERATURE SENSOR (FRONT OF LEFT CYLINDER HEAD) ENGINE OIL LEVEL SWITCH (RIGHT SIDE OF OIL PAN) FUEL PUMP RELAY FUEL PUMP RELAY (SECONDARY) (DUAL TANKS) (ON UNDERHOOD FUSE BLOCK BRACKET) FUEL PUMP, SENDER ASSEMBLY (PRIMARY) (IN FUEL TANK) FUSE GRY WIRE HEATED OXYGEN SENSOR (BANK 1 SENSOR 1) (LEFT EXH PIPE, BEFORE CONVERTER) HEATED OXYGEN SENSOR (BANK 1 SENSOR 2) (LEFT EXH PIPE, AFTER CONVERTER) HEATED OXYGEN SENSOR (BANK 2 SENSOR 1) (RIGHT EXH PIPE, BEFORE CONVERTER) HEATED OXYGEN SENSOR (BANK 2 SENSOR 2) (RIGHT EXH PIPE, AFTER CONVERTER) HOT AT ALL TIMES HOT IN RUN, START KNOCK SENSOR (UNDER INTAKE MANIFOLD) LT BLU WIRE LT GRN WIRE NCA WIRE ORG/BLK WIRE PARK/NEUTRAL POSITION SWITCH (LEFT SIDE OF TRANSMISSION) PCM B FUSE PNK PNK WIRE PNK WIRE PNK/BLK WIRE PPL PPL PNK PNK 18 19 WIRE PPL PPL PPL/WHT WIRE RED WIRE RED/WHT WIRE TAN WIRE TAN/WHT WIRE UNDER- HOOD FUSE BLOCK UNDERHOOD FUSE BLOCK WHT WIRE WHT/ BLK WIRE YEL WIRE

1-2 SOL 2-3 SOL 3-2 SOL A/T FLUID PRESSURE MANUAL VALVE POSITION SWITCH AUTOMATIC TRANSAXLE BLK WIRE BLK/WHT WIRE BLU WIRE BRAKE FUSE BRN WIRE BRN/WHT WIRE CAMSHAFT POSITION SENSOR (TOP CENTER REAR OF ENGINE) DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE DK GRN/WHT WIRE ENGINE OIL PRESSURE (EOP) SENSOR (TOP REAR OF ENGINE) EVAPORATIVE EMISSIONS (EVAP) CANISTER PURGE SOLENOID (BEHIND THROTTLE BODY) EVAPORATIVE EMISSIONS CANISTER VENT SOLENOID (RIGHT FRONT SIDE OF FUEL TANK) FUEL TANK PRESSURE SENSOR (IN FUEL TANK) GRY DK GRN WIRE GRY WIRE HOT AT ALL TIMES HOT IN RUN INSTRUMENT CLUSTER SYSTEM LEFT I/P FUSE BLOCK LT BLU WIRE LT BLU/WHT WIRE LT GRN GRY WIRE LT GRN WIRE LT GRN/BLK WIRE MANIFOLD ABSOLUTE PRESSURE SENSOR (TOP REAR OF ENGINE) ORG/ WIRE ORG/BLK WIRE PC SOL VALVE PNK PNK PNK WIRE PNK WIRE PNK/BLK WIRE PPL PPL PNK PNK 18 19 WIRE PPL PNK PNK 28 29 WIRE PPL/WHT WIRE RED WIRE RED/BLK WIRE RED/WHT WIRE REV STOP LAMP SWITCH (TOP OF BRAKE PEDAL BRACKET) STOP LPS FUSE TAN (OR BLK) WIRE TAN WIRE TAN/BLK WIRE TAN/WHT WIRE TCC PWM SOL TCC SOL TFT SENSOR UNDER- HOOD FUSE BLOCK UNDERHOOD FUSE BLOCK VEHICLE SPEED SENSOR (REAR OF TRANSMISSION/ TRANSFER CASE) WHT WIRE YEL WIRE YEL/BLK WIRE